IllustrationABS ACTIVATING FOR NO REASON ON ROUGH SURFACE (GRAVEL COVERED ROADWAY) CAUSING BRAKING DISTANCE TO INCREASE SIGNIFICANTLY...NOT THE FIRST TIME EITHER. NOT HARD BRAKING, JUST ONE ON AN UNEVEN SURFACE.*AK
2002 Subaru Impreza
Owner reports · Recalls · Investigations
More warning signs than most Impreza years
Owner complaints for the 2002 Subaru Impreza are substantially higher than the model-year median of 56.
About this comparison →How this year compares
Owner complaints by model year
Compare all Impreza years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
280–25K
4425–50K
4250–75K
2475–100K
33100–150K
24150K+
195 reports with mileage · 97 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 88 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports3 fire reports8 injury reports
Service Brakes, Hydraulic complaints
56 reportsWHILE COMING TO A STOP AT ABOUT 30-35 MPH, THE BRAKES STOPPED WORKING FOR ABOUT 1-2 SECONDS. AT THE SAME TIME, THE FEEL OF THE BRAKE PEDAL SEEMED TO INDICATE THAT THE ABS SYSTEM HAD BEEN ACTIVATED. CAN'T RECALL IF THIS WAS OVER A BUMPY ROAD AS MENTIONED IN EARLIER COMPLAINTS. HAS OCCURRED AT LEAST TWICE - VERY SCARY AND DANGE…
Read full complaint
WHILE COMING TO A STOP AT ABOUT 30-35 MPH, THE BRAKES STOPPED WORKING FOR ABOUT 1-2 SECONDS. AT THE SAME TIME, THE FEEL OF THE BRAKE PEDAL SEEMED TO INDICATE THAT THE ABS SYSTEM HAD BEEN ACTIVATED. CAN'T RECALL IF THIS WAS OVER A BUMPY ROAD AS MENTIONED IN EARLIER COMPLAINTS. HAS OCCURRED AT LEAST TWICE - VERY SCARY AND DANGEROUS.
ABS FAILED RESULTING IN CAR CRASH. TS
WITH PREVIOUS REPORTS BY CONSUMERS ON NHTSA CONCERNING THIS ISSUE. UNTIL SUBARU ADDRESSES THIS DESIGN FLAW, IT IS AN AWARENESS ISSUE THAT OWNERS MUST RECOGNIZE AND ADJUST THEIR DRIVING HABITS ACCORDINGLY TO COMPENSATE FOR. I HAVE TAKEN MY VEHICLE INTO AN EMPTY PARKING LOT ON THE WEEKEND AND TESTED THE BRAKE PERFORMANCE FULLY,…
Read full complaint
WITH PREVIOUS REPORTS BY CONSUMERS ON NHTSA CONCERNING THIS ISSUE. UNTIL SUBARU ADDRESSES THIS DESIGN FLAW, IT IS AN AWARENESS ISSUE THAT OWNERS MUST RECOGNIZE AND ADJUST THEIR DRIVING HABITS ACCORDINGLY TO COMPENSATE FOR. I HAVE TAKEN MY VEHICLE INTO AN EMPTY PARKING LOT ON THE WEEKEND AND TESTED THE BRAKE PERFORMANCE FULLY, AND THEREFORE THE ABS, BOTH IN A STRAIGHT LINE AND WHILE TURNING VERY SLIGHTLY. ABS PERFORMANCE IS AS EXPECTED IN BOTH WET AND DRY PROVIDED THAT THE ROAD SURFACE WAS PERFECTLY SMOOTH. HOWEVER, EVEN MINOR BUMPS, RIPPLES OR IRREGULARITIES IN THE PAVEMENT REDUCED THE BRAKING POWER BY AT LEAST 50%, IN MY ESTIMATION, AND THE BRAKE PEDAL ITSELF DEPRESSES AN ADDITIONAL 1-2 INCHES FURTHER THAN EXPERIENCED UNDER NORMAL DRIVING CONDITIONS. AGAIN, THIS IS CONSISTENT IN BOTH WET AND DRY CONDITIONS. MY VEHICLE IS ENTIRELY STOCK AND HAS NOT BEEN RACED OFF ROAD, RALLIED OR AUTOCROSSED, ALL OF