IllustrationTL* THE CONTACT OWNS A 2008 SATURN SKY. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE AIR BAG SENSOR WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.
2008 Saturn Sky
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sky years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
630–25K
3125–50K
2950–75K
875–100K
6100–150K
0150K+
137 reports with mileage · 49 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 94 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports1 fire reports3 injury reports
What owners actually said
186 reportsBRAKE FAILURE. HARD BRAKE PEDAL RESULTING IN THE BRAKES NOT HOLDING THE CAR AT A STOP. ON JULY 4, 2012 WHILE STOPPED AT AN INTERSECTION THE BRAKES FAILED TO HOLD THE CAR INPLACE RESULTING IN THE CAR CREEPING INTO THE CENTER OF THE INTERSECTION INTO ONCOMING TRAFFIC. A JEEP WITH 6 PEOPLE AND AN INFANT HIT THE RIGHT FRONT SIDE OF…
Read full complaint
BRAKE FAILURE. HARD BRAKE PEDAL RESULTING IN THE BRAKES NOT HOLDING THE CAR AT A STOP. ON JULY 4, 2012 WHILE STOPPED AT AN INTERSECTION THE BRAKES FAILED TO HOLD THE CAR INPLACE RESULTING IN THE CAR CREEPING INTO THE CENTER OF THE INTERSECTION INTO ONCOMING TRAFFIC. A JEEP WITH 6 PEOPLE AND AN INFANT HIT THE RIGHT FRONT SIDE OF THE CAR AND FLIPPED OVER. THE INFANT AND 2 OF THE PEOPLE IN THE JEEP ARE IN THE HOSPITAL. THE ACCIDENT HAPPENED ON HWY. 84 IN DALEVILLE, ALABAMA. *TR
I WAS TRYING TO TURN THE AC ON BECAUSE IT IS 102 DEGREES OUTSIDE. WHEN I WAS TURNING THE KNOB ON THE CLIMATE CONTROL MODULE TO COLD IT NEVER CHANGED IT STAYED BLOWING HOT. ALSO WHEN I TRIED TO GET THE FAN TO BLOW TOWARDS ME IT WAS STUCK IN THE MODE WHERE IT BLOWS ON THE FLOOR. WHILE IT IS STUCK IN THE MID AND WONT CHANGED ITS ST…
Read full complaint
I WAS TRYING TO TURN THE AC ON BECAUSE IT IS 102 DEGREES OUTSIDE. WHEN I WAS TURNING THE KNOB ON THE CLIMATE CONTROL MODULE TO COLD IT NEVER CHANGED IT STAYED BLOWING HOT. ALSO WHEN I TRIED TO GET THE FAN TO BLOW TOWARDS ME IT WAS STUCK IN THE MODE WHERE IT BLOWS ON THE FLOOR. WHILE IT IS STUCK IN THE MID AND WONT CHANGED ITS STEADY BLOWING OUT HOT AIR EVEN WHEN THE MODULE FOR THE FAN IS TURNED OFF. THIS IS CRAZY THAT MOST OF THE SATURN VUE I READ HAVE THE SAME PROBLEM AND SOMETHING IS ALWAYS MISSING. THERE NEEDS TO BE A SERIOUS RECALL ON THIS VEHICLE SINCE THESE WERE THE LAST ONES MADE. *TR
TL* THE CONTACT OWNS A 2008 SATURN SKY REDLINE. THE CONTACT STATED THAT THE AIR BAG OFF INDICATOR DID NOT ILLUMINATE WHEN AN OCCUPANT WAS POSITIONED IN THE FRONT PASSENGER SEAT. THE FAILURE OCCURRED SPORADICLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON FIVE SEPARATE OCCASIONS, WHERE THE PASSENGER PRESENCE SYSTEM SENSOR AN…
Read full complaint
TL* THE CONTACT OWNS A 2008 SATURN SKY REDLINE. THE CONTACT STATED THAT THE AIR BAG OFF INDICATOR DID NOT ILLUMINATE WHEN AN OCCUPANT WAS POSITIONED IN THE FRONT PASSENGER SEAT. THE FAILURE OCCURRED SPORADICLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON FIVE SEPARATE OCCASIONS, WHERE THE PASSENGER PRESENCE SYSTEM SENSOR AND THE SENSING DIAGNOSTIC MODULE WERE REPLACED AT DIFFERENT TIMES. THE FAILURE CONTINUED TO OCCUR AFTER THE REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 6,027. UPDATED 9/19/11 *CN UPDATED 01.23.12
TL*THE CONTACT OWNS A 2008 SATURN SKY. THE CONTACT STATED THAT THE BRAKE BOOSTER VACUUM DOES NOT WORK. THE MANUFACTURER INFORMED HIM THAT HE MUST WAIT SIXTY SECONDS FOR THE BRAKES TO WORK. THE CONTACT STATED THAT THE MANUFACTURER DOES NOT WANT TO REPAIR THE VEHICLE. HE DOES NOT UNDERSTAND WHY HE MUST WAIT SIXTY SECONDS TO DR…
Read full complaint
TL*THE CONTACT OWNS A 2008 SATURN SKY. THE CONTACT STATED THAT THE BRAKE BOOSTER VACUUM DOES NOT WORK. THE MANUFACTURER INFORMED HIM THAT HE MUST WAIT SIXTY SECONDS FOR THE BRAKES TO WORK. THE CONTACT STATED THAT THE MANUFACTURER DOES NOT WANT TO REPAIR THE VEHICLE. HE DOES NOT UNDERSTAND WHY HE MUST WAIT SIXTY SECONDS TO DRIVE A NEW MODEL VEHICLE. THE CURRENT MILEAGE WAS 15,000 AND FAILURE MILEAGE WAS 14,000.
