NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
511 reports60,034 miles · Jun 19, 2015
Electrical System
MY SATURN WAS DISABLED WHILE DRIVING ON THE FREEWAY DUE TO A CRACKED WAVEPLATE RESULTING IN LOSS OF GEAR WHICH WAS REPAIRED BUT WAS CURRENTLY TURNED OVER FOR REIMBURSEMENT. PROBLEM SOLVED. WHILE MY VEHICLE WAS IN FOR REPAIR THE BODY CONTROL MODULE WAS FOUND TO BE FAULTY AND NEEDED REPLACEMENT. AFTER DISCUSSING THIS WITH MY SERV…
Read full complaint
MY SATURN WAS DISABLED WHILE DRIVING ON THE FREEWAY DUE TO A CRACKED WAVEPLATE RESULTING IN LOSS OF GEAR WHICH WAS REPAIRED BUT WAS CURRENTLY TURNED OVER FOR REIMBURSEMENT. PROBLEM SOLVED. WHILE MY VEHICLE WAS IN FOR REPAIR THE BODY CONTROL MODULE WAS FOUND TO BE FAULTY AND NEEDED REPLACEMENT. AFTER DISCUSSING THIS WITH MY SERVICE REP AT THE DEALERSHIP, AND PERFORMING RESEARCH I HAVE FOUND THAT THIS IS A HUGE PROBLEM THAT IS NOT BEING ADDRESSED. FAILURE OF THE BCM RENDERED MY VEHICLE DEAD IN THE WATER. THANKFULLY OTHER FAULTY EQUIPMENT HAD ME IN A RENTAL CAR AT THE TIME OF THE ISSUE. I WOULD LIKE THIS ISSUE TO BE INVESTIGATED AND BELIEVE A RECALL IS IN ORDER. TO ME, THE FACT THAT I HAD TO REPLACE THE MODULE AND THERE IS A KNOWN ISSUE ONLY TELLS ME IT WILL HAPPEN AGAIN. I DON'T WANT TO BE LEFT STRANDED AND HAVE MY FAMILY ALONG WHEN IT FAILS THE NEXT TIME.
NHTSA ODI #10726151
158,500 miles · May 28, 2015
Steering
ACCELERATED TO GET ON INTERSTATE 41 TO 65 MPH. HEARD A UNUSUAL NOISE. LOST ALL POWER STEERING (PS) , HAD TO USE MANUAL/HARD TO STEER CONTROL. NO WARNING LIGHT CAME ON, NO IDEA OF WHAT WAS HAPPENING. DROVE CAR HOME AT A REDUCED SPEED. CAR MAKER NOTIFIED ME IN SEPTEMBER 2014 THEY HAD A "CAMPAIGN" TO REPLACE PUMPS IF FAILED BEFORE …
Read full complaint
ACCELERATED TO GET ON INTERSTATE 41 TO 65 MPH. HEARD A UNUSUAL NOISE. LOST ALL POWER STEERING (PS) , HAD TO USE MANUAL/HARD TO STEER CONTROL. NO WARNING LIGHT CAME ON, NO IDEA OF WHAT WAS HAPPENING. DROVE CAR HOME AT A REDUCED SPEED. CAR MAKER NOTIFIED ME IN SEPTEMBER 2014 THEY HAD A "CAMPAIGN" TO REPLACE PUMPS IF FAILED BEFORE 150,000 MI. I HAD HEARD A PS WHINE NOISE AND HAD TAKEN THE OUTLOOK TO THE DEALER IN FEBRUARY2015, BEFORE THE 150,000 MI AND THEY SAID IF IT FAILED THEY WOULD HONOR THE CAMPAIGN. THEY WOULD NOT LOOK AT THE PS FLUID OR LISTEN TO THE NOISE.
