IllustrationTHE COMPANY PROVIDED (EXTRA COST) RUBBER FLOOR MATS ARE VERY DANGEROUS AND SLIPPERY. FOR SOME INEXPLICABLE REASON THE GRID LINES RUN FRONT TO BACK (NOT CROSSWISE OR DIAGONAL), SO WHEN FLOOR MATS ARE WET (RAIN, SNOW OCCUR OFTEN HERE) DRIVER'S FEET SLIP WHICH IS DANGEROUS WITH GAS AND BRAKING PEDALS.
2016 Subaru Forester
Owner reports · Recalls · Investigations
More warning signs than most Forester years
Owner complaints for the 2016 Subaru Forester are substantially higher than the model-year median of 131.
About this comparison →How this year compares
Owner complaints by model year
Compare all Forester years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
690–25K
7825–50K
4350–75K
1175–100K
9100–150K
7150K+
217 reports with mileage · 196 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 93 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
39 crash reports3 fire reports14 injury reports
What owners actually said
413 reportsMY SUBARU HAS EXPERIENCED A MALFUNCTION OF THE PASSENGER AIR BAG RESTRAINT SYSTEM SINCE JULY OF 2017. I TOOK THE VEHICLE TO THE DEALER WHERE I PURCHASED IT IN 2016, JOSEPH SUBARU IN FLORENCE, KY ON AUGUST 2, 2017. THE TECHNICIAN DIAGNOSED A SWITCH MALFUNCTION UNDER THE PASSENGER SEAT. THE SERVICE MANAGER ASSURED ME THAT THE P…
Read full complaint
MY SUBARU HAS EXPERIENCED A MALFUNCTION OF THE PASSENGER AIR BAG RESTRAINT SYSTEM SINCE JULY OF 2017. I TOOK THE VEHICLE TO THE DEALER WHERE I PURCHASED IT IN 2016, JOSEPH SUBARU IN FLORENCE, KY ON AUGUST 2, 2017. THE TECHNICIAN DIAGNOSED A SWITCH MALFUNCTION UNDER THE PASSENGER SEAT. THE SERVICE MANAGER ASSURED ME THAT THE PART WOULD BE ORDERED AND THE VEHICLE WOULD BE SCHEDULED FOR REPAIR. AFTER THREE WEEKS WITH NO RESPONSE, I CALLED JOSEPH SUBARU TO ASK ABOUT THE STATUS. HE ASSURED ME ME THAT THE PART HAD BEEN ORDERED ON AUGUST 2 AND THAT I COULD EXPECT THE PART TO BE AVAILABLE AFTER ONE MONTH. THE PART WAS NEVER MADE AVAILABLE. I CONTACTED SUBARU OF AMERICA ON OCTOBER 2, 2017 TO REGISTER A COMPLAINT. I GOT NO RESPONSE. I CONTACTED SUBARU ELECTRONICALLY ON OCTOBER 23, 2017. I RECEIVED A CLAIM NUMBER SR #:1-27120984562. IT IS NOW DECEMBER 6, 2017 AND I HAVE RECEIVED NO REPAIR AND NO CLARIFICATION. NO ONE HAS MADE ANY EFFORT TO CORRECT THE FAULT. IT IS A HAZARD TO ME AND ANY RIDERS IN MY VEHICLE.
MY PASSENGER AIRBAG LIGHT GO ON AND OFF TO SIGNAL IF THE PASSENGER SEAT AIRBAG SYSTEM IS ACTIVATED OR NOT. DEALER DIAGNOSIS IS THAT THE SENSOR IN THE SEAT IS BAD. THE REPLACEMENT PART AND LABOR IS OVER $1000 BECAUSE IT IS INTEGRATED INTO THE SEAT. I CALLED SUBARU AND THEY ARE WILLING TO PAY FOR HALF, HOWEVER THIS IS AN UNACCE…
Read full complaint
MY PASSENGER AIRBAG LIGHT GO ON AND OFF TO SIGNAL IF THE PASSENGER SEAT AIRBAG SYSTEM IS ACTIVATED OR NOT. DEALER DIAGNOSIS IS THAT THE SENSOR IN THE SEAT IS BAD. THE REPLACEMENT PART AND LABOR IS OVER $1000 BECAUSE IT IS INTEGRATED INTO THE SEAT. I CALLED SUBARU AND THEY ARE WILLING TO PAY FOR HALF, HOWEVER THIS IS AN UNACCEPTABLE SOLUTION. THE AIRBAG SYSTEM ON SUCH A NEW CAR SHOULD BE FULLY FUNCTIONING AND SUBARU SHOULD TAKE FULL RESPONSIBILITY FOR SUCH A PROBLEM AS THE SENSOR IN THE SEAT SINCE THEY MADE IT SO EXPENSIVE TO REPLACE DUE TO THE INTEGRATION INTO THE SEAT, YOU CAN'T JUST REPLACE THAT ONE SENSOR.