TL*THE CONTACT OWNS A 2008 SATURN SKY. WHILE DRIVING APPROXIMATELY 55 MPH ON NORMAL ROAD CONDITIONS, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IMMEDIATELY, WHITE SMOKE APPEARED FROM THE INSTRUMENT PANEL, WHICH RESULTED IN REDUCED VISIBILITY. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD WIT…
Read full complaint
TL*THE CONTACT OWNS A 2008 SATURN SKY. WHILE DRIVING APPROXIMATELY 55 MPH ON NORMAL ROAD CONDITIONS, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IMMEDIATELY, WHITE SMOKE APPEARED FROM THE INSTRUMENT PANEL, WHICH RESULTED IN REDUCED VISIBILITY. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD WITH CAUTION AND ROADSIDE ASSISTANCE WAS CALLED TO THE SCENE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR INSPECTION AND THEY STATED THAT THE HEATING AND AIR CONDITIONING SYSTEM CAUSED THE FAILURE. THE SYSTEM WAS REPLACED. THE CONTACT SMELLED A STRONG ODOR OF COOLANT INSIDE THE VEHICLE FOLLOWING THE REPAIR AND THE TRACTION CONTROL FAILED TO OPERATE. WHENEVER THE VEHICLE WAS IN OPERATION, THE ABS WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. ON SIX SEPARATE OCCASIONS, THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALER FOR IDENTICAL FAILURES, BUT THERE WERE NO RESOLUTIONS. THE FAILURE MILEAGE WAS 2,000 AND CURRENT MILEAGE WAS 15,500.
TL*THE CONTACT OWNS A 2008 SATURN SKY REDLINE. UPON STARTING THE VEHICLE, THE CONTACT NOTICED THAT THE BRAKES WERE INOPERATIVE. HE ATTEMPTED TO UTILIZE THE BRAKES SEVERAL TIMES WHILE BACKING OUT OF HIS DRIVEWAY. HE HAD TO PUMP THE BRAKE PEDAL OVER EIGHT TIMES IN ORDER FOR THE BRAKING SYSTEM TO ENGAGE. ON A SEPARATE OCCASION,…
Read full complaint
TL*THE CONTACT OWNS A 2008 SATURN SKY REDLINE. UPON STARTING THE VEHICLE, THE CONTACT NOTICED THAT THE BRAKES WERE INOPERATIVE. HE ATTEMPTED TO UTILIZE THE BRAKES SEVERAL TIMES WHILE BACKING OUT OF HIS DRIVEWAY. HE HAD TO PUMP THE BRAKE PEDAL OVER EIGHT TIMES IN ORDER FOR THE BRAKING SYSTEM TO ENGAGE. ON A SEPARATE OCCASION, WHILE DRIVING LESS THAN 5 MPH, THE BRAKING SYSTEM WOULD NOT OPERATE AND THE VEHICLE ROLLED AWAY UNTIL IT STOPPED ON ITS OWN. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT A PUMP WAS NEEDED, WHICH WOULD ASSIST THE BRAKING SYSTEM WITH BUILDING UP PRESSURE IN ORDER FOR THE BRAKES TO ENGAGE. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 14,000. UPDATED 3/19/09 *CN UPDATED 03/25/09.*JB
2008 SATURN SKY REDLINE 700 MILES ON THE OD BRAKE PROBLEM. COLD START PRODUCES PEDAL VIBRATION AND LITTLE OR NO BRAKE POWER. FORTUNATELY I HAVEN'T RAN INTO ANYTHING. *TR
TL*THE CONTACT OWNS A 2008 SATURN SKY. THE CONTACT STATED THAT HER VEHICLE HAS BEEN LEAKING GASOLINE FOR APPROXIMATELY THREE MONTHS. THE DEALER COULD NOT DETERMINE THE CAUSE OF THE FAILURE; HOWEVER, THEY FOUND A HOLE IN THE HOSE AND MADE THE REPAIR. SHE WENT TO PUMP GAS INTO THE VEHICLE AND FUEL STILL LEAKS OUT. THE CURRENT …
Read full complaint
TL*THE CONTACT OWNS A 2008 SATURN SKY. THE CONTACT STATED THAT HER VEHICLE HAS BEEN LEAKING GASOLINE FOR APPROXIMATELY THREE MONTHS. THE DEALER COULD NOT DETERMINE THE CAUSE OF THE FAILURE; HOWEVER, THEY FOUND A HOLE IN THE HOSE AND MADE THE REPAIR. SHE WENT TO PUMP GAS INTO THE VEHICLE AND FUEL STILL LEAKS OUT. THE CURRENT AND FAILURE MILEAGES WERE 67,000.
TL*THE CONTACT OWNS A 2008 SATURN SKY REDLINE. WHENEVER THE VEHICLE HAS BEEN PARKED FOR MORE THAN 5 OR 6 HOURS, THERE IS POOR POWER BRAKE ASSIST FUNCTIONALITY. WHEN THE BRAKE PEDAL IS DEPRESSED, THE PEDAL IS EXTREMELY HARD AND CAUSES THE CONTACT TO APPLY MORE PRESSURE TO GET THE VEHICLE TO STOP. THE FAILURE WAS NOTICED WHILE …
Read full complaint
TL*THE CONTACT OWNS A 2008 SATURN SKY REDLINE. WHENEVER THE VEHICLE HAS BEEN PARKED FOR MORE THAN 5 OR 6 HOURS, THERE IS POOR POWER BRAKE ASSIST FUNCTIONALITY. WHEN THE BRAKE PEDAL IS DEPRESSED, THE PEDAL IS EXTREMELY HARD AND CAUSES THE CONTACT TO APPLY MORE PRESSURE TO GET THE VEHICLE TO STOP. THE FAILURE WAS NOTICED WHILE DRIVING 5 MPH. AFTER A FEW MINUTES OF THE VEHICLE RUNNING, THE BRAKES RETURN TO NORMAL. HE TOOK THE VEHICLE TO THE DEALER AND THEY REPROGRAMMED THE BRAKE CONTROL MODULE ACCORDING TO A GM SERVICE BULLETIN; HOWEVER, THAT DID NOT CORRECT THE FAILURE. HE TOOK THE VEHICLE TO THE DEALER FOR A SECOND TIME, BUT THEY WERE UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE DEALER HAS NOT RESPONDED OR CALLED BACK. THE FAILURE MILEAGE WAS 50 AND CURRENT MILEAGE WAS 900. UPDATED 09/10/08 *BF UPDATED 09/10/08. *JB
Official recalls
417V061000 · Air Bags:sensor:occupant Classification
Jan 26, 2017
General Motors LLC (GM) is recalling certain 2006-2010 Pontiac Solstice and 2007-2010 Saturn Sky vehicles. The Passenger Air Bag Suppression System (PPS) sensor may become bent or damaged within the front passenger seat, possibly disabling the front passenger air bag.