WHICH INCUR GREATER WEAR AND TEAR ON THE VEHICLE. ALSO, I HAVE NOT TAKEN THE VEHICLE IN TO A DEALER BECAUSE I BELIEVED IT TO BE A DESIGN FLAW, WHICH HAS ONLY BEEN CONFIRMED BY SIMILAR REPORTS I HAVE READ ON THE NHTSA WEBSITE. IN THE NORTHEAST, WHERE THE ROADS ARE FREQUENTLY IN POOR CONDITION DUE TO FROST HEAVES AND OTHER EFFECTS OF HARSH WEATHER, I HAVE ALTERED MY DRIVING HABITS ON THE LOCAL ROADS TO AVOID THE STREETS THAT HAVE PAVEMENT IRREGULARITIES NEAR OR IN THE BRAKING AREAS. GIVEN SUBARU'S IMPRESSIVE FOCUS ON SAFETY, HOPEFULLY THEY CAN AND WILL RESOLVE THIS ISSUE BEFORE ANY FATALITIES RESULT. DT
NO DESCRIPTION GIVEN. NLM
RANDOMLY WHILE MODERATELY BRAKING ON DRY NORMAL TEXTURED PAVEMENT ABS SYSTEM WILL ENGAGE, THIS CAUSES A MAJOR AND DANGEROUS LOSS OF BRAKING POWER AND PEDAL PRESSURE. IN ORDER TO RESTORE SOME BRAKING POWER THE BRAKE PEDAL MUST BE DISENGAGED COMPLETELY AND THEN HAVE PRESSURE REAPPLIED. THIS WILL RESULT IN ABOUT 3/4 OF THE NORMAL B…
Read full complaint
RANDOMLY WHILE MODERATELY BRAKING ON DRY NORMAL TEXTURED PAVEMENT ABS SYSTEM WILL ENGAGE, THIS CAUSES A MAJOR AND DANGEROUS LOSS OF BRAKING POWER AND PEDAL PRESSURE. IN ORDER TO RESTORE SOME BRAKING POWER THE BRAKE PEDAL MUST BE DISENGAGED COMPLETELY AND THEN HAVE PRESSURE REAPPLIED. THIS WILL RESULT IN ABOUT 3/4 OF THE NORMAL BRAKING POWER. IF THE ABS ENGAGES AGAIN THE PROCESS MUST BE REPEATED. THIS ENTIRE PROCESS CAUSES BRAKING DISTANCE TO SUBSTANTIALLY INCREASE FROM THE EXPECTED AMOUNT.*AK
TRAVELING ALONG A STRAIGHT, DRY, PAVED ROAD. SPEED APPROX 50MPH. ENCOUNTERED A SITUATION REQUIRING AGGRESSIVE BRAKING (APPROX 75-80%). WHILE BRAKING, CAR CROSSED A SMALL BUMP, ABS ENGAGED FOR AN EXTENDED TIME AND BRAKING POWER WAS ALMOST COMPLETELY LOST. SEVERAL CAR LENGTHS LATER (ROAD FREE FROM IMPERFECTIONS NOW), ABS WAS ST…
Read full complaint
TRAVELING ALONG A STRAIGHT, DRY, PAVED ROAD. SPEED APPROX 50MPH. ENCOUNTERED A SITUATION REQUIRING AGGRESSIVE BRAKING (APPROX 75-80%). WHILE BRAKING, CAR CROSSED A SMALL BUMP, ABS ENGAGED FOR AN EXTENDED TIME AND BRAKING POWER WAS ALMOST COMPLETELY LOST. SEVERAL CAR LENGTHS LATER (ROAD FREE FROM IMPERFECTIONS NOW), ABS WAS STILL MODULATING AND THERE WAS STILL VIRTUALLY NO BRAKING POWER. DISTANCE REQUIRED TO STOP WAS *MUCH* LONGER THAN IT SHOULD HAVE BEEN. PROBLEM HAS ALSO OCCURED X2 AT LOW SPEED, NEARING A STOP SIGN, HIT A POTHOLE....LOST BRAKING UNTIL ABSOLUTE LAST SECOND, BARELY STOPPED IN TIME. SEEMS AS THOUGH ABS UNIT IS CONFUSED, AS IF THE WHEELS WITH TRACTION ARE BEING MODULATED WHILE THE TIRE THAT HIT THE BUMP AND HAS POOR TRACTION (POSSIBLY AIRBORNE MOMENTARILY?) IS GETTING BRAKING POWER, THUS RENDERING THE CAR WITH LITTLE STOPPING ABILITY AT ALL. VERY DANGEROUS, I WAS LUCKY IT WAS NOT AN ANIMAL/CHILD/CAR THAT I WAS TRYING TO AVOID. DEFINITELY DANGEROUS, AND NOT NORMAL ABS OPERATION.