NHTSA ODI #10721982
187,880 miles · May 15, 2015
EngineTraction Control System
TL* THE CONTACT OWNS A 2007 SATURN OUTLOOK. WHILE ACCELERATING FROM A COMPLETE STOP, THE TRACTION CONTROL WARNING INDICATOR ILLUMINATED AND AN UNUSUAL NOISE EMITTED. THE VEHICLE BEGAN TO VIBRATE WITH HESITATION AND THEN STALLED. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD, WHERE THE ENGINE WAS TURNED OFF. AFTER WAITING FIVE M…
Read full complaint
TL* THE CONTACT OWNS A 2007 SATURN OUTLOOK. WHILE ACCELERATING FROM A COMPLETE STOP, THE TRACTION CONTROL WARNING INDICATOR ILLUMINATED AND AN UNUSUAL NOISE EMITTED. THE VEHICLE BEGAN TO VIBRATE WITH HESITATION AND THEN STALLED. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD, WHERE THE ENGINE WAS TURNED OFF. AFTER WAITING FIVE MINUTES, THE VEHICLE RESTARTED WITH THE ILLUMINATION OF THE ENGINE WARNING INDICATOR. THE FAILURE RECURRED NUMEROUS TIMES. ON A SEPARATE OCCASION, THE VEHICLE ACCELERATED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FAILURE COULD POSSIBLY BE RELATED TO THE THROTTLE BODY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 187,880.
NHTSA ODI #10716686
133,000 miles · Apr 17, 2015
Electrical SystemEnginePower Train
ISSUES WITH THE 2007 SATURN OUTLOOK INCLUDE ONGOING ELECTRICAL ISSUES (LIGHTS INTERMITTENT FUNCTIONING, STABILITRACK, TRACTION CONTROL AND ABS LIGHTS ON INTERMITTENTLY, REMOTE START DOESN'T WORK, POWER LIFT GATE OPENS ON IT'S OWN, LIFT GATE SWITCH FAILED INTERNALLY), AIR INTAKE FILLED WITH OIL AND WATER MIX, WATER UNDER FUEL IND…
Read full complaint
ISSUES WITH THE 2007 SATURN OUTLOOK INCLUDE ONGOING ELECTRICAL ISSUES (LIGHTS INTERMITTENT FUNCTIONING, STABILITRACK, TRACTION CONTROL AND ABS LIGHTS ON INTERMITTENTLY, REMOTE START DOESN'T WORK, POWER LIFT GATE OPENS ON IT'S OWN, LIFT GATE SWITCH FAILED INTERNALLY), AIR INTAKE FILLED WITH OIL AND WATER MIX, WATER UNDER FUEL INDUCTION SERVICE, INTERMITTENTLY THE STABILITRACK WILL TURN OFF, MESSAGE SAYING 'ENGINE POWER REDUCED', CAR SHAKES, NO POWER AND REQUIRES COASTING TO SIDE OF ROAD. (THIS PARTICULAR ISSUE IS TEMPORARILY ADDRESSED BY TURNING THE CAR OFF, REMOVING THE KEYS, OPENING THE DOOR, WAITING FIVE MINUTES. THEN THE CAR STARTS BUT CHECK ENGINE LIGHT REMAINS ON.) REQUIRED NEW THROTTLE BODY, REPLACING STRUTS, SWAY BAR LINK, SHOT AND/OR STRUT ASSEMBLY. RACK AND PINION, TIE RODS NEEDED TO BE REPLACED. MOST RECENTLY HAVING DIFFICULTIES WITH HARD SHIFTING, CEL AND TRACTION CONTROL LIGHTS ON, INTAKE BOOT FULL OF OIL, VEHICLE WILL NOT SHIFT OUT OF 1ST GEAR UNTIL 4000RMP'S AND DOES THE SAME THING ON HIGHWAY IN 2ND GEAR. *TR
NHTSA ODI #10706246
103,000 miles · Apr 8, 2015
Power Train
TL*THE CONTACT OWNS A 2007 SATURN OUTLOOK. THE CONTACT STATED THAT THE CLUTCH WAVE PLATE MALFUNCTIONED. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE THE TECHNICIAN DIAGNOSED THAT THE SHIFT CABLE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 103,000.
