NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
164 reportsClear category filter91,634 miles · Nov 23, 2014
Air BagsElectrical System
IN MARCH OF THIS YEAR I TURNED MY 2008 SATURN OUTLOOK INTO HALEY GMC IN MIDLOTHIAN VA TO FIX A RECALL CONCERNING AN AIR BAG WARNING LIGHT THAT WAS ON IN THE CAR. AIR BAG RECALL 14030 WAS PERFORMED, HOWEVER, THE WARNING LIGHT WAS STILL ON IN THE CABIN. SERVICE DEPARTMENT AT HALEY INFORMED ME THAT THE RECALL WAS PERFORMED PER GM…
Read full complaint
IN MARCH OF THIS YEAR I TURNED MY 2008 SATURN OUTLOOK INTO HALEY GMC IN MIDLOTHIAN VA TO FIX A RECALL CONCERNING AN AIR BAG WARNING LIGHT THAT WAS ON IN THE CAR. AIR BAG RECALL 14030 WAS PERFORMED, HOWEVER, THE WARNING LIGHT WAS STILL ON IN THE CABIN. SERVICE DEPARTMENT AT HALEY INFORMED ME THAT THE RECALL WAS PERFORMED PER GM SPECIFICATIONS HOWEVER, THE WARNING LIGHT WAS STILL ON DUE TO A FAULTY PASSENGER PRESENCE MODULE (DIAGNOSTIC CODE: B0081). AT THE TIME OF THIS REPAIR I HAD AN EXTENDED WARRANTY UNDER THE GMPP (GENERAL MOTORS PROTECTION PLAN) WHICH WAS STILL VALID UNTIL AUGUST OF 2014 OR 107,000 MILES WHICH EVER CAME FIRST. I WAS TOLD BY GMPP THAT THIS MODULE WAS NOT COVERED UNDER MY CURRENT WARRANTY. SINCE THIS VISIT I HAVE TAKEN MY COMPLAINT THROUGH NOT ONLY THE DEALERSHIP BUT THROUGH CORPORATE GM ON TWO SEPARATE OCCASIONS PLEADING WITH THEM THAT THIS WAS A SAFETY RELATED ISSUE NOT A WARRANTY ISSUE. GM HAS STATED TO ME THAT THIS IS NOT A SAFETY RELATED ISSUE AND THAT THIS PART IS NO LONGER COVERED UNDER WARRANTY. THEY WANT ME TO PAY THEM $900 FOR THIS REPAIR AND I REFUSE TO PAY THEM BECAUSE THIS REPAIR SHOULD BE COVERED UNDER GENERAL MOTORS. THIS SAME ISSUE HAS BEEN REPORTED BY NUMEROUS OTHER GM VEHICLES BESIDES THE SATURN OUTLOOK, INCLUDING THE GMC ACADIA AND SATURN SKY. I WOULD LIKE TO GET ASSISTANCE FROM YOUR DEPARTMENT IN CHALLENGING BACK TO GM TO GET THIS ISSUE ADDRESSED FOR I AM DRIVING AROUND IN AN UNSAFE VEHICLE THAT THERE IS A GOOD CHANCE THAT IF A PASSENGER IS TRAVELING WITH ME IN THE FRONT OF THE VEHICLE THAT THE AIR BAG WILL NOT GO OFF IN A FRONTAL COLLISION. *TR
NHTSA ODI #10660310
79,000 miles · Sep 25, 2014
Electrical SystemEngineFire
I WAS TRAVELING ABOUT 60 MPH ON HWY. CAR SHUT OFF AND BACK ON, IT WAS ALSO RAINING. SMELT REALLY BAD LIKE A FIRE. WENT STRAIGHT HOME, TOOK CAR TO SHOP THE NEXT DAY. THE WATER LEAK I THOUGHT HAD BEEN FIXED WAS LEAKING INTO THE ELECTRICAL BOARD CAUSED A BURN OUT WHILE I WAS DRIVING BECAUSE IT WAS RAINING. *TR
NHTSA ODI #10639028
65,489 miles · Sep 23, 2014
Electrical SystemEquipment Adaptive/mobility
WHILE PARKED ON A RESIDENT DRIVEWAY, IT WAS RAINING FOR AWHILE THERE AND RAIN CAME THRU BOTH SIDE FRAMES FROM THE WINDSHIELD INNER PILLAR PANELS AND WAS DRIPPING ON THE FLOOR MATS AND WENT THRU THE CARPET AND SOAK THE FLOOR, IT DOES THIS EVERY TIME IT RAINS IT COMES THROUGH LIKE THAT, SMELL LIKE BURNT WIRES CAME OUT ON OUR WAY B…
Read full complaint
WHILE PARKED ON A RESIDENT DRIVEWAY, IT WAS RAINING FOR AWHILE THERE AND RAIN CAME THRU BOTH SIDE FRAMES FROM THE WINDSHIELD INNER PILLAR PANELS AND WAS DRIPPING ON THE FLOOR MATS AND WENT THRU THE CARPET AND SOAK THE FLOOR, IT DOES THIS EVERY TIME IT RAINS IT COMES THROUGH LIKE THAT, SMELL LIKE BURNT WIRES CAME OUT ON OUR WAY BACK HOME. *TR
NHTSA ODI #10638427
106,000 miles · Sep 8, 2014
Electrical SystemStructure
WATER LEAKS INTO MY VEHICLE FROM A VARIETY OF LOCATIONS. ONE THROUGH THE BACK-UP DISTANCE INDICATOR IN THE BACK OF THE VEHICLE, DOWN THE INSIDES OF THE DOOR PANELS ONTO THE DRIVER AND PASSENGER FLOOR, AND DOWN THE INSIDE OF THE WINDSHIELD. MY CAR STARTED NOT TURNING OFF WHEN I WOULD TURN THE IGNITION OFF WITH THE KEY AND PULL …
Read full complaint
WATER LEAKS INTO MY VEHICLE FROM A VARIETY OF LOCATIONS. ONE THROUGH THE BACK-UP DISTANCE INDICATOR IN THE BACK OF THE VEHICLE, DOWN THE INSIDES OF THE DOOR PANELS ONTO THE DRIVER AND PASSENGER FLOOR, AND DOWN THE INSIDE OF THE WINDSHIELD. MY CAR STARTED NOT TURNING OFF WHEN I WOULD TURN THE IGNITION OFF WITH THE KEY AND PULL IT OUT. I BROUGHT IT TO A MECHANIC AND HE FIXED 5 LEAKS IN THE SUNROOF DRAINS. NOW MY BLOWER MOTOR WON'T WORK, BUT MY CAR DOES TURN OFF AGAIN WHEN I WANT IT TO. MECHANIC SAID I SHOULD BRING THE CAR BACK IN TO HAVE ALL THE CARPET/SEATS TAKEN OUT AND COMPLETELY DRIED OUT SO I DON'T GET MOLD UNDER THE CARPET, TOO. DON'T HAVE THE FUNDS FOR ALL THE FIXES FOR THIS VEHICLE AND THE ELECTRIC PROBLEMS, SO I'LL HAVE TO DO ONE AT A TIME. I LOVE THE VEHICLE, BUT IT'S A LOVE/HATE RELATIONSHIP. I THE LEAKS AND THE DAMAGE THE LEAKS CAUSED, SINCE THEY ARE KNOWN ISSUES, WERE COVERED UNDER SOME KIND OF A RECALL. *TR
NHTSA ODI #10631650
57,000 miles · Aug 18, 2014
Electrical SystemExterior Lighting
DRIVER SIDE HEADLAMP DID NOT WORK ON MANY OCCASIONS OVER 1 1/2 YEARS. DEALER REPLACED BOTH DRIVER AND PASSENGER BULBS BUT DRIVERS SIDE WENT OUT AND DID NOT COME BACK ON. AN INSPECTION REVEALED A BURNT / MELTED CONNECTION AT THE BULB. *TR
NHTSA ODI #10626133
57,000 miles · Jul 22, 2014
Air BagsElectrical SystemStructure
THE PROBLEM STARTS WITH HEAVY RAIN LEAKING THROUGH THE SUN ROOF. ACCORDING TO THE ED MORSE DEALERSHIP REPRESENTATIVE, THE SUNROOF IS PROJECTED TO PASS SOME WATER (VERY FEW) THAT WILL DRAIN THROUGH THE DRAIN TUBES LOCATED AT THE FRONT AND REAR COLUMNS (SIDES OF THE WINDSHIELD). HOWEVER, THE TUBES MAY GET CLOGGED AN THE WATER STAR…
Read full complaint
THE PROBLEM STARTS WITH HEAVY RAIN LEAKING THROUGH THE SUN ROOF. ACCORDING TO THE ED MORSE DEALERSHIP REPRESENTATIVE, THE SUNROOF IS PROJECTED TO PASS SOME WATER (VERY FEW) THAT WILL DRAIN THROUGH THE DRAIN TUBES LOCATED AT THE FRONT AND REAR COLUMNS (SIDES OF THE WINDSHIELD). HOWEVER, THE TUBES MAY GET CLOGGED AN THE WATER STARTS LEAKING INSIDE THE CAR THROUGH THE COLUMNS WERE AIRBAG ARE LOCATED. NEVERTHELESS, THESE TUBES ARE NOT LONG ENOUGH TO DRIVE THE WATER UNTIL THE BOTTOM OF THE CAR SO THE WATER WILL LEAK INTO THE INNER FUSE BLOCK, WILL DAMP THE CARPETS ON THE PASSENGER AND DRIVER SIDES AND MAKE MUCH MORE DAMAGE THAN YOU CAN BELIEVE. AS THE INSULATOR BETWEEN THE CARPET AND THE FLOOR IS LIKE A SPONGE, IT WILL ABSORB THE WATER AND SOAKS ALL THE CONNECTORS THAT RUN BELOW THE INSULATOR (CABLES THAT RUN FROM THE BATTERY, TO THE SEATS MOTORS AND HEATER, ETC, ETC). NOT TO MENTION THAT IT MAY DAMAGE THE AIRBAG TRIGGERS MECHANISMS LOCATED ON THE COLUMNS BESIDES THE WINDSHIELD?.BASED ON THE NUMBER OF COMPLAINS ABOUT THIS ISSUE AT THE INTERNET, WHY NOBODY HAS DONE ANYTHING YET? WHAT IF THE FRONT SIDES AIRBAG DOES NOT DEPLOY AS EXPECTED DUE TO THIS RAIN INSIDE THE CAR????? NHTSA SHOULD SERIOUSLY INQUIRE GM FOR THAT AS IT MAY PUT MANY LIVES AT RISK. AND NOT ONLY TO SATURN OUTLOOK OWNERS. THE SAME IS HAPPENING TO GMC ACADIAS AND BUICK ENCLAVES....THERE ARE MANY FORUMS WITH SUCH COMPLAIN AT THE INTERNET AND IN ONE OF THEM A REPRESENTATIVE FROM GM ASK US TO CONTACT HER BUT I SENT HER 2 E-MAILS AND SO FAR I HAVE NO ANSWER. HER E-MAIL IS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10615199
57,000 miles · Jul 21, 2014
Air BagsElectrical SystemStructure
I JUST LEFT MY 2008 OUTLOOK XR AT THE DEALER. ACCORDING TO THEM THE PROBLEM ARE THE TUBES THAT DRAIN THE WATER FROM THE SUNROOF. THESE TUBES RUN INSIDE THE FRONT AND REAR COLUMNS (ON THE SIDES THE WINDSHIELD IN THE FRONT AND THE SIDE COLUMNS ON THE BACK OF THE CAR). THESE TUBES ARE NOT LONG ENOUGH TO DRIVE THE WATER UNTIL THE BO…
Read full complaint
I JUST LEFT MY 2008 OUTLOOK XR AT THE DEALER. ACCORDING TO THEM THE PROBLEM ARE THE TUBES THAT DRAIN THE WATER FROM THE SUNROOF. THESE TUBES RUN INSIDE THE FRONT AND REAR COLUMNS (ON THE SIDES THE WINDSHIELD IN THE FRONT AND THE SIDE COLUMNS ON THE BACK OF THE CAR). THESE TUBES ARE NOT LONG ENOUGH TO DRIVE THE WATER UNTIL THE BOTTOM OF THE CAR SO THE WATER WILL LEAK INTO THE INNER FUSE BLOCK, WILL DAMP THE CARPETS ON THE PASSENGER AND DRIVER SIDES AND MAKE MUCH MORE DAMAGE THAN YOU CAN BELIEVE. AS THE INSULATOR BETWEEN THE CARPET AND THE FLOOR IS LIKE A SPONGE, IT WILL ABSORB THE WATER AND SOAKS ALL THE CONNECTORS THAT RUN BELOW THE INSULATOR (CABLES THAT RUN FROM THE BATTERY, TO THE SEATS MOTORS AND HEATER, ETC, ETC). NOT TO MENTION THAT IT MAY DAMAGE THE AIRBAG TRIGGERS MECHANISMS LOCATED ON THE COLUMNS BESIDES THE WINDSHIELD?.BASED ON THE NUMBER OF COMPLAINS ABOUT THIS ISSUE AT THE INTERNET, WHY NOBODY HAS DONE ANYTHING YET? WHAT IF THE FRONT SIDES AIRBAG DOES NOT DEPLOY AS EXPECTED DUE TO THIS RAIN INSIDE THE CAR????? NHTSA SHOULD SERIOUSLY INQUIRE GM FOR THAT AS IT MAY PUT MANY LIVES AT RISK. AND NOT ONLY TO SATURN OUTLOOK OWNERS. THE SAME IS HAPPENING TO GMC ACADIAS AND BUICK ENCLAVES.... *TR
NHTSA ODI #10614986
Mileage unknown · May 27, 2014
Electrical System
TL* THE CONTACT OWNS A 2008 SATURN OUTLOOK. THE CONTACT STATED UPON STARTING THE IGNITION, THE KEY REMAINED LODGED IN THE IGNITION SWITCH. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE FAILURE MILEAGE WAS UNAVAILABLE. PM
NHTSA ODI #10594361
171,000 miles · May 4, 2014
Electrical SystemEngine And Engine CoolingPower Train
EVERY SINCE I HAVE HAD A RECALL FIXED...MY LIGHTS FLICKER ON THE DASH AND I HAVE BEEN HAVING PROBLEMS WITH THE TRANSMISSION SEEMING TO STAY IN ONE GEAR. IT WAS TOLD TO ME THAT IT MAY BE A TIMING CHAIN ISSUE BUT IT IS NOT A RECALL. I HAVE READ NUMEROUS COMPLAINTS IN REGARDS TO THIS ISSUE FROM OTHER OUTLOOK OWNERS. *TR
NHTSA ODI #10586477
82,000 miles · Apr 15, 2014
Electrical SystemEngineStructure
LAST WEEK WE HAD HEAVY RAIN AND RAIN BEGAN LEAKING INTO THE CAR NEAR THE FRONT PILLAR ON THE PASSENGER SIDE. THE NEXT DAY THE CAR WOULD NOT START AND IT APPEARED THE BATTERY WAS DEAD. WHEN I HAD IT TESTED IT SHOWED IT NEEDED REPLACEMENT. I PURCHASED THE BATTERY AND WENT TO HAVE IT INSTALLED. WHILE I WAS THERE I TURNED THE CAR…
Read full complaint
LAST WEEK WE HAD HEAVY RAIN AND RAIN BEGAN LEAKING INTO THE CAR NEAR THE FRONT PILLAR ON THE PASSENGER SIDE. THE NEXT DAY THE CAR WOULD NOT START AND IT APPEARED THE BATTERY WAS DEAD. WHEN I HAD IT TESTED IT SHOWED IT NEEDED REPLACEMENT. I PURCHASED THE BATTERY AND WENT TO HAVE IT INSTALLED. WHILE I WAS THERE I TURNED THE CAR OFF AND THE ENGINE WAS STILL RUNNING. THE TECHNICIAN ADVISED THAT THE FUSE BOX WAS CORODED AND CLEANED THE CONNECTIONS. THE CAR CONTINUED TO REMAIN ON THROUGHOUT THE DAY UNTIL IT SEEMED TO DRY OUT. IT RAINED AGAIN YESTERDAY AND THE SAME ISSUE OCCURRED WHERE THERE WAS WATER LEAKING FROM THE DRIVER SIDE PILLAR NEAR THE AIR BAG. I NOTICED THE CAR STAYING ON ONE TIME AND THEN THE NEXT MORNING THE CAR WOULD NOT START. I BEGAN RESEARCHING THE ISSUE AND FOUND SIMILAR COMPLAINTS FROM OTHER GM USERS. I AM CONCERNED NOT ONLY ABOUT THE ELECTRICAL SYSTEM, BUT POTENTIAL MOLD AND CONTACTED THE DEALER AS MANY NOTED THERE WAS A SERVICE BULLETIN. THEY WERE UNABLE TO ASSIST AS THERE HAS NOT BEEN AN OFFICIAL RECALL. I WOULD URGE THAT THIS BE PUSHED AS IT IS ANOTHER KNOWN ISSUE WITH GM CARS THAT GM REFUSES TO DO ANYTHING ABOUT: 2007 GM ACADIA CONSUMER COMPLAINTS ODI ID NUMBER SPECIFIC TO WATER LEAK: 10258230 (THIS IS MY COMPLAINT ID #) 10255735 10254149 10248331 10211267 10210839 10210533 2008 GM ACADIA CONSUMER COMPLAINTS ODI ID NUMBER SPECIFIC TO WATER LEAK: 10246694 10243591 10241649 10230134 10229896 10212682 *TT
NHTSA ODI #10582847
Official recalls
5Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Jun 4, 2010
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence & remedy
Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Aug 28, 2008
GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Consequence & remedy
Consequence: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Aug 14, 2008
GM IS RECALLING 88,809 MY 2008 BUICK ENCLAVE, AND MY 2007-2008 GMC ACADIA AND SATURN OUTLOOK VEHICLES CURRENTLY OR PREVIOUSLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IF A BUILDUP OF SNOW OR ICE ON THE WINDSHIELD OR ON THE WIPERS RESTRICTS THE MOVEMENT OF THE WIPER ARM, THE WINDSHIELD WIPER LINKAGE MAY BECOME DETACHED FROM THE MOTOR SHAFT AND THE WIPERS MAY BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A NEW WIPER CRANK ARM, DRIVER'S SIDE LINK, AND A CRANK ARM NUT. THE RECALL BEGAN O OCTOBER 13, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, SATURN AT 1-800-972-8876, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12003 · Loss Of Headlamp Illumination
Opened Jun 4, 2012 · Closed Jul 24, 2014
Status: closed (inferred from source dates) · Exterior Lighting:headlights
As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp would intermittently fail to come on or flickers before becoming completely inoperative. For the seventeen complaints that alleged simultaneous failure of both head lamps while attempting to turn them on or while driving, the head lamp failures likely had occurred one at a time. The subject vehicle's head lamps are connected in a parallel circuit and each circuit is fused. Therefore, failure of one head lamp or its harness should not affect the other head lamp operation. Over the last 25 years, ODI has opened numerous defect investigations of the loss of headlamp illumination.Investigations that resulted in safety recalls involved simultaneous loss of illumination from both headlamps. NHTSA does not consider the loss of a single headlamp as presenting an unreasonable safety risk-such failures are readily detectable by the driver while allowing the vehicle to retain forward visibility and conspicuity from the remaining headlamp.There is typically enough time between the failure of the first headlamp and the second during which the vehicle operator can obtain the needed repairs. Based on the information currently available, NHTSA does not believe that the headlamp condition as alleged by the petitioner indicates the likelihood of a safety-related defect that would warrant a formal investigation.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is denied.Further specifics can be found in the Federal Register Notice ODI complaint ID numbers are referenced on the next page.
EA08010 · NON-CRASH Engine Compartment Fires
Opened Jun 12, 2008 · Closed Sep 8, 2008
Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Engine And Engine Cooling; Engine And Engine Cooling:engine; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:switch/wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (9)
Electrical SYSTEM:12V/24V/48V Battery
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring:front Underhood
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring:fuses And Circuit Breakers
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Engine And Engine Cooling:engine
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Engine And Engine Cooling
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Visibility:windshield Wiper/washer
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Visibility:windshield Wiper/washer:switch/wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Illustration