NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
876 reports9,000 miles · Apr 24, 2008
Steering
TL*THE CONTACT OWNS A 2007 SATURN ION. IN DECEMBER OF 2007, THE ELECTRONIC POWER STEERING BEGAN TO FAIL INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER IN JANUARY OF 2008 AND THEY INITIALLY COULD NOT IDENTIFY THE CAUSE OF THE FAILURE. AFTER SEVERAL ATTEMPTS, THEY DISCOVERED THAT THE ELECTRONIC POWER STEERING FAILED. THE …
Read full complaint
TL*THE CONTACT OWNS A 2007 SATURN ION. IN DECEMBER OF 2007, THE ELECTRONIC POWER STEERING BEGAN TO FAIL INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER IN JANUARY OF 2008 AND THEY INITIALLY COULD NOT IDENTIFY THE CAUSE OF THE FAILURE. AFTER SEVERAL ATTEMPTS, THEY DISCOVERED THAT THE ELECTRONIC POWER STEERING FAILED. THE FIRST REPAIR WAS NOT MADE UNTIL FEBRUARY 25, 2008. THE FAILURE RECURRED SEVERAL TIMES IN MARCH AND AGAIN ON APRIL 14TH. THE DEALER INFORMED THE CONTACT TO REMOVE THE AFTERMARKET LIGHTS SHE INSTALLED ON THE VEHICLE. ONCE THE LIGHTS WERE REMOVED, THE VEHICLE MET THE MANUFACTURER'S SPECIFICATIONS. THE VEHICLE WAS TAKEN IN FOR REPAIR AGAIN AND ON APRIL 23, 2008, THE CONTACT RETRIEVED THE VEHICLE. SHE WAS ONLY ABLE TO DRIVE FIVE MILES BEFORE THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 9,000 AND CURRENT MILEAGE IS 13,000. UPDATED 05/20/08. *LJ UPDATED 05/20/08
NHTSA ODI #10225564
Mileage unknown · Mar 29, 2008
Engine And Engine Cooling
I PURCHASED MY 2007 ION IN OCTOBER 2007. WITHIN A MONTH OF ITS PURCHASE, I WAS AT THE DEALER GETTING THE CAR WASHED AND MENTIONED THAT THE CAR WAS "BREATHING HEAVY" LIKE IT WANTED TO STALL. THE SALES PERSON PACIFIED ME BY MENTIONING TO TIGHTEN THE GAS CAP WITH 3 - 5 CLICKS. THE WANTING TO STALL AND HEAVY BREATHING CONTINUED…
Read full complaint
I PURCHASED MY 2007 ION IN OCTOBER 2007. WITHIN A MONTH OF ITS PURCHASE, I WAS AT THE DEALER GETTING THE CAR WASHED AND MENTIONED THAT THE CAR WAS "BREATHING HEAVY" LIKE IT WANTED TO STALL. THE SALES PERSON PACIFIED ME BY MENTIONING TO TIGHTEN THE GAS CAP WITH 3 - 5 CLICKS. THE WANTING TO STALL AND HEAVY BREATHING CONTINUED, SO THE SCIENCE PROJECT BEGAN. I TRIED SEVERAL DIFFERENT GAS STATIONS- MAY IT WAS BAD GAS; NO. I TRIED SWITCHING TO MEDIUM GRADE GAS; NO. THE CAR SEEMS TO IDLE LOW: 600RPMS. IT WOULD SHAKE AND RUMBLE LIKE IT S "COUGHING." I BROUGHT IT TO THE DEALER IN FEBRUARY 2008. THEY FOUND A SIX INCH SHARD OF METAL IN THE EXHAUST SYSTEM. THEY DIDN'T SHOW IT TO ME. THE DEALER REPLACED THE WHOLE EXHAUST SYSTEM. THE PROBLEM STILL EXISTED. I BROUGHT IT BACK AGAIN. THE DEALER REPLACED THE CATALYTIC CONVERTER AND A SENSOR. THE PROBLEM STILL EXISTED. I BROUGHT IT IN A THIRD TIME. A FIELD INSPECTOR WAS TO BE IN THE AREA. HE COULDN'T MAKE IT SO THEY CONSULTED WITH HIM OVER THE TELEPHONE AND THE REPORT BACK TO ME WAS THAT THEY COULDN'T DUPLICATE THE STALLING, ALTHOUGH THEY COULD HEAR THE "HEAVY BREATHING" THE CAR IS WORKING IN NORMAL OPERATING CONDITIONS. I DON'T ACCEPT THIS! THE CAR HAS A DEFECT AND TRIES TO STALL WEEKLY! THE MAJORITY OF MY DRIVING IS ON THE WEEKENDS WHICH IS WHEN THE PROBLEM IS MOST EVIDENT. *TR
