IllustrationCONSUMER EXPERENCING PROBLEMS WITH REPLACING THE BATTERY. BATTERY HAS BEEN REPLACED ON FIVE DIFFERENT OCCASIONS. DEALER UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. PLEASE PROVIDE ANY FURTHER DETAILS. *AK
1991 Saturn Sl
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1991 Saturn Sl do not stand out strongly from the model-year median of 171.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sl years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 29 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seat Belts. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seats. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports1 fire reports3 injury reports
What owners actually said
29 reportsI INQUIRED THE SERVICE DEPARTMENT AT SATURN OF MONROVIA (MONROVIA,CA, 91016) IF THEY WERE AWARE OF THE AFOREMENTIONED PROBLEMS. THEY DENIED ANY KNOWLEDGE OF ANY PROBLEMS ASSOCIATED WITH ELECTRICAL WIRING UNDER THE HOOD. *AK
NONE
THE SEAT BELTS ARE ELECTRIC AND ARE SUPPOSE TO SLIDE ALONG THE INTERIOR SURFACE. THE PASSENGER SIDE WENT OUT FIRST, AND A PERMANENT LATCH WAS PUT IN SO THAT ANY ONE SITTING ON THE PASSENGER SIDE HAVE TO CLAMP THE SEAT BELT EVERY TIME THE ENTER AND EXIT THE CAR. SOMETIME LATER THE DRIVER SIDE SEAT BELT WENT OUT. THE SEAT CABLE…
Read full complaint
THE SEAT BELTS ARE ELECTRIC AND ARE SUPPOSE TO SLIDE ALONG THE INTERIOR SURFACE. THE PASSENGER SIDE WENT OUT FIRST, AND A PERMANENT LATCH WAS PUT IN SO THAT ANY ONE SITTING ON THE PASSENGER SIDE HAVE TO CLAMP THE SEAT BELT EVERY TIME THE ENTER AND EXIT THE CAR. SOMETIME LATER THE DRIVER SIDE SEAT BELT WENT OUT. THE SEAT CABLE WOULD PULL THE LATCH BUT WOULD NOT SECURE THE LATCH TO LOCK. WITH THE LATCH NOT LOCKING I COULD STILL CLAMP THE SEAT BELT ON TO THE LATCH. I WOULD CLAMP THE SEAT BELT ON THE LATCH EVEN THOUGH IT WOULD NOT LOCK, TO AVOID GETTING A CITATION FOR NOT HAVING A SEAT BELT. MY MAIN CONCERN IS IF I WAS TO GET INTO AN ACCIDENT WITH THE SIT BELT NOT SECURED, I AM AFRAID THAT MY SEAT BELT WILL NOT PROTECT ME.
NO SUMMARY PROVIDER BY CONSUMER.
WHILE DRIVING VEHICLE 60 MPH ON THE FREEWAY VEHICLE STARTED ACCELERATING BY ITSELF. DRIVER STEPPED ON THE BRAKES TO STOP. BUT VEHICLE DID NOT STOP, AND DRIVING OVER CURVES WITHOUT STOPPING, SHE FINALLY STOPPED IT BY PULLING THE IGNITION KEY ON A MALL PARKING LOT. *AK
DRIVER SIDE AUTOMATIC SEAT BELT FAILED.
DRIVER'S SIDE AUTOMATIC SHOULDER BELT FAILURE.
THE DRIVER'S SIDE AUTOMATIC SEAT BELT FAILURE.
WHILE COMING TO A STOP THE RIGHT FRONT WHEEL FOUR LUG: NUTS BROKE OFF, CAUSING THE WHEEL TO FALL OFF. PLEASE PROVIDE DETAILS. *AK
Official recalls
193V132000 · Electrical System:alternator/generator/regulator
Aug 10, 1993
THE GENERATOR ELECTRICAL WIRING IS NOT PROTECTED AGAINST EXCESSIVE CURRENT FLOW WHICH MAY BE CAUSED BY AN ELECTRICAL SHORT CIRCUIT IN THE GENERATOR.
Consequence & remedy
Consequence: SHOULD AN ELECTRICAL SHORT CIRCUIT OCCUR IN THEGENERATOR, THE GENERATOR WIRING HARNESS WOULD EXPERIENCE EXCESSIVE CURRENT FLOW.UNDER CERTAIN CONDITIONS, ENOUGH HEAT COULD BE GENERATED TO IGNITE SURROUNDINGMATERIALS. IF THIS OCCURS, AN UNDERHOOD FIRE COULD RESULT WITH OR WITHOUT THEENGINE RUNNING AND WITHOUT PRIOR WARNING.
Remedy: THE GENERATOR WIRING HARNESS WILL BE REPLACED WITH ONE THAT WILL OPEN AS A FUSE WOULD UNDER CERTAIN EXCESSIVE CURRENT FLOW CONDITIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA93016 · Fr Seatback Recliner Fails
Opened Jun 8, 1993 · Closed Jul 26, 1994
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
There is no summary currently available