IllustrationVEHICLE SHIFTED HARD AND SHUDDERED. THE WAVE PLATE AND PLANETARY GEARS HAD FAILED AFTER ONLY 95K MILES NEEDING A NEW TRANSMISSION. WHILE IT THANKFULLY DIDN'T CAUSE AN ACCIDENT, IT HAD THE POTENTIAL TO. IT DEFINITELY FELT UNSAFE AND SHOULDN'T HAVE FAILED THIS SOON. *TR
2007 Saturn Outlook
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Outlook years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
330–25K
7625–50K
12750–75K
8875–100K
81100–150K
31150K+
436 reports with mileage · 75 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 154 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 115 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports10 fire reports7 injury reports
Power Train complaints
128 reportsMY WIFE WAS DRIVING DOWN THE HIGHWAY WHEN ALL OF SUDDEN WHEN SHE HIT THE GAS PEDAL THERE WAS NO RESPONSE, JUST A JERK AND NO ENGINE RESPONSE. SHE HAD TO COAST OFF THE SIDE OF THE ROAD AND LET THE CAR COME TO A RESTING STOP. WHEN SHE DID THAT SHE TRIED TO PUSH THE GAS PEDAL AGAIN AND THE CAR HAD LITTLE TO NO RESPONSE AND THE GE…
Read full complaint
MY WIFE WAS DRIVING DOWN THE HIGHWAY WHEN ALL OF SUDDEN WHEN SHE HIT THE GAS PEDAL THERE WAS NO RESPONSE, JUST A JERK AND NO ENGINE RESPONSE. SHE HAD TO COAST OFF THE SIDE OF THE ROAD AND LET THE CAR COME TO A RESTING STOP. WHEN SHE DID THAT SHE TRIED TO PUSH THE GAS PEDAL AGAIN AND THE CAR HAD LITTLE TO NO RESPONSE AND THE GEAR GRIND-ED. SHE PUT THE CAR IN REVERSE AND THE CAR WOULDN'T GO IN REVERSE AT ALL. TRIED PUTTING THE CARE IN DRIVE AGAIN AND THE CAR WOULDN'T RESPOND OR MOVE FORWARD, SHE ENDED UP STUCK ON THE SIDE OF THE ROAD AND HAD TO CALL FOR A TOE. AFTER DOING A QUICK RESEARCH ONLINE IT SEEMS THIS PROBLEM IS VERY COMMON WITH THE OUTLOOK, TRAVERSE, ACADIA AND OTHER MODELS JUST LIKE IT. HOPEFULLY THIS WILL END UP BECOMING A RECALL PROBLEM AS LOOSING YOUR ABILITY TO DRIVE AND STEER WHEN GOING DOWN THE ROAD IS VERY DANGEROUS, I'M JUST GLAD MY WIFE WASN'T ON A MAJOR HIGHWAY DRIVING AT A HIGHER SPEED. HOPEFULLY IT WON'T TAKE A MAJOR CRASH OF FATALITY BEFORE THIS BECOMES RECOGNIZED AS A SAFETY HAZARD. *TR
WHILE DRIVING WITH MY 3 CHILDREN IN THE VEHICLE WITH ME, I STOPPED AT A STOPLIGHT. UPON THE LIGHT TURNING GREEN I FOUND MY VEHICLE SEEMED TO LACK THE POWER TO GO AND THE CHECK ENGINE LIGHT ILLUMINATED. I INCHED MY WAY THROUGH THE INTERSECTION AND OFF TO THE SIDE OF THE HIGHWAY. THANKFULLY, NO ONE COLLIDED WITH MY VEHICLE DURING …
Read full complaint
WHILE DRIVING WITH MY 3 CHILDREN IN THE VEHICLE WITH ME, I STOPPED AT A STOPLIGHT. UPON THE LIGHT TURNING GREEN I FOUND MY VEHICLE SEEMED TO LACK THE POWER TO GO AND THE CHECK ENGINE LIGHT ILLUMINATED. I INCHED MY WAY THROUGH THE INTERSECTION AND OFF TO THE SIDE OF THE HIGHWAY. THANKFULLY, NO ONE COLLIDED WITH MY VEHICLE DURING THIS LONG SCARY PROCESS. ONSTAR INFORMED ME OF CODES RELATING TO THE TRANSMISSION. ONCE I GOT THE VEHICLE TO THE DEALERSHIP, I WAS INFORMED THIS WAS VERY COMMON