NHTSA ODI #10222656
19,000 miles · Mar 17, 2008
Electrical System
ON FIVE SEPARATE OCCASIONS, OUR 07 SATURN ION HAS STALLED WHILE DRIVING. WHEN IT STALLS ALL ELECTRICAL SYSTEMS FAIL - CAN'T EVEN PUT ON THE HAZARDS LIGHTS. THE SATURN DEALER HAS EVALUATED THE COMPUTER SYSTEM EACH TIME WITH NO RESULT. *TR
NHTSA ODI #10221491
500 miles · Mar 3, 2008
Structure
TL*THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT STATED THAT THERE WAS A BLIND SPOT ON BOTH SIDES OF THE VEHICLE. WHEN SHE LOOKED OVER HER SHOULDER BEFORE CHANGING LANES, HER VISION WAS RESTRICTED AND SHE COULD NOT LOOK THROUGH THE REAR WINDOW. THE RESTRICTION WAS CAUSED BY THE METAL THAT WAS IN BETWEEN THE FRONT AND REAR D…
Read full complaint
TL*THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT STATED THAT THERE WAS A BLIND SPOT ON BOTH SIDES OF THE VEHICLE. WHEN SHE LOOKED OVER HER SHOULDER BEFORE CHANGING LANES, HER VISION WAS RESTRICTED AND SHE COULD NOT LOOK THROUGH THE REAR WINDOW. THE RESTRICTION WAS CAUSED BY THE METAL THAT WAS IN BETWEEN THE FRONT AND REAR DOORS. SHE WAS UNCOMFORTABLE CHANGING LANES BECAUSE SHE COULD NOT SEE PROPERLY. WHEN LOOKING THROUGH THE REAR MIRROR, HER VISION WAS ALSO RESTRICTED. THE CONTACT BELIEVES THE FAILURE WAS CAUSED BY THE STRUCTURE OF THE VEHICLE. THE DEALER ALLOWED HER TO TEST DRIVE A VEHICLE WITHOUT THE SPOILER, BUT THE FAILURE STILL OCCURRED. THE FAILURE MILEAGE WAS 500 AND CURRENT MILEAGE WAS 18,070. UPDATED 3/18/08 *CN UPDATED 03/18/08 *TR
NHTSA ODI #10219886
8,840 miles · Dec 20, 2007
Engine And Engine Cooling
VEHICLE TRAVELED THROUGH WATER PUDDLE ON A RAIN SOAKED ROADWAY. PUDDLE WAS NO DEEPER THAN MID- TIRE HEIGHT LEVEL. ENGINE STALLED OUT CAUSING LOSS OF STEERING AND SOME BRAKING ABILITY. ENGINE WAS RESTARTED AND VEHICLE DROVE LESS THAN TWO MILES HOME. NEXT DAY, ENGINE STARTED AFTER NUMEROUS ATTEMPTS. ENGINE SKIPPING AND A CHECK ENG…
Read full complaint
VEHICLE TRAVELED THROUGH WATER PUDDLE ON A RAIN SOAKED ROADWAY. PUDDLE WAS NO DEEPER THAN MID- TIRE HEIGHT LEVEL. ENGINE STALLED OUT CAUSING LOSS OF STEERING AND SOME BRAKING ABILITY. ENGINE WAS RESTARTED AND VEHICLE DROVE LESS THAN TWO MILES HOME. NEXT DAY, ENGINE STARTED AFTER NUMEROUS ATTEMPTS. ENGINE SKIPPING AND A CHECK ENGINE LIGHT WAS ON. VEHICLE WAS DRIVEN TO DEALERSHIP. DEALERSHIP REPORTED THAT WATER HAD BEEN DRAWN INTO THE ENGINE AIR INTAKE, WHICH IS LOCATED AT FRONT BUMPER LEVEL ON RIGHT SIDE OF VEHICLE, AND INTO TRAVELED THROUGH THE SYSTEM INTO THE ENGINE. WATER PRESENT IN AT LEAST TWO CYLINDERS, INTAKE MANIFOLD, AND OIL PAN. ENGINE HAD TO BE REPLACED. DEALER, NOR MANUFACTURER, WOULD HONOR WARRANTY. AUTO INSURANCE CLAIM FILED AND PAID. I AM CONCERNED THAT IT IS UNSAFE TO OPERATE THIS MODEL IN RAINEY WEATHER. *TR
NHTSA ODI #10212464
85 miles · Dec 17, 2007
Power Train
TL*THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING 65 MPH, THE CONTACT WAS UNABLE TO DISENGAGE THE GEAR SHIFTER OUT OF FIFTH GEAR. APPROXIMATELY 5-6 SECONDS LATER, THE GEAR SHIFTER DISENGAGED. AS OF DECEMBER 17, 2007, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE FAILURE MILEAGE WAS 85 AND CURRENT MILEAGE WAS 2,700.
