IllustrationAIRBAG WARNING LIGHT REGISTERS OFF WHEN PASSENGER IN SEAT. SUBARU DEALER FOUND CODES B1650, OCCUPANT DETECTION, AND CODE B1760, SENSOR MAT ABNORMAL. DETERMINED THAT SEAT BOTTOM WITH SENSOR NEEDED TO BE REPLACED. 10/2/19 QUOTE TO REPLACE AIRBAG WAS $1168.00. IS THIS ISSUE COVERED UNDER RECALL?
2016 Subaru Forester
Owner reports · Recalls · Investigations
More warning signs than most Forester years
Owner complaints for the 2016 Subaru Forester are substantially higher than the model-year median of 131.
About this comparison →How this year compares
Owner complaints by model year
Compare all Forester years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
690–25K
7825–50K
4350–75K
1175–100K
9100–150K
7150K+
217 reports with mileage · 196 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 93 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
39 crash reports3 fire reports14 injury reports
What owners actually said
413 reportsPASSANGER AIRBAG IS OFF NO MATTER IF SOMEONE IS SITTING IN THE SEAT AND WILL NOT TURN BACK ON. THIS HAPPENS IF IT IS SITTING STILL OR MOVING SO NOT SAFE FOR PASSANGERS
CVT CODES P0700 AND P2764 CAME ON. THE DEALERSHIP SAID THAT IT NEEDS A WHOLE NEW TRANSMISSION AS FIXING JUST THE TORQUE CONVERTER WILL NOT FIX THE ISSUE. ALL WARNING LIGHTS CAME ON AND NONE OF THE SAFETY FEATURES WILL WORK. THE CAR WAS DOING THIS FROM A STARTING POINT AND STAYED ON NO MATTER SPEED. SEEMS TO BE A KNOWN ISSUE WITH…
Read full complaint
CVT CODES P0700 AND P2764 CAME ON. THE DEALERSHIP SAID THAT IT NEEDS A WHOLE NEW TRANSMISSION AS FIXING JUST THE TORQUE CONVERTER WILL NOT FIX THE ISSUE. ALL WARNING LIGHTS CAME ON AND NONE OF THE SAFETY FEATURES WILL WORK. THE CAR WAS DOING THIS FROM A STARTING POINT AND STAYED ON NO MATTER SPEED. SEEMS TO BE A KNOWN ISSUE WITH CVT...$7,731.00 TO REPLACE
FRONT SEAT AIRBAG SENSOR LIGHT CAME ON AND WON'T GO OFF. CODE SAYS THAT THE SEAT SENSOR IS NOT WORKING AND AIRBAG STAYS OFF. MOVING, STATIONARY AND CODE WILL NOT RESET
PASSENGER AIR BAG DASH BOARD WARNING LIGHT READS "PASSENGER AIR BAG OFF" REGARDLESS OF A PASSENGER BEING IN THE SEAT OR NOT. THIS OCCURS WHILE THE CAR IS BEING DRIVEN. THE AIRBAG SYSTEM SHUTS OFF WITHOUT CAUSE.
THE HORN STOPPED WORKING. I WAS TOLD IF WAS THE ELECTRONIC / ELECTRICAL "CLOCK SPRING MECHANISM?" IN THE STEERING WHEEL. IT IS A SAFETY ISSUE AND JUST AILED AFTER THE WARRANTY EXPIRED.
