IllustrationI HAVE TROUBLE MAKING TURNS FOR IT HESITATES BEFORE IT WILL KICK IN,YESTERDAY I WAS ALMOST HIT BY A POLICE CAR GOING ON A CALL, LIGHTS/SIREN ON . I JUST MADE A TURN AND IT HESITATED ICOULDN'T GET OUT OF HIS WAY. THIS IS AN ONGOING PROBLEM WITH THIS CAR.
2018 Subaru Forester
Owner reports · Recalls · Investigations
More warning signs than most Forester years
Owner complaints for the 2018 Subaru Forester are substantially higher than the model-year median of 131.
About this comparison →How this year compares
Owner complaints by model year
Compare all Forester years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1560–25K
6525–50K
1350–75K
575–100K
2100–150K
0150K+
241 reports with mileage · 252 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility/wiper. Review the 135 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 96 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports1 fire reports6 injury reports
What owners actually said
493 reportsI WAS DRIVING ON I-95 IN FAIRFIELD CT AND STARTED TO ACCELERATE TO MERGE WITH TRAFFIC WHEN MY CAR STARTED TO RACE. I IMMEDIATELY TRIED TO BRAKE, I NEEDED TO PRESS VERY HARD ON THE BRAKE PEDDLE FOR THE CAR TO STOP ACCELERATING. AS SOON AS I TOOK MY FOOT OFF THE BRAKE, THE CAR ACCELERATED AGAIN AT A VERY HIGH SPEED. WHEN I WAS BRA…
Read full complaint
I WAS DRIVING ON I-95 IN FAIRFIELD CT AND STARTED TO ACCELERATE TO MERGE WITH TRAFFIC WHEN MY CAR STARTED TO RACE. I IMMEDIATELY TRIED TO BRAKE, I NEEDED TO PRESS VERY HARD ON THE BRAKE PEDDLE FOR THE CAR TO STOP ACCELERATING. AS SOON AS I TOOK MY FOOT OFF THE BRAKE, THE CAR ACCELERATED AGAIN AT A VERY HIGH SPEED. WHEN I WAS BRAKING, I COULD NOT CONTROL THE BRAKE SPEED, IT SEEMED LIKE THE CAR WAS SHUTTING OFF SO I REMOVED MY FOOT FROM THE BRAKE. THIS HAPPENED FOUR MORE TIMES UNTIL I WAS ABLE TO GET OVER TO AN OFF RAMP AND SHUT THE CAR DOWN. THE CAR SMELLED LIKE SOMETHING BURNING. I HAD THE CAR TOWED TO SUBARU DEALER.
WHEN DRIVING FORWARD ON LEVEL ROAD, THE VEHICLE DRIFTS OR GOES TO THE RIGHT. I MUST KEEP TURNING THE STEERING WHEEL TO THE LEFT TO CORRECT THIS PROBLEM. I NOTICE WHEN THE VEHICLE DRIFTS TO THE RIGHT SIDE, STEERING WHEEL MAINTAINS A CENTERED POSITION.
2018 SUBARU FORESTER 2.5I AUTOMATIC CVT: DEFECTIVE LOW GEAR - SAFETY ISSUE. 21 DAYS AFTER PURCHASE TOOK IT TO DURANGO COLORADO MOUNTAINS, PUT IT IN LOW GEAR BEFORE DESCENDING AND THE LOW GEAR NEVER KICKED IN TO SLOW THE VEHICLE DOWN. STOPPED MULTIPLE TIMES TO RE-ATTEMPT AND LOW GEAR FAILED EACH TIME. I DARED ONLY 40MPH ON THE GR…
Read full complaint
2018 SUBARU FORESTER 2.5I AUTOMATIC CVT: DEFECTIVE LOW GEAR - SAFETY ISSUE. 21 DAYS AFTER PURCHASE TOOK IT TO DURANGO COLORADO MOUNTAINS, PUT IT IN LOW GEAR BEFORE DESCENDING AND THE LOW GEAR NEVER KICKED IN TO SLOW THE VEHICLE DOWN. STOPPED MULTIPLE TIMES TO RE-ATTEMPT AND LOW GEAR FAILED EACH TIME. I DARED ONLY 40MPH ON THE GRAVELLY SWITCHBACKS. MANUFACTURER & DEALER REFUSED TO ACKNOWLEDGE DEFECT EVEN THOUGH I RECORDED ANOTHER INSTANCE ON TEXAS HILLS. MECHANIC SHOP IN THE AREA SAID THAT THE CAR HAS NO LOW GEAR FAILURE LIGHT SO DIAGNOSTIC MACHINES WILL NEVER BE ABLE TO PICK UP A CODE THAT DOES NOT EXIST. THE MANUFACTURER REFUSED TO FIX ISSUE AND DEALER SAID DIAGNOSTIC MACHINE DID NOT FIND ANYTHING. I GAVE BOTH THE VIDEO OF LOW GEAR FAILURE AND A JAPANESE & USA ARTICLE ON HOW LOW GEAR WORKS. I OFFERED EVEN EXCHANGE FOR A MANUAL PREMIUM. NO RESOLUTION.
