IllustrationMY FORESTER ACCELERATES WITHOUT MY KNOWLEDGE. THERE HAVE BEEN INSTANCES WHEN I STOP AT LIGHT AND ADVANCE IT SOMETIMES ACCELERATES MORE THAN I HAVE PRESSED ON GAS. *TR
2016 Subaru Forester
Owner reports · Recalls · Investigations
More warning signs than most Forester years
Owner complaints for the 2016 Subaru Forester are substantially higher than the model-year median of 131.
About this comparison →How this year compares
Owner complaints by model year
Compare all Forester years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
690–25K
7825–50K
4350–75K
1175–100K
9100–150K
7150K+
217 reports with mileage · 196 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 93 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
39 crash reports3 fire reports14 injury reports
Vehicle Speed Control complaints
37 reports2016 SUBARU FORESTER XT WITH 57000 MILES. THE CEL CAME ON DURING A 5 MINUTE DRIVE AND STARTED TO STALL. AFTER STOPPING AND STARTING THE CAR, THE ENGINE CONTINUOUSLY SPUTTERED. CEL CAME ON, STABILITY CONTROL DISABLED, TRACTION CONTROL DISABLED, CRUISE CONTROL DISABLED. TO KEEP THE CAR FROM DYING, DRIVER HAD TO REV ENGINE. …
Read full complaint
2016 SUBARU FORESTER XT WITH 57000 MILES. THE CEL CAME ON DURING A 5 MINUTE DRIVE AND STARTED TO STALL. AFTER STOPPING AND STARTING THE CAR, THE ENGINE CONTINUOUSLY SPUTTERED. CEL CAME ON, STABILITY CONTROL DISABLED, TRACTION CONTROL DISABLED, CRUISE CONTROL DISABLED. TO KEEP THE CAR FROM DYING, DRIVER HAD TO REV ENGINE. DRIVER TOOK IT TO THE DEALERSHIP BECAUSE THE CAR WAS UNSAFE TO DRIVE (STALLED IN THE MIDDLE OF INTERSECTIONS). CEL WAS RESET AFTER DEALERSHIP CHANGED THE O2 SENSOR. CAR RAN FINE FOR 50 MILES. CEL CAME ON, STABILITY CONTROL, TRACTION CONTROL AND CRUISE CONTROL WERE ALL DISABLED. CAR WOULD SKID ON WET SURFACES. CAR WOULD STALL. CAR WOULD LAG ON THE THROTTLE RESPONSE AND THEN ACCELERATE AT A VERY HIGH-RATE, RESULTING IN NEAR MISS ACCIDENTS. RETURNED TO THE DEALERSHIP. BRAKE-LIGHT SENSOR WAS REPLACED FIRST AND CEL RESET. ISSUE APPEARED IMMEDIATELY AFTERWORDS AND ALL FUEL INJECTORS HAD TO REPLACED. DROVE CAR FROM DEALERSHIP AND 1 DAY LATER, SAME PROBLEM APPEARED. DEALERSHIP REPLACED EGR VALVE. DID NOT RESOLVE THE PROBLEM. AS OF AUGUST 20, 2018, THE CAR IS UNDRIVEABLE AND WITH THE DEALERSHIP UNDERGOING DIAGNOSTICS. ALL INCIDENTS OCCURRED WHILE THE VEHICLE WAS IN MOTION DRIVING ON BOTH A HIGHWAY, CITY STREET, AND MAKING TURNS. THE FAULT HAS NOT BEEN SUCCESSFULLY IDENTIFIED BUT ALL ATTEMPTS AT RESOLUTION HAVE BEEN ON THE FUEL, THROTTLE, AND EXHAUST SYSTEMS.