UNABLE TO REMOVE THE KEY FROM THE IGNITION SWITCH WHEN THE VEHICLE IS IN PARK AND THE CAR IS STATIONARY. PER TSP 16 112 18R THE CAUSE IS CONTAMINATION OF THE PARK-RANGE SWITCH INTERNAL COMPONENTS. WE OWN 2 IDENTICAL CARS PURCHASED THE SAME DAY. BOTH HAVE STARTED TO EXPERIENCE THIS EVERY DAY SINCE WE HIT 30,000 MILES. WE PURCHASE…
Read full complaint
UNABLE TO REMOVE THE KEY FROM THE IGNITION SWITCH WHEN THE VEHICLE IS IN PARK AND THE CAR IS STATIONARY. PER TSP 16 112 18R THE CAUSE IS CONTAMINATION OF THE PARK-RANGE SWITCH INTERNAL COMPONENTS. WE OWN 2 IDENTICAL CARS PURCHASED THE SAME DAY. BOTH HAVE STARTED TO EXPERIENCE THIS EVERY DAY SINCE WE HIT 30,000 MILES. WE PURCHASED IN APRIL 2016, SO WARRANTY NO LONGER COVERS. THERE ARE HUNDREDS (MAYBE THOUSANDS) OF POSTINGS ON MANY FORUMS INDICATING THE SAME ISSUE. THIS HAS RESULTED IN US HAVING TO LEAVE THE KEY IN THE CAR WHEN WE PARK SOMEWHERE. IT TAKES AROUND 3-4 MINUTES TO START AND RESTART THE CAR AND MOVE IT BACK AND FORTH IN ORDER TO RELEASE THE KEY. THIS IS NOT THE SITUATION THAT OCCURS WHEN YOU JUST NEED TO TURN THE STEERING WHEEL.
UNABLE TO REMOVE THE KEY FROM THE IGNITION SWITCH WHEN THE VEHICLE IS IN PARK. PER TSP 16 112 18R THE CAUSE IS CONTAMINATION OF THE PARK-RANGE SWITCH INTERNAL COMPONENTS. WE OWN 2 IDENTICAL CARS PURCHASED THE SAME DAY. BOTH HAVE STARTED TO EXPERIENCE THIS EVERY DAY SINCE WE HIT 30,000 MILES. WE PURCHASED IN APRIL 2016, SO WA…
Read full complaint
UNABLE TO REMOVE THE KEY FROM THE IGNITION SWITCH WHEN THE VEHICLE IS IN PARK. PER TSP 16 112 18R THE CAUSE IS CONTAMINATION OF THE PARK-RANGE SWITCH INTERNAL COMPONENTS. WE OWN 2 IDENTICAL CARS PURCHASED THE SAME DAY. BOTH HAVE STARTED TO EXPERIENCE THIS EVERY DAY SINCE WE HIT 30,000 MILES. WE PURCHASED IN APRIL 2016, SO WARRANTY NO LONGER COVERS. THERE ARE HUNDREDS (MAYBE THOUSANDS) OF POSTINGS ON MANY FORUMS INDICATING THE SAME ISSUE. THIS HAS RESULTED IN US HAVING TO LEAVE THE KEY IN THE CAR WHEN WE PARK SOMEWHERE. IT TAKES ROUND 3-4 MINUTES TO START AND RESTART THE CAR AND MOVE IT BACK AND FORTH IN ORDER TO RELEASE THE KEY. THIS IS NOT THE SITUATION THAT OCCURS WHEN YOU JUST NEED TO TURN THE STEERING WHEEL.
WHILE DRIVING ON STRAIGHT ROAD WITH NO VEHICLES ANYWHERE AROUND OR ANY ROAD DEBRIS HEARD WHAT SOUNDED LIKE WINDSHIELD GLASS IMPACT. SAW NO DAMAGE. NO CRACK APPEARED. 4 HOURS LATER HAD 12 INCH CRACK FROM BOTTOM LEFT BASE OF WINDSHIELD. THERE WAS NO IMPACT AS NO OTHER VEHICLE WAS AROUND ME WHEN THIS OCCURRED. WEATHER WAS A SUNNY 7…
Read full complaint
WHILE DRIVING ON STRAIGHT ROAD WITH NO VEHICLES ANYWHERE AROUND OR ANY ROAD DEBRIS HEARD WHAT SOUNDED LIKE WINDSHIELD GLASS IMPACT. SAW NO DAMAGE. NO CRACK APPEARED. 4 HOURS LATER HAD 12 INCH CRACK FROM BOTTOM LEFT BASE OF WINDSHIELD. THERE WAS NO IMPACT AS NO OTHER VEHICLE WAS AROUND ME WHEN THIS OCCURRED. WEATHER WAS A SUNNY 75 AT THE TIME. BAD GLASS? VEHICLE HAS EYESIGHT. IN MOTION AT 50 MPH, GOING STRAIGHT ON COUNTRY 2 LANE ROAD. BEGINNING OF FRACTURE IS TOO LOW TO HAVE BEEN AN IMPACT.