FOR THIS VEHICLE. IT TURNED OUT TO BE THE WAVE PLATE HAD BUSTED CAUSING MULTIPLE OTHER TRANSMISSION DAMAGES. EVEN THOUGH MY VEHICLE WAS UNDER THE 100,000 MILE POWERTRAIN WARRANTY PROVIDED BY GM, I WAS OVER BY A FEW MONTHS TIME WISE. NOW IT IS JUNE 2013 AND I AM AT JUST A FEW MILES UNDER THE 12,000 MILE WARRANTY ON THE REPAIR WORK DONE LAST OCTOBER AND I ENCOUNTERED A VERY SIMILAR INCIDENT. I INCHED MY WAY DOWN THE REST OF THE VERY WINDY AND DANGEROUS HIGHWAY TO MY HOME AS IT WAS SATURDAY AND THE DEALERSHIP HAD CLOSED 20 MINUTES EARLIER. ONSTAR AGAIN GAVE ME THE SAME DIAGNOSTIC CODES AS BEFORE TOO. ON MONDAY, I CONTACTED THE DEALERSHIP SERVICE MANAGER WHO SENT A TOW TRUCK TO PICK MY OUTLOOK UP. AFTER NOT HEARING FROM THEM, I CALLED THIS AFTERNOON (TUESDAY) TO SEE WHAT WAS GOING ON. I WAS INFORMED THIS TIME IT WAS DIFFERENT PARTS OF THE TRANSMISSION AND THEY WOULD NOT BE COVERING THE REPAIRS. SHE ALSO STATED THERE WOULD BE A CHARGE FOR THE TOWING! THESE ARE ALL ISSUES COMMON TO ALL OUTLOOK, ACADIA, AND TRAVERSE OWNERS. I AM VERY THANKFUL NEITHER MY FAMILY NOR ANYONE ELSE WAS HURT DURING THESE INCIDENTS, BUT IS THAT WHAT IT IS GOING TO TAKE FOR GM TO BE FORCED TO RECALL THESE TRANSMISSIONS? *TR
IT JERKS REALLY HARD AROUND 50-60MPH ABOUT 10 TIMES A WEEK. ABOUT EVERY OTHER DAY, WITHIN THE FIRST QUARTER MILE FROM MY BEGINNING DESTINATION, AND BEFORE REACHING A SPEED OF 30MPH, MY 07 OUTLOOK JERKS REALLY HARD, THE CHECK ENGINE LIGHT COMES ON, AND IT WILL NOT SHIFT DOWN. *TR
TRANSMISSION FAILED TO KEEP IN GEAR WHILE TRAVELING ON FREEWAY AT FREEWAY SPEEDS. WOULD NOT RE-ENGAGE. LIMPED TO SIDE OF ROAD. TOWED TO DEALERSHIP AND MECHANIC NOTED INTERNAL TRANSMISSION FAILURE DUE TO FAULTY WAVE PLATE. VEHICLE HAS LESS THAN 100K MILES, HOWVER 6 YEARS OLD. *TR
WAS SITTING AT STOP LIGHT AND ACCELERATED NORMALLY GOING THROUGH FIRST GEAR WHEN THE TRANNY SLIPPED AND THE RPMS REVVED UP. I STEPPED BACK OFF THE GAS AND WAS ABLE TO GET BACK HOME DOING ONLY 20-25 MPH;WHEN I GOT INTO THE GARAGE, I FOUND I HAD NO REVERSE AND THE ENGINE WOULD ONLY GO UP IN RPMS WITH NO MOVEMENT. I ENTERED A TIC…
Read full complaint
WAS SITTING AT STOP LIGHT AND ACCELERATED NORMALLY GOING THROUGH FIRST GEAR WHEN THE TRANNY SLIPPED AND THE RPMS REVVED UP. I STEPPED BACK OFF THE GAS AND WAS ABLE TO GET BACK HOME DOING ONLY 20-25 MPH;WHEN I GOT INTO THE GARAGE, I FOUND I HAD NO REVERSE AND THE ENGINE WOULD ONLY GO UP IN RPMS WITH NO MOVEMENT. I ENTERED A TICKET W/ GM CS THE NEXT MORNING AND CALLED AROUND, LEARNING THE REPAIR JOB WOULD BE $4K-5K BECAUSE OF COURSE, I WAS OUT OF WARRANTY DUE TO TIME. IT APPEARS THIS HAS HAPPENED TO MANY, MANY SATURN OWNERS AND GM IS DOING NOTHING TO HELP THE AMERICAN CONSUMER WHEN IT'S CLEARLY OBVIOUS THERE IS A MASS FAILURE OF THE WAVE PLATE. I FINALLY GOT A CALLBACK FROM GM 3 DAYS AFTER I FILED THE COMPLAINT AND THEY 'OFFERED' TO PAY FOR ROUGHLY 25% OF THE COST OF THE REPAIR WITH ME FOOTING THE REST. TOO LATE. I TRADED IT IN YESTERDAY AND WAS NOT HAPPY WITH THE TRADE-IN VALUE BUT DIDN'T HAVE MUCH CHOICE. I PLAN ON JOINING ANY LAWSUIT THAT COMES ALONG AGAINST GM IF ONE HITS MY MAILBOX. *TR
AS I WAS PULLING AWAY FROM A STOP LIGHT, THE CAR WOULD NOT SHIFT OUT OF SECOND GEAR. MADE IT HOME AT A SPEED OF 25-30 MPH. MY CHECK ENGINE CAME ON. AFTER TAKING IT TO THE DEALERSHIP, I WAS TOLD THAT THE TRANSMISSION NEEDED TO BE TORN DOWN AND REPAIRED FOR POSSIBLE BROKEN 3-5-R WAVE PLATE. CAR IS 5 YEARS 10 MONTHS IN SERVICE …
Read full complaint
AS I WAS PULLING AWAY FROM A STOP LIGHT, THE CAR WOULD NOT SHIFT OUT OF SECOND GEAR. MADE IT HOME AT A SPEED OF 25-30 MPH. MY CHECK ENGINE CAME ON. AFTER TAKING IT TO THE DEALERSHIP, I WAS TOLD THAT THE TRANSMISSION NEEDED TO BE TORN DOWN AND REPAIRED FOR POSSIBLE BROKEN 3-5-R WAVE PLATE. CAR IS 5 YEARS 10 MONTHS IN SERVICE WITH ROUGHLY 65,000 MILES ON IT. THE COST OF THE REPAIR OR TRANSMISSION REPLACEMENT WILL BE $3000-$4000. TIMING CHAINS WERE JUST REPLACED IN MARCH OF 2013. I FOUND A SERVICE BULLETIN DATED 1/12/2010 THAT STATED NEW PLATE SHOULD BE INSTALLED WHEN TRANSMISSION IS DISASSEMBLED FOR ANY REASON. GM KNOWS IT'S A PROBLEM AND ISN'T DOING ANYTHING ABOUT IT. *TR
DRIVING ON HWY 377 AND THE CAR STARTED TO GO IN AND OUT OF GEAR. THE ENGINE WAS RUNNING FINE BUT THE TRANSMISSION WOULD NOT ENGAGE AND WE ENDED UP PULLING OVER IN TRAFFIC AS TO NOT CAUSE AN ACCIDENT. WE HAD TO HAVE IT TOWED TO THE DEALERSHIP IN GRANDBURY TX WHERE THEY SAID THE TRANSMISSION HAD TO BE REBUILT. THE ISSUE IS THE …
Read full complaint
DRIVING ON HWY 377 AND THE CAR STARTED TO GO IN AND OUT OF GEAR. THE ENGINE WAS RUNNING FINE BUT THE TRANSMISSION WOULD NOT ENGAGE AND WE ENDED UP PULLING OVER IN TRAFFIC AS TO NOT CAUSE AN ACCIDENT. WE HAD TO HAVE IT TOWED TO THE DEALERSHIP IN GRANDBURY TX WHERE THEY SAID THE TRANSMISSION HAD TO BE REBUILT. THE ISSUE IS THE WAVE PLATE AND IT IS QUITE OFTEN DOCUMENTED WHEN YOU SEARCH SATURN ISSUES ON THE INTERNET. THE CAR HAS 78,000 MILES ON IT AND IS OUTSIDE OF THE 5 YEAR WARRANTY FROM GM. THE DEALER SAID THIS REPAIR IS INCREDIBLY COMMON ON THIS MAKE OF GM CARE, IE. OUTLOOK, ACADIA, TRAVERSE, ENCORE. LOOKING UP ON THE VARIOUS FORUMS ON-LINE THIS SAME INCIDENT HAS HAPPENED TO 1000'S OF PEOPLE. I FEEL THAT GM KNOWS ABOUT THIS UNSAFE MECHANICAL ISSUE AND SHOULD BE HELD RESPONSIBLE FOR IT SINCE IT IS EFFECTING 1000'S OF PEOPLE AND COULD CAUSE MAJOR ACCIDENTS LET ALONE EXPENSE TO THEIR CUSTOMERS WHO HAVE PURCHASED THESE MODELS. *TR
WHEN I WAS PICKING MY SON UP FROM SCHOOL, I TRIED TO ACCELERATE, BUT THE CAR WOULDN'T GO MUCH FASTER THEN WHAT I WAS ALREADY DOING, BUT THE RPMS WERE GOING HIGH. IT WAS AS IF THE TRANSMISSION WASN'T SHIFTING GEARS PROPERLY. IF SEEMED LIKE IT WAS IN SECOND OR THIRD GEAR WHEN IT SHOULD BE IN FOURTH OR FIFTH. I HAVE BEEN READING ON…
Read full complaint
