NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
115 reportsClear category filter133,000 miles · Apr 17, 2015
Electrical SystemEnginePower Train
ISSUES WITH THE 2007 SATURN OUTLOOK INCLUDE ONGOING ELECTRICAL ISSUES (LIGHTS INTERMITTENT FUNCTIONING, STABILITRACK, TRACTION CONTROL AND ABS LIGHTS ON INTERMITTENTLY, REMOTE START DOESN'T WORK, POWER LIFT GATE OPENS ON IT'S OWN, LIFT GATE SWITCH FAILED INTERNALLY), AIR INTAKE FILLED WITH OIL AND WATER MIX, WATER UNDER FUEL IND…
Read full complaint
ISSUES WITH THE 2007 SATURN OUTLOOK INCLUDE ONGOING ELECTRICAL ISSUES (LIGHTS INTERMITTENT FUNCTIONING, STABILITRACK, TRACTION CONTROL AND ABS LIGHTS ON INTERMITTENTLY, REMOTE START DOESN'T WORK, POWER LIFT GATE OPENS ON IT'S OWN, LIFT GATE SWITCH FAILED INTERNALLY), AIR INTAKE FILLED WITH OIL AND WATER MIX, WATER UNDER FUEL INDUCTION SERVICE, INTERMITTENTLY THE STABILITRACK WILL TURN OFF, MESSAGE SAYING 'ENGINE POWER REDUCED', CAR SHAKES, NO POWER AND REQUIRES COASTING TO SIDE OF ROAD. (THIS PARTICULAR ISSUE IS TEMPORARILY ADDRESSED BY TURNING THE CAR OFF, REMOVING THE KEYS, OPENING THE DOOR, WAITING FIVE MINUTES. THEN THE CAR STARTS BUT CHECK ENGINE LIGHT REMAINS ON.) REQUIRED NEW THROTTLE BODY, REPLACING STRUTS, SWAY BAR LINK, SHOT AND/OR STRUT ASSEMBLY. RACK AND PINION, TIE RODS NEEDED TO BE REPLACED. MOST RECENTLY HAVING DIFFICULTIES WITH HARD SHIFTING, CEL AND TRACTION CONTROL LIGHTS ON, INTAKE BOOT FULL OF OIL, VEHICLE WILL NOT SHIFT OUT OF 1ST GEAR UNTIL 4000RMP'S AND DOES THE SAME THING ON HIGHWAY IN 2ND GEAR. *TR
NHTSA ODI #10706246
110,000 miles · Mar 20, 2015
Electrical SystemVisibility/wiper
WE PURCHASED THIS SATURN OUTLOOK IN MAY OF 2013, IT WAS USED BUT VERY WELL TAKEN CARE OF. SOON AFTER WE PURCHASED THE VEHICLE, THE HEADLIGHTS PERIODICALLY GO OUT. IT IS NOT THE BULB BECAUSE THE BULB COMES BACK ON, BUT IN THE ELECTRICAL WIRING, WE HAVE OWNED THIS CAR FOR ALMOST 2 YEARS AND COUNTLESS TIMES THE HEADLIGHTS WILL C…
Read full complaint
WE PURCHASED THIS SATURN OUTLOOK IN MAY OF 2013, IT WAS USED BUT VERY WELL TAKEN CARE OF. SOON AFTER WE PURCHASED THE VEHICLE, THE HEADLIGHTS PERIODICALLY GO OUT. IT IS NOT THE BULB BECAUSE THE BULB COMES BACK ON, BUT IN THE ELECTRICAL WIRING, WE HAVE OWNED THIS CAR FOR ALMOST 2 YEARS AND COUNTLESS TIMES THE HEADLIGHTS WILL COMPLETELY GO OFF WHILE WE ARE DRIVING! THIS IS FRIGHTENING AND SO VERY DANGEROUS. I KNOW OF OTHER OUTLOOK OWNERS THAT HAVE THE SAME EXACT PROBLEM! PLEASE DO A RECALL AND HELP US, BEFORE SOMEONE GETS HURT IN A HORRIBLE ACCIDENT FROM THEIR HEADLIGHTS GOING OUT WHILE THEY ARE DRIVING! *TR
NHTSA ODI #10700676
135,000 miles · Feb 10, 2015
Electrical SystemStructure
PURCHASED THIS 2007 SATURN OUTLOOK IN 2013 USED WITH ONLY AROUND 80K MILES ON IT. THE PREVIOUS OWNER DID TELL US ABOUT THE LEAKING AREAS ONCE THE DRAINS GET CLOGGED, MY HUSBAND HAS BEEN DILIGENT CLEANING THEM, BUT LIVING IN FLORIDA IT RAINS HEAVY ALL THE TIME. WE NOTICED MORE AND MORE FREQUENTLY THE INSIDE DRIPPING IN THE 3RD RO…
