2018 Subaru Outback

This my [XXX] mother's car, she would have panicked had she witnessed this incident. Upon starting vehicle in morning after cleaning off light dusting of snow, the driver's side mirror started to smoke for almost a minute with an electrical and plastic burn smell. I was able to video some of the smoking and took a picture afterwards that seems to show a burn mark at the bottom of the mirror housing. This short caused a 10 amp fuse to blow which also took out interior lights and the ability to lock/unlock the car with the remote. The vehicle has not yet been inspected by anyone other than myself. I found a user on [XXX] with similar experience that a Subaru garage diagnosed as a short in the approach light module [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The STARLINK touchscreen display on my 2018 Subaru Outback has experienced progressive delamination — a separation of the screen's protective layer from the display panel — resulting in large, spreading opaque blotches that obscure significant portions of the screen. This is a known manufacturing defect that Subaru of America acknowledged through the issuance of a Technical Service Bulletin and an extended warranty for 2018 model year vehicles. That extended warranty has since expired, and Subaru has declined goodwill coverage despite the defect being documented by an authorized Subaru dealership (SOA Case No. 260106-1800881). The screen serves as the primary interface for the backup camera, navigation, and climate controls. Obscured visibility of this screen while driving creates a distraction hazard. I am requesting NHTSA investigate this defect and take appropriate action.

The contact owns a 2018 Subaru Outback. The contact stated that when driving approximately 30- 40 MPH, veering off the highway, the vehicle suddenly lost power, but had immediately regained power. The failure had occurred 3 - 4 times total. The last time it occurred, the vehicle took a bit longer to regain power. After pulling into the desired parking lot, the contact checked the battery. When touching a wire connecting to the battery, it sparked and caught fire. The contact immediately grabbed some snow nearby and threw it onto the wire to put out the fire. There was no fire report filed. There were no injuries or medical attention needed. The contact had noticed that the instrument panel would flash with several warning lights; however, it would illuminate quickly and intermittently. The vehicle was then scheduled to be towed from the parking lot, but it had not been taken to the dealer after the incident. The vehicle had not been diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was unknown.

the Infotainment system is malfunctioning. the screen is delaminating and pressing ghost buttons, flickering between screens or not functioning at all and I am unable to press any buttons on the screen. safety: when making calls hands free with the system, it will mute calls, end calls, or switch calls between the car speaker and the phone speaker. This is problematic if emergency services are ever needed to be called and makes it difficult to remain hands free as the buttons on the screen often don't work properly when this is happening. it also changes between screens when using the GPS maps and does not leave the map/directions displayed on the screen which puts the driver and others at greater risk of an accident when relying on the GPS to get places. The vehicle was inspected by a Subaru dealership on 1/8/2026 and confirmed the issues with the screen and confirmed that this is a known issue with the 2018 Subaru outback infotainment system. symptoms were first mild and started in the summer of 2025 but have significantly worsened over the past couple of months.

This is a Base model automobile with manual seats. The right front passenger seat unlocked without warning during a quick deceleration. The seat slid forward on mounting rails and caused the front passenger to be squished between forward motion of seat and the seat belt. Lucky this was not a collision, but weight of seat moving forward & smashing passenger against seat belt was very uncormfortable. During a collision, this may have resulted in a serious injury. Seat bottom was replaced by dealer at my expense. I have kept defective seat bottom for further inspection. I have attached the repair invoice. Car has been used afterward without front passenger awaiting for part to be made available. Invoice incorrectly reports mileage. There is less that 15,000 miles on this car.

While the lane keeping assistance is on the car will follow the exit lane beside the lane I’m in and jerk over into it. There has been a car beside me when has happened but I caught the steering wheel before a crash. Also if a car is turning in front of me sometimes, not always, the brakes will jam on when I’m not even close to the car that is turning but I would be going around the car after it has turned almost all the way. There has been no crashes or injuries yet.

The head unit on the vehicle has delaminated. The touchscreen display no longer works, it has false touches. This affects navigational safety of the vehicle, as navigation no longer works. This also affects sounds of the vehicle, not being able to change volume for ADAS alerts. This also affects the backup camera, which is a big safety concern. The problem has been confirmed and inspected by a dealer, it costs $2300.00 to replace. Warning symptoms were bubbles on the screen and the screen stopped working/became jittery.

The contact owns a 2018 Subaru Outback. The contact stated that while attempting to start the vehicle, the infotainment system was displaying a blank screen. No warning light was illuminated. A dealer was contacted. The vehicle was taken to a dealer where it was diagnosed and determined that the infotainment system needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 68,000.