← New search

2007 Saturn Ion

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2007 Saturn Ion do not stand out strongly from the model-year median of 816.5.

About this comparison →

When problems were reported

Mileage at the reported incident

736 reports with mileage · 140 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Steering. Review the 408 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 215 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 130 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

38 crash reports0 fire reports24 injury reports

What owners actually said

876 reports
Mileage unknown · Mar 23, 2013
Engine

2007 SATURN ION I WAS INVOLVED IN A CAR ACCIDENT 02/03/2013, WITH VERY MINIMAL DAMAGE TO MY LEFT, FRONT PANEL. ALMOST A MONTH LATER, THE VEHICLE WAS REPAIRED AND DROVE FINE FOR 3 DAYS. AFTER THE 3RD DAY MY CAR WOULD TURN OVER BUT IT WOULD NOT START. I HAD THE ORIGINAL REPAIR CENTER INSPECT MY VEHICLE AND THEY TOLD ME THE TIM…

Read full complaint

2007 SATURN ION I WAS INVOLVED IN A CAR ACCIDENT 02/03/2013, WITH VERY MINIMAL DAMAGE TO MY LEFT, FRONT PANEL. ALMOST A MONTH LATER, THE VEHICLE WAS REPAIRED AND DROVE FINE FOR 3 DAYS. AFTER THE 3RD DAY MY CAR WOULD TURN OVER BUT IT WOULD NOT START. I HAD THE ORIGINAL REPAIR CENTER INSPECT MY VEHICLE AND THEY TOLD ME THE TIMING CHAIN WAS OFF, BUT IT WAS NOT RELATED TO THE CAR ACCIDENT. I GOT A SECOND OPINION FROM ANOTHER MECHANIC AND HE ADVISED ME THAT THE TIMING CHAIN WAS NOT DUE TO MY ACCIDENT. I'VE NEVER HAD ANY TROUBLE WITH MY VEHICLE BEFORE THIS INCIDENT AND AFTER SEARCHING THE WEB AND FINDING NUMEROUS COMPLAINTS ABOUT TIMING CHAIN ISSUES, I'M CURIOUS AS TO WHY THERE'S NO RECALL. *TR

NHTSA ODI #10504238

59,600 miles · Mar 21, 2013
Electrical System

I WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION SWITCH TO TURN THE CAR OFF. I HAD NOTED IN THE MONTHS LEADING UP TO THIS FIRST OCCURRENCE THAT I WAS ABLE TO TURN THE CAR OFF, REMOVING THE KEY FROM THE IGNITION SWITCH, WITHOUT PUTTING THE CAR IN PARK FIRST. I CONTACTED SATURN'S 800# FOR ASSISTANCE AND THEY HAD ME REMOVE A FUSE…

Read full complaint

I WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION SWITCH TO TURN THE CAR OFF. I HAD NOTED IN THE MONTHS LEADING UP TO THIS FIRST OCCURRENCE THAT I WAS ABLE TO TURN THE CAR OFF, REMOVING THE KEY FROM THE IGNITION SWITCH, WITHOUT PUTTING THE CAR IN PARK FIRST. I CONTACTED SATURN'S 800# FOR ASSISTANCE AND THEY HAD ME REMOVE A FUSE FROM THE ENGINE TO TURN THE CAR OFF. THE CAR WAS TOWED TO A SATURN DEALERSHIP THE NEXT DAY, JUNE 1ST, WHERE THEY HAD TO COMPLETELY REPLACE THE IGNITION CYLINDER AS THE KEY COULD NOT BE REMOVED. THEN, IN MARCH 2011, I FOUND THE KEY HAD A TENDENCY TO GET STUCK IN THE IGNITION UNTIL, ONCE AGAIN, I COULD NO LONGER REMOVE THE KEY OR TURN THE CAR OFF. RECALLING REMOVAL OF A FUSE AFTER THE FIRST INSTANCE, I DID SO AGAIN IN THIS CASE UNTIL I COULD GET IT TO A GARAGE FOR REPAIR. I CONTACTED SATURN'S 800# TO ADVISE THEM AS TO WHAT HAD AGAIN HAPPENED, INQUIRING IF THERE HAD BEEN ANY SORT OF A RECALL. I WAS ADVISED THERE WAS NOT. I TOOK THE CAR TO MY OWN GARAGE FOR REPAIR AND THEY HAD TO COMPLETELY REPLACE THE IGNITION CYLINDER & SWITCH. HOWEVER, THEY WERE ABLE TO DISLODGE THE KEY THIS TIME. THE VEHICLE MILEAGE AT THE TIME OF REPAIR WAS 120462. NOW, IN MARCH 2013, I AM ONCE AGAIN FINDING THE KEY HAVING A TENDENCY TO STICK. I CAN GET THE CAR TO TURN OFF, BUT THE LOCKING MECHANISM WILL NOT DISENGAGE THE DOOR LOCKS. UNLESS THE DOOR LOCKS DISENGAGE, I CANNOT GET THE KEY OUT OF THE IGNITION. ON OCCASION, I'VE BEEN HAVING TO RESTART THE CAR MULTIPLE TIMES BEFORE THE LOCKING MECHANISM WILL DISENGAGE THE DOOR LOCKS ALLOWING ME TO REMOVE THE KEY. MY CURRENT MILEAGE IS APPROXIMATELY 165,000. *TR