Consequence & remedy
Consequence: In the event of a crash, if the front passenger air bag does not deploy as intended, the front passenger has an increased risk of injury.
Remedy: The remedy for this recall is still under development. A permanent remedy is currently under development. The recall began February 26, 2018. Owners may contact Pontiac customer service at 1-800-762-2737 or Saturn customer service at 1-800-553-6000. GM's number for this recall is 17036.
14V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
07V454000 · Seat Belts:front:anchorage
Sep 26, 2007
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." AND STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THESE VEHICLES MAY HAVE ONE TO FOUR INBOARD SEAT STUD FASTENERS THAT DO NOT MEET SPECIFICATION FOR STRENGTH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT AND SEAT BELT ASSEMBLY MAY NOT RESTRAIN THE OCCUPANT AS INTENDED AND COULD RESULT IN INJURY TO THE OCCUPANT.
Remedy: DEALERS WILL INSPECT THE INBOARD SEAT STUDS AND, IF NECESSARY, REMOVE THE STUD AND INSTALL A BOLT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 10, 2007. OWNERS MAY CONTACT PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP20002 · Hvac Blower Motor Connector
Opened Feb 7, 2020 · Closed Oct 27, 2022
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash
The Office of Defects Investigation (ODI) has completed its review of a Defect Petition received December 12, 2019 requesting an investigation into the possibility of passenger compartment fires attributed to overheating HVAC blower motor connectors in Model Years (MY) 2006-2010 Pontiac Solstice and Saturn Sky vehicles.An analysis of General Motors (GM) complaint data and information in NHTSA?s databases identified thirteen unique vehicle identification numbers (VINs) with reported incidents that could pertain to blower motor overheating, smoking, or melting in the 90,938 MY2006-2010 Saturn Sky and Pontiac Solstice vehicles produced. Two of the thirteen cited incidents reported smoke and thermal damage that may be attributed to the HVAC blower motor although neither incident was confirmed through vehicle inspection. One incident, a MY2008 Saturn Sky with substantial field exposure from a frontal collision, could not have the root cause identified. The other, a MY2007 Pontiac Solstice, did not inform the manufacturer nor take the vehicle to a dealer for evaluation.Most of the 13 incidents reported an overheated or discolored connector with attendant loss of HVAC blower fan function. GM reported 354 warranty claims with the subject components for the Sky and Solstice, none of which included a report of fire and only one report of smoke. Over a period of ten to fourteen years in service, there are two reports of smoke or thermal damage.While the subject Sky and Solstice vehicles and the recalled Hummer H3 and H3T vehicles do share common components, the Sky and Solstice vehicles have demonstrated very different behavior and their HVAC system has a lower power draw than the recalled Hummer H3 and H3T vehicles. The recalled H3 and H3T vehicles generate over triple the failure rate of the Sky and Solstice vehicles. GM suggested in its response to the ODI?s information request that this difference was due to the larger interior volume of a recalled Hummer vehicle imposing a heavier electrical load and duty cycle on its HVAC blower. The duty cycle is defined as how long it takes for the vehicle to cool down enough before the HVAC blower motor fan speed is lowered or turned off completely.Additionally, due to the size differential between the Sky and Solstice vehicles and the recalled Hummer H3 and H3T vehicles, the parts have a different power draw. The Sky and Solstice vehicles, due to their smaller size, draw less wattage, which reduces the likelihood of a thermal event. This condition in the Sky and Solstice vehicles typically leads to an inoperable HVAC blower motor as opposed to a thermal event.Despite the commonality of parts in the Sky and Solstice vehicles with those that were the basis of a safety recall, the subject vehicles have not demonstrated a safety defect trend that would likely lead to a safety recall or merit further investigation by the ODI. The subject vehicles have a low rate of reported thermal events over the ten to fourteen years they have been in service with the most recent occurring in 2017 with no confirmed fires. The HVAC blower motor was not confirmed to be the root cause for either thermal event cited above.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA?s possession, information submitted by GM in response to an information request, and the potential risks to safety implicated by the petitioner?s allegation, NHTSA does not believe that the petition warrants a formal investigation at this time. Consequently, the petition is denied.The entire petition denial can be viewed in the October 14, 2022 Federal Register under DP20-002.(https://www.f
DP16001 · Passenger Sensing System Sensor Mat
Opened May 16, 2016 · Closed Apr 24, 2017
Status: closed (inferred from source dates) · Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) received a petition requesting the opening of an investigation into the air bag system on model year 2006-2010 Pontiac Solstice and 2007-2010 Saturn Sky, the subject vehicles.The petitioner raised the issue of failure of the Passenger Sensing System for the front passenger seating position.On January 26, 2017, General Motors filed a defect information report recalling the subject vehicles to address the issue raised by the petition.In view of the recall, ODI considers the petition moot and is closing the action.The closing of the petition does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by future circumstances.