SUN GLARE THAT BLINDS THE DRIVER WHEN SUN REFLECTS OFF THE SOUND SYSTEM SCREEN WHILE DRIVING.
PAGE 9-6 FIGURE 8 OF THE OWNERS MANUAL SHOWS HOW TO PLACE THE JACK ON THE FRAME TO RAISE THE CAR TO CHANGE A TIRE. THE PROBLEM IS THAT WHEN YOU REEF DOWN ON EITHER LOOSENING OR TIGHTENING THE TIRE, THE CAR WILL ROCK EITHER FORWARD OF BACKWARDS AND SLIDE OFF OF THE JACK. THE CAR WILL THEN FALL FORWARDS OR BACKWARDS DROPPING THE…
Read full complaint
PAGE 9-6 FIGURE 8 OF THE OWNERS MANUAL SHOWS HOW TO PLACE THE JACK ON THE FRAME TO RAISE THE CAR TO CHANGE A TIRE. THE PROBLEM IS THAT WHEN YOU REEF DOWN ON EITHER LOOSENING OR TIGHTENING THE TIRE, THE CAR WILL ROCK EITHER FORWARD OF BACKWARDS AND SLIDE OFF OF THE JACK. THE CAR WILL THEN FALL FORWARDS OR BACKWARDS DROPPING THE CAR TO THE GROUND, POTENTIALLY INJURING THE PERSON CHANGING THE TIRE. THE CAR FELL TWICE WHEN I WAS TRYING TO CHANGE THE TIRE. THIS CAN BE EASILY RESOLVED BY HAVING A JACK THAT FITS SNUGLY WITH THE MOUNT POINTS ON THE CAR SO THAT THERE IS NO POSSIBILITY OF THE CAR MOVING AS THE PERSON IS TIGHTENING OR LOOSING THE LIRE LUG BOLTS. THE CAR WAS IN PARK WITH THE HAND BRAKE SET, YET WILL STILL MOVE SLIGHTLY AS THE PERSON PRESSES HARD ON THE LUG WRENCH. THE CAR COULD FALL ONTO THE PERSON EITHER INJURING THEM OR TRAPPING THEM UNDER THE CAR. THE CAR NEEDS TO COME WITH THE CORRECT JACK, WHICH WOULD SOLVE THIS PROBLEM. PHOTO 109 SHOWS HOW THE JACK IS TOO NARROW FOR THE SLOTS ON THE FRAME, THE JACK HEAD SHOULD BE ABOUT A HALF INCH WIDER TO FIT SNUGLY WITH THE CAR FRAME. FILE 105 SHOWS HOW CLOSE THE JACK HEAD WHEN CENTERED IS NEXT TO THE FRAME SLOTS.
TL* THE CONTACT OWNS A 2018 SUBARU FORSTER. APPROXIMATELY ONE MONTH AFTER PURCHASING THE VEHICLE, A CRACK SUDDENLY APPEARED IN THE WINDSHIELD. AFTER HAVING THE WINDSHIELD REPLACED WEEKS LATER, ANOTHER CRACK WAS PRESENT AFTER A SMALL PEBBLE MADE CONTACT WITH THE WINDSHIELD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTU…
Read full complaint
TL* THE CONTACT OWNS A 2018 SUBARU FORSTER. APPROXIMATELY ONE MONTH AFTER PURCHASING THE VEHICLE, A CRACK SUDDENLY APPEARED IN THE WINDSHIELD. AFTER HAVING THE WINDSHIELD REPLACED WEEKS LATER, ANOTHER CRACK WAS PRESENT AFTER A SMALL PEBBLE MADE CONTACT WITH THE WINDSHIELD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER (DAY APOLLO SUBARU IN MOON TOWNSHIP, PA) WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 6,000.