NHTSA ODI #10503898

69,000 miles · Mar 18, 2013
Electrical System

TL* THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT STATED THAT AFTER PARKING HER VEHICLE AND TRYING TO REMOVE THE KEY, IT FAILED TO RELEASE. THE VEHICLE WAS LATER TOWED TO A DEALER. AFTER DIAGNOSIS, THEY ADVISED HER THAT THE IGNITION LOCK CYLINDER AND HOUSING FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUF…

Read full complaint

TL* THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT STATED THAT AFTER PARKING HER VEHICLE AND TRYING TO REMOVE THE KEY, IT FAILED TO RELEASE. THE VEHICLE WAS LATER TOWED TO A DEALER. AFTER DIAGNOSIS, THEY ADVISED HER THAT THE IGNITION LOCK CYLINDER AND HOUSING FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 69,000. *TR UPDATED 4/24/13 *CN UPDATED 05/17/2013 *JS

NHTSA ODI #10503386

100,000 miles · Mar 10, 2013
Suspension

LOAD METAL CLANG ON BUMPS ? DRIVER SIDE FRONT. THE BUTTON BUSHING IS CONTAINED IN A METAL RING THAT IS PRESSED INTO THE ARM. THE RING DOES NOT SEPARATE FROM THE CONTROL ARM. THE PROBLEM IS THE BUSHING IS NOT SECURED WELL ENOUGH IN THAT RING (THE RING IS NOT CRIMPED AROUND THE TOP AND BOTTOM OF THE BUSHING AS IT SHOULD BE) …

Read full complaint

LOAD METAL CLANG ON BUMPS ? DRIVER SIDE FRONT. THE BUTTON BUSHING IS CONTAINED IN A METAL RING THAT IS PRESSED INTO THE ARM. THE RING DOES NOT SEPARATE FROM THE CONTROL ARM. THE PROBLEM IS THE BUSHING IS NOT SECURED WELL ENOUGH IN THAT RING (THE RING IS NOT CRIMPED AROUND THE TOP AND BOTTOM OF THE BUSHING AS IT SHOULD BE) AND SEPARATES ALLOWING THE WHOLE ARM TO GO UP AND BUMP AGAINST THE FRAME CAUSING A LOUD CLANG WHEN THE SUSPENSION REBOUNDS FROM A BUMP. IT IS EASILY DIAGNOSED BY VISUAL INSPECTION SEEING THE REAR AREA OF THE CONTROL ARM UP AGAINST THE FRAME. I CAN SEE THE BUSHING SHREDDING AS A WEAR ISSUE BUT THIS IS A DEFECT WHERE THE BUSING IS FAILING BECAUSE IT IS NOT SECURED AS IT SHOULD BE. I REPLACED IT MYSELF AND MADE THIS VIDEO OF IT. MANY OTHERS HAVE THE SAME ISSUE. *TR

