NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
876 reports96,000 miles · Nov 30, 2010
Electrical SystemLatches/locks/linkages
MY 2007 SATURN ION'S IGNITION LOCK CYLINDER IS BROKEN. APPARENTLY THIS IS A VERY COMMON PROBLEM WITH SATURNS, AND FIXING THE PROBLEM ONCE IS NOT A GUARANTEE THAT IT WILL NOT NEED TO BE REPLACED AGAIN. WHEN I ARRIVED HOME, MY CAR WOULD NOT TURN OFF. THE KEY WOULD NOT TURN BACK, HOWEVER, WE COULD COMPLETELY REMOVE THE KEY, AND WE…
Read full complaint
MY 2007 SATURN ION'S IGNITION LOCK CYLINDER IS BROKEN. APPARENTLY THIS IS A VERY COMMON PROBLEM WITH SATURNS, AND FIXING THE PROBLEM ONCE IS NOT A GUARANTEE THAT IT WILL NOT NEED TO BE REPLACED AGAIN. WHEN I ARRIVED HOME, MY CAR WOULD NOT TURN OFF. THE KEY WOULD NOT TURN BACK, HOWEVER, WE COULD COMPLETELY REMOVE THE KEY, AND WE COULD TURN THE KEY TO THE ON POSITION. MY HUSBAND WAS ABLE TO TURN OFF THE CAR BY PULLING A FUSE FROM THE UNDER THE HOOD OF THE CAR AFTER A LITTLE BIT OF RESEARCH AND A LOT OF WASTED GAS. WE PURCHASED A NEW IGNITION LOCK CYLINDER FROM THE CLOSEST DEALERSHIP, BUT THAT DID NOT RESOLVE THE PROBLEM. WE HAVE NOW LEARNED WE ALSO NEED TO REPLACE THE IGNITION STARTER SWITCH. THERE IS NO REASON THAT THIS MANY SATURNS SHOULD BE HAVING THE EXACT SAME PROBLEM. HTTP://WWW.CONSUMERAFFAIRS.COM/AUTOMOTIVE/SATURN_IGNITION_LOCK.HTML HAS OVER 50 PAGES OF PEOPLE COMPLAINING ABOUT THE EXACT SAME PROBLEM! THIS NEEDS TO BE RECALLED! *TR
NHTSA ODI #10368445
62,000 miles · Nov 29, 2010
Electrical System
TL*THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT STATED THAT THE KEY COULD NOT BE TAKEN OUT OF THE IGNITION. THE CONTACT CALLED THE LOCAL DEALER WHO ADVISED HER TO CALL NHTSA AND THAT THERE WERE NO RELATED RECALLS. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 62,000.
NHTSA ODI #10368203
46,500 miles · Nov 29, 2010
Steering
I PURCHASED A 2007 SATURN ION IN AUGUST 2007. APPROX 1-2 MONTHS AFTER PURCHASE, MY POWER STEERING WENT OUT ALMOST RESULTING IN A CRASH WITH ANOTHER VEHICLE. I TOOK MY CAR TO THE SATURN DEALERSHIP WHERE I PURCHASED IT, AND THEY PROMPTLY FIXED THE PROBLEM; SO I THOUGHT. NOV 28, 2010 I WAS DRIVING ON THE EISENHOWER EXPRESSWAY AN…
Read full complaint
I PURCHASED A 2007 SATURN ION IN AUGUST 2007. APPROX 1-2 MONTHS AFTER PURCHASE, MY POWER STEERING WENT OUT ALMOST RESULTING IN A CRASH WITH ANOTHER VEHICLE. I TOOK MY CAR TO THE SATURN DEALERSHIP WHERE I PURCHASED IT, AND THEY PROMPTLY FIXED THE PROBLEM; SO I THOUGHT. NOV 28, 2010 I WAS DRIVING ON THE EISENHOWER EXPRESSWAY AND MY POWER STEERING WENT OUT AGAIN. BECAUSE IT WAS EARLY SUNDAY AFTER THANKSGIVING THERE WASN'T MUCH TRAFFIC. BUT THIS INCIDENT COULD HAVE TURNED TRAGIC. I REQUEST THAT INVESTIGATION BE MADE INTO THE 2007 SATURN ION. EVEN THOUGH GM CLOSED THIS PRODUCT LINE (WISH I WOULD'VE KNEW THEIR PLAN BEFORE MY PURCHASE), I WOULD LIKE TO THINK THAT THEY WOULD INVESTIGATE THIS SINGLE INCIDENT, AS THERE COULD BE MANY OTHER CONSUMERS WITH THE SAME EXPERIENCE. NOT TO MENTION THE POTENTIAL LEGAL RAMIFICATIONS IF IT IS FOUND THAT THE IONS ARE DEFECTIVE. IF I JUST GOT A LEMON CAR...THEN SO BE IT. *TR
NHTSA ODI #10368129
112,700 miles · Nov 29, 2010
Steering
TL*THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING APPROXIMATELY 25 MPH, THE STEERING WHEEL BECAME STIFF AND THE POWER STEERING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE CONTACT'S RESIDENCE AND PARKED. THE NEXT TIME THE VEHICLE WAS STARTED, THE POWER STEERING FUNCTIONED NORMALLY. THE VEHICLE HAD N…
Read full complaint
TL*THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING APPROXIMATELY 25 MPH, THE STEERING WHEEL BECAME STIFF AND THE POWER STEERING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE CONTACT'S RESIDENCE AND PARKED. THE NEXT TIME THE VEHICLE WAS STARTED, THE POWER STEERING FUNCTIONED NORMALLY. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 112,700.
