2016 Subaru Crosstrek

While driving down the highway, the hood popped open and slammed backwards, shattering my windshield, damaging both fenders (to the point where the hood could not be lowered back down), and wrinkling the roof. I was in the middle lane and had to navigate blindly over to the shoulder, while covered in glass; miraculously, I was able to do so safely. It is a miracle I was not hurt or killed and that others around me were not hurt or killed. There was very real potential for a multi car pile up that day. I'm not aware of reproduction or confirmation of the problem. Police responded, but stated since I did not hit anything, there would be no accident report. My insurance inspected the vehicle at least twice, as did my mechanic throughout the course of his estimation and repair. At my last oil change at the dealership (months prior), the desk agent mentioned the auto techs had a hard time getting my hood closed but recommended no further service to me.

Sunroof exploded - driving on interstate at about 75 miles an hour, Sunday around 11:30a, temperature around 80 degrees, no flying debris, heard something like a small explosion and then shattered car glass blowing along roof. Pulled over to see the sunroof looked like it had blown up and out leaving hole about a foot wide. The interior ceiling panel had been closed so I couldn't see it from the inside, no damage to the interior panel that I could see. The car had been parked under my car port overnight, I'd been on the road about 15-20 minutes, no drastic changes in weather and no sounds from roof before explosion. No apparent damage to car/roof prior to explosion.

In October 2020, the OEM transmission on my 2016 Subaru Crosstrek failed at 87,500 miles. The transmission was covered under a recent extension of the warranty from 60,000 to 100,000 miles. See website info regarding extended warranty: https://static.nhtsa.gov/odi/tsbs/2018/MC-10146475-9999.pdf After driving the "new" transmission for 18 months and 40,000 miles, the transmission failed again. This time, Subaru America refused, at first, to admit any fault. They initially offered $1000 for replacement, then increased to $3500 as a final offer. My out of pocket was $4710. Now, after 8 months and less than 12,000 miles, the transmission has failed AGAIN. This transmission is under a 1 year/unlimited miles warranty. This will be the 4th transmission in a vehicle with 143,000 miles on it.

Car caught fire from what seemed to be an electrical issue. Car became engulfed in flames within a few seconds. Fire department was called to extinguish the fire. I was lucky myself to make it out in time. The fire became so big, so quickly, I was concerned for the safety of the surrounding property. Luckily, no one was injured and no property damage took place. Car was inspected and totaled by insurance. The headlights were constantly needing to be changed. Otherwise the car was fine. I had just replaced the battery and just a few hours later the fire happened. The fire appeared to start somewhere under the hood on the passenger side.

On 3/30 my steering column started to make a grinding sound when I turned my steering wheel over 90 degrees to make a turn. On 3/31 the airbag light went on and I made an appointment to bring it in to get looked at by my nearest Subaru dealership (Tacoma Subaru). I was told the light meant the airbags would not deploy if I got into a car accident so I didn’t drive my car until I needed to pick up grocery order on 4/2. On 4/2 I was making a slow right hand turn into the parking lot and my airbag deployed as I turned and hit/burned my forearm through a heavy sweatshirt. I didn’t bump it, experience an impact or accident of any kind. It simply deployed while I was turning without any warning.

My car has stopped working while driving 70 mph on the interstate in so separate occasions. Both times it has been driving fine, with fuel in the tank, and all of the sudden it shuts off and completely loses power. All of the warning lights on the dash light up and the only thing to do is to coast to the shoulder of the highway. Couldn’t start the car back up (cranked, no start). Battery is fine. Fuel level is fine. First time it happened it had to be towed. Towed to mechanic who ran diagnostics on it the next day but nothing threw a code. It started fine the next day. I’ve had certified Subaru mechanics tear this thing apart trying to figure out what causes the issue but they can’t find anything wrong. I’m scared this is going to happen again and will put me in a dangerous situation in the middle of a highway or on the side of the road. This is definitely an issue putting myself and others at risk. It seems similar to other issues Subaru crosstreks have had in close model years to mine (20 where recalls have been issued for fuel pump malfunctions etc. Please look into this, this could cause a terrible wreck and needs to be resolved ASAP.

My friend and I drove from Minneapolis to Duluth for a two-day short trip (Oct 20 - 21, 2022). On our way back, my car suddenly slowed down (from 70 m/h to 40 m/h and was non-responsive), and shut down completely at the intersection between Highway I-35 W and Lino Lake, MN 55038, about 30 miles away from TC around 8:30 pm, Friday night. And then I cannot start my car at all. Originally I thought it was the gas issue but the screen indicated there were at least 100miles to drive. Therefore, I called 911 right after (see EXHIBIT 1) and asked for help as well as Subaru roadside service (see EXHIBIT 2 ). Fortunately, my car stopped at the shoulders and we were not involved in a crash. This happened three days AFTER I had my car maintenance (Oct 17 at 10:15 am, Morrie's Minnetonka Subaru, 12520 Wayzata Blvd, Minnetonka, MN 55305), and according to the report from that maintenance, the car was functioning well and had no red flag (see EXHIBIT 3). My car is currently located at Morrie's Minnetonka Subaru for further inspection. However, as far as I know so far (from the dealership mechanics), they have no clue what happened and they need to ask for additional help to figure out why the car engine suddenly lost power. In addition, I saw this is not a solo accident, many other Subaru Crosstrek Owners have encountered similar situations (i.e., lost power completely on the highway or freeway after regular car maintenance). Please see EXHIBIT 4 for detailed information.

At 89,000 the transmission was replaced because of a “known issue” and I was having problems. The car would lurch and hesitate coming off traffic stops. This prompted me to go to the dealer who called Subaru who offered to replace transmission, no further questions asked. Less than 20,000 miles later, this new transmission is causing problems again to the tune of $12,000! They refuse to replace it at no charge when they KNOW the CVT transmissions have issues