NHTSA ODI #10502222

2,000 miles · Mar 10, 2013
Fuel/propulsion System

THE CAR, WHEN JUST WEEKS OLD, SMELLED OF GAS COMING FROM THE FRONT GRILLE, A STRONG ODOR 5 MINUTES AFTER SHUTTING IT OFF. DEALER CHECKED SAID ALL WAS NORMAL. ALONG WITH THIS ISSUE WAS A LOSS OF VACUUM IN THE BRAKE ASSIST CANISTER WHEN IT SAT IN THE DRIVEWAY ? WHEN YOU GOT IN THE CAR THE BRAKE THE BRAKE PEDAL WAS ROCK-HARD. …

Read full complaint

THE CAR, WHEN JUST WEEKS OLD, SMELLED OF GAS COMING FROM THE FRONT GRILLE, A STRONG ODOR 5 MINUTES AFTER SHUTTING IT OFF. DEALER CHECKED SAID ALL WAS NORMAL. ALONG WITH THIS ISSUE WAS A LOSS OF VACUUM IN THE BRAKE ASSIST CANISTER WHEN IT SAT IN THE DRIVEWAY ? WHEN YOU GOT IN THE CAR THE BRAKE THE BRAKE PEDAL WAS ROCK-HARD. THERE SHOULD BE 5 ? 10 PUMPS OF VACUUM IN THE CANISTER ON ANY CAR. THIS IS NOTICEABLE IN A STICK SHIFT (IT IS) OR ANY CAR YOU HAVE TO STEP ON THE BRAKE FOR THE INTERLOCKED STARTER. DEALER CHECKED ALSO SAID WAS NORMAL. THEN ABOUT TWO YEARS AFTER THE SMELL OF GAS STOPPED ALTOGETHER AND THE POWER ASSIST SEEMED NORMAL AS THE PEDDLE HAD POWER WHEN THE CAR WAS LEFT TO SIT. ABOUT 6 MONTHS AGO THE GAS SMELL STARTED COMING BACK WHEN IT WAS PARKED ? THIS TIME FOR JUST A MINUTE OR SO ? INTERMITTENT. THEN ABOUT 3 MONTHS AGO IT STARTED GETTING WORSE ? NOT JUST WHEN THE CAR WAS SHUT OFF BUT NOW GAS ODOR WITH CLOSED WINDOWS AT THE FIRST FEW LIGHTS YOU CAME TO AFTER STARTING THE CAR, WITH WINDOWS SHUT IN COLD WEATHER. NOW THE ODOR IS STRONG, SOMETIMES NAUSEATING AT TRAFFIC LIGHTS. THE BRAKE PEDAL ISSUE ALSO RETURNED IN FEBRUARY ON VERY COLD MORNINGS. I DO NOT KNOW IF A VACUUM LEAK AND A FUEL SMELL ARE RELATED HERE. I CANNOT SEE ANY LEAKING GAS OR SPOTS ON THE PAVEMENT AND I HAVE LOOKED A FEW DOZEN TIMES OVER THE TWO TIME PERIODS THIS PROBLEM(S) HAVE OCCURRED. A VERY STRONG SMELL OF GAS AND NO VISIBLE LEAK. I AM FAMILIAR THAT CAR IS RECALLED IN SOUTHERN STATES ONLY FOR A FUEL PUMP THAT HAS CRACKS IN THE PLASTIC RETURN LINES ? AND ALSO HAVE READ (ALTHOUGH CANNOT BE SURE IF THIS IS TRUE LEAK FUEL IN A POOL ON TOP OF THE TANK AND NOT DRIP AND THE EVAPORATING ODOR WILL MAKE ITS WAY FORWARD TO THE ENGINE COMPARTMENT OR THE BACK WHEEL WELLS - I CAN SMELL GAS IN THE REAR WHEEL WELLS ALSO ALTHOUGH SOMETIMES NOT AS STRONG AS THE GRILLE. *TR

NHTSA ODI #10502221

60,000 miles · Mar 5, 2013
Fuel/propulsion SystemSteering

TL* THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS OR WHEN STANDING OUTSIDE THE VEHICLE, HE NOTICED A STRONG ODOR OF GASOLINE. IN ADDITION, HE ALSO NOTICED THAT THE POWER STEERING WOULD FAIL WHEN COMPLETING A TURN. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. T…