VEHICLE'S ABS CONTROLLER WENT BAD, ABS WAS GETTING ACTIVATED EVER IN A DRY NON SLIP CONDITION, CONTACTED DEALER, AND THEY REPLACED THE ABS CONTROLLER. REPORTED PROBLEM ABOUT ENGINE VIBRATION AT IDLE SPEED, DEALER REFUSES TO ACCEPT IT, COMPARED WITH A NEW VEHICLE AT DEALER'S STOCK AND THE VIBRATION IN MY VEHICLE WAS DISTINGUISHAB…
Read full complaint
VEHICLE'S ABS CONTROLLER WENT BAD, ABS WAS GETTING ACTIVATED EVER IN A DRY NON SLIP CONDITION, CONTACTED DEALER, AND THEY REPLACED THE ABS CONTROLLER. REPORTED PROBLEM ABOUT ENGINE VIBRATION AT IDLE SPEED, DEALER REFUSES TO ACCEPT IT, COMPARED WITH A NEW VEHICLE AT DEALER'S STOCK AND THE VIBRATION IN MY VEHICLE WAS DISTINGUISHABLE. STILL DEALER REFUSES TO ACCEPT IT. CONTACTED 1-800-SUBARU3 AND THEY SAID THAT THEY WOUL DGET IN TOUCH WITH THE DEALERSHIP AND SEE WHATS GOING ON.*AK
FAILURE WAS AN EXTREME INCREASE IN STOPPING DISTANCE FOR NO APPARENT REASON ON DRY PAVEMENT. BRAKE PEDAL WENT NEARLY TO FLOOR , NO PEDAL PULSING, BUT ONLY ABOUT 30% OF NORMAL BRAKE FORCE AVAILABLE INSPITE OF EXTREME PRESSURE ON PEDAL. NARROWLY AVOIDED HEAD ON WITH CARS IN ONCOMING LANES WHILE ATTEMPTING LEFT TURN. LACK OF BRAKE…
Read full complaint
FAILURE WAS AN EXTREME INCREASE IN STOPPING DISTANCE FOR NO APPARENT REASON ON DRY PAVEMENT. BRAKE PEDAL WENT NEARLY TO FLOOR , NO PEDAL PULSING, BUT ONLY ABOUT 30% OF NORMAL BRAKE FORCE AVAILABLE INSPITE OF EXTREME PRESSURE ON PEDAL. NARROWLY AVOIDED HEAD ON WITH CARS IN ONCOMING LANES WHILE ATTEMPTING LEFT TURN. LACK OF BRAKE EFFORT RESULTED IN EXCESSIVE SPEED FOR SAFE LEFT TURN.*AK
I WAS GOING TO OLYMPUS GYM IN SPRINGFIELD, VA, PULLING INTO THE FAR END OF THE PARKING LOT (THE LOT IS EMPTY). THE LOT WAS CLEAN, DRY ASPHALT WITH A COUPLE OF ROCKS SCATTERED ON IT (CLUE?). I PULL IN QUICK TO THE LOT (A RIGHT TURN FROM THE STREET 90 DEGREES) DON'T KNOW HOW FAST BUT NOT WORRISOME. THEN PULL A 180 DEGREE LEFT TURN…
Read full complaint
I WAS GOING TO OLYMPUS GYM IN SPRINGFIELD, VA, PULLING INTO THE FAR END OF THE PARKING LOT (THE LOT IS EMPTY). THE LOT WAS CLEAN, DRY ASPHALT WITH A COUPLE OF ROCKS SCATTERED ON IT (CLUE?). I PULL IN QUICK TO THE LOT (A RIGHT TURN FROM THE STREET 90 DEGREES) DON'T KNOW HOW FAST BUT NOT WORRISOME. THEN PULL A 180 DEGREE LEFT TURN TO COME INTO THE PARKING SPACE BRAKING FAIRLY HARD AS I GO. KEEPING ON THE BRAKES I THINK I'LL COME TO A STOP, BUT, THE ABS ACTIVATES WITH 7 