WHEN I WAS PICKING MY SON UP FROM SCHOOL, I TRIED TO ACCELERATE, BUT THE CAR WOULDN'T GO MUCH FASTER THEN WHAT I WAS ALREADY DOING, BUT THE RPMS WERE GOING HIGH. IT WAS AS IF THE TRANSMISSION WASN'T SHIFTING GEARS PROPERLY. IF SEEMED LIKE IT WAS IN SECOND OR THIRD GEAR WHEN IT SHOULD BE IN FOURTH OR FIFTH. I HAVE BEEN READING ONLINE AND EVERYONE SEEMS TO BE TALKING ABOUT A WAVE PLATE????? IT SEEMS TO ME THAT IT WILL BECOME VERY DANGEROUS WHEN DRIVING ON MAIN ROADS (I WAS ON A BACK ROAD TO HIS SCHOOL). WE JUST BOUGHT THIS CAR, IT DOESN'T HAVE A WARRANTY AND I CAN'T AFFORD TO FIX THIS PROBLEM!!! HOW DOES THIS GO ON WITHOUT HAVING A RECALL IF SOOOOO MANY PEOPLE HAVE THE SAME COMPLAINTS? *TR
WHILE DRIVING MY 2007 SATURN OUTLOOK DOWN THE HIGHWAY, MY ENGINE LIGHT CAME ON AND MY RPM'S WENT UP. I PULLED TO THE SIDE OF THE ROAD, TURNED THE VEHICLE OFF AND WAITED A COUPLE OF MINUTES TO SEE IF THE COMPUTER SYSTEM NEEDED TO RESET. I HAVE HAD A FEW ISSUES WITH THIS CAR AND THAT SEEMS TO BE THE SUGGESTED ANSWER IN THE MANUAL.…
Read full complaint
WHILE DRIVING MY 2007 SATURN OUTLOOK DOWN THE HIGHWAY, MY ENGINE LIGHT CAME ON AND MY RPM'S WENT UP. I PULLED TO THE SIDE OF THE ROAD, TURNED THE VEHICLE OFF AND WAITED A COUPLE OF MINUTES TO SEE IF THE COMPUTER SYSTEM NEEDED TO RESET. I HAVE HAD A FEW ISSUES WITH THIS CAR AND THAT SEEMS TO BE THE SUGGESTED ANSWER IN THE MANUAL. I STARTED TO CAR AND COULDN'T GO FASTER THAN 40MPH. I TRIED REVERSE AND FOUND THAT I DID NOT HAVE ANY REVERSE AT ALL. *TR
Official recalls
515V415000 · Structure:body:hatchback/liftgate
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
10V240000 · Electrical System
Jun 4, 2010
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence & remedy
Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
08V441000 · Electrical System
Aug 28, 2008
GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Consequence & remedy
Consequence: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
08V410000 · Visibility:windshield Wiper/washer:linkages
Aug 14, 2008
GM IS RECALLING 88,809 MY 2008 BUICK ENCLAVE, AND MY 2007-2008 GMC ACADIA AND SATURN OUTLOOK VEHICLES CURRENTLY OR PREVIOUSLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IF A BUILDUP OF SNOW OR ICE ON THE WINDSHIELD OR ON THE WIPERS RESTRICTS THE MOVEMENT OF THE WIPER ARM, THE WINDSHIELD WIPER LINKAGE MAY BECOME DETACHED FROM THE MOTOR SHAFT AND THE WIPERS MAY BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A NEW WIPER CRANK ARM, DRIVER'S SIDE LINK, AND A CRANK ARM NUT. THE RECALL BEGAN O OCTOBER 13, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, SATURN AT 1-800-972-8876, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
07V062000 · Air Bags:frontal:sensor/control MODULE-INACTIVE
Feb 21, 2007
ON CERTAIN VEHICLES, THE SENSING AND DIAGNOSTIC MODULE (SDM), WHICH CONTROLS THE FUNCTION OF FRONT AIR BAGS, MAY NOT OPERATE PROPERLY. AS A RESULT, THE FRONT AIR BAGS MAY FAIL TO DEPLOY IN A FRONTAL CRASH. ALSO, THE AIR BAG WARNING LAMP ON THE INSTRUMENT PANEL MAY FAIL TO PROVIDE WARNING THAT THE SYSTEM IS INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THIS CONDITION COULD INCREASE THE RISK OF INJURY TO OCCUPANTS IN THE FRONT SEAT.