PE08016 · Inadequate Brake Power Assist
Opened Mar 6, 2008 · Closed Jun 24, 2008
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
IN MODEL YEAR (MY) 2007, PONTIAC SOLSTICE AND SATURN SKY VEHICLES EQUIPPED WITH THE 2.0L TURBOCHARGED ENGINE USED AN AUXILIARY VACUUM PUMP TO SUPPLEMENT THE ENGINE AS A SOURCE OF VACUUM TO THE BRAKE BOOSTER DURING LOW VACUUM CONDITIONS, SUCH AS IMMEDIATELY AFTER A COLD START.THE VACUUM PUMP OPERATION WAS CONTROLLED BY SWITCHES THAT SENSED BOOSTER VACUUM, TURNING THE PUMP ON WHEN BOOSTER VACUUM DROPPED BELOW A SPECIFIED LEVEL.IN THE MY 2008 SOLSTICE AND SKY VEHICLES (THE SUBJECT VEHICLES), GENERAL MOTORS (GM) ELIMINATED THE AUXILIARY VACUUM PUMP AND REPLACED IT WITH THE OPTIMIZED HYDRAULIC BRAKING (OHB) SYSTEM.THE DESIGN INTENT OF OHB IS TO SUPPLEMENT ENGINE VACUUM, IN CONDITIONS WHERE LOW VACUUM IS GENERATED BY THE ENGINE, WITH HYDRAULIC PRESSURE GENERATED BY THE STABILITY CONTROL SYSTEM PUMP CONTROLLED BY THE ELECTRONIC BRAKE CONTROL MODULE (EBCM). FOR UP TO ABOUT AMINUTE AFTER A COLD START, WHEN THE SYSTEM IS IN OHB ASSIST MODE, THE DRIVER MUST PRESS HARDER ON THE BRAKE PEDAL TO ACHIEVE DESIRED DECELERATION.ALSO, WHEN THE OHB MODE IS ACTIVATED, THE DRIVER CAN HEAR AND FEEL, THROUGH BRAKE PEDAL VIBRATION, THE STABILITY CONTROL SYSTEM PUMP OPERATION.STARTING IN LATE APRIL 2008, GM CHANGED FROM THE OHB SYSTEM BACK TO THE VACUUM PUMP SYSTEM DESIGN.ODI IS AWARE OF 264 NON-DUPLICATIVE COMPLAINTS TO ODI AND GM ALLEGING INADEQUATE BRAKE POWER ASSIST IN THE SUBJECT VEHICLES WHEN APPLYING THE BRAKES JUST AFTER A COLD START, INCLUDING ONE INCIDENT INVOLVING A CRASH INTO A TREE DURING A DRIVEWAY MANEUVER.TO ADDRESS THESE CONCERNS BY CONSUMERS, GM HAS ISSUED THREETECHNICAL SERVICE BULLETINS.ON JUNE 4, 2007, GM RELEASED AN INFORMATIONAL BULLETIN (NO PART REPLACEMENT OR SOFTWARE UPDATES), BULLETIN# 07-05-22-002, TO DEALERS EXPLAINING THE FUNCTIONALITY OF THE OHB SYSTEM.ON NOVEMBER 29, 2007, GM RELEASED A SERVICE BULLETIN, BULLETIN# 07-05-22-007, WITH INSTRUCTIONS TO RECALIBRATE THE EBCM WITH REVISED SOFTWARE TO MAKE OHB OPERATION FEEL MORE LIKE A NORMAL VACUUM ASSIST SYSTEM.TO IMPROVE COLD START BRAKING PERFORMANCE COMPARABLE TO MY 2007 VEHICLES, GM RELEASED A THIRD SERVICE BULLETIN IN TWO PARTS, BULLETINS 07-05-25-007A (APRIL 29, 2008) AND 07-05-25-007B (MAY 16, 2008), FOR AUTOMATIC AND MANUAL TRANSMISSION VEHICLES RESPECTIVELY.THESE BULLETINS RELEASED NEW ENGINE CONTROL SOFTWARE TO CHANGE THE IDLE STRATEGY AFTER A COLD START SO THAT MORE VACUUM IS AVAILABLE FOR BRAKE POWER ASSIST.BEGINNING THE WEEK OF JUNE 23, 2008, GM WILL BEGIN SENDING LETTERS TO CONSUMERS TO MAKE THEM AWARE OF THE AVAILABILITY OF MOST RECENT CALIBRATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (6)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN MODEL YEAR (MY) 2007, PONTIAC SOLSTICE AND SATURN SKY VEHICLES EQUIPPED WITH THE 2.0L TURBOCHARGED ENGINE USED AN AUXILIARY VACUUM PUMP TO SUPPLEMENT THE ENGINE AS A SOURCE OF VACUUM TO THE BRAKE BOOSTER DURING LOW VACUUM CONDITIONS, SUCH AS IMMEDIATELY AFTER A COLD START.THE VACUUM PUMP OPERATION WAS CONTROLLED BY SWITCHES THAT SENSED BOOSTER VACUUM, TURNING THE PUMP ON WHEN BOOSTER VACUUM DROPPED BELOW A SPECIFIED LEVEL.IN THE MY 2008 SOLSTICE AND SKY VEHICLES (THE SUBJECT VEHICLES), GENERAL MOTORS (GM) ELIMINATED THE AUXILIARY VACUUM PUMP AND REPLACED IT WITH THE OPTIMIZED HYDRAULIC BRAKING (OHB) SYSTEM.THE DESIGN INTENT OF OHB IS TO SUPPLEMENT ENGINE VACUUM, IN CONDITIONS WHERE LOW VACUUM IS GENERATED BY THE ENGINE, WITH HYDRAULIC PRESSURE GENERATED BY THE STABILITY CONTROL SYSTEM PUMP CONTROLLED BY THE ELECTRONIC BRAKE CONTROL MODULE (EBCM). FOR UP TO ABOUT AMINUTE AFTER A COLD