CAR WAS SOMETIMES DIFFICULT TO START, OTHER TIMES IT WOULD STALL/HESITATE WHEN IN MOTION ON CITY STREET. DISCOVERED TO BE CAUSED BY AGED/WORN FUEL PUMP CAUSING OVERCURRENT DRAW THAT FAILS TO BLOW FUSE CAUSING MELTDOWN IN WIRING HARNESS CONNECTOR WHERE PIGTAIL FROM PUMP CONNECTS TO THE CHASSIS SIDE OF THE WIRING HARNESS. HEAT/SPA…
Read full complaint
CAR WAS SOMETIMES DIFFICULT TO START, OTHER TIMES IT WOULD STALL/HESITATE WHEN IN MOTION ON CITY STREET. DISCOVERED TO BE CAUSED BY AGED/WORN FUEL PUMP CAUSING OVERCURRENT DRAW THAT FAILS TO BLOW FUSE CAUSING MELTDOWN IN WIRING HARNESS CONNECTOR WHERE PIGTAIL FROM PUMP CONNECTS TO THE CHASSIS SIDE OF THE WIRING HARNESS. HEAT/SPARK POTENTIAL IS CREATED IN CLOSE PROXIMITY TO FUEL TANK THAT HAS MANY REPORTED CASES OF FUEL FILLER NECK RUSTING OFF AND LEAKING FUEL. A QUICK GOOGLE SEARCH REVEALS THAT A NUMBER OF PEOPLE, WITH PHOTOS, HAVE EXPERIENCED THIS FAILURE. PHOTO PROVIDED IS FROM INTERNET BUT THE RESULT IS THE SAME.
NHTSA ODI #11375007
75,000 miles · Feb 7, 2012
Electrical System
TL* THE CONTACT OWNS A 1997 SUBARU LEGACY. THE CONTACT ATTEMPTED TO START THE IGNITION AND THE ENGINE FAILED TO START. THE BATTERY WAS JUMP STARTED; HOWEVER THE FAILURE RECURRED WHILE DRIVING. THE BATTERY WAS RECHARGED FOR A SECOND TIME. THE CONTACT REPLACED THE BATTERY TERMINAL DUE TO SEVERE RUST AND CORROSION. THE MANUFACTURER…
Read full complaint
TL* THE CONTACT OWNS A 1997 SUBARU LEGACY. THE CONTACT ATTEMPTED TO START THE IGNITION AND THE ENGINE FAILED TO START. THE BATTERY WAS JUMP STARTED; HOWEVER THE FAILURE RECURRED WHILE DRIVING. THE BATTERY WAS RECHARGED FOR A SECOND TIME. THE CONTACT REPLACED THE BATTERY TERMINAL DUE TO SEVERE RUST AND CORROSION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000. UPDATED 02/28/12 *BF THE CONSUMER STATED BATTERY CORROSION DESTROYED THE NEGATIVE TERMINAL. UPDATED 03/08/12
NHTSA ODI #10446947
Mileage unknown · Sep 30, 2002
Electrical System
THE VEHICLE EXPERIENCED REOCCURING ALTERNATOR FAILURES, AS A RESULT OF THE ALTERNATOR FAILING THE HARNESS WIRES HAVE MELTED AND BURNED, ALSO THE BATTERY HAD TO BE REPLACE.*NLM
NHTSA ODI #567692
Mileage unknown · Jun 7, 2002
Electrical System
HAVE HAD INTERMITTENT DIFFICULTY WITH STARTING VEHICLE BETWEEN 03/2002 & 05/2002. WHEN STARTING THE VEHICLE ON COOL MORNING AND OCCASIONAL AFTERNOONS, IT DOESN'T START. THE RADIO, GAUGES FUNCTION BUT THE ENGINE DOESN'T ENGAGE. THERE IS A CLICKING SOUND AND A PARTIAL TURNING OF THE ENGINE. AFTER 4-8 ATTEMPTS, VEHICLE STARTS …
Read full complaint