ON FIVE DIFFERENT OCCURRENCES WHILE THE CRUISE CONTROL WAS ON AND WE WERE DRIVING AT AROUND 70 MILES AN HOUR ON AN INTERSTATE, OUR CAR WOULD ELECTRONICALLY PUT ITSELF IN NEUTRAL, THE AUTOMATIC GEAR SHIFTER WOULD PHYSICALLY REMAIN IN DRIVE, THE RPM'S WOULD GO UP TO ABOUT 5500 RPMS, BECAUSE THE CAR WAS SLOWING DOWN AND THE CRUISE …
Read full complaint
ON FIVE DIFFERENT OCCURRENCES WHILE THE CRUISE CONTROL WAS ON AND WE WERE DRIVING AT AROUND 70 MILES AN HOUR ON AN INTERSTATE, OUR CAR WOULD ELECTRONICALLY PUT ITSELF IN NEUTRAL, THE AUTOMATIC GEAR SHIFTER WOULD PHYSICALLY REMAIN IN DRIVE, THE RPM'S WOULD GO UP TO ABOUT 5500 RPMS, BECAUSE THE CAR WAS SLOWING DOWN AND THE CRUISE CONTROL WAS ON. WE WOULD PULL OVER TO THE SIDE OF THE INTERSTATE AND THE ENGINE WILL SHUT OFF AFTER ABOUT 30 SECONDS. THREE OF THE FIVE TIMES, THE CAR WOULD START AFTER SITTING FOR ABOUT 15 MINUTES. THE THIRD TIME THE BATTERY DIED AFTER TRYING TO START IT A FEW TIMES WHILE IT WAS COLD OUT. THE FIFTH TIME THE CAR LEFT US STRANDED ON THE INTERSTATE FOR TWO HOURS WHILE WE WAITED FOR A TOW TRUCK. WE HAVE NOTIFIED SUBARU EVERY TIME THAT THE CAR WOULD DO THIS. ON THE THIRD TIME IT HAPPENED, SUBARU HAD US REMOVE THE REMOTE STARTER WE HAD PURCHASED AND INSTALLED AT BEST BUY. AFTER HAVING BEST BUY REMOVE THE REMOTE STARTED, I INSTALLED A DASHCAM BEHIND THE DRIVER TO RECORD THE DRIVER, DASHBOARD AND THE SHIFTER BECAUSE SUBARU COULD NOT FIND ANY EVIDENCE OF THIS ISSUE HAPPENING. THE FOURTH AND FIFTH TIME HAPPENED WHILE WE WERE ON A FAMILY VACATION OUT OF STATE. THE CAR WAS LEFT AT A DEALERSHIP OUT OF STATE AND FOUR WEEKS AFTER THE INCIDENT THEY DETERMINED IT WAS A FAULTY FUEL PUMP. I WAS TOLD ON THE PHONE THAT THEY WERE UNABLE TO TEST IF THE FUEL PUMP THEY REMOVED WAS IN FACT FAULTY. SUBARU TOLD ME THEY HAD A TECHNICIAN DRIVE IT FOR 500 MILES AND THEY DIDN'T EXPERIENCE THE SAME ISSUE. INCIDENTS WERE AT THE FOLLOWING MILEAGES - DATES: 31190 - MAY 27TH, 2017 34383 - AUGUST 27TH, 2017 APPROXIMATELY 42300 - FEBRUARY 2ND, 2018 51778 - AUGUST 9TH, 2018 52129 - AUGUST 14TH, 2018
TL* THE CONTACT OWNS A 2016 SUBARU FORESTER. WHILE ATTEMPTING TO PARK THE VEHICLE, IT SUDDENLY ACCELERATED WITHOUT THE ACCELERATOR PEDAL BEING DEPRESSED. AS A RESULT, THE VEHICLE CRASHED INTO A FENCE AND A POLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THERE WAS EXTENSIVE DAMAGE TO THE BUMPER. THE VEHICLE WAS TO…
Read full complaint
TL* THE CONTACT OWNS A 2016 SUBARU FORESTER. WHILE ATTEMPTING TO PARK THE VEHICLE, IT SUDDENLY ACCELERATED WITHOUT THE ACCELERATOR PEDAL BEING DEPRESSED. AS A RESULT, THE VEHICLE CRASHED INTO A FENCE AND A POLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THERE WAS EXTENSIVE DAMAGE TO THE BUMPER. THE VEHICLE WAS TOWED TO AN INDEPENDENT BODY SHOP AND THEN TO SUBARU OF ENGLEWOOD (135 SOUTH DEAN STREET, ENGLEWOOD, NJ 07631, (201) 816-6000). THE DEALER STATED THAT THEY COULD NOT FIND ANY FAILURES. THE CONTACT RESEARCHED AND