2006 Subaru Outback

The contact owns a 2006 Subaru Outback. The contact stated while driving 55 MPH, the vehicle shut-off with the check engine and cruise control warning lights illuminated on the instrument panel. The vehicle went into limp mode as the contact steered the vehicle to the shoulder of the highway. Due to the failure, the contact had the vehicle towed to an independent mechanic where they diagnosed the vehicle with a defective throttle body. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was repaired but remained in the possession of the dealer. The failure mileage was approximately 217,000.

TL* THE CONTACT OWNS A 2006 SUBARU OUTBACK. WHILE DRIVING, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO BERTERA SUBARU (499 RIVERDALE ST, WEST SPRINGFIELD, MA 01089, (413) 734-4964) AND A SMOKE TEST WAS COMPLETED. THE CONTACT WAS INFORMED BY THE TECHNICIAN THAT A NEW FUEL TANK WAS NEEDED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT HAD PREVIOUSLY TAKEN THE VEHICLE TO THE SAME DEALER. AT THAT TIMES, A SMOKE TEST WAS COMPLETED AND THE FUEL CAP WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THEY WOULD PROVIDE A SMALL ALLOWANCE TOWARDS THE REPAIR OR TOWARDS A NEW OR USED VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 153,000. THE VIN WAS NOT AVAILABLE.

MY WIFE WAS DRIVING OUR 2006 SUBARU OUTBACK. SHE WAS DRIVING IN WINTER CONDITIONS. SHE WAS DRIVING THE 2 MILE BRIDGE TO OUR HOME WHEN THE ACCELERATION SUDDENLY FAILED AND THE VEHICLE ABRUPTLY SLOWED FROM 55 MPH TO 35 MPH. THE ROADS HAD SNOW AND ICE ON THEM. THE VEHICLE BEHIND HER CLOSED IN ON THE REAR OF OUR SUBARU AND BEGAN HONKING AND FLASHING ITS LIGHTS. THE CHECK ENGINE LIGHT IN OUR CAR CAME ON AND THE CRUISE CONTROL FLASHED. SHE WAS SCARED BY THE MISFUNCTION. THE CAR REVVED UP ABOVE 4000 RPMS WHEN SHE PUT IT INTO PARK. SHE SHUT THE VEHICLE OFF AND I CHECKED AND FOUND AN ERROR CODE. P2138. THE ACCELERATOR HAS 2 CIRCUITS THAT RELAY THE DESIRED SPEED TO THE CAR'S COMPUTER. WHEN THE CIRCUITS DON'T MATCH THE COMPUTER CUTS THE SPEED OUT OF THE VEHICLE. I THINK THAT THE ENGINEERING BEHIND THIS SYSTEM NEEDS TO BE RE THOUGHT SO THAT THIS DOESN'T OCCUR. I READ OTHER REPORTS ONLINE OF PEOPLE IN HEAVY TRAFFIC WHO HAD NEAR ACCIDENTS. *TR

I WAS PARKED IN A SHOPPING MALL PARKING LOT. WHEN I STARTED THE ENGINE AND PULLED OUT OF THE PARKING SPACE THE GAS PEDAL WAS UNRESPONSIVE. I JUST ROLLED ALONG WITH NO POWER. THE CHECK ENGINE LIGHT CAME ON AND I ROLLED INTO ANOTHER PARKING SPACE. I READ IN THE OWNER'S MANUAL THAT IT COULD BE AN EMISSION CONTROL PROBLEM OR SOMETHING TO DO WITH THE GAS CAP. I TOOK THE GAS CAP OFF AND RE-SEATED IT AND WHEN I TRIED TO START THE CAR AGAIN ON THE THIRD TRY, THE CHECK ENGINE LIGHT WENT OFF AND THE CAR HAD POWER AGAIN AND THE GAS PEDAL WAS RESPONSIVE. I TOOK IT TO MY MECHANIC AND HE FOUND THE CODE TO BE P3128. I WAS FORTUNATE THAT THIS DID NOT HAPPEN WHILE I WAS ON THE HIGHWAY OR ANYWHERE IN BUSY TRAFFIC. I HAD THE ENTIRE THROTTLE/PEDAL ASSEMBLY REPLACED AT A COST OF APROX. $500 AND HOPE THAT THIS SOLVES THE PROBLEM. *TR

