NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
27 reportsClear category filter70,000 miles · May 3, 2008
Service Brakes, Hydraulic
IN COLD WEATHER (ZERO OR BELOW), THE BRAKE PEDAL ON MY 1997 SUBARU LEGACY SEDAN BECOMES HARD, AND WHEN I PUT IT ANY GEAR, FORWARD OR REVERSE, THE IDLE SPEED WILL CAUSE THE CAR TO MOVE AND THE BRAKES WILL NOT STOP THE CAR-I HAVE TO SHIFT INTO NEUTRAL. I HAVE LEARNED THAT PUMPING THE BRAKE PEDAL WHILE THE CAR IS AT IDLE IN N OR P…
Read full complaint
IN COLD WEATHER (ZERO OR BELOW), THE BRAKE PEDAL ON MY 1997 SUBARU LEGACY SEDAN BECOMES HARD, AND WHEN I PUT IT ANY GEAR, FORWARD OR REVERSE, THE IDLE SPEED WILL CAUSE THE CAR TO MOVE AND THE BRAKES WILL NOT STOP THE CAR-I HAVE TO SHIFT INTO NEUTRAL. I HAVE LEARNED THAT PUMPING THE BRAKE PEDAL WHILE THE CAR IS AT IDLE IN N OR P WILL USUALLY HELP, AT -20 DEGREES, I HAVE TO LET THE CAR IDLE FOR 5 TO 10 MINUTES AND THEN TRY IT. THE DEALER INDICATED THAT THIS IS NOT UNCOMMON, BUT THAT THERE IS NO EASY FIX FOR THIS. THIS HAS HAPPENED EVERY WINTER SINCE I BOUGHT THE CAR IN 2001. *TR
NHTSA ODI #10226565
Mileage unknown · Aug 16, 2005
Service Brakes, Hydraulic
RIGHT FRONT BRAKE HAS FAILED TO OPERATE PROPERLY ON AT LEAST FOUR OCCASIONS. THE BRAKES HAVE GOTTEN VERY HOT AND COULD POSSIBLY CAUSE A FIRE OR CAUSE THE BRAKES TO LOCK UP. THE DUAL PISTON DESIGN RESULTS IN ONE PISTON DOING MOST OF THE WORK SO THE OTHER PISTON BECOMES STIFF AND DOES NOT RELEASE. WE HAVE HAD THE BRAKES GRAB AN…
Read full complaint
RIGHT FRONT BRAKE HAS FAILED TO OPERATE PROPERLY ON AT LEAST FOUR OCCASIONS. THE BRAKES HAVE GOTTEN VERY HOT AND COULD POSSIBLY CAUSE A FIRE OR CAUSE THE BRAKES TO LOCK UP. THE DUAL PISTON DESIGN RESULTS IN ONE PISTON DOING MOST OF THE WORK SO THE OTHER PISTON BECOMES STIFF AND DOES NOT RELEASE. WE HAVE HAD THE BRAKES GRAB AND BECOME EXTREMELY HOT TO THE POINT THAT WE ARE NOW ON OUR FOURTH SET OF CALIPERS WITH JUST OVER 36,000 MILES ON THE CAR. OUR MECHANIC ADVISES THIS PROBLEM IS QUITE COMMON ON SUBARU'S FOR AT LEAST THE 1996 THROUGH 1998 MODEL YEARS. WE HAVE HAD THE BRAKES REPLACED THREE TIMES BUT DO NOT HAVE THE OLD PARTS AVAILABLE. *JB
NHTSA ODI #10133120
80,000 miles · Mar 24, 2005
Service Brakes, Hydraulic
THE BRAKES MALFUNCTIONED WHEN THE WEATHER STARTED TO GET COLD. THE BRAKES SEEM TO FREEZE UP. DEALER HAD TO BLEED THE LINES. HOWEVER THE PROBLEM RECURRED. *AK *NM
NHTSA ODI #10109548
44,000 miles · Jan 8, 2005
Service Brakes, Hydraulic
VEHICLE LURCHES FORWARD AFTER BRAKES ARE APPLIED. VEHICLE JUMPS FORWARD A FEW FEET BEFORE STOPPING COMPLETELY. HAPPENS WHEN VEHICLE IS STOPPED. LAST INCIDENT RESULTED TO IMPACT WITH ANOTHER CAR IN PARKING LOT. DEALER COULD NOT FIND FAULT ON TWO OCCASIONS. SAYS IT MAY BE DUE TO AIR CONDITIONER COMING ON.*AK
NHTSA ODI #10105986
Mileage unknown · Apr 10, 2002
Service Brakes, Hydraulic
WHEN APPLYING BRAKES IN SNOW ONLY RIGHT FRONT BRAKE GRABS, BRAKE LIGHT CAME ON, AS WELL. BRAKES WORK FINE IN DRY ROAD CONDITIONS.*AK
NHTSA ODI #8007307
Mileage unknown · Nov 14, 2001
Service Brakes, HydraulicStructure
1) ALL 4 RIMS HAVE A TENDENCY TO COLLECT ROAD SILT AND WATER INSIDE. THIS IMBALANCES THE CAR AND MAY EXPLAIN SOME OF THE BRAKE PROBLEMS. PERHAPS AIRFLOW UNDER THE VEHICLE SHOULD BE STUDIED. 2) PADS AND SPRINGS LOCATED ON FRAME WHERE THE REAR GATE CLOSES AGAINST THE BODY ARE RUSTED TIGHT. 3) DASH LIGHTS FOR HVAC HAVE FAILED AT AB…
Read full complaint
1) ALL 4 RIMS HAVE A TENDENCY TO COLLECT ROAD SILT AND WATER INSIDE. THIS IMBALANCES THE CAR AND MAY EXPLAIN SOME OF THE BRAKE PROBLEMS. PERHAPS AIRFLOW UNDER THE VEHICLE SHOULD BE STUDIED. 2) PADS AND SPRINGS LOCATED ON FRAME WHERE THE REAR GATE CLOSES AGAINST THE BODY ARE RUSTED TIGHT. 3) DASH LIGHTS FOR HVAC HAVE FAILED AT ABOUT 30,000 MILES. 4) GAS GAUGE DOES NOT DESCEND ACCURATLY.