NHTSA ODI #10368111
140,000 miles · Nov 24, 2010
Latches/locks/linkages
TL*THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT STATED THAT BOTH THE DRIVER SIDE AND REAR PASSENGER SIDE DOOR LOCKS FAILED. THE DOORS WOULD UNLOCK WHILE THE CONTACT WAS DRIVING. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE LATCH MECHANISM NEEDED TO BE REPLACED. THE CONTACT CALLED THE MA…
Read full complaint
TL*THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT STATED THAT BOTH THE DRIVER SIDE AND REAR PASSENGER SIDE DOOR LOCKS FAILED. THE DOORS WOULD UNLOCK WHILE THE CONTACT WAS DRIVING. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE LATCH MECHANISM NEEDED TO BE REPLACED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000.
NHTSA ODI #10367778
67,400 miles · Nov 12, 2010
Steering
THE KEY GETS STUCK IN THE IGNITION WHILE TRYING TO TURN THE CAR ON AND OFF. FINALLY THE KEY IS STUCK IN THE ON POSITION AND THE VEHICLE CANNOT BE TURNED OFF. AFTER SEVERAL ATTEMPTS, THE KEY COMES OUT WHILE THE CAR IS STILL RUNNING AND IN THE ON POSITION AND THE CAR IS NOT IN PARK. AFTER SEVERAL REPAIRS, THE IGNITION HOUSING C…
Read full complaint
THE KEY GETS STUCK IN THE IGNITION WHILE TRYING TO TURN THE CAR ON AND OFF. FINALLY THE KEY IS STUCK IN THE ON POSITION AND THE VEHICLE CANNOT BE TURNED OFF. AFTER SEVERAL ATTEMPTS, THE KEY COMES OUT WHILE THE CAR IS STILL RUNNING AND IN THE ON POSITION AND THE CAR IS NOT IN PARK. AFTER SEVERAL REPAIRS, THE IGNITION HOUSING CONTINUES TO FAIL. THE CAR CAN EASILY ROLL OFF AS THE KEY COMES OUT AND THE VEHICLE IS NOT IN PARK, THE KEY EVEN COMES OUT WHILE THE CAR IS DRIVING OR IN DRIVE. THE ONLY WAY TO SHUT THE CAR OFF IS TO MANUALLY REMOVE THE WIRE HARNESS FROM THE BATTERY LOCATED UNDER THE STEERING COLUMN. *TR
NHTSA ODI #10365455
19,226 miles · Nov 2, 2010
Tires
STARTED DRIVING MY 2007 SATURN ION FROM TAMPA TO ORLANDO. WHEN I NOTICE A VIBRATION THROUGH OUT THE VEHICLE. IT GRADUALLY GREW WORSE SO I PULLED OVER. AT WHICH TIME SOMETHING FLEW OUT FROM UNDER MY CAR. COMING TO A STOP, I CHECKED THE CAR OUT AND SAW NOTHING WRONG. I STARTED DRIVING, IN HOPES TO MAKE IT TO THE NEXT EXIT, BUT IT…
Read full complaint
STARTED DRIVING MY 2007 SATURN ION FROM TAMPA TO ORLANDO. WHEN I NOTICE A VIBRATION THROUGH OUT THE VEHICLE. IT GRADUALLY GREW WORSE SO I PULLED OVER. AT WHICH TIME SOMETHING FLEW OUT FROM UNDER MY CAR. COMING TO A STOP, I CHECKED THE CAR OUT AND SAW NOTHING WRONG. I STARTED DRIVING, IN HOPES TO MAKE IT TO THE NEXT EXIT, BUT IT DIDN'T. THE VIBRATION GOT RIDICULOUS AND I PULLED OVER TO FIND MY FRONT DRIVER SIDE TIRE FLAT. UPON REMOVING THE TIRE, DISCOVERED A LARGE PIECE OF THREADING WAS MISSING ALONG WITH OTHER DAMAGE TO THE INSIDE OF THE TIRE. WHICH IS WHY I DID NOT SEE IT THE FIRST TIME I PULLED OVER. TIRE IS THE GOOD YEAR ASSURANCE. *TR