FEET LEFT IN THE SPOT. STAYS RELEASED ALL THE WAY TO THE END WHERE I BUMP INTO THE POLE AT THE END OF THE SPOT MARKING MY BUMPER BADLY. I DID NOT EVEN TRY TO COME OFF THE BRAKES AND BACK ON TO RESET (I SHOULD HAVE). I JUST HELD THE BRAKE PRAYING THEY WOULD COME BACK. WHEN THE ABS ACTIVATED, MY HEAD JERKED BACK INTO THE HEAD REST AND STAYED THERE (AT LEAST HALF A SECOND) UNTIL I HIT THE POLE. THE ABS RELEASED THE BRAKES (ALL FOUR) AND LEFT THEM RELEASED. *AK
Official recalls
611V464000 · Suspension:front:control Arm:lower Arm
Sep 6, 2011
SUBARU IS RECALLING CERTAIN MODEL YEAR 2002-2007 IMPREZA, MODEL YEAR 2003-2008 FORESTER, AND MODEL YEAR 2005-2006 SAAB 9-2X VEHICLES MANUFACTURED FROM SEPTEMBER 5, 2000 THROUGH NOVEMBER 26, 2007 ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, MASSACHUSETTS, MARYLAND, MICHIGAN, NEW HAMPSHIRE, NEW YORK, PENNSYLVANIA, VERMONT, WISCONSIN, CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, MAINE, MINNESOTA, MISSOURI, NEW JERSEY, OHIO, RHODE ISLAND, WEST VIRGINIA AND THE DISTRICT OF COLUMBIA. THE FRONT LOWER CONTROL ARMS MAY BREAK AT THE HANGER BRACKETS DUE TO CORROSION IF THE HANGER BRACKET IS EXPOSED TO SALTY AND HUMID ENVIRONMENTS SUCH AS ROADS CONTAINING SNOW MELTING AGENT.
Consequence & remedy
Consequence: A BROKEN CONTROL ARM CAN RESULT IN THE LOSS OF CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: SUBARU WILL HANDLE THEIR VEHICLES AND SAAB WILL HANDLE THEIRS. DEALERS WILL INSPECT THE DEGREE OF CORROSION OF THE FRONT LOWER CONTROL ARMS, AND WILL EITHER RUSTPROOF OR REPLACE THEM. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2011. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
09V468000 · Fuel System, Gasoline:delivery:fuel Pump
Dec 4, 2009
SUBARU IS RECALLING CERTAIN MODEL YEAR 2002 AND 2003 IMPREZA WRX VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF SOUTH DAKOTA, NEBRASKA, NORTH DAKOTA, MINNESOTA, IDAHO, IOWA, MONTANA, COLORADO, WISCONSIN, NEW YORK, WYOMING, MICHIGAN, ALASKA, NEW HAMPSHIRE, VERMONT, AND MAINE. DURING COLD STARTS, TYPICALLY UNDER EXTREMELY COLD TEMPERATURES, FUEL LEAKS IN THE FUEL DELIVERY LINE COULD OCCUR WHERE THE LINE CONNECTS WITH A RUBBER HOSE.
Consequence & remedy
Consequence: FUEL LEAKS, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL LINE FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 31, 2009. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783.