LEARNED OF MANY SIMILAR OCCURRENCES, WHICH WERE DUE TO ELECTRICAL FAILURES. THE MANUFACTURER STATED THAT THERE WAS AN EVENT DATA RECORDER THAT THE DEALERS DID NOT HAVE AND THEY WERE INVESTIGATING THE MATTER. THE MANUFACTURER FURTHER STATED THAT THEY WOULD CALL THE CONTACT IF THEY DECIDE TO SEND THE EQUIPMENT TO THE DEALER FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS 20,000. THE CONSUMER STATED THE VEHICLE HAS HAD TO INCIDENTS OF SUDDEN ACCELERATION THAT CAUSED THE VEHICLE TO CRASH INTO OTHER VEHICLES CAUSING DAMAGE.*JS
TL* THE CONTACT OWNS A 2016 SUBARU FORESTER. THE CONTACT STATED THAT THE VEHICLE ACCELERATED UNEXPECTEDLY AND CRASHED INTO A FENCE ON OCTOBER 24, 2017. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE LOCAL DEALER WAS NOT CONTACTED THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THER…
Read full complaint
TL* THE CONTACT OWNS A 2016 SUBARU FORESTER. THE CONTACT STATED THAT THE VEHICLE ACCELERATED UNEXPECTEDLY AND CRASHED INTO A FENCE ON OCTOBER 24, 2017. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE LOCAL DEALER WAS NOT CONTACTED THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN. ON JULY 18, 2018, WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE ACCELERATED AGAIN AND CRASHED INTO A SECURITY POLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND REFERRED THE CONTACT TO THE LOCAL DEALER. THE FAILURE MILEAGE WAS 20,000.
DURING PERIODS OF HEAVY RAIN, THE VEHICLE APPEARS TO SUFFER MAJOR ELECTRICAL ISSUES. SINCE FEBRUARY OF 2018, MY VEHICLE HAS REPORTED PROBLEMS AFTER A MAJOR STORM WITH THE EYESIGHT CAMERA SYSTEM, ABS, HILL ASSIST, AND FUEL GAUGE. FYI-EYESIGHT INCLUDES THE DYNAMIC CRUISE CONTROL, CRASH AVOIDANCE, AND LANE MONITORING SYSTEM. TH…
Read full complaint
DURING PERIODS OF HEAVY RAIN, THE VEHICLE APPEARS TO SUFFER MAJOR ELECTRICAL ISSUES. SINCE FEBRUARY OF 2018, MY VEHICLE HAS REPORTED PROBLEMS AFTER A MAJOR STORM WITH THE EYESIGHT CAMERA SYSTEM, ABS, HILL ASSIST, AND FUEL GAUGE. FYI-EYESIGHT INCLUDES THE DYNAMIC CRUISE CONTROL, CRASH AVOIDANCE, AND LANE MONITORING SYSTEM. THE ISSUE HAS BEEN REPORTED TO OUR SUBARU DEALER/MAINTENANCE TEAM BUT THEY HAVE NOT BEEN ABLE TO DISCOVER THE SOURCE OF THE ISSUE.
I WAS PARKING MY CAR. I HAD THE BRAKE APPLIED AND PUT IT IN PARK. THE CAR ACCELERATED ON ITS OWN OVER A PARKING BARRIER, OVER A 1.5' STONE BARRIER, UP A SMALL GRADE AND INTO AND PARTIALLY THRU A CONCRETE PATIO WALL. THE CAR'S GEARSHIFT WAS IN PARK. I HAD TO MOVE IT BACK TO REVERSE TO GET IT BACK INTO THE PARKING SPACE. AND E…
Read full complaint
I WAS PARKING MY CAR. I HAD THE BRAKE APPLIED AND PUT IT IN PARK. THE CAR ACCELERATED ON ITS OWN OVER A PARKING BARRIER, OVER A 1.5' STONE BARRIER, UP A SMALL GRADE AND INTO AND PARTIALLY THRU A CONCRETE PATIO WALL. THE CAR'S GEARSHIFT WAS IN PARK. I HAD TO MOVE IT BACK TO REVERSE TO GET IT BACK INTO THE PARKING SPACE. AND EVEN THOUGH THE IMPACT WAS SUBSTANTIAL THE AIRBAG DID NOT DEPLOY.