NHTSA ODI #10363773
22,500 miles · Nov 2, 2010
Electrical System
WHEN PLACING VEHICLE IN PARK, THE DOORS REMAIN LOCKED AND KEY CANNOT BE REMOVED FROM IGNITION. TOOK VEHICLE TO CHEVY DEALER FOR REPAIR AND THEY SAID MY FACTORY WARRANTY WAS EXPIRED. I CURRENTLY HAVE 22,500 ON VEHICLE AND I PURCHASED THE VEHICLE ON 1-1-2008 AS A NEW VEHICLE AT THE DEALERSHIP. I AM BEING TOLD BY SATURN CUSTOMER…
Read full complaint
WHEN PLACING VEHICLE IN PARK, THE DOORS REMAIN LOCKED AND KEY CANNOT BE REMOVED FROM IGNITION. TOOK VEHICLE TO CHEVY DEALER FOR REPAIR AND THEY SAID MY FACTORY WARRANTY WAS EXPIRED. I CURRENTLY HAVE 22,500 ON VEHICLE AND I PURCHASED THE VEHICLE ON 1-1-2008 AS A NEW VEHICLE AT THE DEALERSHIP. I AM BEING TOLD BY SATURN CUSTOMER SERVICE THAT THE WARRANTY WENT INTO EFFECT IN 2006 ON THE DAY THAT MY VEHICLE "WAS DELIVERED" TO DEALERSHIP AND OVER A YEAR BEFORE I EVER OWNED IT! WHAT A SCAM! *TR
NHTSA ODI #10363711
Mileage unknown · Oct 26, 2010
Electrical System
I OWN A 2007 SATURN ION AND HAVE BEEN EXPERIENCING AN IGNITION PROBLEM. EVERYTIME I PARK MY CAR AND TURN THE KEY TO SHUT IT OFF IT GETS "STUCK". NO MATTER HOW I PARK, WIGGLE IT, ETC.. IT GETS STUCK THEN I HAVE TO SIT THERE ANYWHERE FROM 30SEC-HOURS BEFORE IT WILL RELEASE. I BROUGHT IT TO MY LOCAL SATURN AUTHORIZED SERVICE DEPAR…
Read full complaint
I OWN A 2007 SATURN ION AND HAVE BEEN EXPERIENCING AN IGNITION PROBLEM. EVERYTIME I PARK MY CAR AND TURN THE KEY TO SHUT IT OFF IT GETS "STUCK". NO MATTER HOW I PARK, WIGGLE IT, ETC.. IT GETS STUCK THEN I HAVE TO SIT THERE ANYWHERE FROM 30SEC-HOURS BEFORE IT WILL RELEASE. I BROUGHT IT TO MY LOCAL SATURN AUTHORIZED SERVICE DEPARTMENT (1HR AWAY) AND THEY COULD NOT FIND ANYTHING WRONG THEY TOLD ME IT MUST BE SPILT SODA IN THE SHIFTER AND CLEANED THE INSIDE OF MY SHIFTER AND CHARGED $90. TO ONLY DRIVE AN HOUR HOME AND HAVE IT KEEP HAPPENING! SATURN WILL NOT HELP AND MY WARRANTY EXPIRED. I DID SOME RESEARCH ONLINE AND THOUSANDS OF PEOPLE HAVE THE SAME PROBLEM. SHOULDN'T THIS BE A RECALL? *TR
NHTSA ODI #10362554
Mileage unknown · Oct 20, 2010
Steering
2007 SATURN ION. CONSUMER EXPRESSES DISCONTENT WITH ELECTRIC POWER STEERING ISSUES *TGW THE CONSUMER STATED SHE IS AFRAID IF THE POWER STEERING FAILS, SHE MAY NOT BE ABLE TO CONTROL THE VEHICLE DUE TO HER AGE AND STRENGTH. *JB
NHTSA ODI #10361990
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Illustration