2020 Subaru Outback

While we were at a speed of about 55 mph on a state highway, I had just selected cruise control when all the lights went on in the dash--including the warning lights for the brake, the check engine light--and power shut down in the vehicle as if we'd run out of gas. We were able to keep a very slow speed of about 20-25mph, but had to activate the 4-way flashers to alert other drivers that we were losing speed. We managed to get over to the shoulder and call for a tow. We feel this was a catastrophic failure of the vehicle, which endangered both of us. At least we still had power steering. At the dealer, the techs advised us that the issue was likely due to a failure of the electronic thermostat control. The car was in the shop for a week, and was repaired at no cost to us. The thermo control valve and all related parts were replaced. If not under warranty, this would have cost over $2K. We had no warning that this component was failing.

I purchased the lease for the vehicle in January 2020. I first notified Subaru in Austin of an obvious "glitch" with the computer operating system in April 2020. The "glitchy" OS challenges came and went, I would notify Subaru and they would remedy the issue with a "patch" update at the service center. On April 29 2022 a clear night and a suitably clean vehicle, the RAB system completely failed to recognize/notify/respond to a mailbox behind me, upon impact the mailbox broke the rear windshield. on June 28 2022 the vehicle fails to start, and is "surging" completely draining a new jumper box, and then promptly burning it out, the box will no longer operate. Put in a new battery(#1), make an appointment for service on the vehicle. The dealership replaces the battery(#2), computer updates are completed. Vehicle goes to the body shop for the rest of the work to be completed. 28 days later, I arrive to pick up my vehicle, all work is complete. However the vehicle will not start (again) Auto body shop replaces the battery(#3).on 9/23/2022 after dark, my Subaru Outback 2020 Limited, stops and puts its Parking break on., all dials spike, then dies, rear hatch signal goes off continuously, regardless of its actual state of open/close. The vehicle refuses to jump with a new jumper box. Outback 2020 is successfully jumped by a newer vehic. New battery installed(#4). 9/29/2022 another appointment at Subaru service center to look at my vehicle, they swap out the battery(#5) and update computer. Upon pickup vehicle is without trailer lights, 3 airbag lights on, ABS light on/off. 10/17/2022 appointment at a different service center for an Oil change service, 10/18/2022 diagnostic check appt, 3 blown fuses found. 11/16/2022 Austin service, found many lost comm. codes.- reprograms , engine control module. Outback 2020 intermittently has problems opening and closing hatch/windows, display loading issues, many warning/hazzard lights & signals on/off (from April 2022- present day.)

Car lurches when put into gear, Transmission make loud chirping noise when place into gear from park, transmission shudders when turning. Car has had all recalls updated. Symptoms have been reported to dealer numerous times. Currently vehicle is at Subaru Dealer in Temecula Calif. Dealer states a know transmission problem is being addressed thru a Subaru Engineer. Have been without the vehicle for approx 3 weeks.

My vehicle stalled abruptly as I came to a stop while driving on a slope. Shortly afterward I determined that this was caused by a loose battery terminal; the battery had been replaced a day earlier. This much was the fault of the mechanic, not the manufacturer. My complaint is with respect to the state which the vehicle failed into: 1. The gear shift was stuck in drive and could not be moved into park. 2. It was not possible to engage the parking break, as it can only be controlled by an electronic switch. 3. The steering wheel column was locked. As a result of this, the only way to prevent the vehicle from rolling backward down the hill was to continuously keep my foot on the brake. It also was not possible, as a result of the locked steering wheel column, to guide the vehicle downhill safely. I was stuck holding the brake and unable to get out of my vehicle until another motorist stopped to give me a jump and enable me to engage the parking brake.

The contact owns a 2020 Subaru Outback. The contact stated that while attempting to start the vehicle, the battery was completely drained. The contact stated that he was able to jumpstart the vehicle and continued to operate the vehicle. The contact stated no warning light was illuminated. The contact stated that the failure was intermittent but had become more frequent. The contact stated that he had not replaced the battery which was the original OEM battery. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that he needed to drive the vehicle more frequently. The vehicle had not been repaired. The failure reoccurred and the contact took the vehicle back to the same dealer who advised that there were no electrical failures and that he should return after one month to reprogram the computer. The manufacturer had not been informed of the failure. The failure mileage was approximately 8,000.

When we started vehicle, a wide array of systems shut down including cruise, Eye Sight, lane detection, auto high bean, adaptive light cornering - essentially anything “automated” or assisted - along with the heating. The car ran at a higher RPM at idle - 2000 vs a usual 700-800 - and rough shifted at speed. Again, as if the automatic transmission lost its sync. The water temp gauge was also off. Have since learned this was the “thermo control valve” and somewhat of a known fault on Outbacks of this year. We were lucky to reach home from the long trip we were on and to the dealership. At the dealership, the service team did not admit this was wide spread. Nor did they tell us there is an updated part from Subaru available. They intend to install the OEM part, which concerns us that in another 40-50k we will face the same $2k problem. We are unlucky that we just went over 60k miles, so this will not be covered under Subaru’s 60k drivetrain warranty. That Subaru is covering a cooling system problem under the guise of being drive train tells me they know they have something to keep quiet.

On Friday Feb 24, 2023 our Subaru suffered a complete loss of electrial power leaving us stranded in very cold weaher here in northeastern Ohio. We were finally able to get one door open only to find nothing else in the car would work. We contacted Subaru roadside assistance and they dispached a Lift car & a tow truck to our location. The tow truck driver determined the battery had a complete failure. He told us this was a very common problem they see on the Subaru cars. He was successful in getting the car started via jumper box. Later in the day we received a follow up call from Subaru roadside assistance to confirm our safety. I asked if this battery failure on new Subaru vehicles was common he said more than 90% of the rodaside assistance calls are related to this issue of early battery failure. As I called my dealer to schedule an appointment on this issue I was told Subaru has placed strict inspection rules before replacement is allowed. Does it take a genius to know a car with 8000 miles should not experience a complete battery failure. My previous experience with Subaru is that they only respond to correct an issue when forced. Had this failure occured under different circumstances it could have been more dangerous.

On Dec. 20, 2022, my Outback totally stopped working while sitting at a red light, causing traffic to be forced to maneuver around my car. A kind policeman put out flares until the tow truck arrived. I could not shift into park, nothing electric would work, except the radio continued to play and the flashers worked until it all died. I could not turn the radio off and the seat would not adjust. The electronic screen flashed on and off until it went totally black, after about an hour. This vehicle only has about 21,000 miles on it and was under warranty until 3 weeks prior to the incident. Every time I took it to the dealership, I explained that the electronics had glitches. They always said it was fixed but it never was right. The TomTom navigation system was totally unreliable from day one; the screen went blank and the radio would not work at all, as well as all the screen functions, without warning. The screen would read out that I should keep my hands on the wheel, although both hands were on the wheel. Over and over it had problems which were not resolved.