DRIVER WAS PARKING FRONT FIRST INTO A PARKING SPOT, TRAVELING STRAIGHT FORWARD AT LESS THAN 5 MPH. WHEN THE 2016 SUBARU FORESTER REACHED THE PROPER PARKING LOCATION, THE DRIVER, WITH HIS FOOT ON THE BRAKE, ATTEMPTED TO MOVE THE GEAR SHIFTER FROM D TO P. SUDDENLY THE ENGINE REV'D AND THE CAR LURCHED FORWARD, OVER THE PARKING CONC…
Read full complaint
DRIVER WAS PARKING FRONT FIRST INTO A PARKING SPOT, TRAVELING STRAIGHT FORWARD AT LESS THAN 5 MPH. WHEN THE 2016 SUBARU FORESTER REACHED THE PROPER PARKING LOCATION, THE DRIVER, WITH HIS FOOT ON THE BRAKE, ATTEMPTED TO MOVE THE GEAR SHIFTER FROM D TO P. SUDDENLY THE ENGINE REV'D AND THE CAR LURCHED FORWARD, OVER THE PARKING CONCRETE BLOCK, OVER A SMALL BUSH AND INTO THE WINDOW WALL OF THE ADJACENT CONDO. DAMAGE WAS SUSTAINED TO THE WALL, AND RIGHT HAND SIDE FRONT OF VEHICLE. DRIVER STATED THAT HE COULD NOT DO ANYTHING ELSE BECAUSE HIS FOOT WAS ALREADY ON THE BRAKE. NEITHER AIRBAG DEPLOYED.
I'VE HAD THE SAME ISSUE HAPPEN ON 2 SEPARATE OCCASIONS (OCTOBER AND NOVEMBER 2016) - WHILE DRIVING THE CAR I BOUGHT BRAND NEW, AND GOING APPX. 75 MPH DOWN THE INTERSTATE, DRIVING APPROXIMATELY 2 HOURS STRAIGHT ON FLAT INTERSTATE, THE RPM'S ALL OF A SUDDEN SHOOT UP AND IT FEELS LIKE MY CAR FALLS OUT OF GEAR. THE CAR ESSENTIALLY …
Read full complaint
I'VE HAD THE SAME ISSUE HAPPEN ON 2 SEPARATE OCCASIONS (OCTOBER AND NOVEMBER 2016) - WHILE DRIVING THE CAR I BOUGHT BRAND NEW, AND GOING APPX. 75 MPH DOWN THE INTERSTATE, DRIVING APPROXIMATELY 2 HOURS STRAIGHT ON FLAT INTERSTATE, THE RPM'S ALL OF A SUDDEN SHOOT UP AND IT FEELS LIKE MY CAR FALLS OUT OF GEAR. THE CAR ESSENTIALLY SHUTS DOWN AND FAILS TO ACCELERATE AND SLOWS DOWN QUICKLY, WHILE TOTALLY UNRESPONSIVE. WE HAVE TO QUICKLY PULL OFF THE ROAD TO AVOID BEING HIT. SEVERAL LIGHTS SHOW ON THE DASH (HAVE PHOTO) AND THE VEHICLE DOES NOT RESPOND TO ACCELERATION. WE HAD TO SHUT THE CAR OFF COMPLETELY AND TURN IT BACK ON - NO RESPONSE TO ACCELERATION OR ANYTHING. IT DID NOT RESPOND UNTIL THE 2ND TIME TURNING IT OFF AND BACK ON. UPON BRINGING TO DEALERSHIP, THEY HAVE NOT BEEN ABLE TO PULL ANY CODES OR DUPLICATE THE ERROR (EITHER TIME). THEY ALSO HAD A SUBARU FIELD ENGINEER LOOK AT IT AND FOUND NOTHING. I AM CONTINUOUSLY SENT AWAY WITHOUT A SOLUTION OTHER THAN TO "CALL ROADSIDE ASSISTANCE" IF IT HAPPENS AGAIN, WHICH PUTS MYSELF AND OTHERS IN SERIOUS DANGER. THE MOST RECENT TIME THEY PUT 300 MILES ON IT AND FOUND THAT IT "FELL OUT OF CRUISE CONTROL", BUT AREN'T OFFERING TO FIX IT AND DIDN'T ACTUALLY DUPLICATE THE SAME ERROR AS I HAD. I'M AFRAID I'M GOING TO GET INTO A SERIOUS CAR ACCIDENT AND HURT MYSELF OR SOMEONE ELSE THE NEXT TIME THIS HAPPENS. IT FEELS LIKE SUBARU (OR DEALER) ISN'T OWNING UP TO THIS PROBLEM OR POSSIBLY TRYING TO COVER IT UP TO KEEP THEIR GOOD SAFETY RATINGS. THE DEALERSHIP HAS TOLD ME THAT I'M "THE ONLY PERSON IN THE WHOLE UNITED STATES REPORTING THIS ISSUE", WHICH I FIND VERY DIFFICULT TO BELIEVE.