NHTSA ODI #10704504
79,000 miles · Apr 1, 2015
Air Bags
INFLATABLE RESTRAINT PASSENGER PRESENCE SYSTEM STOPPED WORKING. *TR
NHTSA ODI #10703067
110,000 miles · Mar 20, 2015
Electrical SystemVisibility/wiper
WE PURCHASED THIS SATURN OUTLOOK IN MAY OF 2013, IT WAS USED BUT VERY WELL TAKEN CARE OF. SOON AFTER WE PURCHASED THE VEHICLE, THE HEADLIGHTS PERIODICALLY GO OUT. IT IS NOT THE BULB BECAUSE THE BULB COMES BACK ON, BUT IN THE ELECTRICAL WIRING, WE HAVE OWNED THIS CAR FOR ALMOST 2 YEARS AND COUNTLESS TIMES THE HEADLIGHTS WILL C…
Read full complaint
WE PURCHASED THIS SATURN OUTLOOK IN MAY OF 2013, IT WAS USED BUT VERY WELL TAKEN CARE OF. SOON AFTER WE PURCHASED THE VEHICLE, THE HEADLIGHTS PERIODICALLY GO OUT. IT IS NOT THE BULB BECAUSE THE BULB COMES BACK ON, BUT IN THE ELECTRICAL WIRING, WE HAVE OWNED THIS CAR FOR ALMOST 2 YEARS AND COUNTLESS TIMES THE HEADLIGHTS WILL COMPLETELY GO OFF WHILE WE ARE DRIVING! THIS IS FRIGHTENING AND SO VERY DANGEROUS. I KNOW OF OTHER OUTLOOK OWNERS THAT HAVE THE SAME EXACT PROBLEM! PLEASE DO A RECALL AND HELP US, BEFORE SOMEONE GETS HURT IN A HORRIBLE ACCIDENT FROM THEIR HEADLIGHTS GOING OUT WHILE THEY ARE DRIVING! *TR
NHTSA ODI #10700676
128,000 miles · Mar 11, 2015
Engine
I WAS STOPPED AT A RED LIGHT ON AN OFF RAMP, AND MY CAR JUST SHUT OFF. WHEN I TRIED TO START IT, IT MADE HORRIBLE NOISES AND WOULD NEVER STAY ON. I TOOK IT TO A MECHANIC AND HE SAID IT'S POSSIBLY THE TIMING CHAIN. THERE IS A RECALL OF TIMING CHAINS EXCEPT IT'S 120,000 MILES OR 10 YEARS, WHICH COMES FIRST. MY CAR HAS 128,000 MILE…
Read full complaint
I WAS STOPPED AT A RED LIGHT ON AN OFF RAMP, AND MY CAR JUST SHUT OFF. WHEN I TRIED TO START IT, IT MADE HORRIBLE NOISES AND WOULD NEVER STAY ON. I TOOK IT TO A MECHANIC AND HE SAID IT'S POSSIBLY THE TIMING CHAIN. THERE IS A RECALL OF TIMING CHAINS EXCEPT IT'S 120,000 MILES OR 10 YEARS, WHICH COMES FIRST. MY CAR HAS 128,000 MILES ON IT AND IS NOT ELIGIBLE BY 8,000 MILES!!!!! THIS CAR HAS ALREADY HAD TOO MANY PROBLEMS, NOW GM KNOWS THERE IS A TIMING CHAIN ISSUE, THEY SHOULD NOT LIMIT THE REPLACEMENT ON THIS OR ANY OTHER ITEM THAT THEY KNOW IS FAULTY OR WILL BE A PROBLEM FOR ALL 2007 SATURNS. *TR
NHTSA ODI #10693667
Mileage unknown · Mar 11, 2015
Air BagsStructure
MY 2007 SATURN OUTLOOK CONTINUOUSLY LEAKS WATER FROM THE ROOF EVERY TIME IT RAINS. THE LEAKING WATER IS NOT ONE DRIP HERE AND THERE, BUT A GUSH OF WATER WILL COME OUT OF THESE AREAS AND WILL CONTINUE TO LEAK WHILE IT IS RAINING. THE WATER WILL DRAIN OUT OF THE HEADLINER, THE AIRBAG AREAS, THE LIGHT FIXTURES, THE SEAT BELT AREA…
Read full complaint
MY 2007 SATURN OUTLOOK CONTINUOUSLY LEAKS WATER FROM THE ROOF EVERY TIME IT RAINS. THE LEAKING WATER IS NOT ONE DRIP HERE AND THERE, BUT A GUSH OF WATER WILL COME OUT OF THESE AREAS AND WILL CONTINUE TO LEAK WHILE IT IS RAINING. THE WATER WILL DRAIN OUT OF THE HEADLINER, THE AIRBAG AREAS, THE LIGHT FIXTURES, THE SEAT BELT AREAS ALL IN THE FRONT AND BACK OF THE CAR AND WILL ALSO DRENCH THE PASSENGER AND DRIVER SIDE FLOOR BOARDS. THIS HAS CAUSED MY CAR TO HAVE A MUSTY MOLDY SMELL TO IT. I FIND IT VERY DISCERNING THAT AFTER YOU PURCHASE A VEHICLE, IT WILL HAVE THESE SAFETY ISSUES SUCH AS WATER LEAKING. I UNDERSTAND THAT THESE THINGS HAPPEN, BUT I AM AFRAID THAT THIS WILL CAUSE A SHORTAGE WITH THE WIRING SYSTEMS IN MY VEHICLE THUS CAUSING EVEN MORE DAMAGE. SINCE THE WATER STARTED LEAKING FROM THE ROOF, I HAVE HAD AIRBAG ISSUES AND WINDSHIELD WIPER ISSUES (IT RUNS CONSTANTLY). I WOULD NOT RECOMMEND THIS VEHICLE TO ANYONE. *TR