START, WHEN THE SYSTEM IS IN OHB ASSIST MODE, THE DRIVER MUST PRESS HARDER ON THE BRAKE PEDAL TO ACHIEVE DESIRED DECELERATION.ALSO, WHEN THE OHB MODE IS ACTIVATED, THE DRIVER CAN HEAR AND FEEL, THROUGH BRAKE PEDAL VIBRATION, THE STABILITY CONTROL SYSTEM PUMP OPERATION.STARTING IN LATE APRIL 2008, GM CHANGED FROM THE OHB SYSTEM BACK TO THE VACUUM PUMP SYSTEM DESIGN.ODI IS AWARE OF 264 NON-DUPLICATIVE COMPLAINTS TO ODI AND GM ALLEGING INADEQUATE BRAKE POWER ASSIST IN THE SUBJECT VEHICLES WHEN APPLYING THE BRAKES JUST AFTER A COLD START, INCLUDING ONE INCIDENT INVOLVING A CRASH INTO A TREE DURING A DRIVEWAY MANEUVER.TO ADDRESS THESE CONCERNS BY CONSUMERS, GM HAS ISSUED THREETECHNICAL SERVICE BULLETINS.ON JUNE 4, 2007, GM RELEASED AN INFORMATIONAL BULLETIN (NO PART REPLACEMENT OR SOFTWARE UPDATES), BULLETIN# 07-05-22-002, TO DEALERS EXPLAINING THE FUNCTIONALITY OF THE OHB SYSTEM.ON NOVEMBER 29, 2007, GM RELEASED A SERVICE BULLETIN, BULLETIN# 07-05-22-007, WITH INSTRUCTIONS TO RECALIBRATE THE EBCM WITH REVISED SOFTWARE TO MAKE OHB OPERATION FEEL MORE LIKE A NORMAL VACUUM ASSIST SYSTEM.TO IMPROVE COLD START BRAKING PERFORMANCE COMPARABLE TO MY 2007 VEHICLES, GM RELEASED A THIRD SERVICE BULLETIN IN TWO PARTS, BULLETINS 07-05-25-007A (APRIL 29, 2008) AND 07-05-25-007B (MAY 16, 2008), FOR AUTOMATIC AND MANUAL TRANSMISSION VEHICLES RESPECTIVELY.THESE BULLETINS RELEASED NEW ENGINE CONTROL SOFTWARE TO CHANGE THE IDLE STRATEGY AFTER A COLD START SO THAT MORE VACUUM IS AVAILABLE FOR BRAKE POWER ASSIST.BEGINNING THE WEEK OF JUNE 23, 2008, GM WILL BEGIN SENDING LETTERS TO CONSUMERS TO MAKE THEM AWARE OF THE AVAILABILITY OF MOST RECENT CALIBRATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
IN MODEL YEAR (MY) 2007, PONTIAC SOLSTICE AND SATURN SKY VEHICLES EQUIPPED WITH THE 2.0L TURBOCHARGED ENGINE USED AN AUXILIARY VACUUM PUMP TO SUPPLEMENT THE ENGINE AS A SOURCE OF VACUUM TO THE BRAKE BOOSTER DURING LOW VACUUM CONDITIONS, SUCH AS IMMEDIATELY AFTER A COLD START.THE VACUUM PUMP OPERATION WAS CONTROLLED BY SWITCHES THAT SENSED BOOSTER VACUUM, TURNING THE PUMP ON WHEN BOOSTER VACUUM DROPPED BELOW A SPECIFIED LEVEL.IN THE MY 2008 SOLSTICE AND SKY VEHICLES (THE SUBJECT VEHICLES), GENERAL MOTORS (GM) ELIMINATED THE AUXILIARY VACUUM PUMP AND REPLACED IT WITH THE OPTIMIZED HYDRAULIC BRAKING (OHB) SYSTEM.THE DESIGN INTENT OF OHB IS TO SUPPLEMENT ENGINE VACUUM, IN CONDITIONS WHERE LOW VACUUM IS GENERATED BY THE ENGINE, WITH HYDRAULIC PRESSURE GENERATED BY THE STABILITY CONTROL SYSTEM PUMP CONTROLLED BY THE ELECTRONIC BRAKE CONTROL MODULE (EBCM). FOR UP TO ABOUT AMINUTE AFTER A COLD START, WHEN THE SYSTEM IS IN OHB ASSIST MODE, THE DRIVER MUST PRESS HARDER ON THE BRAKE PEDAL TO ACHIEVE DESIRED DECELERATION.ALSO, WHEN THE OHB MODE IS ACTIVATED, THE DRIVER CAN HEAR AND FEEL, THROUGH BRAKE PEDAL VIBRATION, THE STABILITY CONTROL SYSTEM PUMP OPERATION.STARTING IN LATE APRIL 2008, GM CHANGED FROM THE OHB SYSTEM BACK TO THE VACUUM PUMP SYSTEM DESIGN.ODI IS AWARE OF 264 NON-DUPLICATIVE COMPLAINTS TO ODI AND GM ALLEGING INADEQUATE BRAKE POWER ASSIST IN THE SUBJECT VEHICLES WHEN APPLYING THE BRAKES JUST AFTER A COLD START, INCLUDING ONE INCIDENT INVOLVING A CRASH INTO A TREE DURING A DRIVEWAY MANEUVER.TO ADDRESS THESE CONCERNS BY CONSUMERS, GM HAS ISSUED THREETECHNICAL SERVICE BULLETINS.ON JUNE 4, 2007, GM RELEASED AN INFORMATIONAL BULLETIN (NO PART REPLACEMENT OR SOFTWARE UPDATES), BULLETIN# 07-05-22-002, TO DEALERS EXPLAINING THE FUNCTIONALITY OF THE OHB SYSTEM.ON NOVEMBER 29, 2007, GM RELEASED A SERVICE BULLETIN, BULLETIN# 07-05-22-007, WITH INSTRUCTIONS TO RECALIBRATE THE EBCM WITH REVISED SOFTWARE TO MAKE OHB OPERATION FEEL MORE LIKE A NORMAL VACUUM ASSIST SYSTEM.TO