Read full complaint
PURCHASED THIS 2007 SATURN OUTLOOK IN 2013 USED WITH ONLY AROUND 80K MILES ON IT. THE PREVIOUS OWNER DID TELL US ABOUT THE LEAKING AREAS ONCE THE DRAINS GET CLOGGED, MY HUSBAND HAS BEEN DILIGENT CLEANING THEM, BUT LIVING IN FLORIDA IT RAINS HEAVY ALL THE TIME. WE NOTICED MORE AND MORE FREQUENTLY THE INSIDE DRIPPING IN THE 3RD ROW, UNTIL MANY TIMES, UNTIL THIS PAST NOVEMBER IT RAINED HEAVY FOR 2 DAYS AND THE WATER STARTED COMING THRU WHAT SEEMED TO BE FROM THE AC VENTS ON BOTH ROWS, AND THROUGH THE FRONT DRIVER AND PASSENGER SIDE WALLS VERY HEAVY, UPON LEAVING WORK WENT TO TURN OFF THE CAR TOOK KEYS OUT TWICE AND IT WOULD NOT SHUT OFF. SO NOW THERE IS THE ELECTRICAL AREAS BEING SOAKED, LET IT DRY OUT CLEANED DRAINS AGAIN, AND IT JUST SEEMS THE MORE RAIN WE HAVE THE MORE WATER COMES IN. RIGHT NOW CAR IS IN GARAGE SINCE WE HAD THE SAME SITUATION WITH RAIN AND NOW IT IS DRIPPING FROM EVERYWHERE.. AFRAID TO DRIVE CAR SINCE WE KNOW THAT THE ELECTRICAL SYSTEM AND WIRES ARE WET. I HAVE A TODDLER WHOM I HAD TO COVER WITH A TOWEL CAUSE WATER WAS DRIPPING ON HER. GM NEEDS TO DO SOMETHING ABOUT THIS, BEFORE IT CAUSED A FIRE AND COULD CAUSE DEATH TOO. THIS SEEMS TO BE HAPPENING TO TOO MANY FAMILIES.. WHAT ARE THEY WAITING FOR??? *TR
NHTSA ODI #10682484
260,000 miles · Feb 8, 2015
Air BagsElectrical SystemElectronic Stability Control (esc)
BOUGHT THIS PIECE OF CRAP CAR OUT OF DESPERATION FROM A PAY AS YOU GO RIP OFF CAR "DEALERSHIP" WHO TOLD ME NOTHING ABOUT THIS CARS FAULTS AND IT'S DONE NOTHING BUT BITE ME IN THE ASS SINCE THEN. LEAKS LIKE A STUCK PIG, CAUSING WATER TO POOL AT THE FLOOR MATS, WHEN ITS COLE THE INSIDE OF THE WINDSHIELD FROSTS. HEADLIGHTS WILL BOT…
Read full complaint
BOUGHT THIS PIECE OF CRAP CAR OUT OF DESPERATION FROM A PAY AS YOU GO RIP OFF CAR "DEALERSHIP" WHO TOLD ME NOTHING ABOUT THIS CARS FAULTS AND IT'S DONE NOTHING BUT BITE ME IN THE ASS SINCE THEN. LEAKS LIKE A STUCK PIG, CAUSING WATER TO POOL AT THE FLOOR MATS, WHEN ITS COLE THE INSIDE OF THE WINDSHIELD FROSTS. HEADLIGHTS WILL BOTH SHUT OFF WHILE DRIVING, BATTERY DIED SO I CHARGED IT THEN THE RADIO WENT HAYWIRE. OPENED UP THE BATTERY TERMINAL TO FIND MY BATTERY WAS ENCASED IN ICE DUE TO THE LEAKY SUNROOF, THE BATTERY WAS SPARKING AND SMOKING. WINDOWS WON'T GO DOWN ALL OF A SUDDEN. I CAN'T WAIT TO GET RID OF THIS CAR. NEVER AGAIN. SO DANGEROUS IT'S RIDICULOUS. *JS
NHTSA ODI #10682037
122,222 miles · Dec 29, 2014
Electrical SystemExterior Lighting
I HAD MY PASSENGER LOW BEAM LIGHT ALREADY FIXED BECAUSE OF THIS ISSUE WITH THE WIRING HARNESS TO THE LOW BEAM LIGHT MELT. NOW MY DRIVER SIDE HEADLIGHT WENT OUT AND ITS THE SAME ISSUE AS BEFORE WITH THE WIRING HARNESS MELTING AND THE LIGHT NOT WORKING ON SOME DAYS AND THEN WORKING THE NEXT DAY OR LATER IN THE DAY WHEN I START THE…