HAVE HAD INTERMITTENT DIFFICULTY WITH STARTING VEHICLE BETWEEN 03/2002 & 05/2002. WHEN STARTING THE VEHICLE ON COOL MORNING AND OCCASIONAL AFTERNOONS, IT DOESN'T START. THE RADIO, GAUGES FUNCTION BUT THE ENGINE DOESN'T ENGAGE. THERE IS A CLICKING SOUND AND A PARTIAL TURNING OF THE ENGINE. AFTER 4-8 ATTEMPTS, VEHICLE STARTS AND FUNCTIONS NORMALLY. THE VEHICLE WAS EXAMINED BY THE LOCAL SERVICE CENTER WHEN PROBLEM FIRST OCCURRED, BUT WAS UNABLE TO REPEAT IT. CONTACTED MANUFACTURER WHO CONTACTED LOCAL SERVICE CENTER AND CENTER OFFERED TO REPEAT EXAM. CURRENTLY, VEHICLE IN SERVICE CENTER'S POSSESSION BUT PROBLEM HAS NOT REOCCURRED FOR THEM. UNABLE TO DIAGNOSE VEHICLE PROBLEM. THIS IS AN ANNOYING SITUATION WHEN ONE HAS TO RELY ON PRIVATE AUTO FOR TRANSPORTATION TO SCHOOL AND WORK.*AK
NHTSA ODI #762757
Mileage unknown · Aug 17, 2001
Electrical System
CONSUMER TRIED TO START VEHICLE, AND IT WOULD NOT START. VEHICLE TOWED TO DEALER. DEALER FOUND A PINCHED WIRE IN WIRING HARNESS. WIRE NEEDED TO BE REPLACED AT A COST OF $ 2200.00 . CONSUMER FELT SUBARU WAS RESPONSIBLE FOR REPAIRS. *AK
NHTSA ODI #894633
Mileage unknown · Aug 31, 2000
Electrical System
I HAVE HAD PROBLEMS WITH THE HEATED SEATS (LIGHT WHICH ILLUMINATES SWITCH HASN'T WORKED IN MONTHS, AND SEATS APPEAR TO REMAIN ON EVEN WHEN SWITCHED OFF), CONSOLE LIGHTS (CLIMATE CONTROL LIGHTS ARE NO LONGER ILLUMINATED AT NIGHT) & FUEL GAGE (STOPPED WORKING, HAD TO RESART THE VEHICLE TO GET IT FUNCTIONING AGAIN).
NHTSA ODI #729767
Mileage unknown · Aug 21, 2000
Electrical System
ALTERNATORS ON 1995 & 1996 MODELS WERE RECALLED, 1997 MODELS HAVE THE SAME PROBLEM, WHY NO RECALL?
NHTSA ODI #728593
Mileage unknown · Jul 26, 2000
Electrical System
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #726041
Mileage unknown · Jan 6, 2000
Electrical SystemUnknown Or Other
CHECK ENGINE LIGHT WENT ON - CAR DROVE WITHOUT INCIDENT - LIGHT WENT OUT- LIGHT WENT ON AGAIN, AND CAR BEGAN TO VIBRATE AND MAKE KNOCKING SOUNDS. WAS TAKEN TO DEALER, WHERE THEY FOUND WIRING DEFECTIVE. *AK
NHTSA ODI #716964
Mileage unknown · Oct 21, 1999
Electrical System
BATTERY EXPLODED AND DAMAGED THE HOOD OF THE VEHICLE. MJS
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FRONT COIL SPRINGS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW YORK, NEW JERSEY, NEW HAMPSHIRE, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS WERE PRODUCED WITH POOR PAINT QUALITY WHICH, AFTER CONTINUED EXPOSURE TO CORROSIVE SALT, CAN RESULT IN BREAKAGE OF THE SPRING.
Consequence & remedy
Consequence: DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE. SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.