NHTSA ODI #10693638
125,000 miles · Mar 4, 2015
Electronic Stability Control (esc)EngineFuel/propulsion System
DRIVING IN SUB ZERO WEATHER, I DRIVING ON THE FREEWAY WHEN MY CAR LOST POWER AND NOW I FIND OUT, IT IS SOMETHING CALLED "LIMP" MODE. CAR WOULD NOT GO MORE THAN 35 MILES PER HOUR AND I HAD MULTIPLE WARNING LIGHTS COMING ONE. HOW DANGEROUS TO BE ON THE HIGHWAY AT 70 MILES PER HOUR SEE A CHECK ENGINE LIGHT COME ON AND SUDDENLY R…
Read full complaint
DRIVING IN SUB ZERO WEATHER, I DRIVING ON THE FREEWAY WHEN MY CAR LOST POWER AND NOW I FIND OUT, IT IS SOMETHING CALLED "LIMP" MODE. CAR WOULD NOT GO MORE THAN 35 MILES PER HOUR AND I HAD MULTIPLE WARNING LIGHTS COMING ONE. HOW DANGEROUS TO BE ON THE HIGHWAY AT 70 MILES PER HOUR SEE A CHECK ENGINE LIGHT COME ON AND SUDDENLY REALIZE YOU HAVE NO POWER. TRYING TO GET INTO THE OUTER LANE AND GET OFF THE HIGHWAY ALMOST COST ME MY LIFE. I WAS -20 DEGREES OUT THAT DAY. I FOUND THIS LISTED ON A WEB SITE, SOUND LIKE GM KNOWS THERE IS A PROBLEM ALREADY. I WORK WITH A GIRL THAT HAS A ACADIA. SHE SAW MY FACEBOOK POST ABOUT MY CAR. SHE WAS ALSO ON THE HIGHWAY THE SAME DAY I WAS AND HERE CAR WAS DOING THE EXACT SAME THING MY WAS. TWO CARS WITH LOSS OF POWER AT THE SAME TIME AND DAY. THIS IS DANGEROUS. HERE IS THE LINK I FOUND REGARDING THIS PROBLEM:HTTP://RICKSFREEAUTOREPAIRADVICE.COM/OIL-IN-AIR-INTAKE-DUCT/ GM HAS ISSUED A SERVICE BULLETIN TO ADDRESS A PROBLEM WITH OIL IN AIR INTAKE DUCT, ALONG WITH A CHECK ENGINE LIGHT, POOR ACCELERATION, AND THROTTLE BODY FREEZING. THE BULLETIN APPLIES TO THE FOLLOWING VEHICLES EQUIPPED WITH THE 3.6L ENGINE: 2008-11 BUICK ENCLAVE, 2007-11 CHEVROLET MALIBU, 2009-11 CHEVROLET TRAVERSE,2007-11 GMC ACADIA,2007-10 PONTIAC G6, 2007-09 SATURN AURA, 2007-10 SATURN OUTLOOK GM STATES THAT THE PROBLEM OCCURS AFTER A COLD START UP OR WHEN DRIVING IN COLD TEMPERATURES. IF YOU SCAN THE PCM, ICE FORMATION IS CAUSED BY CONDENSATION FREEZING AT THE BASE OF THE THROTTLE BODY WITH ADDITIONAL COLLECTION OF ICE FORMATION DEPOSITS IN THE AIR INLET DUCT. FREEZING CONDENSATION FORMS AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED IN LOW AMBIENT TEMPERATURES. OIL DEPOSITS ARE THE COLLECTION OF THE ENGINE VAPORS, FUEL DILUTION AND OIL MIST AT THE BASE OF THE THROTTLE BODY WITH ADDITIONAL FORMATION COLLECTING IN THE DUCT. *TR
NHTSA ODI #10691991
Official recalls
5Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
Jun 4, 2010
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence & remedy
Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Aug 28, 2008
GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Consequence & remedy
Consequence: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Aug 14, 2008
GM IS RECALLING 88,809 MY 2008 BUICK ENCLAVE, AND MY 2007-2008 GMC ACADIA AND SATURN OUTLOOK VEHICLES CURRENTLY OR PREVIOUSLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IF A BUILDUP OF SNOW OR ICE ON THE WINDSHIELD OR ON THE WIPERS RESTRICTS THE MOVEMENT OF THE WIPER ARM, THE WINDSHIELD WIPER LINKAGE MAY BECOME DETACHED FROM THE MOTOR SHAFT AND THE WIPERS MAY BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A NEW WIPER CRANK ARM, DRIVER'S SIDE LINK, AND A CRANK ARM NUT. THE RECALL BEGAN O OCTOBER 13, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, SATURN AT 1-800-972-8876, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Feb 21, 2007