SAME SYMPTOM HAPPENED TWICE: ONCE JUST AFTER STARTING FROM A SERVICE AREA ON THE INTERSTATE, THE SECOND ON SUBURBAN ROADS I DESCRIBE HERE. DURING A NORMAL 30 MILE SUBURBAN TRIP, AFTER ABOUT 20 MILES THE VEHICLE SUDDENLY LOST POWER AND THE CHECK ENGINE LIGHT CAME ON. THE ENGINE CONTINUED RUNNING BUT THE ACCELERATOR PEDAL SEEMED TO HAVE NO CONTROL OVER THE ENGINE SPEED OR POWER. AFTER COASTING TO A STOP AND TURNING THE ENGINE OFF FOR A MINUTE THE CAR STARTED AND RAN NORMALLY, THOUGH THE CHECK ENGINE LIGHT STAYED ON FOR A DAY OR SO. WHEN WE TOOK THE VEHICLE TO THE DEALER AFTER THE FIRST INCIDENT THEY WERE NOT ABLE TO INTERPRET THE CHECK ENGINE CODES; AFTER THE SECOND INCIDENT THEY FOUND A P2138 CODE -- "ACCELERATOR POSITION SENSOR" FAILURE. THEY REPLACED THE ACCELERATOR ASSEMBLY AND THE VEHICLE SEEMS TO BE RUNNING CORRECTLY AGAIN. AS I UNDERSTAND IT THE ISSUE IS A FAILURE IN THE ACCELERATOR POSITION SENSOR: THERE ARE DUAL SENSORS IN THE ASSEMBLY AND IF THEIR READINGS DIFFER THE ACCELERATOR PEDAL IS EFFECTIVELY "DISCONNECTED" AND THE DRIVER LOSES ALL POWER. I BELIEVE THIS IS A SERIOUS SAFETY ISSUE: THE FAILURE COULD JUST AS WELL HAVE TAKEN PLACE AT HIGH SPEED ON THE INTERSTATE WITHOUT THE POSSIBILITY OF A SAFE STOP, AND HAVING THE FIRST INDICATION OF TROUBLE BEING "LOSING ALL POWER" IS NOT ACCEPTABLE. *TR

HAPPENED TWICE IN ONE WEEK. ALL OF SUDDEN, ACCELERATOR NOT RESPONSIVE AND LOST OF POWER. CHECK ENGINE LIGHT COMES ON AND CRUISE FLASHING. AFTER TURNING ON AND OFF OR STAY OFF FOR A NIGHT, LIGHTS WENT OUT THEMSELVES. ERROR CODE P2138 ACCELERATOR POSITION SENSOR. CHECK SENSOR NO OBVIOUS LOOSE ON CONNECTOR. PRESS CONNECT ON AND NO ISSUE SO FAR. IT SEEMS THE CONNECTOR TOO CLOSE TO THE FLOOR AND EASY TO KICKED OR TOUCHED BY FOOT. \ CAR WAS BOUGHT IN BUFFALO WEST HERR SUBARU AND USED IN TORONTO. *TR

WHILE DRIVING 70MPH IN THE FAST LANE DOWN THE HIGHWAY I TURNED CRUISE CONTROL ON. AS SOON AS THE CRUISE CONTROL WAS ENGAGED ALL THROTTLE WAS LOST. WHILE IN MOTION I PUT THE CAR IN NEUTRAL THEN BACK INTO DRIVE AND NOTHING HAPPENED. THE CAR WAS DECELERATING SO I PULLED OFF THE HIGHWAY. ONCE SAFELY ON THE SIDE OF THE ROAD I TURNED THE CAR OFF FOR SEVERAL MINUTES AND THEN BACK ON. THE ACCELERATION CAPABILITY RETURNED BUT THE CHECK ENGINE LIGHT WAS ON. I TOOK THE CAR TO A MECHANIC TO READ THE CODE WHICH CAME BACK AS THE THROTTLE CONTROL SENSOR. THIS IS A VERY DANGEROUS DEFECT AND SHOULD BE ADDRESSED BY SUBARU AMERICA. *TR

I WAS ACCELERATING TO GET ON THE FREEWAY ENTRANCE IN MY SUBARU OUTBACK (WITH MY WIFE AND TWO SMALL CHILDREN) WHEN I NOTICE A COMPLETE LOSS IN THROTTLE RESPONSE. THE CAR WAS JUST BARELY MOVING DUE TO THE ENGINE IDLE. CHECK ENGINE LIGHT CAME ON. I DROVE AT THAT PACE TO A PARKING LOT TO CHECK MY OPTIONS. I HAD NOT NOTED, UNTIL NOW, THAT THIS CAR HAS NO THROTTLE CABLE AND IS COMPLETELY DRIVE-BY-WIRE. I LOOKED AT THE CONNECTION OF WIRE HARNESS TO THE PEDAL ASSEMBLY AND DID NOT SEE ANY RED FLAGS - NO CORROSION, ETC. IT APPEARED TO BE IN GOOD SHAPE. I SHUT THE CAR OFF, WAITED ABOUT 30 SEC, AND RESTARTED IT. IT THEN GOT US HOME. WHEN I GOT HOME TONIGHT, I RAN MY OBD DIAGNOSTIC TOOL AND GOT A P2138 ERROR CODE. THIS IS LISTED AS "THROTTLE/PEDAL POSITION SENSOR/SWITCH "D"/"E" VOLTAGE CORRELATION" TROUBLE CODE DESCRIPTION. I AM GOING TO CHECK INTO MY OPTIONS TOMORROW, BUT FELT THIS WAS WORTH REPORTING SINCE IT APPEARS THERE ARE OTHERS OUT THERE THAT HAVE EXPERIENCED THIS PROBLEM AS WELL. THERE IS DEFINITELY A SAFETY CONCERN WITH A FAILURE OF THIS NATURE AS I WAS TRAVELING AT A GOOD RATE AND IN TRAFFIC. LUCKILY, EVERYONE IS OK - BUT MY WIFE AND I WORRY WHEN THIS WILL HAPPEN AGAIN. THANKS. *TR