Remedy: DEALERS WILL NOTIFIY CUSTOMERS TO BRING THEIR VEHICLE TO AN AUTHORIZE DEALERSHIP TO HAVE A SPRING GUARD INSTALLED ON BOTH FRONT STRUTS TO PREVENT TIRE PUNCTURE AND REPLACE ANY BROKEN SPRINGS FREE OF CHARGE. OWNER NOTIFICATION BEGAN SEPTEMBER 18, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
VEHICLE DESCRIPTION: PASSENGER STATION WAGON, SEDAN AND SPORT UTILITY VEHICLES. DUE TO IMPROPER WELDING, FRACTURES CAN OCCUR ON THE SUPPORT BRACKET OF THE FRONT TRANSVERSE LINK.
Consequence & remedy
Consequence: SUCH FRACTURES CAN RESULT IN PARTIAL OR COMPLETE SEPARATION OF THE BRACKET CAUSING A FAILURE OF THE LOWER SUSPENSION MOUNTING, LEADING TO A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL INSPECT AND REPLACE IF NECESSARY THE FRONT SUSPENSION SUPPORT BRACKETS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE THROTTLE SHAFT BALL BEARING ON THE SENSOR SIDE OF THE THROTTLE BODY ASSEMBLY WAS NOT INSTALLED IN CERTAIN THROTTLE BODIES.
Consequence & remedy
Consequence: OPERATION OF A VEHICLE WITH A MISSING THROTTLE SHAFT BEARING CAN EVENTUALLLY LEAD TO AN INCOMPLETE RETURN OF THE THROTTLE VALVE RESULTING IN A HIGH IDLING CONDITION.
Remedy: DEALERS WILL INSPECT THE THROTTLE BODY AND REPLACE THE THROTTLE ASSEMBLY IF THE BEARING IS MISSING.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. DUE TO POOR WELDS, IGNITION KEYS CAN STICK, SHIFT LEVERS/LINKAGES CAN BREAK AND SHIFT LEVERS CAN MOVE.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE UNEXPECTED MOVEMENT OF THE VEHICLE INCREASING THE RISK OF A CRASH OR PROPERTY DAMAGE.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION SHIFT LEVER ASSEMBLIES (EXCEPT THE HANDLE GRIP).
VEHICLE DESCRIPTION: PASSENGER VEHICLES. INSUFFICIENT CLEARANCE WITHIN THE HAZARD WARNING LIGHT SWITCH HOUSING CAN CAUSE A BINDING BETWEEN THE ACTUATING BUTTON AND THE HOUSING.
Consequence & remedy
Consequence: THE SWITCH COULD STICK IN AN INTERMEDIATE POSITION WHEN DEACTIVATING, RESULTING IN THE TURN SIGNALS BECOMING INOPERABLE.
Remedy: DEALERS WILL INSTALL A MODIFIED HAZARD WARNING SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE99067 · Electrical System
Opened Nov 1, 1999 · Closed May 31, 2000
Status: closed (inferred from source dates) · Electrical System
ODI HAS RECEIVED 5,820 COMPLAINTS CONCERNING A VARIETY OF ELECTRICAL SYSTEM FAILURES THAT RESULT IN THE VEHICLE STALLING.OUR COMPLAINT ANALYSIS INDICATES THAT THE MAJORITY OF THESE COMPAINTS ARE CAUSED BY ALTERNATOR FAILURE.IN SOME INSTANCES, THE VEHICLE IS COMPLETELY DEAD AND WILL NOT RESTART.BASED ON OUR INVESTIGATION AND THE MANUFACTURER'S RESPOMSE, ODI IS CLOSING THIS INVESTIGATION BECAUSE THE MANUFACTURER HAS AGREED TO PERFORM THE OWNER NORTIFICATION PROGRAM CITED ABOVE, INCLUDING QUARTERLY NOTIFICATIONS TO ODI.THIS PROGRAM ALLOWS OWNERS TO GET THEIR ALTERNATOR REPLACED FOR FREE.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTINUE TO MONITOR THIS MATTER CLOSELY, AND THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THESE MODELS IF WARRANTED BY THE CIRCUMSTANCES.
1997 Subaru Legacy Problems, Complaints & Recalls | Skip That Year
Illustration