08V135000 · Latches/locks/linkages:tailgate:latch
Mar 24, 2008
SUBARU IS RECALLING 36,791 MY 2002-2003 IMPREZA WAGONS. THE STUD BOLT(S) OF REAR GATE STAY MAY HAVE BEEN TIGHTENED WITH INSUFFICIENT TIGHTENING TORQUE AND A GAP MAY HAVE RESULTED BETWEEN THE REAR GATE PANEL AND STUD BOLT BASE. AFTER REPEATED REAR GATE OPERATIONS (OPENING AND CLOSING), THE REAR GATE INNER PANEL AT THE WELDING NUT MAY BREAK, WHICH WILL LEAD TO DETACHMENT OF THE REAR GATE STAY, AND THE REAR GATE DROPPING DOWN.
Consequence & remedy
Consequence: IN CASE SOMEONE IS UNDERNEATH OR NEAR THE REAR GATE, THERE IS A POSSIBILITY THAT A DROPPING REAR GATE PANEL MAY HIT THEM INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT TO SEE IF THERE IS ANY GAP AT THE STUD BOLT OF THE REAR GATE STAY INSTALLATION. IF A GAP IS FOUND, THE STUD BOLT WILL BE REMOVED TO CHECK FOR DAMAGE TO THE WELDING NUT. IF THE WELD NUT IS CRACKED, THE REAR GATE STAY WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 2, 2008. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783.
04V342000 · Seats
Jul 14, 2004
ON CERTAIN SEDAN AND WAGON MODEL VEHICLES, THE LEFT FRONT BOLT THAT RETAINS THE FORWARD PART OF THE DRIVER'S SEAT TO THE SEAT SLIDE RAIL MAY LOOSEN. IF THE SEAT SLIDE RAIL BOLT LOOSENS, IT WILL EVENTUALLY FALL OUT, AND THE SEAT MAY SEPARATE FROM THE SEAT SLIDE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVER MAY SUSTAIN MORE SEVERE INJURIES DUE TO THE SEAT MOVEMENT.
Remedy: DEALERS WILL INSTALL A NEW LEFT HAND DRIVER'S SEAT RAIL MOUNTING BOLT. THE RECALL BEGAN ON AUGUST 20, 2004. OWNERS SHOULD CONTACT SUBARU AT 1-800-782-2783.
04V128000 · Vehicle Speed Control:cables
Mar 16, 2004
ON CERTAIN PASSENGER SEDANS, WAGONS, AND SPORT UTILITY VEHICLES, THE CRUISE CONTROL CABLE COULD COME OUT OF ITS TRACK ON THE CRUISE CONTROL LEVER AND LODGE ON THE CONTROL LEVER TAB WHEN THE ACCELERATOR PEDAL IS RELEASED. IF THIS CONDITION OCCURS, THE THROTTLE WILL NOT RETURN TO THE IDLE POSITION AND WILL REMAIN IN AN OPEN POSITION.
Consequence & remedy
Consequence: IF THIS OCCURS DURING VEHICLE OPERATION, THE DRIVER COULD LOSE CONTROL OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A CRUISE CONTROL CABLE RETAINING CLIP TO THE CRUISE CONTROL LEVER TAB ON THE THROTTLE SHAFT IN ORDER TO PREVENT THE CRUISE CONTROL CABLE FROM COMING OUT OF ITS TRACK. OWNER NOTIFICATION BEGAN ON APRIL 12, 2004. OWNERS SHOULD CONTACT SUBARU AT 1-800-782-2783.
02V282000 · Power Train:automatic Transmission
Oct 30, 2002
CERTAIN SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS WERE PRODUCED WITH AN IMPROPERLY MANUFACTURED TRANSMISSION PARKING ROD. WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE "P" (PARK) POSITION, THE TRANSMISSION PARK MECHANISM, THAT IS INTENDED TO HOLD YOUR VEHICLE, MAY NOT ENGAGE.