NHTSA ODI #10212062
Mileage unknown · Dec 14, 2007
Engine And Engine CoolingCrashInjury
I PURCHASED THE 2007 IN MAY OF 2007. AS OF TODAY, THE CAR HAS 18,000 ON IT. DIRECTLY AFTER I GOT THE CAR, I BEGAN TO HAVE SEVERE HEADACHES. THE CAR MOSTLY RAN WITHOUT ANY ISSUES, JUST THAT I HAS VERY BAD HEADACHES, AND THEN BEGAN TO BLACK OUT WHILE DRIVING. I HAVE HAD SEVERAL MEDICAL BILLS, INCLUDING A 5 DAY STAY IN JUNE AFTER A…
Read full complaint
I PURCHASED THE 2007 IN MAY OF 2007. AS OF TODAY, THE CAR HAS 18,000 ON IT. DIRECTLY AFTER I GOT THE CAR, I BEGAN TO HAVE SEVERE HEADACHES. THE CAR MOSTLY RAN WITHOUT ANY ISSUES, JUST THAT I HAS VERY BAD HEADACHES, AND THEN BEGAN TO BLACK OUT WHILE DRIVING. I HAVE HAD SEVERAL MEDICAL BILLS, INCLUDING A 5 DAY STAY IN JUNE AFTER AN ACCIDENT. ALL OF THE TESTS COMPLETED SHOWED THAT I DID NOT HAVE ANY TUMORS, HOWEVER I DID HAVE A RISE IN THE CO LEVELS. THE CAR WAS TAKEN TO THE DEALER,AND A DEVISE WAS PLACED ON THE CAR. THE DEALER THEN DROVE THE CAR HOME, AND SAID THAT HE FELT LIGHT HEADED, AND WAS UNSURE IF IT WAS THE CAR. HE THEN DROVE THE CAR BACK TO THE DEALERSHIP IN THE MORNING AND PLACED THE DEVICE ON IT AGAIN. ON 2 OCCASIONS HE REPORTED TO ME THAT HE HAD RECORDED DIFFERENT READINGS, BOTH VERY HIGH. HE THEN CALLED SATURN DIRECTLY, AND WAS INSTRUCTED TO WAIT AND HE WOULD SEND ANOTHER DEVICE TO RECORD THE CO LEVELS. THAT SAME EVENING, I WAS CALLED BY DAVID QUIRK THE OWNER OF THE BUSINESS, AND HE SAID THAT HE PERSONALLY DROVE THE CAR AND TOOK IT TO THE CAR TO A FIRE HOUSE, AND HAD A FIREMAN THAT HE KNEW AND HE SAID THAT HE COULD NOT DETECT ANYTHING IN THE CAR. CLEARLY, THIS WAS JUST A TACTIC TO SEE IF I WAS GOING TO SUE HIM. I ONLY WANT FOR THE CAR TO BE REPLACED. *TR
NHTSA ODI #10211905
8,000 miles · Dec 14, 2007
Engine And Engine CoolingInjury
TL*THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT'S BLOOD TEST INDICATED THAT HIS CARBON MONOXIDE LEVEL WAS HIGH. THE DEALER STATED THAT THE CARBON MONOXIDE READING INSIDE THE PASSENGER COMPARTMENT WAS HIGH. THE VEHICLE WAS TESTED AT A FIRE HOUSE, BUT CARBON MONOXIDE WAS UNABLE TO BE DETECTED. THE CONTACT SUFFERED BAD HEADA…
Read full complaint
TL*THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT'S BLOOD TEST INDICATED THAT HIS CARBON MONOXIDE LEVEL WAS HIGH. THE DEALER STATED THAT THE CARBON MONOXIDE READING INSIDE THE PASSENGER COMPARTMENT WAS HIGH. THE VEHICLE WAS TESTED AT A FIRE HOUSE, BUT CARBON MONOXIDE WAS UNABLE TO BE DETECTED. THE CONTACT SUFFERED BAD HEADACHES AND FAINTED WHILE DRIVING LONG DISTANCES. THE FAILURE MILEAGE WAS 8,000 AND CURRENT MILEAGE WAS 18,000. UPDATED 01/08/08 *BF UPDATED
NHTSA ODI #10211896
14,000 miles · Sep 24, 2007
Suspension