Remedy: DEALERS WILL REPROGRAM THE SDM COMPUTER MODULE. THIS RECALL BEGAN ON FEBRUARY 22, 2007. OWNERS MAY CONTACT GMC AT 1-866-966-9463 OR SATURN AT 1-800-972-8876.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12003 · Loss Of Headlamp Illumination
Opened Jun 4, 2012 · Closed Jul 24, 2014
Status: closed (inferred from source dates) · Exterior Lighting:headlights
As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp would intermittently fail to come on or flickers before becoming completely inoperative. For the seventeen complaints that alleged simultaneous failure of both head lamps while attempting to turn them on or while driving, the head lamp failures likely had occurred one at a time. The subject vehicle's head lamps are connected in a parallel circuit and each circuit is fused. Therefore, failure of one head lamp or its harness should not affect the other head lamp operation. Over the last 25 years, ODI has opened numerous defect investigations of the loss of headlamp illumination.Investigations that resulted in safety recalls involved simultaneous loss of illumination from both headlamps. NHTSA does not consider the loss of a single headlamp as presenting an unreasonable safety risk-such failures are readily detectable by the driver while allowing the vehicle to retain forward visibility and conspicuity from the remaining headlamp.There is typically enough time between the failure of the first headlamp and the second during which the vehicle operator can obtain the needed repairs. Based on the information currently available, NHTSA does not believe that the headlamp condition as alleged by the petitioner indicates the likelihood of a safety-related defect that would warrant a formal investigation.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is denied.Further specifics can be found in the Federal Register Notice ODI complaint ID numbers are referenced on the next page.
EA08010 · NON-CRASH Engine Compartment Fires
Opened Jun 12, 2008 · Closed Sep 8, 2008
Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Engine And Engine Cooling; Engine And Engine Cooling:engine; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:switch/wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (9)
Electrical SYSTEM:12V/24V/48V Battery
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring:front Underhood
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring:fuses And Circuit Breakers
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Engine And Engine Cooling:engine
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Engine And Engine Cooling
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Visibility:windshield Wiper/washer
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Visibility:windshield Wiper/washer:switch/wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.