IMPROVE COLD START BRAKING PERFORMANCE COMPARABLE TO MY 2007 VEHICLES, GM RELEASED A THIRD SERVICE BULLETIN IN TWO PARTS, BULLETINS 07-05-25-007A (APRIL 29, 2008) AND 07-05-25-007B (MAY 16, 2008), FOR AUTOMATIC AND MANUAL TRANSMISSION VEHICLES RESPECTIVELY.THESE BULLETINS RELEASED NEW ENGINE CONTROL SOFTWARE TO CHANGE THE IDLE STRATEGY AFTER A COLD START SO THAT MORE VACUUM IS AVAILABLE FOR BRAKE POWER ASSIST.BEGINNING THE WEEK OF JUNE 23, 2008, GM WILL BEGIN SENDING LETTERS TO CONSUMERS TO MAKE THEM AWARE OF THE AVAILABILITY OF MOST RECENT CALIBRATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic
IN MODEL YEAR (MY) 2007, PONTIAC SOLSTICE AND SATURN SKY VEHICLES EQUIPPED WITH THE 2.0L TURBOCHARGED ENGINE USED AN AUXILIARY VACUUM PUMP TO SUPPLEMENT THE ENGINE AS A SOURCE OF VACUUM TO THE BRAKE BOOSTER DURING LOW VACUUM CONDITIONS, SUCH AS IMMEDIATELY AFTER A COLD START.THE VACUUM PUMP OPERATION WAS CONTROLLED BY SWITCHES THAT SENSED BOOSTER VACUUM, TURNING THE PUMP ON WHEN BOOSTER VACUUM DROPPED BELOW A SPECIFIED LEVEL.IN THE MY 2008 SOLSTICE AND SKY VEHICLES (THE SUBJECT VEHICLES), GENERAL MOTORS (GM) ELIMINATED THE AUXILIARY VACUUM PUMP AND REPLACED IT WITH THE OPTIMIZED HYDRAULIC BRAKING (OHB) SYSTEM.THE DESIGN INTENT OF OHB IS TO SUPPLEMENT ENGINE VACUUM, IN CONDITIONS WHERE LOW VACUUM IS GENERATED BY THE ENGINE, WITH HYDRAULIC PRESSURE GENERATED BY THE STABILITY CONTROL SYSTEM PUMP CONTROLLED BY THE ELECTRONIC BRAKE CONTROL MODULE (EBCM). FOR UP TO ABOUT AMINUTE AFTER A COLD START, WHEN THE SYSTEM IS IN OHB ASSIST MODE, THE DRIVER MUST PRESS HARDER ON THE BRAKE PEDAL TO ACHIEVE DESIRED DECELERATION.ALSO, WHEN THE OHB MODE IS ACTIVATED, THE DRIVER CAN HEAR AND FEEL, THROUGH BRAKE PEDAL VIBRATION, THE STABILITY CONTROL SYSTEM PUMP OPERATION.STARTING IN LATE APRIL 2008, GM CHANGED FROM THE OHB SYSTEM BACK TO THE VACUUM PUMP SYSTEM DESIGN.ODI IS AWARE OF 264 NON-DUPLICATIVE COMPLAINTS TO ODI AND GM ALLEGING INADEQUATE BRAKE POWER ASSIST IN THE SUBJECT VEHICLES WHEN APPLYING THE BRAKES JUST AFTER A COLD START, INCLUDING ONE INCIDENT INVOLVING A CRASH INTO A TREE DURING A DRIVEWAY MANEUVER.TO ADDRESS THESE CONCERNS BY CONSUMERS, GM HAS ISSUED THREETECHNICAL SERVICE BULLETINS.ON JUNE 4, 2007, GM RELEASED AN INFORMATIONAL BULLETIN (NO PART REPLACEMENT OR SOFTWARE UPDATES), BULLETIN# 07-05-22-002, TO DEALERS EXPLAINING THE FUNCTIONALITY OF THE OHB SYSTEM.ON NOVEMBER 29, 2007, GM RELEASED A SERVICE BULLETIN, BULLETIN# 07-05-22-007, WITH INSTRUCTIONS TO RECALIBRATE THE EBCM WITH REVISED SOFTWARE TO MAKE OHB OPERATION FEEL MORE LIKE A NORMAL VACUUM ASSIST SYSTEM.TO IMPROVE COLD START BRAKING PERFORMANCE COMPARABLE TO MY 2007 VEHICLES, GM RELEASED A THIRD SERVICE BULLETIN IN TWO PARTS, BULLETINS 07-05-25-007A (APRIL 29, 2008) AND 07-05-25-007B (MAY 16, 2008), FOR AUTOMATIC AND MANUAL TRANSMISSION VEHICLES RESPECTIVELY.THESE BULLETINS RELEASED NEW ENGINE CONTROL SOFTWARE TO CHANGE THE IDLE STRATEGY AFTER A COLD START SO THAT MORE VACUUM IS AVAILABLE FOR BRAKE POWER ASSIST.BEGINNING THE WEEK OF JUNE 23, 2008, GM WILL BEGIN SENDING LETTERS TO CONSUMERS TO MAKE THEM AWARE OF THE AVAILABILITY OF MOST RECENT CALIBRATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:power Assist
IN MODEL YEAR (MY) 2007, PONTIAC SOLSTICE AND SATURN SKY VEHICLES EQUIPPED WITH THE 2.0L TURBOCHARGED ENGINE USED AN AUXILIARY VACUUM PUMP TO SUPPLEMENT THE ENGINE AS A SOURCE OF VACUUM TO THE BRAKE BOOSTER DURING LOW VACUUM CONDITIONS, SUCH AS IMMEDIATELY AFTER A COLD START.THE VACUUM PUMP OPERATION WAS CONTROLLED BY SWITCHES THAT SENSED BOOSTER VACUUM, TURNING THE PUMP ON WHEN BOOSTER VACUUM DROPPED BELOW A SPECIFIED LEVEL.IN THE MY 2008 SOLSTICE AND SKY VEHICLES (THE SUBJECT VEHICLES), GENERAL MOTORS (GM) ELIMINATED THE AUXILIARY VACUUM PUMP AND REPLACED IT WITH THE OPTIMIZED HYDRAULIC BRAKING (OHB) SYSTEM.THE DESIGN INTENT OF OHB IS TO SUPPLEMENT ENGINE VACUUM, IN CONDITIONS WHERE LOW VACUUM IS GENERATED BY THE ENGINE, WITH HYDRAULIC PRESSURE GENERATED BY THE STABILITY CONTROL SYSTEM PUMP CONTROLLED BY THE ELECTRONIC BRAKE CONTROL MODULE (EBCM). FOR UP TO ABOUT AMINUTE AFTER A COLD START, WHEN THE SYSTEM IS IN OHB ASSIST MODE, THE DRIVER MUST PRESS HARDER ON THE BRAKE PEDAL TO ACHIEVE DESIRED DECELERATION.ALSO, WHEN THE OHB MODE IS ACTIVATED, THE DRIVER CAN HEAR AND FEEL, THROUGH BRAKE PEDAL VIBRATION, THE STABILITY CONTROL SYSTEM PUMP OPERATION.STARTING IN LATE APRIL 2008, GM CHANGED FROM THE OHB SYSTEM BACK TO THE VACUUM PUMP SYSTEM DESIGN.ODI IS AWARE OF 264 NON-DUPLICATIVE COMPLAINTS TO ODI AND GM ALLEGING INADEQUATE BRAKE POWER ASSIST IN THE SUBJECT VEHICLES WHEN APPLYING THE BRAKES JUST AFTER A COLD START, INCLUDING ONE INCIDENT INVOLVING A CRASH INTO A TREE DURING A DRIVEWAY MANEUVER.TO ADDRESS THESE CONCERNS BY CONSUMERS, GM HAS ISSUED THREETECHNICAL SERVICE BULLETINS.ON JUNE 4, 2007, GM RELEASED AN INFORMATIONAL BULLETIN (NO PART REPLACEMENT OR SOFTWARE UPDATES), BULLETIN# 07-05-22-002, TO DEALERS EXPLAINING THE FUNCTIONALITY OF THE OHB SYSTEM.ON NOVEMBER 29, 2007, GM RELEASED A SERVICE BULLETIN, BULLETIN# 07-05-22-007, WITH INSTRUCTIONS TO RECALIBRATE THE EBCM WITH REVISED SOFTWARE TO MAKE OHB OPERATION FEEL MORE LIKE A NORMAL VACUUM ASSIST SYSTEM.TO IMPROVE COLD START BRAKING PERFORMANCE COMPARABLE TO MY 2007 VEHICLES, GM RELEASED A THIRD SERVICE BULLETIN IN TWO PARTS, BULLETINS 07-05-25-007A (APRIL 29, 2008) AND 07-05-25-007B (MAY 16, 2008), FOR AUTOMATIC AND MANUAL TRANSMISSION VEHICLES RESPECTIVELY.THESE BULLETINS RELEASED NEW ENGINE CONTROL SOFTWARE TO CHANGE THE IDLE STRATEGY AFTER A COLD START SO THAT MORE VACUUM IS AVAILABLE FOR BRAKE POWER ASSIST.BEGINNING THE WEEK OF JUNE 23, 2008, GM WILL BEGIN SENDING LETTERS TO CONSUMERS TO MAKE THEM AWARE OF THE AVAILABILITY OF MOST RECENT CALIBRATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:power Assist:hydraulic
IN MODEL YEAR (MY) 2007, PONTIAC SOLSTICE AND SATURN SKY VEHICLES EQUIPPED WITH THE 2.0L TURBOCHARGED ENGINE USED AN AUXILIARY VACUUM PUMP TO SUPPLEMENT THE ENGINE AS A SOURCE OF VACUUM TO THE BRAKE BOOSTER DURING LOW VACUUM CONDITIONS, SUCH AS IMMEDIATELY AFTER A COLD START.THE VACUUM PUMP OPERATION WAS CONTROLLED BY SWITCHES THAT SENSED BOOSTER VACUUM, TURNING THE PUMP ON WHEN BOOSTER VACUUM DROPPED BELOW A SPECIFIED LEVEL.IN THE MY 2008 SOLSTICE AND SKY VEHICLES (THE SUBJECT VEHICLES), GENERAL MOTORS (GM) ELIMINATED THE AUXILIARY VACUUM PUMP AND REPLACED IT WITH THE OPTIMIZED HYDRAULIC BRAKING (OHB) SYSTEM.THE DESIGN INTENT OF OHB IS TO SUPPLEMENT ENGINE VACUUM, IN CONDITIONS WHERE LOW VACUUM IS GENERATED BY THE ENGINE, WITH HYDRAULIC PRESSURE GENERATED BY THE STABILITY CONTROL SYSTEM PUMP CONTROLLED BY THE ELECTRONIC BRAKE CONTROL MODULE (EBCM). FOR UP TO ABOUT AMINUTE AFTER A COLD START, WHEN THE SYSTEM IS IN OHB ASSIST MODE, THE DRIVER MUST PRESS HARDER ON THE BRAKE PEDAL TO ACHIEVE DESIRED DECELERATION.ALSO, WHEN THE OHB MODE IS ACTIVATED, THE DRIVER CAN HEAR AND FEEL, THROUGH BRAKE PEDAL VIBRATION, THE STABILITY CONTROL SYSTEM PUMP OPERATION.STARTING IN LATE APRIL 2008, GM CHANGED FROM THE OHB SYSTEM BACK TO THE VACUUM PUMP SYSTEM DESIGN.ODI IS AWARE OF 264 NON-DUPLICATIVE COMPLAINTS TO ODI AND GM ALLEGING INADEQUATE BRAKE POWER ASSIST IN THE SUBJECT VEHICLES WHEN APPLYING THE BRAKES JUST AFTER A COLD START, INCLUDING ONE INCIDENT INVOLVING A CRASH INTO A TREE DURING A DRIVEWAY MANEUVER.TO ADDRESS THESE