IllustrationI OWNED THIS NEW CAR ONLY 2 WEEKS AND IT DEVELOPED A CRACK IN THE WINDSHIELD. I HAD THE CRACK REPAIRED AT A PRIVATE SHOP. I WAS DRIVING THE CAR ON A RESIDENTIAL STREET WHEN THIS HAPPENED.
2018 Subaru Forester
Owner reports · Recalls · Investigations
More warning signs than most Forester years
Owner complaints for the 2018 Subaru Forester are substantially higher than the model-year median of 131.
About this comparison →How this year compares
Owner complaints by model year
Compare all Forester years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1560–25K
6525–50K
1350–75K
575–100K
2100–150K
0150K+
241 reports with mileage · 252 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility/wiper. Review the 135 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 96 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports1 fire reports6 injury reports
Unknown Or Other complaints
82 reportsCRACKED/DENTS IN WINDSHIELD
2018 SUBARU FORESTER HAS A CRACK IN THE WINDSHIELD, PASSENGER SIDE FOR NO APPARENT REASON. FIRST NOTICED IN AUGUST 2018.
ON RANDOM AND UNPREDICTABLE OCCASIONS THE KEY WILL NOT TURN IN THE IGNITION TO START THE VEHICLE APPARENTLY AS AN ISSUE WITH THE ANTI-THEFT MECHANISM. WHEN THIS OCCURS, NOTHING WORKS TO TRY TO RESOLVE EXCEPT TO EXIT THE VEHICLE AND WAIT FOR 10-15 MINUTES AND THE MECHANISM WILL RESET ITSELF AND THEN WORK NORMALLY. THIS HAS OCCURR…
Read full complaint
ON RANDOM AND UNPREDICTABLE OCCASIONS THE KEY WILL NOT TURN IN THE IGNITION TO START THE VEHICLE APPARENTLY AS AN ISSUE WITH THE ANTI-THEFT MECHANISM. WHEN THIS OCCURS, NOTHING WORKS TO TRY TO RESOLVE EXCEPT TO EXIT THE VEHICLE AND WAIT FOR 10-15 MINUTES AND THE MECHANISM WILL RESET ITSELF AND THEN WORK NORMALLY. THIS HAS OCCURRED SEVERAL TIMES AND THE DEALER HAS BEEN UNABLE TO RESOLVE THE ISSUE.
BOUGHT THE CAR NEW IN 2018, IN 2019 A SMALL PIECE OF GRAVEL HIT THE WINDSHIELD AND A HUGE CRACK APPEARED A FEW WEEKS LATER. HAD IT REPLACED. NOW 10//27/2020 THERE IS A CRACK THAT JUST APPEARED IN THE WINDSHIELD AGAIN. NO ROCKS HAVE HIT THE WINDSHIELD. .I DROVE THE CAR AND DID NOT SEE A CRACK. PARKED IN MY DRIVEWAY FOR AN HOUR AN…
Read full complaint
BOUGHT THE CAR NEW IN 2018, IN 2019 A SMALL PIECE OF GRAVEL HIT THE WINDSHIELD AND A HUGE CRACK APPEARED A FEW WEEKS LATER. HAD IT REPLACED. NOW 10//27/2020 THERE IS A CRACK THAT JUST APPEARED IN THE WINDSHIELD AGAIN. NO ROCKS HAVE HIT THE WINDSHIELD. .I DROVE THE CAR AND DID NOT SEE A CRACK. PARKED IN MY DRIVEWAY FOR AN HOUR AND WENT OUTSIDE TO CLEAN THE INSIDE OF THE WINDSHIELD AND THERE WAS A CRACK. THEY APPEAR WHEN THE CAR IS JUST SITTING IN THE DRIVEWAY..THE FIRST CRACKED WINDSHIELD AND CLAIM WERE FROM 9/19 CLAIM 06-B531-7M4 WITH STATE FARM.
THE WINDSHIELD CRACKED AS I WAS DRIVING DOWN A STREET. NOTHING HIT IT. THERE WERE NO OTHER CARS NEAR ME. THE CRACK STARTED AT THE OUTER EDGE OF THE WINDSHIELD.
VEHICLE WAS STATIONARY WHEN "SRS AIRBAG SYSTEM NEEDS TO BE CHECKED" WARNING APPEARED ON CONSOLE. PASSENGER WAS PRESENT IN PASSENGER SEAT. VEHICLE WAS DRIVEN AND TURNED OFF. AFTER RESTARTING VEHICLE, ERROR MESSAGE APPEARED AGAIN WHEN CAR WAS STATIONARY AND IN MOTION. MESSAGE WAS PRESENT BOTH WHEN PASSENGER WAS PRESENT AND NO PASS…
Read full complaint
VEHICLE WAS STATIONARY WHEN "SRS AIRBAG SYSTEM NEEDS TO BE CHECKED" WARNING APPEARED ON CONSOLE. PASSENGER WAS PRESENT IN PASSENGER SEAT. VEHICLE WAS DRIVEN AND TURNED OFF. AFTER RESTARTING VEHICLE, ERROR MESSAGE APPEARED AGAIN WHEN CAR WAS STATIONARY AND IN MOTION. MESSAGE WAS PRESENT BOTH WHEN PASSENGER WAS PRESENT AND NO PASSENGER. SYMPTOM MATCHES EXISTING NHTSA CAMPAIGN 19V701000. PERFORMED INSPECTION PER HTTPS://STATIC.NHTSA.GOV/ODI/RCL/2019/RCRIT-19V701-0743.PDF, FOUND PASSENGER-SIDE FRONT AIRBAG OCCUPANT DETECTION SYSTEM (ODS) HARNESS THAT MATCHES DEFECTIVE PART DESCRIPTION PROVIDED BY SUBARU (DATE CODE IS BEFORE 18074, SUPPLIER CODE IS 6578). OWNER CONCERN IS THAT THE VEHICLE VIN DOES NOT APPEAR LISTED UNDER RECALL PROVIDED ON NHTSA OR SUBARU WEBSITE, EVEN THOUGH THE DEFECTIVE, RECALLED PART IS PRESENT IN THIS VEHICLE. OWNER BELIEVES THAT SCOPE OF RECALL IS INCORRECT AND DID NOT INCLUDE ALL AFFECTED VEHICLES.
WINDSHIELD HAS EASILY CRACKED MULTIPLE TIMES AND IS VERY EXPENSIVE TO FIX. *TR
I HEARD A LOUD POP WHEN DRIVING ON A MAJOR ROAD. JUST DRIVING. I LOOKED UP AT THE REAR VIEW AND SAW THE WINDSHIELD HAD A VERY LARGE / LONG CRACK IN IT. I CALLED SUBARU DEALERSHIP THEY TOLD ME TO CALL MY INSURANCE COMPANY. NO MENTION OF PROBLEMS WITH WINDSHIELDS. *TR
I PURCHASE A 2018 SUBARU FORESTER AND 5 MONTH LATER THE SIDE/BACK RADAR WARNING SYSTEMS WENT DEAD. I RETURNED IT TO THE DEALER AND WAS TOLD BECAUSE OF A SCRATCH ON THE BUMPER THE CAR WAS IN AN ACCIDENT AND THE PART WAS NOT WARRANTED AND WOULD COST OVER $2K TO REPAIR. THIS PART WARNS ME FROM GOING BACK OR CHANGING LANES BECAUSE …
Read full complaint
I PURCHASE A 2018 SUBARU FORESTER AND 5 MONTH LATER THE SIDE/BACK RADAR WARNING SYSTEMS WENT DEAD. I RETURNED IT TO THE DEALER AND WAS TOLD BECAUSE OF A SCRATCH ON THE BUMPER THE CAR WAS IN AN ACCIDENT AND THE PART WAS NOT WARRANTED AND WOULD COST OVER $2K TO REPAIR. THIS PART WARNS ME FROM GOING BACK OR CHANGING LANES BECAUSE OF BLIND SPOTS OR EXCESSIVE SPEED OF OTHERS DRIVERS AND PREVENTS ACCIDENTS. I BROUGHT IT TO SEVERAL REPAIR SHOPS AND HAD THE PART REPLACED AND PAID OUT OF POCKET. RECENTLY I FOUND IN MY PAPERS THAT THE DEALER HAD INCLUDED IN MY PRICE AN EXTENDED WARRANTY FOR THE SAME PERIOD AS THE MANUFACTURERS WARRANTY AND CHARGED ME OVER $300 FOR IT. I RE-APPLIED TO HAVE THE REPAIR COVERED BY THE NEW WARRANTY AND AGAIN DENIED. I REPORTED THIS TO CONSUMER REPORTS IF THEY WOULD BE WILLING TO TEST THE ORIGINAL DEFECTIVE PART TO SHOW IT WAS NOT MADE DEFECTIVE BY A SCRATCH/BUMP TO THE BUMPER. BECAUSE THIS PIECE IS SUCH AN INTEGRAL SAFELY PIECE OF THE CAR, LIKE A COMPUTER OR TV ELECTRONIC PARTS DON;T GO DEFECTIVE IN SUCH SHORT PERIODS AND WITH NO REAL PHYSICAL DAMAGE. I NOTICED THE DEFECTIVE DEVICE WHEN BACKING OUT OF MY DRIVEWAY AND WHEN ON THE STREETS AND VEHICLES WERE PASSING AND DEVICE NOT WARNING ME. *TR
Official recalls
321V587000 · Fuel System, Gasoline:delivery:fuel Pump
Jul 29, 2021
Subaru of America, Inc. (Subaru) is recalling certain 2019-2020 Ascent, 2018 Forester, 2018-2020 Impreza, Legacy, Outback, 2018-2019 BRZ, WRX, and Toyota 86 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the low-pressure fuel pump, free of charge. Owner notification letters were mailed September 24, 2021. Subaru and Toyota owners may call customer service at 1-844-373-6614. Subaru's number for this recall is WRG-21.
19V701000 · Air Bags:sensor:occupant Classification
Oct 3, 2019
Subaru of America, Inc. (Subaru) is recalling certain 2015-2018 Forester vehicles equipped with heated seats. An electrical connection in the front passenger seat for the Occupant Detection System (ODS) may loosen.
Consequence & remedy
Consequence: If the connection loosens, the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.
Remedy: Subaru will notify owners, and dealers will inspect and, as necessary, replace the ODS sensor mat harness, free of charge. The recall began February 11, 2020. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUM-98.
18V455000 · Equipment:other:labels; Tires
Jul 10, 2018
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Additional source detail variants (2)
Equipment:other:labels
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Tires
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19009 · Occupant Detection System (ods) Failure
Opened Aug 6, 2019 · Closed Jan 22, 2020
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:passenger Side:inflator Module; Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Additional source detail variants (4)
Air Bags:frontal:passenger Side:inflator Module
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:frontal
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.