AT LOW SPEED (UNDER 15 MPH) A HESITATION OCCURS CAUSING THE VEHICLE TO LOOSE ACCELERATION POWER FOR AS LONG AS 3 OR 4 SECONDS. IT IS AN INTERMITTENT PROBLEM OCCURRING ONLY 8 TIMES IN THREE MONTHS. PROBLEM ALMOST CAUSED A COLLISION WHILE TURNING LEFT BEFORE ONCOMING TRAFFIC. LATER RECURRENCES PRODUCED THE SAME PROBLEM DURING RIGH…
Read full complaint
AT LOW SPEED (UNDER 15 MPH) A HESITATION OCCURS CAUSING THE VEHICLE TO LOOSE ACCELERATION POWER FOR AS LONG AS 3 OR 4 SECONDS. IT IS AN INTERMITTENT PROBLEM OCCURRING ONLY 8 TIMES IN THREE MONTHS. PROBLEM ALMOST CAUSED A COLLISION WHILE TURNING LEFT BEFORE ONCOMING TRAFFIC. LATER RECURRENCES PRODUCED THE SAME PROBLEM DURING RIGHT TURNS ALSO. WE RETURNED THE CAR TO THE DEALER AND PURCHASED A 2017 OF THE SAME MODEL HOPING THIS PROBLEM WILL BE SOLVED.
Official recalls
319V701000 · Air Bags:sensor:occupant Classification
Oct 3, 2019
Subaru of America, Inc. (Subaru) is recalling certain 2015-2018 Forester vehicles equipped with heated seats. An electrical connection in the front passenger seat for the Occupant Detection System (ODS) may loosen.
Consequence & remedy
Consequence: If the connection loosens, the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.
Remedy: Subaru will notify owners, and dealers will inspect and, as necessary, replace the ODS sensor mat harness, free of charge. The recall began February 11, 2020. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUM-98.
19V149000 · Exterior Lighting:brake Lights:switch
Feb 28, 2019
Subaru of America, Inc. (Subaru) is recalling certain 2014-2016 Forester, 2008-2016 Impreza sedans, 2012-2016 Impreza station wagons, 2008-2014 WRX sedans (including STI), and 2013-2017 Crosstrek vehicles. Exposure to certain contaminants may cause the brake light switch to malfunction, preventing the brake lights from illuminating and also preventing keyless ignition vehicles from starting and CVT/automatic transmissions from being able to be shifted out of Park.
Consequence & remedy
Consequence: Brake lights that do not illuminate properly will not alert other drivers that the vehicle is slowing or stopping, increasing the risk of crash.
Remedy: Subaru will notify owners, and dealers will replace the brake light switch, free of charge. The recall began April 15, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUE-90.
16V162000 · Engine And Engine Cooling:engine:gasoline:turbo/supercharger
Mar 21, 2016
Subaru of America, Inc. (Subaru) is recalling certain model year 2015-2016 WRX vehicles manufactured April 10, 2015, to October 21, 2015, and Forester 2.0XT vehicles manufactured April 10, 2015, to October 20, 2015. The turbocharger air intake duct may crack and possibly result in an engine stall.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Subaru will notify owners, and dealers will inspect the turbocharger air intake duct, and replace it as necessary, free of charge, depending on the lot number found on the duct. The recall began April 2016. Owners may contact Subaru customer service at 1-800-782-2783. Subaru's number for this recall is WTA-62.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19009 · Occupant Detection System (ods) Failure
Opened Aug 6, 2019 · Closed Jan 22, 2020
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:passenger Side:inflator Module; Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Additional source detail variants (4)
Air Bags:frontal:passenger Side:inflator Module
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:frontal
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.