Consequence & remedy
Consequence: THE VEHICLE COULD THEN MOVE/ROLL WITHOUT PRIOR WARNING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION PARKING ROD ASSEMBLY. OWNER NOTIFICATION JANUARY 8, 2003. AN INTERIM OWNER NOTIFICATION WILL BE SENT DURING NOVEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE11011 · Front Suspension Control Arm Failure
Opened Apr 7, 2011 · Closed Sep 23, 2011
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Additional source detail variants (4)
Suspension:front:control Arm:lower Arm
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Suspension:front:control Arm
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Suspension:front
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Suspension
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
EA09011 · Fuel Line Leak
Opened Jul 2, 2009 · Closed Dec 14, 2009
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
THE DESIGN OF THE FUEL LINE (METAL RAIL/RUBBER HOSE INTERFACE) IS SUSCEPTIBLE TO FUEL ODOR AND/OR SEEPAGE IN EXTREME COLD TEMPERATURE CONDITIONS.OWNERS MOST OFTEN NOTICED FUEL ODOR IN THE OCCUPANT COMPARTMENT AREA DURING INITIAL COLD ENGINE START-UP.ONCE THE ENGINE IS WARMED, THE ODOR/SEEPAGE ISSUE DISSIPATES.FROM SUBARU'S DATA, ODI NOTES THAT THE INCIDENT RATES ARE HIGHER IN STATES WITH COLDER TEMPERATURES.THERE WAS ONE ALLEGATION OF A FIRE INCIDENT IN WHICH THE OWNER HAD REPORTED THAT HE NOTICED FUEL ODOR A FEW DAYS EARLIER, BUT ODI COULD NOT CONFIRM THE ORIGIN OF THE FIRE. TO ADDRESS THIS ISSUE, SUBARU WILL REPLACE THE FUEL LINE WITH A LONGER RUBBER HOSE SEGMENT VERSION/DESIGN ON 5,724 MY 2002-2003 VEHICLES BUILT THROUGH SEPTEMBER 12, 2002 IN 16 STATES (AK, CO, IA, ID, ME, MI, MN, MT, ND, NE, NH, NY, SD, VT, WI & WY).IN ADDITION, SUBARU WILL EXTEND THE WARRANTY COVERAGE TO 12 YEARS/UNLIMITED MILEAGE ON VEHICLES IN THE REMAINING 34 STATES.THIS ENGINEERING ANALYSIS IS CLOSED (SEE RECALL CAMPAIGN 09V-468)
PE09017 · Fuel Line Leak
Opened Mar 10, 2009 · Closed Jul 2, 2009
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:carburetor System; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:fuel Injection System; Fuel System, Gasoline:fuel Injection System:fuel Rail; Fuel System, Gasoline:fuel Injection System:injectors; Fuel System, Other; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings; Fuel System, Other:fuel Injection System
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Additional source detail variants (11)
Fuel System, Gasoline:carburetor System
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Gasoline:delivery:fuel Pump
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Gasoline:delivery
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Gasoline:fuel Injection System:fuel Rail
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Gasoline:fuel Injection System:injectors
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Gasoline:fuel Injection System
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Gasoline
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Other:fuel Injection System
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Other
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
PE04002 · Fuel Line Leakage In Engine Compartment
Opened Jan 7, 2004 · Closed May 27, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