Read full complaint

TL* THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS OR WHEN STANDING OUTSIDE THE VEHICLE, HE NOTICED A STRONG ODOR OF GASOLINE. IN ADDITION, HE ALSO NOTICED THAT THE POWER STEERING WOULD FAIL WHEN COMPLETING A TURN. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000. THE CURRENT MILEAGE WAS APPROXIMATELY 85,000. *TR

NHTSA ODI #10501385

Mileage unknown · Feb 25, 2013
Steering

WAS DRIVING WHEN MY CAR DINGED AND I GOT A POWER STEERING LIGHT ON MY DASH AND MY POWER STEERING FAILED. THIS HAS HAPPENED SEVERAL TIMES IN THE LAST FEW MONTHS. *TR

NHTSA ODI #10499924

Mileage unknown · Feb 21, 2013
Fuel System, Gasoline

LETTER FROM CONGRESSMAN TOOMEY ON BEHALF OF CONSTITUENT REGARDING HER 2007 SATURN VEHICLE; SHE BELIEVE THERE WAS A SAFETY RECALL, BUT HAS YET TO BE REIMBURSED; ATTN: JESSICA KEMMERER 1150 S. CEDAR CREST BLVD, SUITE 101 ALLENTOWN PA. 18103. *SMD THE CONSUMER STATED THE FUEL PUMP WAS REPLACED AT A COST $ 578.38. THE CONSUMER WA…

Read full complaint

LETTER FROM CONGRESSMAN TOOMEY ON BEHALF OF CONSTITUENT REGARDING HER 2007 SATURN VEHICLE; SHE BELIEVE THERE WAS A SAFETY RECALL, BUT HAS YET TO BE REIMBURSED; ATTN: JESSICA KEMMERER 1150 S. CEDAR CREST BLVD, SUITE 101 ALLENTOWN PA. 18103. *SMD THE CONSUMER STATED THE FUEL PUMP WAS REPLACED AT A COST $ 578.38. THE CONSUMER WAS INFORMED HER VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED IN THE RECALL. *JB

NHTSA ODI #10500281

56,000 miles · Feb 20, 2013
Air Bags

I WAS RECENTLY IN AN ACCIDENT AND NOW A LITTLE WHILE LATER MY AIRBAG LIGHT IS COMING. I WANT TO KNOW WHY AFTER SO MANY COMPLAINTS ABOUT THIS SAME ISSUE NOTHING HAS BEEN DONE ABOUT IT. OBVIOUSLY SOMETHING IS WRONG WITH THE AIRBAGS... *TR

NHTSA ODI #10499493

76,000 miles · Feb 19, 2013
Fuel/propulsion System

AFTER REPLACING THE FUEL PUMP LAST YEAR I AM NOW FACING A CRACKED GAS TANK. I ASKED THE MECHANIC IF IT COULD BE DUE TO ME HITTING ANYTHING, I HAD NOT BEEN IN ANY ACCIDENTS, AND I WAS ADVISED THERE WASN'T ANYTHING TO INDICATE AND OUTSIDE DAMAGE. JUST THAT THE TANK ITSELF HAS WORN AWAY. *TR

NHTSA ODI #10498554

Official recalls

5

14V171000 · Electrical System:ignition

Apr 10, 2014

General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

Consequence & remedy

Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

14V153000 · Steering:electric Power Assist System

Mar 31, 2014

General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Consequence & remedy

Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

14V047000 · Air Bags; Electrical System:ignition:switch

Feb 10, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Additional source detail variants (2)

Air Bags

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Electrical System:ignition:switch

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

12V459000 · Fuel System, Gasoline:delivery:fuel Pump

Sep 19, 2012

General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.

Consequence & remedy

Consequence: Fuel leakage in the presence of an ignition source may result in a fire.

Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.

09V419000 · Fuel System, Gasoline:delivery:fuel Pump

Oct 29, 2009

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.

Consequence & remedy

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

EA11014 · Electric Power Steering Failure

Opened Sep 29, 2011 · Closed Apr 15, 2014

Status: closed (inferred from source dates) · Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Additional source detail variants (2)

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

RQ10004 · Electric Power Steering Failure

Opened Dec 15, 2010 · Closed Oct 5, 2011

Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Additional source detail variants (2)

Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Steering

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.