WAS HEARING A POPPING,CLICKING, AND RUBBING SOUND AND TOOK TO SATURN THE FIRST TIME THEY SAID IT WAS MY HUB CAP MAKING THE NOISE. I WENT BACK ABOUT AN HOUR LATER AND HAD THEM REMOVE MY HUB CAP AND NOISE WAS EVEN WORSE AND YOU COULD FEEL IT UNDER YOU FEET. THEY SAID IT WAS MY HALF SHAFT ON THE LEFT SIDE SO A WEEK LATER THEY REP…
Read full complaint
WAS HEARING A POPPING,CLICKING, AND RUBBING SOUND AND TOOK TO SATURN THE FIRST TIME THEY SAID IT WAS MY HUB CAP MAKING THE NOISE. I WENT BACK ABOUT AN HOUR LATER AND HAD THEM REMOVE MY HUB CAP AND NOISE WAS EVEN WORSE AND YOU COULD FEEL IT UNDER YOU FEET. THEY SAID IT WAS MY HALF SHAFT ON THE LEFT SIDE SO A WEEK LATER THEY REPLACED IT. THAT WAS ON A FRIDAY AND BY MONDAY MORNING I WAS HEARING AND FEELING THE NOISE AGAIN SO I TOOK IT BACK AND THEY SAID THAT NOTHING WAS WRONG WITH IT BUT THAT I HAD A BENT RIM IN THE REAR. I LEFT BUT THEN THOUGHT ABOUT IT AND KNEW THAT WAS NOT RIGHT SO I WENT BACK YET AGAIN AND THEY LOOKED AT IT AND YOU COULD SEE WHERE MY TIRES AND RIMS ARE GRINDING INTO AND STARTING TO CUT MY TIE ROD ON THE RIGHT BUT THAT WAS "NORMAL" KNOWING IT WASN'T I PROCEEDED TO GO TO A 3RD PARTY SHOP AND PAY OUT OF POCKET FOR THEM TO LOOK AT THE WHOLE CAR. TO NO SURPRISE TO ME THAT ISN'T "NORMAL" AND IF NOT FIXED SOON WILL CAUSE SAFETY ISSUES. THE 3RD PARTY ALSO NOTICED WHAT SATURN DID NOT AND THAT ON MY LEFT SIDE IT IS RUBBING ON NOT JUST THE TIE ROD BUT THE CONTROL ARM AS WELL. 3RD PARTY TOLD ME THAT I HAVE NOTHING THERE TO PREVENT ME FROM OVER TURNING MY WHEELS AND THAT IS WHY I AM HAVING THESE PROBLEMS. BUT ONLY AFTER CONTACTING THE BBB IN COLORADO SPRINGS DID THE GM OF SATURN OF COLORADO SPRINGS WANT TO LISTEN TO ME. I HAVE SERIOUS CONCERNS ABOUT MY SAFETY AND MY SONS SAFETY IN THIS VEHICLE. PLEASE HELP. *JB
NHTSA ODI #10204010
11,000 miles · Sep 21, 2007
Electrical System
TL*THE CONTACT OWNS A 2007 SATURN ION. ON SEVERAL OCCASIONS, WHILE DRIVING 55 MPH, THE ENGINE LIGHT ILLUMINATED AND THE VEHICLE SUDDENLY DECELERATED TO 30 MPH AND EVENTUALLY TO ZERO. THE CONTACT PULLED OVER AND RESTARTED THE VEHICLE, BUT THE ENGINE LIGHT REMAINED ILLUMINATED. THE VEHICLE JERKED UNTIL IT REACHED 30 MPH AND THE…
Read full complaint
TL*THE CONTACT OWNS A 2007 SATURN ION. ON SEVERAL OCCASIONS, WHILE DRIVING 55 MPH, THE ENGINE LIGHT ILLUMINATED AND THE VEHICLE SUDDENLY DECELERATED TO 30 MPH AND EVENTUALLY TO ZERO. THE CONTACT PULLED OVER AND RESTARTED THE VEHICLE, BUT THE ENGINE LIGHT REMAINED ILLUMINATED. THE VEHICLE JERKED UNTIL IT REACHED 30 MPH AND THEN IT DROVE NORMALLY. THE VEHICLE STALLED TWO MORE TIMES APPROXIMATELY 25 MILES LATER. THE CONTACT TOOK THE VEHICLE TO THE DEALER TWICE. THE FIRST TIME THEY STATED THAT NOTHING WAS WRONG AND THE SECOND TIME THEY CHANGED THE SENSOR IN THE ACCELERATOR PEDAL. THE VEHICLE WAS TOWED TO THE DEALER FOR THE THIRD TIME ON SEPTEMBER 20, 2007. THE CURRENT MILEAGE WAS 13,000 AND FAILURE MILEAGE WAS 11,000.
NHTSA ODI #10203617
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Illustration