ON CERTAIN VEHICLES, THE SENSING AND DIAGNOSTIC MODULE (SDM), WHICH CONTROLS THE FUNCTION OF FRONT AIR BAGS, MAY NOT OPERATE PROPERLY. AS A RESULT, THE FRONT AIR BAGS MAY FAIL TO DEPLOY IN A FRONTAL CRASH. ALSO, THE AIR BAG WARNING LAMP ON THE INSTRUMENT PANEL MAY FAIL TO PROVIDE WARNING THAT THE SYSTEM IS INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THIS CONDITION COULD INCREASE THE RISK OF INJURY TO OCCUPANTS IN THE FRONT SEAT.
Remedy: DEALERS WILL REPROGRAM THE SDM COMPUTER MODULE. THIS RECALL BEGAN ON FEBRUARY 22, 2007. OWNERS MAY CONTACT GMC AT 1-866-966-9463 OR SATURN AT 1-800-972-8876.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12003 · Loss Of Headlamp Illumination
Opened Jun 4, 2012 · Closed Jul 24, 2014
Status: closed (inferred from source dates) · Exterior Lighting:headlights
As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp would intermittently fail to come on or flickers before becoming completely inoperative. For the seventeen complaints that alleged simultaneous failure of both head lamps while attempting to turn them on or while driving, the head lamp failures likely had occurred one at a time. The subject vehicle's head lamps are connected in a parallel circuit and each circuit is fused. Therefore, failure of one head lamp or its harness should not affect the other head lamp operation. Over the last 25 years, ODI has opened numerous defect investigations of the loss of headlamp illumination.Investigations that resulted in safety recalls involved simultaneous loss of illumination from both headlamps. NHTSA does not consider the loss of a single headlamp as presenting an unreasonable safety risk-such failures are readily detectable by the driver while allowing the vehicle to retain forward visibility and conspicuity from the remaining headlamp.There is typically enough time between the failure of the first headlamp and the second during which the vehicle operator can obtain the needed repairs. Based on the information currently available, NHTSA does not believe that the headlamp condition as alleged by the petitioner indicates the likelihood of a safety-related defect that would warrant a formal investigation.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is denied.Further specifics can be found in the Federal Register Notice ODI complaint ID numbers are referenced on the next page.
EA08010 · NON-CRASH Engine Compartment Fires
Opened Jun 12, 2008 · Closed Sep 8, 2008
Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Engine And Engine Cooling; Engine And Engine Cooling:engine; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:switch/wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (9)
Electrical SYSTEM:12V/24V/48V Battery
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring:front Underhood
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring:fuses And Circuit Breakers
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Engine And Engine Cooling:engine
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Engine And Engine Cooling
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Visibility:windshield Wiper/washer
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Visibility:windshield Wiper/washer:switch/wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Illustration