CONCERNS BY CONSUMERS, GM HAS ISSUED THREETECHNICAL SERVICE BULLETINS.ON JUNE 4, 2007, GM RELEASED AN INFORMATIONAL BULLETIN (NO PART REPLACEMENT OR SOFTWARE UPDATES), BULLETIN# 07-05-22-002, TO DEALERS EXPLAINING THE FUNCTIONALITY OF THE OHB SYSTEM.ON NOVEMBER 29, 2007, GM RELEASED A SERVICE BULLETIN, BULLETIN# 07-05-22-007, WITH INSTRUCTIONS TO RECALIBRATE THE EBCM WITH REVISED SOFTWARE TO MAKE OHB OPERATION FEEL MORE LIKE A NORMAL VACUUM ASSIST SYSTEM.TO IMPROVE COLD START BRAKING PERFORMANCE COMPARABLE TO MY 2007 VEHICLES, GM RELEASED A THIRD SERVICE BULLETIN IN TWO PARTS, BULLETINS 07-05-25-007A (APRIL 29, 2008) AND 07-05-25-007B (MAY 16, 2008), FOR AUTOMATIC AND MANUAL TRANSMISSION VEHICLES RESPECTIVELY.THESE BULLETINS RELEASED NEW ENGINE CONTROL SOFTWARE TO CHANGE THE IDLE STRATEGY AFTER A COLD START SO THAT MORE VACUUM IS AVAILABLE FOR BRAKE POWER ASSIST.BEGINNING THE WEEK OF JUNE 23, 2008, GM WILL BEGIN SENDING LETTERS TO CONSUMERS TO MAKE THEM AWARE OF THE AVAILABILITY OF MOST RECENT CALIBRATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:power Assist:vacuum
IN MODEL YEAR (MY) 2007, PONTIAC SOLSTICE AND SATURN SKY VEHICLES EQUIPPED WITH THE 2.0L TURBOCHARGED ENGINE USED AN AUXILIARY VACUUM PUMP TO SUPPLEMENT THE ENGINE AS A SOURCE OF VACUUM TO THE BRAKE BOOSTER DURING LOW VACUUM CONDITIONS, SUCH AS IMMEDIATELY AFTER A COLD START.THE VACUUM PUMP OPERATION WAS CONTROLLED BY SWITCHES THAT SENSED BOOSTER VACUUM, TURNING THE PUMP ON WHEN BOOSTER VACUUM DROPPED BELOW A SPECIFIED LEVEL.IN THE MY 2008 SOLSTICE AND SKY VEHICLES (THE SUBJECT VEHICLES), GENERAL MOTORS (GM) ELIMINATED THE AUXILIARY VACUUM PUMP AND REPLACED IT WITH THE OPTIMIZED HYDRAULIC BRAKING (OHB) SYSTEM.THE DESIGN INTENT OF OHB IS TO SUPPLEMENT ENGINE VACUUM, IN CONDITIONS WHERE LOW VACUUM IS GENERATED BY THE ENGINE, WITH HYDRAULIC PRESSURE GENERATED BY THE STABILITY CONTROL SYSTEM PUMP CONTROLLED BY THE ELECTRONIC BRAKE CONTROL MODULE (EBCM). FOR UP TO ABOUT AMINUTE AFTER A COLD START, WHEN THE SYSTEM IS IN OHB ASSIST MODE, THE DRIVER MUST PRESS HARDER ON THE BRAKE PEDAL TO ACHIEVE DESIRED DECELERATION.ALSO, WHEN THE OHB MODE IS ACTIVATED, THE DRIVER CAN HEAR AND FEEL, THROUGH BRAKE PEDAL VIBRATION, THE STABILITY CONTROL SYSTEM PUMP OPERATION.STARTING IN LATE APRIL 2008, GM CHANGED FROM THE OHB SYSTEM BACK TO THE VACUUM PUMP SYSTEM DESIGN.ODI IS AWARE OF 264 NON-DUPLICATIVE COMPLAINTS TO ODI AND GM ALLEGING INADEQUATE BRAKE POWER ASSIST IN THE SUBJECT VEHICLES WHEN APPLYING THE BRAKES JUST AFTER A COLD START, INCLUDING ONE INCIDENT INVOLVING A CRASH INTO A TREE DURING A DRIVEWAY MANEUVER.TO ADDRESS THESE CONCERNS BY CONSUMERS, GM HAS ISSUED THREETECHNICAL SERVICE BULLETINS.ON JUNE 4, 2007, GM RELEASED AN INFORMATIONAL BULLETIN (NO PART REPLACEMENT OR SOFTWARE UPDATES), BULLETIN# 07-05-22-002, TO DEALERS EXPLAINING THE FUNCTIONALITY OF THE OHB SYSTEM.ON NOVEMBER 29, 2007, GM RELEASED A SERVICE BULLETIN, BULLETIN# 07-05-22-007, WITH INSTRUCTIONS TO RECALIBRATE THE EBCM WITH REVISED SOFTWARE TO MAKE OHB OPERATION FEEL MORE LIKE A NORMAL VACUUM ASSIST SYSTEM.TO IMPROVE COLD START BRAKING PERFORMANCE COMPARABLE TO MY 2007 VEHICLES, GM RELEASED A THIRD SERVICE BULLETIN IN TWO PARTS, BULLETINS 07-05-25-007A (APRIL 29, 2008) AND 07-05-25-007B (MAY 16, 2008), FOR AUTOMATIC AND MANUAL TRANSMISSION VEHICLES RESPECTIVELY.THESE BULLETINS RELEASED NEW ENGINE CONTROL SOFTWARE TO CHANGE THE IDLE STRATEGY AFTER A COLD START SO THAT MORE VACUUM IS AVAILABLE FOR BRAKE POWER ASSIST.BEGINNING THE WEEK OF JUNE 23, 2008, GM WILL BEGIN SENDING LETTERS TO CONSUMERS TO MAKE THEM AWARE OF THE AVAILABILITY OF MOST RECENT CALIBRATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.