NHTSA ODI #754517
Mileage unknown · Nov 14, 2001
Service Brakes, HydraulicStructureVisibility
7) ALL 4 RIMS HAVE A TENDENCY TO COLLECT ROAD SILT AND WATER INSIDE. THIS IMBALANCES THE CAR AND MAY EXPLAIN SOME OF THE BRAKE PROBLEMS. PERHAPS AIRFLOW UNDER THE VEHICLE SHOULD BE STUDIED. 8) LEFT REAR PASSENGER WINDOW DOES NOT GO UP ALL THE WAY ANY LONGER. 84,000 MILES. 9) PADS AND SPRINGS LOCATED ON FRAME WHERE THE REAR GATE …
Read full complaint
7) ALL 4 RIMS HAVE A TENDENCY TO COLLECT ROAD SILT AND WATER INSIDE. THIS IMBALANCES THE CAR AND MAY EXPLAIN SOME OF THE BRAKE PROBLEMS. PERHAPS AIRFLOW UNDER THE VEHICLE SHOULD BE STUDIED. 8) LEFT REAR PASSENGER WINDOW DOES NOT GO UP ALL THE WAY ANY LONGER. 84,000 MILES. 9) PADS AND SPRINGS LOCATED ON FRAME WHERE THE REAR GATE CLOSES AGAINST THE BODY ARE RUSTED TIGHT. 10) DASH LIGHTS FOR HVAC HAVE FAILED AT ABOUT 30,000 MILES. 11) GAS GAUGE DOES NOT DESCEND ACCURATLY.
NHTSA ODI #754516
Mileage unknown · Nov 13, 2001
Engine And Engine CoolingService Brakes, HydraulicSuspension
ENGINE WAS KNOCKING AND MAKING A TICKING NOISE, BRAKES WERE MAKING A SQUEAK/ LOUD NOISE, DEALERSHIP IS AWARE OF PROBLEM. *AK CONSUMER STATED THAT THE VEHICLE PULLS TO THE RIGHT AND STEERING WHEEL WOBBLES, ALSO RIM WAS REPLACED DUE TO IT BEING BENT. *YD
NHTSA ODI #899069
Mileage unknown · Apr 5, 2001
Service Brakes, HydraulicCrash
BRAKES DID NOT WORK WHEN DRIVER BRAKED TO AVOID ACCIDENT ON ROAD AHEAD. DRIVER HAD TO SWERVE OFF ROAD INTO DITCH, SLIDING DOWN SLOPE AND IMPACTING CULVERT AND CAUSING EXTENSIVE DAMAGE TO CAR. CAR TOWED AWAY. CAR REPAIRED AT SPRINGFIELD VA SUBARU DEALER, AND COMPLETELY CHECKED OUT. SEVERAL WEEKS LATER, CAR BROUGHT IN TO DEALE…
Read full complaint
BRAKES DID NOT WORK WHEN DRIVER BRAKED TO AVOID ACCIDENT ON ROAD AHEAD. DRIVER HAD TO SWERVE OFF ROAD INTO DITCH, SLIDING DOWN SLOPE AND IMPACTING CULVERT AND CAUSING EXTENSIVE DAMAGE TO CAR. CAR TOWED AWAY. CAR REPAIRED AT SPRINGFIELD VA SUBARU DEALER, AND COMPLETELY CHECKED OUT. SEVERAL WEEKS LATER, CAR BROUGHT IN TO DEALER TO ADDRESS BRAKE CONCERNS (SHUDDERING, NOISE), DEALER SAID BRAKES WERE OK. CAR BROUGHT IN AGAIN FOR CONTINUING BRAKE CONCERNS, DEALER THEN SAID ALL 4 BRAKES NEEDED REPLACEMENT AT COST OF ABOUT $800. WE CONTACTED SUBARU CUSTOMER SERVICE REGARDING THIS, THEY REFUSED TO COMMUNICATE A REPLY TO US UNTIL ONLY AFTER REPEATED CALLING. THEY TOLD US THEY WOULD REFUSE TO PROVIDE ANY REFUND ON THE BRAKE WORK (WE THOUGHT THE REPAIR EXCESSIVE IN COST). MY CONCERN IS THERE IS A BRAKE FLAW WITH THE SUBARU LEGACY OUTBACK THAT IS NOT BEING ACKNOWLEDGED BY SUBARU. WE HAVE ALSO HAD THE CAR SUDDENLY ACCELERATE WHEN STOPPED AT IDLE AT STOPLIGHT, REQUIRING STRONG BRAKE FORCE TO RESTRAIN THE CAR FROM MOVING.*AK
NHTSA ODI #743563
Mileage unknown · Apr 2, 2001
Service Brakes, Hydraulic