I'VE HAD THIS CAR FOR 1.5 YEARS AND IT'S ALREADY STALLED TWICE TIMES. BOTH TIMES I WAS DRIVING ON THE HIGHWAY AND WITHOUT ANY WARNING MY CAR JUST STARTED TO RAPIDLY DECREASE SPEED. BOTH TIMES, I MY GAS METER SAID THAT I HAD OVER 50 MILES OF GAS LEFT IN MY CAR. ITS ABSOLUTELY TERRIFYING BECAUSE WHEN THE CAR SHUTS OFF, I HAVE ABOU…
Read full complaint
I'VE HAD THIS CAR FOR 1.5 YEARS AND IT'S ALREADY STALLED TWICE TIMES. BOTH TIMES I WAS DRIVING ON THE HIGHWAY AND WITHOUT ANY WARNING MY CAR JUST STARTED TO RAPIDLY DECREASE SPEED. BOTH TIMES, I MY GAS METER SAID THAT I HAD OVER 50 MILES OF GAS LEFT IN MY CAR. ITS ABSOLUTELY TERRIFYING BECAUSE WHEN THE CAR SHUTS OFF, I HAVE ABOUT TWO MINUTE TO GET TO THE SHOULDER BEFORE IT'S COMPLETELY DEAD.
MY AIRBAG LIGHT GOES ON TO SIGNAL THE AIRBAGS ARE NOT WORKING. IT GOES OFF AND ON AT WILL. I HAVE TAKEN THE CAR TO THE DEALERSHIP 4 TIMES NOW AND FINALLY THEY THINK THEY KNOW WHAT IS WRONG, BUT WILL NOT HAVE THE PART TO FIX THE PROBLEM UNTIL SOMETIME IN THE FUTURE. THE BLUETOOTH IS SO BAD THAT THE PEOPLE I TALK TO CANNOT HEAR…
Read full complaint
MY AIRBAG LIGHT GOES ON TO SIGNAL THE AIRBAGS ARE NOT WORKING. IT GOES OFF AND ON AT WILL. I HAVE TAKEN THE CAR TO THE DEALERSHIP 4 TIMES NOW AND FINALLY THEY THINK THEY KNOW WHAT IS WRONG, BUT WILL NOT HAVE THE PART TO FIX THE PROBLEM UNTIL SOMETIME IN THE FUTURE. THE BLUETOOTH IS SO BAD THAT THE PEOPLE I TALK TO CANNOT HEAR ME. BIG SAFETY CONCERNS.
TL* THE CONTACT OWNS A 2016 SUBARU FORESTER. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE'S POWER SEIZED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO FITZGERALD TOYOTA (907 N FREDERICK AVE, GAITHERSBURG, MD 20879) WHERE THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS NOT MADE …
Read full complaint
TL* THE CONTACT OWNS A 2016 SUBARU FORESTER. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE'S POWER SEIZED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO FITZGERALD TOYOTA (907 N FREDERICK AVE, GAITHERSBURG, MD 20879) WHERE THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
MY ACCIDENT INVOLVED HITTING A TREE HEAD-ON TRAVELING AT LEAST 10-15 MPH. I WOULD HAVE THOUGHT AT LEAST 3 AIRBAGS WOULD HAVE DEPLOYED (SIDE CURTAIN, STEERING, AND DASH FOR KNEES) PREVENTING ME FROM HITTING MY HEAD.
FRONT END TOTAL COLLISION TRAVELING APPROXIMATELY 30MPH ON A RESIDENTIAL SECTION OF A MAIN STREET. HIT, AND BROKE, A TELEPHONE POLE. CAR DEEMED TOTALED. NO AIRBAGS DEPLOYED.
STEERING WHEEL LOCKED WHILE IN GARAGE, ON LEVEL WITH WHEELS STRAIGHT. TOWED TO WAGNER DEALERSHIP WHO AGREED IT WAS MALFUNCTIONING. EXTENDED MANIPULATION FREED IT. HOW DO I FIX THIS?
I WAS PARKING MY CAR. I HAD THE BRAKE APPLIED AND PUT IT IN PARK. THE CAR ACCELERATED ON ITS OWN OVER A PARKING BARRIER, OVER A 1.5' STONE BARRIER, UP A SMALL GRADE AND INTO AND PARTIALLY THRU A CONCRETE PATIO WALL. THE CAR'S GEARSHIFT WAS IN PARK. I HAD TO MOVE IT BACK TO REVERSE TO GET IT BACK INTO THE PARKING SPACE. AND E…
Read full complaint
I WAS PARKING MY CAR. I HAD THE BRAKE APPLIED AND PUT IT IN PARK. THE CAR ACCELERATED ON ITS OWN OVER A PARKING BARRIER, OVER A 1.5' STONE BARRIER, UP A SMALL GRADE AND INTO AND PARTIALLY THRU A CONCRETE PATIO WALL. THE CAR'S GEARSHIFT WAS IN PARK. I HAD TO MOVE IT BACK TO REVERSE TO GET IT BACK INTO THE PARKING SPACE. AND EVEN THOUGH THE IMPACT WAS SUBSTANTIAL THE AIRBAG DID NOT DEPLOY.
Official recalls
319V701000 · Air Bags:sensor:occupant Classification
Oct 3, 2019
Subaru of America, Inc. (Subaru) is recalling certain 2015-2018 Forester vehicles equipped with heated seats. An electrical connection in the front passenger seat for the Occupant Detection System (ODS) may loosen.
Consequence & remedy
Consequence: If the connection loosens, the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.
Remedy: Subaru will notify owners, and dealers will inspect and, as necessary, replace the ODS sensor mat harness, free of charge. The recall began February 11, 2020. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUM-98.
19V149000 · Exterior Lighting:brake Lights:switch
Feb 28, 2019
Subaru of America, Inc. (Subaru) is recalling certain 2014-2016 Forester, 2008-2016 Impreza sedans, 2012-2016 Impreza station wagons, 2008-2014 WRX sedans (including STI), and 2013-2017 Crosstrek vehicles. Exposure to certain contaminants may cause the brake light switch to malfunction, preventing the brake lights from illuminating and also preventing keyless ignition vehicles from starting and CVT/automatic transmissions from being able to be shifted out of Park.
Consequence & remedy
Consequence: Brake lights that do not illuminate properly will not alert other drivers that the vehicle is slowing or stopping, increasing the risk of crash.
Remedy: Subaru will notify owners, and dealers will replace the brake light switch, free of charge. The recall began April 15, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUE-90.
16V162000 · Engine And Engine Cooling:engine:gasoline:turbo/supercharger
Mar 21, 2016
Subaru of America, Inc. (Subaru) is recalling certain model year 2015-2016 WRX vehicles manufactured April 10, 2015, to October 21, 2015, and Forester 2.0XT vehicles manufactured April 10, 2015, to October 20, 2015. The turbocharger air intake duct may crack and possibly result in an engine stall.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Subaru will notify owners, and dealers will inspect the turbocharger air intake duct, and replace it as necessary, free of charge, depending on the lot number found on the duct. The recall began April 2016. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is WTA-62.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19009 · Occupant Detection System (ods) Failure
Opened Aug 6, 2019 · Closed Jan 22, 2020
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:passenger Side:inflator Module; Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Additional source detail variants (4)
Air Bags:frontal:passenger Side:inflator Module
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:frontal
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.