SUBARU REPORTS THAT THE FUEL ODOR IS CAUSED BY FUEL SEEPAGE DURING COLD START OF THE ENGINE UNDER EXTREMELY COLD TEMPERATURES. THE LEAK OCCURS IN A FUEL LINE IN THE ENGINE COMPARTMENT.IT REPORTS THAT THE FAILURE IS DUE TO THE MISALIGNED ANGLE BETWEEN TWO FUEL DELIVERY LINES WHICH RESULTED IN SUCH FUEL SEEPAGE DURING THE FIRST FEW SECONDS OF COLD ENGINE START DURING THESE COLD TEMPERATURES.SUBARU REPORTS THAT THE TWO FUEL LINES ARE CONNECTED WITH A HOSE THAT BECOMES TOO STIFF IN VERY COLD TEMPERATURES TO CONFORM TO THE MISALIGNMENT. SUBARU HAS ISSUED A TECHNICAL SERVICE BULLETIN (SUBARU SERVICE BULLETIN NUMBER 09-36-03) TO REPLACE THE FUEL LINES WITH NEW LINES THAT ARE PROPERLY ALIGNED AND THAT HAVE A LONGER CONNECTING HOSE.ODI PHONE CALLS TO MANY OF THE COMPLAINANTS CONFIRM THAT FUEL ODOR IS NOTICABLE DURING VERY COLD TEMPERATURES AND COLD START BUT GOES AWAY AS THE ENGINE WARMS UP, AND THE ODOR IS NOT PRESENT IN WARMER TEMPERATURES. A FEW OWNERS REPORT THAT ATTEMPTS TO ELIMINATE THE LEAKAGE BY TIGHTENING THE CONNECTING HOSE CLAMPS IS NOT EFFECTIVE IN ELIMINATING THE FUEL ODOR.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
SUBARU REPORTS THAT THE FUEL ODOR IS CAUSED BY FUEL SEEPAGE DURING COLD START OF THE ENGINE UNDER EXTREMELY COLD TEMPERATURES. THE LEAK OCCURS IN A FUEL LINE IN THE ENGINE COMPARTMENT.IT REPORTS THAT THE FAILURE IS DUE TO THE MISALIGNED ANGLE BETWEEN TWO FUEL DELIVERY LINES WHICH RESULTED IN SUCH FUEL SEEPAGE DURING THE FIRST FEW SECONDS OF COLD ENGINE START DURING THESE COLD TEMPERATURES.SUBARU REPORTS THAT THE TWO FUEL LINES ARE CONNECTED WITH A HOSE THAT BECOMES TOO STIFF IN VERY COLD TEMPERATURES TO CONFORM TO THE MISALIGNMENT. SUBARU HAS ISSUED A TECHNICAL SERVICE BULLETIN (SUBARU SERVICE BULLETIN NUMBER 09-36-03) TO REPLACE THE FUEL LINES WITH NEW LINES THAT ARE PROPERLY ALIGNED AND THAT HAVE A LONGER CONNECTING HOSE.ODI PHONE CALLS TO MANY OF THE COMPLAINANTS CONFIRM THAT FUEL ODOR IS NOTICABLE DURING VERY COLD TEMPERATURES AND COLD START BUT GOES AWAY AS THE ENGINE WARMS UP, AND THE ODOR IS NOT PRESENT IN WARMER TEMPERATURES. A FEW OWNERS REPORT THAT ATTEMPTS TO ELIMINATE THE LEAKAGE BY TIGHTENING THE CONNECTING HOSE CLAMPS IS NOT EFFECTIVE IN ELIMINATING THE FUEL ODOR.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Gasoline
SUBARU REPORTS THAT THE FUEL ODOR IS CAUSED BY FUEL SEEPAGE DURING COLD START OF THE ENGINE UNDER EXTREMELY COLD TEMPERATURES. THE LEAK OCCURS IN A FUEL LINE IN THE ENGINE COMPARTMENT.IT REPORTS THAT THE FAILURE IS DUE TO THE MISALIGNED ANGLE BETWEEN TWO FUEL DELIVERY LINES WHICH RESULTED IN SUCH FUEL SEEPAGE DURING THE FIRST FEW SECONDS OF COLD ENGINE START DURING THESE COLD TEMPERATURES.SUBARU REPORTS THAT THE TWO FUEL LINES ARE CONNECTED WITH A HOSE THAT BECOMES TOO STIFF IN VERY COLD TEMPERATURES TO CONFORM TO THE MISALIGNMENT. SUBARU HAS ISSUED A TECHNICAL SERVICE BULLETIN (SUBARU SERVICE BULLETIN NUMBER 09-36-03) TO REPLACE THE FUEL LINES WITH NEW LINES THAT ARE PROPERLY ALIGNED AND THAT HAVE A LONGER CONNECTING HOSE.ODI PHONE CALLS TO MANY OF THE COMPLAINANTS CONFIRM THAT FUEL ODOR IS NOTICABLE DURING VERY COLD TEMPERATURES AND COLD START BUT GOES AWAY AS THE ENGINE WARMS UP, AND THE ODOR IS NOT PRESENT IN WARMER TEMPERATURES. A FEW OWNERS REPORT THAT ATTEMPTS TO ELIMINATE THE LEAKAGE BY TIGHTENING THE CONNECTING HOSE CLAMPS IS NOT EFFECTIVE IN ELIMINATING THE FUEL ODOR.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.