SECOND MASTER CYLINDER WAS PURCHASED FROM SUBARU SERVICE CENTER, BUT FAILED IN LESS THAN A YEAR AND APPROXIMATELY 8,000 MILES. *AK
NHTSA ODI #743425
Official recalls
5Jun 25, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FRONT COIL SPRINGS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW YORK, NEW JERSEY, NEW HAMPSHIRE, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS WERE PRODUCED WITH POOR PAINT QUALITY WHICH, AFTER CONTINUED EXPOSURE TO CORROSIVE SALT, CAN RESULT IN BREAKAGE OF THE SPRING.
Consequence & remedy
Consequence: DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE. SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.
Remedy: DEALERS WILL NOTIFIY CUSTOMERS TO BRING THEIR VEHICLE TO AN AUTHORIZE DEALERSHIP TO HAVE A SPRING GUARD INSTALLED ON BOTH FRONT STRUTS TO PREVENT TIRE PUNCTURE AND REPLACE ANY BROKEN SPRINGS FREE OF CHARGE. OWNER NOTIFICATION BEGAN SEPTEMBER 18, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
May 4, 1998
VEHICLE DESCRIPTION: PASSENGER STATION WAGON, SEDAN AND SPORT UTILITY VEHICLES. DUE TO IMPROPER WELDING, FRACTURES CAN OCCUR ON THE SUPPORT BRACKET OF THE FRONT TRANSVERSE LINK.
Consequence & remedy
Consequence: SUCH FRACTURES CAN RESULT IN PARTIAL OR COMPLETE SEPARATION OF THE BRACKET CAUSING A FAILURE OF THE LOWER SUSPENSION MOUNTING, LEADING TO A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL INSPECT AND REPLACE IF NECESSARY THE FRONT SUSPENSION SUPPORT BRACKETS.
Feb 20, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE THROTTLE SHAFT BALL BEARING ON THE SENSOR SIDE OF THE THROTTLE BODY ASSEMBLY WAS NOT INSTALLED IN CERTAIN THROTTLE BODIES.
Consequence & remedy
Consequence: OPERATION OF A VEHICLE WITH A MISSING THROTTLE SHAFT BEARING CAN EVENTUALLLY LEAD TO AN INCOMPLETE RETURN OF THE THROTTLE VALVE RESULTING IN A HIGH IDLING CONDITION.
Remedy: DEALERS WILL INSPECT THE THROTTLE BODY AND REPLACE THE THROTTLE ASSEMBLY IF THE BEARING IS MISSING.
Feb 20, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. DUE TO POOR WELDS, IGNITION KEYS CAN STICK, SHIFT LEVERS/LINKAGES CAN BREAK AND SHIFT LEVERS CAN MOVE.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE UNEXPECTED MOVEMENT OF THE VEHICLE INCREASING THE RISK OF A CRASH OR PROPERTY DAMAGE.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION SHIFT LEVER ASSEMBLIES (EXCEPT THE HANDLE GRIP).
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. INSUFFICIENT CLEARANCE WITHIN THE HAZARD WARNING LIGHT SWITCH HOUSING CAN CAUSE A BINDING BETWEEN THE ACTUATING BUTTON AND THE HOUSING.
Consequence & remedy
Consequence: THE SWITCH COULD STICK IN AN INTERMEDIATE POSITION WHEN DEACTIVATING, RESULTING IN THE TURN SIGNALS BECOMING INOPERABLE.
Remedy: DEALERS WILL INSTALL A MODIFIED HAZARD WARNING SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration