Illustration2018 SUBARU FORESTER, SITTING AT HOUSE UNDRIVEN (STATIONARY) FOR OVER A MONTH DUE TO STAY AT HOME ORDER, DEVELOPED A CRACKED WINDSHIELD FOR NO REASON.
2018 Subaru Forester
Owner reports · Recalls · Investigations
More warning signs than most Forester years
Owner complaints for the 2018 Subaru Forester are substantially higher than the model-year median of 131.
About this comparison →How this year compares
Owner complaints by model year
Compare all Forester years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1560–25K
6525–50K
1350–75K
575–100K
2100–150K
0150K+
241 reports with mileage · 252 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility/wiper. Review the 135 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 96 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports1 fire reports6 injury reports
What owners actually said
493 reportsWE HAVE NOW HAD TO REPLACE THE WINDSHIELD TWICE. BOTH TIMES, THERE WAS A CRACK ORIGINATING FROM THE BOTTOM OF THE GLASS AND COMING UP INTO THE LINE OF SITE. BOTH TIMES, THE CRACK OCCURRED WITHOUT AN APPARENT ROCK HIT OR OTHER ISSUE. BOTH TIMES, THE CRACK WAS NOTICED AFTER THE CAR HAD BEEN STATIONARY WITH NO APPARENT ISSUES. …
Read full complaint
WE HAVE NOW HAD TO REPLACE THE WINDSHIELD TWICE. BOTH TIMES, THERE WAS A CRACK ORIGINATING FROM THE BOTTOM OF THE GLASS AND COMING UP INTO THE LINE OF SITE. BOTH TIMES, THE CRACK OCCURRED WITHOUT AN APPARENT ROCK HIT OR OTHER ISSUE. BOTH TIMES, THE CRACK WAS NOTICED AFTER THE CAR HAD BEEN STATIONARY WITH NO APPARENT ISSUES. THE FIRST TIME WE TOOK IT TO SUBARU, WHO SAID IT WAS PROBABLY A ROCK. I SAW NO EVIDENCE OF A ROCK.
FORESTER WAS PARKED IN UNDER GROUND PARKING GARAGE FOR BETWEEN ONE AND TWO WEEKS. THE BATTERY WAS COMPLETELY DEAD, NO SOUND AT ALL WHEN I TRIED TO START IT. THE ONLY DOOR THAT WAS LOCKED WAS THE REAR HATCH DOOR. NEIGHBOR BROUGHT A BATTERY CHARGER AND GOT THE FORESTER STARTED. FOLLOWING THAT, I DROVE IT TO THE LOCAL SUBARU DEA…
Read full complaint
FORESTER WAS PARKED IN UNDER GROUND PARKING GARAGE FOR BETWEEN ONE AND TWO WEEKS. THE BATTERY WAS COMPLETELY DEAD, NO SOUND AT ALL WHEN I TRIED TO START IT. THE ONLY DOOR THAT WAS LOCKED WAS THE REAR HATCH DOOR. NEIGHBOR BROUGHT A BATTERY CHARGER AND GOT THE FORESTER STARTED. FOLLOWING THAT, I DROVE IT TO THE LOCAL SUBARU DEALER AND ASK THEM TO CHECK AND SEE IF ANYTHING WAS DRAINING THE BATTERY. THEY CHECK EVERYTHING AND DID NOT FIND ANY PROBLEM. THE FELLOW AT THE SERVICE DESK SAID THAT STARTING A CAR IS THE BIGGEST DRAIN ON A BATTERY AND IF THE CAR ISN'T DRIVEN ENOUGH BETWEEN STARTUPS, IT TENDS TO BRING THE BATTERY DOWN. HE RECOMMENDED PARTICULAR BATTERY CHARGER WHICH HE SAID I COULD PURCHASE AT WALMART. SINCE I ONLY HAVE A LITTLE OVER ELEVEN THOUSAND MILES ON MY FORESTER, AND I HAVE NEVER HAD THIS SITUATION OCCUR WITH ANY OF MY OTHER AUTOMOBILES IN THE PAST. I DO WORRY ABOUT WHAT WOULD HAPPEN SHOULD I LEAVE MY CAR PARKED AT THE AIRPORT FOR A COUPLE WEEKS AND THERE IS NO PLACE TO PLUG IN A CHARGER. I STILL LOVE MY FORESTER.
MY CAR WAS SITTING IN THE DRIVEWAY AND OVERNIGHT A WINDSHIELD CRACK OF 8-12 INCHES APPEARED OUT OF NOWHERE.
THE WINDSHIELD CRACKED, THE CRACK IS GROWING FROM BOTTOM PASSENGER SIDE AND UP, HEADING MID SHIELD TOWARDS DRIVER. NO LOGICAL REASON FOR CRACK. NO ROCK CHIP MARKET, NO ACCIDENT.
WINDSHIELD CRACKED DUE TO AN UNKNOWN REASON. 13" CRACK IN THE CENTER OF THE WINDSHIELD STARTING AT THE BASE. VEHICLE WAS STATIONARY. MY ONLY SPECULATION IS THAT SNOW COVERED THE WINDSHIELD DURING THE NIGHT AND THE SUN HEATED THE INTERIOR OF THE VEHICLE IN THE MORNING CAUSING AN ABRUPT TEMPERATURE STRESS ON THE GLASS. DEFECTI…
Read full complaint
WINDSHIELD CRACKED DUE TO AN UNKNOWN REASON. 13" CRACK IN THE CENTER OF THE WINDSHIELD STARTING AT THE BASE. VEHICLE WAS STATIONARY. MY ONLY SPECULATION IS THAT SNOW COVERED THE WINDSHIELD DURING THE NIGHT AND THE SUN HEATED THE INTERIOR OF THE VEHICLE IN THE MORNING CAUSING AN ABRUPT TEMPERATURE STRESS ON THE GLASS. DEFECTIVE WINDSHIELD.