SUNDAY APRIL8 2018, THE 'EYESIGHT' WHICH IS A SAFETY DEVICE WAS POSSIBLY TURNED OFF REMOTELY, THUS RENDERING THIS SAFETY DEVICE INOPERABLE AND COULD CAUSE THE VEHICLE TO GET INTO AN ACCIDENT WITHOUT ANY WARNING, THE SAFETY DEVICE WARNS YOU IF YOU CROSS OVER THE CENTER OR SHOULDER TRAFFIC LINE. THIS IS THE SECOND TIME IT HAPPENED…
Read full complaint
SUNDAY APRIL8 2018, THE 'EYESIGHT' WHICH IS A SAFETY DEVICE WAS POSSIBLY TURNED OFF REMOTELY, THUS RENDERING THIS SAFETY DEVICE INOPERABLE AND COULD CAUSE THE VEHICLE TO GET INTO AN ACCIDENT WITHOUT ANY WARNING, THE SAFETY DEVICE WARNS YOU IF YOU CROSS OVER THE CENTER OR SHOULDER TRAFFIC LINE. THIS IS THE SECOND TIME IT HAPPENED AND WAS REPORTED TO FCC, SUBARU AND THEIR DEALERSHIP. I HAVE AN IDEA WHO'S BEHIND THIS DANGEROUS MANIPULATION BUT I DON'T HAVE THE TALENT OR RESOURCE TO PROVE IT.
THE CAR WILL PERIODICALLY STALL FOR A SECOND OR TWO ON OCCASSIONS WHEN STARTING OUT AND THEN ACCELERATE WITH A JOLT. WHEN IN TRAFFIC THIS IS UNACCEPTABLE. I UNDERSTAND THIS MAY BE COMMON WITH CVT TRANSMISSIONS. IF THAT IS THE CASE I QUESTION WHY THEY ARE ALLOWED ON THE ROAD. I WLL NOT PURCHASE ANOTHER SUBARU OR ANY OTHER CAR W…
Read full complaint
THE CAR WILL PERIODICALLY STALL FOR A SECOND OR TWO ON OCCASSIONS WHEN STARTING OUT AND THEN ACCELERATE WITH A JOLT. WHEN IN TRAFFIC THIS IS UNACCEPTABLE. I UNDERSTAND THIS MAY BE COMMON WITH CVT TRANSMISSIONS. IF THAT IS THE CASE I QUESTION WHY THEY ARE ALLOWED ON THE ROAD. I WLL NOT PURCHASE ANOTHER SUBARU OR ANY OTHER CAR WITH A CVT.
WHEN ATTEMPTING TO ACCELERATE TO MAKE A LEFT-HAND TURN THE CAR STOPPED - THE ENGINE WOULD NOT GET ABOVE IDLE, EVEN WHEN THE ACCELERATOR WAS PRESSED TO THE FLOOR. THE CAR STOPPED IN ONCOMING TRAFFIC. IT DID ACCELERATE AFTER COMPLETELY REMOVING PRESSURE FROM THE PEDAL AND PUSHING IT PARTIALLY DOWN AGAIN IT BEGAN TO PICK UP SPEED…
Read full complaint
WHEN ATTEMPTING TO ACCELERATE TO MAKE A LEFT-HAND TURN THE CAR STOPPED - THE ENGINE WOULD NOT GET ABOVE IDLE, EVEN WHEN THE ACCELERATOR WAS PRESSED TO THE FLOOR. THE CAR STOPPED IN ONCOMING TRAFFIC. IT DID ACCELERATE AFTER COMPLETELY REMOVING PRESSURE FROM THE PEDAL AND PUSHING IT PARTIALLY DOWN AGAIN IT BEGAN TO PICK UP SPEED.
Official recalls
321V587000 · Fuel System, Gasoline:delivery:fuel Pump
Jul 29, 2021
Subaru of America, Inc. (Subaru) is recalling certain 2019-2020 Ascent, 2018 Forester, 2018-2020 Impreza, Legacy, Outback, 2018-2019 BRZ, WRX, and Toyota 86 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the low-pressure fuel pump, free of charge. Owner notification letters were mailed September 24, 2021. Subaru and Toyota owners may call customer service at 1-844-373-6614. Subaru's number for this recall is WRG-21.
19V701000 · Air Bags:sensor:occupant Classification
Oct 3, 2019
Subaru of America, Inc. (Subaru) is recalling certain 2015-2018 Forester vehicles equipped with heated seats. An electrical connection in the front passenger seat for the Occupant Detection System (ODS) may loosen.
Consequence & remedy
Consequence: If the connection loosens, the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.
Remedy: Subaru will notify owners, and dealers will inspect and, as necessary, replace the ODS sensor mat harness, free of charge. The recall began February 11, 2020. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUM-98.
18V455000 · Equipment:other:labels; Tires
Jul 10, 2018
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Additional source detail variants (2)
Equipment:other:labels
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Tires
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19009 · Occupant Detection System (ods) Failure
Opened Aug 6, 2019 · Closed Jan 22, 2020
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:passenger Side:inflator Module; Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Additional source detail variants (4)
Air Bags:frontal:passenger Side:inflator Module
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:frontal
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.