TL* THE CONTACT OWNS A 2016 SUBARU FORESTER. WHEN THE VEHICLE WAS STARTED, THE AIR BAG INDICATOR ILLUMINATED. THE NEXT TIME THE VEHICLE WAS STARTED, THE INDICATOR DID NOT APPEAR. WHEN THE INDICATOR ILLUMINATED AGAIN, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO SUGGESTED THE CONTACT TAKE THE VEHICLE TO A DEALER BECAUSE T…
Read full complaint
TL* THE CONTACT OWNS A 2016 SUBARU FORESTER. WHEN THE VEHICLE WAS STARTED, THE AIR BAG INDICATOR ILLUMINATED. THE NEXT TIME THE VEHICLE WAS STARTED, THE INDICATOR DID NOT APPEAR. WHEN THE INDICATOR ILLUMINATED AGAIN, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO SUGGESTED THE CONTACT TAKE THE VEHICLE TO A DEALER BECAUSE THE DEFECT MAY BE INCLUDED IN A RECALL. THE CONTACT TOOK THE VEHICLE TO #1 COCHRAN SUBARU OF BUTLER COUNTY (340 NEW CASTLE RD, BUTLER, PA 16001, 888-230-0231) WHERE IT WAS DIAGNOSED THAT A SENSOR FAILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BY LETTER. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 39,767. *DT CONSUMER STATED NO EDITS EXCEPT TO SAY SUBARU REIMBURSED ME THE ENTIRE AMT I PAID FOR THE REPAIRS AT #1 COCKRAN IN BUTLER. VIN NUMBER ######## 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB *TR*JB
Official recalls
319V701000 · Air Bags:sensor:occupant Classification
Oct 3, 2019
Subaru of America, Inc. (Subaru) is recalling certain 2015-2018 Forester vehicles equipped with heated seats. An electrical connection in the front passenger seat for the Occupant Detection System (ODS) may loosen.
Consequence & remedy
Consequence: If the connection loosens, the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.
Remedy: Subaru will notify owners, and dealers will inspect and, as necessary, replace the ODS sensor mat harness, free of charge. The recall began February 11, 2020. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUM-98.
19V149000 · Exterior Lighting:brake Lights:switch
Feb 28, 2019
Subaru of America, Inc. (Subaru) is recalling certain 2014-2016 Forester, 2008-2016 Impreza sedans, 2012-2016 Impreza station wagons, 2008-2014 WRX sedans (including STI), and 2013-2017 Crosstrek vehicles. Exposure to certain contaminants may cause the brake light switch to malfunction, preventing the brake lights from illuminating and also preventing keyless ignition vehicles from starting and CVT/automatic transmissions from being able to be shifted out of Park.
Consequence & remedy
Consequence: Brake lights that do not illuminate properly will not alert other drivers that the vehicle is slowing or stopping, increasing the risk of crash.
Remedy: Subaru will notify owners, and dealers will replace the brake light switch, free of charge. The recall began April 15, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUE-90.
16V162000 · Engine And Engine Cooling:engine:gasoline:turbo/supercharger
Mar 21, 2016
Subaru of America, Inc. (Subaru) is recalling certain model year 2015-2016 WRX vehicles manufactured April 10, 2015, to October 21, 2015, and Forester 2.0XT vehicles manufactured April 10, 2015, to October 20, 2015. The turbocharger air intake duct may crack and possibly result in an engine stall.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Subaru will notify owners, and dealers will inspect the turbocharger air intake duct, and replace it as necessary, free of charge, depending on the lot number found on the duct. The recall began April 2016. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is WTA-62.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19009 · Occupant Detection System (ods) Failure
Opened Aug 6, 2019 · Closed Jan 22, 2020
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:passenger Side:inflator Module; Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Additional source detail variants (4)
Air Bags:frontal:passenger Side:inflator Module
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:frontal
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.