WHEN I WAS DRIVING ON THE HIGHWAY, A SMALL ROCK HIT MY WINDSHIELD IN THE LEFT CORNER (FROM THE DRIVER'S PERSPECTIVE) OF THE WINDSHIELD. ALTHOUGH THE INITIAL DAMAGE TO THE WINDSHIELD WAS A SMALL DENT IN THE WINDSHIELD (PICTURED BELOW) THE CRACK STARTED SPREADING AS WE DROVE AND REACHED OVER 2/3 OF THE WINDSHIELD IN LENGTH (ALSO P…
Read full complaint
WHEN I WAS DRIVING ON THE HIGHWAY, A SMALL ROCK HIT MY WINDSHIELD IN THE LEFT CORNER (FROM THE DRIVER'S PERSPECTIVE) OF THE WINDSHIELD. ALTHOUGH THE INITIAL DAMAGE TO THE WINDSHIELD WAS A SMALL DENT IN THE WINDSHIELD (PICTURED BELOW) THE CRACK STARTED SPREADING AS WE DROVE AND REACHED OVER 2/3 OF THE WINDSHIELD IN LENGTH (ALSO PICTURED BELOW). IT SEEMS UNREASONABLE THAT SUCH A SMALL DENT SHOULD CAUSE MORE THAN HALF OF THE WINDSHIELD TO CRACK. AS A RESULT, I THINK THAT THE WEAK CONSTRUCTION OF THE WINDSHIELD IS WHAT CAUSED THIS LARGE DAMAGE TO IT. ALTHOUGH THE CRACK ISN'T SEEMING TO SPREAD PAST ITS CURRENT LENGTH, IT IS STILL A CONCERN THAT THE WINDSHIELD MIGHT BREAK IN HALF AT SOME POINT IN THE FUTURE, ESPECIALLY DURING THE WINTER OR IF ANOTHER SMALL ROCK WERE TO HIT IT.
EXHAUST GETTING INTO THE CAR COMING FROM THE OUTSIDE WHILE CAR IS STATIONARY OR AROUND OTHER CARS. ONLY STOPS SUCKING EXHAUST IN IF WE CHANGE THE AIR VENTILATION MODE TO INSIDE THE CAR ONLY. IT MAKES IT VERY HARD TO DRIVE AROUND BECAUSE THE CAR GETS HUMID FAST AND THE WINDOWS FOG UP AND IT IS DANGEROUS TO DRIVE WITH DECREASED VI…
Read full complaint
EXHAUST GETTING INTO THE CAR COMING FROM THE OUTSIDE WHILE CAR IS STATIONARY OR AROUND OTHER CARS. ONLY STOPS SUCKING EXHAUST IN IF WE CHANGE THE AIR VENTILATION MODE TO INSIDE THE CAR ONLY. IT MAKES IT VERY HARD TO DRIVE AROUND BECAUSE THE CAR GETS HUMID FAST AND THE WINDOWS FOG UP AND IT IS DANGEROUS TO DRIVE WITH DECREASED VISIBILITY BECAUSE WE CANNOT CHANGE THE VENTILATION SYSTEM TO THE BUTTON THAT TAKES AIR FROM OUTSIDE.
WINDSHIELD CRACKED ABOUT 1130 PM ON 29 MARCH 2020 WHEN IT WAS SITTING IN THE DRIVEWAY. NOTHING WAS AROUND, NOTHING HIT IT. NO ONE OR ANIMAL WAS IN THE VEHICLE NOR ANYWHERE NEAR THE VEHICLE.
THE WINDSHIELD OF MY 2018 FORESTER SPONTANEOUSLY CRACKED EIGHT MONTHS AFTER PURCHASE WHILE DRIVING ON I-25 EIGHT MONTHS AFTER PURCHASE. THERE WAS NO COLLISION OR IMPACT THAT CAUSED THE CRACK. I HAD THE WINDSHIELD REPLACED BY SAFELITE AUTOGLASS ON MARCH 26, 2019. THE COST FOR REPLACEMENT AFTER INSURANCE WAS $200.
Official recalls
321V587000 · Fuel System, Gasoline:delivery:fuel Pump
Jul 29, 2021
Subaru of America, Inc. (Subaru) is recalling certain 2019-2020 Ascent, 2018 Forester, 2018-2020 Impreza, Legacy, Outback, 2018-2019 BRZ, WRX, and Toyota 86 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the low-pressure fuel pump, free of charge. Owner notification letters were mailed September 24, 2021. Subaru and Toyota owners may call customer service at 1-844-373-6614. Subaru's number for this recall is WRG-21.
19V701000 · Air Bags:sensor:occupant Classification
Oct 3, 2019
Subaru of America, Inc. (Subaru) is recalling certain 2015-2018 Forester vehicles equipped with heated seats. An electrical connection in the front passenger seat for the Occupant Detection System (ODS) may loosen.
Consequence & remedy
Consequence: If the connection loosens, the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.
Remedy: Subaru will notify owners, and dealers will inspect and, as necessary, replace the ODS sensor mat harness, free of charge. The recall began February 11, 2020. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUM-98.
18V455000 · Equipment:other:labels; Tires
Jul 10, 2018
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Additional source detail variants (2)
Equipment:other:labels
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Tires
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19009 · Occupant Detection System (ods) Failure
Opened Aug 6, 2019 · Closed Jan 22, 2020
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:passenger Side:inflator Module; Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Additional source detail variants (4)
Air Bags:frontal:passenger Side:inflator Module
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:frontal
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.