Read full complaint
I HAD MY PASSENGER LOW BEAM LIGHT ALREADY FIXED BECAUSE OF THIS ISSUE WITH THE WIRING HARNESS TO THE LOW BEAM LIGHT MELT. NOW MY DRIVER SIDE HEADLIGHT WENT OUT AND ITS THE SAME ISSUE AS BEFORE WITH THE WIRING HARNESS MELTING AND THE LIGHT NOT WORKING ON SOME DAYS AND THEN WORKING THE NEXT DAY OR LATER IN THE DAY WHEN I START THE CAR UP AGAIN. THIS NEEDS TO BE ADDRESSED BY GM TO GET IT FIXED. I KNOW THERE WAS A SERVICE BULLETIN PUT OUT FOR THE VEHICLE THAT EXPIRED DECEMBER 31, 2013. BOTH OF MY LOW BEAM LIGHTS HAVE STOPPED WORKING THIS YEAR. *TR
NHTSA ODI #10668644
115,000 miles · Dec 9, 2014
Electrical SystemExterior Lighting
MY LOW BEAM HEADLIGHT WIRING HARNESS MELTED WHICH CAUSED MY LIGHT TO NOT WORK AND REQUIRED IT BEING TAKEN IN TO HAVE A NEW HARNESS PUT ON THE VEHICLE. THERE WAS A SERVICE ANNOUNCEMENT PUT OUT BY GM ABOUT TO SATURN SERVICE PROVIDERS ABOUT REPLACING THE WIRING HARNESS BUT THERE HASN'T BEEN A RECALLED ISSUED FOR THIS AS OF YET. THI…
Read full complaint
MY LOW BEAM HEADLIGHT WIRING HARNESS MELTED WHICH CAUSED MY LIGHT TO NOT WORK AND REQUIRED IT BEING TAKEN IN TO HAVE A NEW HARNESS PUT ON THE VEHICLE. THERE WAS A SERVICE ANNOUNCEMENT PUT OUT BY GM ABOUT TO SATURN SERVICE PROVIDERS ABOUT REPLACING THE WIRING HARNESS BUT THERE HASN'T BEEN A RECALLED ISSUED FOR THIS AS OF YET. THIS COULD BE DANGEROUS BECAUSE IF THEY STOP WORKING WHILE YOU ARE DRIVING AT NIGHT YOU CAN'T SEE ANYTHING. *TR
NHTSA ODI #10663037
140,000 miles · Nov 10, 2014
Electrical SystemStructure
I HAVE A 2007 SATURN OUTLOOK WHIS IS LEAKING WATER IN THROUGH WHAT I ASSUME IS THE SUNROOF. MY SON, WHO WAS SITTING IN THE THIRD ROW OF SEATING (BACK SEAT) NOTICED WATER LEAKING FROM THE DOME LIGHT. THE WATER WAS ALSO NOTICED IN OTHER AREAS OF THE VEHICLE THROUGHOUT THE DRIVE. I HAVE ALSO STARTED NOTICING ELECTRICAL ISSUES WITH …
Read full complaint
I HAVE A 2007 SATURN OUTLOOK WHIS IS LEAKING WATER IN THROUGH WHAT I ASSUME IS THE SUNROOF. MY SON, WHO WAS SITTING IN THE THIRD ROW OF SEATING (BACK SEAT) NOTICED WATER LEAKING FROM THE DOME LIGHT. THE WATER WAS ALSO NOTICED IN OTHER AREAS OF THE VEHICLE THROUGHOUT THE DRIVE. I HAVE ALSO STARTED NOTICING ELECTRICAL ISSUES WITH THE VEHICLE NOT THAT THE RAIN HAS COME IN AS WELL AS WATER STAINS FROM OTHER SUCH ISSUES. *TR
NHTSA ODI #10653981
120,000 miles · Aug 20, 2014
Electrical SystemExterior Lighting
DRIVER SIDE HEAD LIGHT WENT OUT ABOUT A WEEK AGO,I REPLACED THE LIGHT BULB AND IT WORKED FOR A FEW DAYS.THE SAME LIGHT WENT OUT AGAIN.I WENT TO REPLACE IT ,JUST TO NOTICE A WIRE WAS OUT AND THE CONNECTION HAD MELTED.I LOOKED IT UP AND COME TO FIND OUT THERE IS A FAULTY HARNESS. I CONTACTED A GM DEALER AND WAS TOLD THEY WERE AWAR…
Read full complaint
DRIVER SIDE HEAD LIGHT WENT OUT ABOUT A WEEK AGO,I REPLACED THE LIGHT BULB AND IT WORKED FOR A FEW DAYS.THE SAME LIGHT WENT OUT AGAIN.I WENT TO REPLACE IT ,JUST TO NOTICE A WIRE WAS OUT AND THE CONNECTION HAD MELTED.I LOOKED IT UP AND COME TO FIND OUT THERE IS A FAULTY HARNESS. I CONTACTED A GM DEALER AND WAS TOLD THEY WERE AWARE OF IT,BUT THE EXTENDED WARRANTY WAS OVER ON 12-31-13. IF THIS IS A ON GOING ISSUE,WHY WONT A RECALL BE ISSUED?? I DON'T HAVE 400 DOLLARS TO HAVE A NEW HARNESS INSTALLED. *TR
NHTSA ODI #10626792
71,000 miles · Aug 2, 2014
Electrical SystemEngineFuel System, Gasoline
ON SATURDAY JULY 5, 2014, WHILE TRAVELING N/B ON I-81 IN VIRGINIA MY 2007 SATURN OUTLOOK XR SUDDENLY BEGAN TO LOSE POWER TO THE ENGINE. AT THE TIME, I WAS IN THE LEFT LANE AND GOING APPROXIMATELY 70 MPH. AT NO TIME DID ANY CHECK ENGINE LIGHT OR OTHER SERVICE INDICATOR COME ON. FORTUNATELY I WAS ABLE TO STEER THE VEHICLE OVER TO …
Read full complaint
ON SATURDAY JULY 5, 2014, WHILE TRAVELING N/B ON I-81 IN VIRGINIA MY 2007 SATURN OUTLOOK XR SUDDENLY BEGAN TO LOSE POWER TO THE ENGINE. AT THE TIME, I WAS IN THE LEFT LANE AND GOING APPROXIMATELY 70 MPH. AT NO TIME DID ANY CHECK ENGINE LIGHT OR OTHER SERVICE INDICATOR COME ON. FORTUNATELY I WAS ABLE TO STEER THE VEHICLE OVER TO THE RIGHT SHOULDER BEFORE IT COMPLETELY STOPPED. AFTER ABOUT 30 MINUTES ON THE SHOULDER THE VEHICLE LOST ALL ELECTRICAL POWER. I HAD MY WIFE AND 3 KIDS (8YR, 6YR AND 3 MONTH OLD) IN THE CAR WHEN THIS HAPPENED. IT TOOK AN HOUR FOR THE TOW TRUCK TO GET TO US. WE LOADED THE CAR SEATS AND ALL OF US INTO THE TOW TRUCK AND WERE TOWED TO A MECHANICS SHOP IN FRONT ROYAL, VA. SINCE ALL SHOPS WERE CLOSED AT THAT TIME, WE HAD TO LEAVE OUR CAR AND WENT TO A HOTEL. ON MONDAY JULY 7TH, WE WERE TOLD IT WOULD BE AT LEAST A FEW DAYS UNTIL THEY FIGURED OUT WHAT WENT WRONG. I RENTED A CAR AND DROVE HOME TO NJ. ON THURSDAY JULY 10TH, THE MECHANIC SHOP CALLED AND SAID THE ENGINE WAS COMPLETELY SHOT DUE TO A MISSING VALVE COVER INSIDE THE ENGINE, 1 OF THE CATALYTIC CONVERTERS NOT WORKING AND MULTIPLE PISTONS FAILING. ON JULY 24TH THE CAR WAS FINALLY PICKED UP AND TRANSPORTED TO ANOTHER MECHANIC BY MY RESIDENCE. THE NEXT DAY THAT SHOP CALLED WITH THE SAME DIAGNOSIS AND SAID I NEEDED A NEW ENGINE. I HAD TO PURCHASE A NEW ENGINE FROM GM FOR $5,000. THAT PURCHASE WITH LABOR AND TAX WILL COST ME $7,500. THIS WHOLE BREAKDOWN ENDED UP COSTING ME APPROX. $9,000 TOTAL AND I AM STILL WAITING TO GET MY CAR BACK. THE VEHICLE HAS BEEN IN MY FAMILY SINCE IT WAS PURCHASED AND HAD ALL THE RECOMMENDED TUNE UPS/RECALLS PERFORMED. IT BOTHERS ME THAT GM PUTS FAMILIES AT RISK BY NOT ADDRESSING THIS ISSUE. BREAKING DOWN ON THE SIDE OF THE HIGHWAY PUTS PEOPLE IN DANGEROUS SITUATIONS. GM SHOULD OWN UP TO THIS PROBLEM AND TAKE ALL APPROPRIATE ACTION TO PREVENT A POTENTIAL TRAGEDY. *TR
NHTSA ODI #10618325
105,000 miles · Jun 30, 2014
Electrical SystemService BrakesSteering
WHEN DRIVING THROUGH A PUDDLE, THERE WAS A LOSS OF POWER STEERING AND BRAKES. I HAD THE INTERIOR LINERS REPLACED BUT THE PROBLEM STILL OCCURS. THE ELECTRICAL PROBLEMS HAVE INCREASED DRAMATICALLY SINCE THE ORIGINAL DATE OF THE PROBLEM AND AT THIS POINT, I THINK THIS VEHICLE IS EXTREMELY DANGEROUS TO DRIVE. THE DRIVER INFORMATION …
Read full complaint
WHEN DRIVING THROUGH A PUDDLE, THERE WAS A LOSS OF POWER STEERING AND BRAKES. I HAD THE INTERIOR LINERS REPLACED BUT THE PROBLEM STILL OCCURS. THE ELECTRICAL PROBLEMS HAVE INCREASED DRAMATICALLY SINCE THE ORIGINAL DATE OF THE PROBLEM AND AT THIS POINT, I THINK THIS VEHICLE IS EXTREMELY DANGEROUS TO DRIVE. THE DRIVER INFORMATION CENTER IS OUT, THERE ARE TWO WINDOWS THAT NO LONGER OPEN, THE STABILITRAK LIGHT COMES ON INTERMITTENTLY (THIS IS NEW LAST WEEK), THERE IS ANOTHER WARNING SOUND COMING ON WHEN I MAKE A SHARP TURN BUT I AM NOT SURE WHAT THIS IS FOR SINCE THE DRIVER INFORMATION CENTER IS OUT. ONCE I COULD NOT GET THE DOOR TO SHUT COMPLETELY AND I HAD TO START THE CAR, LOCK AND UNLOCK THE DOORS AND THEN THE DOOR WOULD SHUT. THE AUDIO/NAVIGATION SCREEN LOSES POWER AND RESTARTS EVERY COUPLE DAYS DURING MY DRIVE. NOTE: I HAVE ALSO HAD THE POWER STEERING REPLACED IN MARCH AND REPLACED THE REPLACEMENT TRANSMISSION ABOUT THE SAME TIME. *TR
NHTSA ODI #10607040
Official recalls
5Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
Jun 4, 2010
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence & remedy
Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Aug 28, 2008
GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Consequence & remedy
Consequence: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Aug 14, 2008
GM IS RECALLING 88,809 MY 2008 BUICK ENCLAVE, AND MY 2007-2008 GMC ACADIA AND SATURN OUTLOOK VEHICLES CURRENTLY OR PREVIOUSLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IF A BUILDUP OF SNOW OR ICE ON THE WINDSHIELD OR ON THE WIPERS RESTRICTS THE MOVEMENT OF THE WIPER ARM, THE WINDSHIELD WIPER LINKAGE MAY BECOME DETACHED FROM THE MOTOR SHAFT AND THE WIPERS MAY BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A NEW WIPER CRANK ARM, DRIVER'S SIDE LINK, AND A CRANK ARM NUT. THE RECALL BEGAN O OCTOBER 13, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, SATURN AT 1-800-972-8876, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Feb 21, 2007
ON CERTAIN VEHICLES, THE SENSING AND DIAGNOSTIC MODULE (SDM), WHICH CONTROLS THE FUNCTION OF FRONT AIR BAGS, MAY NOT OPERATE PROPERLY. AS A RESULT, THE FRONT AIR BAGS MAY FAIL TO DEPLOY IN A FRONTAL CRASH. ALSO, THE AIR BAG WARNING LAMP ON THE INSTRUMENT PANEL MAY FAIL TO PROVIDE WARNING THAT THE SYSTEM IS INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THIS CONDITION COULD INCREASE THE RISK OF INJURY TO OCCUPANTS IN THE FRONT SEAT.
Remedy: DEALERS WILL REPROGRAM THE SDM COMPUTER MODULE. THIS RECALL BEGAN ON FEBRUARY 22, 2007. OWNERS MAY CONTACT GMC AT 1-866-966-9463 OR SATURN AT 1-800-972-8876.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12003 · Loss Of Headlamp Illumination
Opened Jun 4, 2012 · Closed Jul 24, 2014
Status: closed (inferred from source dates) · Exterior Lighting:headlights
As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp would intermittently fail to come on or flickers before becoming completely inoperative. For the seventeen complaints that alleged simultaneous failure of both head lamps while attempting to turn them on or while driving, the head lamp failures likely had occurred one at a time. The subject vehicle's head lamps are connected in a parallel circuit and each circuit is fused. Therefore, failure of one head lamp or its harness should not affect the other head lamp operation. Over the last 25 years, ODI has opened numerous defect investigations of the loss of headlamp illumination.Investigations that resulted in safety recalls involved simultaneous loss of illumination from both headlamps. NHTSA does not consider the loss of a single headlamp as presenting an unreasonable safety risk-such failures are readily detectable by the driver while allowing the vehicle to retain forward visibility and conspicuity from the remaining headlamp.There is typically enough time between the failure of the first headlamp and the second during which the vehicle operator can obtain the needed repairs. Based on the information currently available, NHTSA does not believe that the headlamp condition as alleged by the petitioner indicates the likelihood of a safety-related defect that would warrant a formal investigation.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is denied.Further specifics can be found in the Federal Register Notice ODI complaint ID numbers are referenced on the next page.
EA08010 · NON-CRASH Engine Compartment Fires
Opened Jun 12, 2008 · Closed Sep 8, 2008
Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Engine And Engine Cooling; Engine And Engine Cooling:engine; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:switch/wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (9)
Electrical SYSTEM:12V/24V/48V Battery
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring:front Underhood
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring:fuses And Circuit Breakers
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Electrical System:wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Engine And Engine Cooling:engine
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Engine And Engine Cooling
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Visibility:windshield Wiper/washer
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Visibility:windshield Wiper/washer:switch/wiring
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.
Illustration