NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
408 reportsClear category filter125,000 miles · Aug 10, 2016
Steering
TL* THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL AND SMELLED MOST OF THE TIME. THE CHECK ENGINE LIGHT REMAINED ILLUMINATED AND THE VEHICLE DID NOT START AT THE FIRST ATTEMPT. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES, BUT DID NOT OFFER ANY ASSISTANC…
Read full complaint
TL* THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL AND SMELLED MOST OF THE TIME. THE CHECK ENGINE LIGHT REMAINED ILLUMINATED AND THE VEHICLE DID NOT START AT THE FIRST ATTEMPT. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES, BUT DID NOT OFFER ANY ASSISTANCE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE FAILURES WERE NOT REMEDIED. THE FAILURE MILEAGE WAS APPROXIMATELY 125,000.
NHTSA ODI #10894826
78,000 miles · May 29, 2016
Electrical SystemSteering
POWER STEERING GOES IN AND OUT VERY DANGEROUS TO DRIVE OR CONTROL IGNITION SWITCH REPAIRED THIS IS JUST AS DANGEROUS MODELS PONTIAC G AND CHEVY COBALTS HAVE SAME POWER STEERING MODULE AND WERE RECALLED NOT SATURN MODELS.
NHTSA ODI #10871378
160,000 miles · Mar 31, 2016
Steering
TL* THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS, THE STEERING WHEEL BECAME INOPERABLE WHILE THE BATTERY WARNING LIGHT ILLUMINATED. THE CONTACT ALSO STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE VEHICLE WAS NOT DIAGNOSED OR REPAIR…
Read full complaint
TL* THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS, THE STEERING WHEEL BECAME INOPERABLE WHILE THE BATTERY WARNING LIGHT ILLUMINATED. THE CONTACT ALSO STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.
NHTSA ODI #10852695
185,500 miles · Mar 30, 2016
Steering
A GENERAL MOTOR RECALL HAS BEEN ISSUED IN THE PAST FOR A LOSS OF POWER STEERING ONLY ON CERTAIN VEHICLES IN THE PAST YEAR. A PROBLEM IS CORROSION OF THE ELECTRIC POWER STEERING MODULE AND THE TORQUE SENSOR CONNECTOR MAY CAUSE A LOSS OF THE POWER STEERING. THIS WILL CAUSE GREATER OPERATING POWER BY THE DRIVER UNDER LOW SPEED DRIV…
Read full complaint
A GENERAL MOTOR RECALL HAS BEEN ISSUED IN THE PAST FOR A LOSS OF POWER STEERING ONLY ON CERTAIN VEHICLES IN THE PAST YEAR. A PROBLEM IS CORROSION OF THE ELECTRIC POWER STEERING MODULE AND THE TORQUE SENSOR CONNECTOR MAY CAUSE A LOSS OF THE POWER STEERING. THIS WILL CAUSE GREATER OPERATING POWER BY THE DRIVER UNDER LOW SPEED DRIVING AND CAUSES A GREATER CHANCE OF AN ACCIDENT OR DEATH BECAUSE THE DIFFICULTY IN DRIVING A VEHICLE EFFECTED BY THIS PROBLEM. GM HAS MADE THIS A RECALL TO BE FIXED IN THE DEALER, BUT ONLY CERTAIN VEHICLES, THE SATURN ION WAS INVOLVED, AND I HAD IT CORRECTED, BUT WHAT I EXPERIENCED BEFORE, IS BACK AGAIN, AND I BELIEVE THE POWER STEERING ASSIST IS DEFECTIVE AGAIN. MANY RECALLS IN THE PAST HAVE BEEN REOCCURRING ISSUES WITH VEHICLES, AND THIS MAY BE ANOTHER ONE.
NHTSA ODI #10852601
55,000 miles · Mar 25, 2016
Steering
TL* THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING AT LOW SPEEDS, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE FAILURE OCCURRED AFTER THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRIC POWER STEERING ASSIST NEEDED TO REPLAC…
Read full complaint
TL* THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING AT LOW SPEEDS, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE FAILURE OCCURRED AFTER THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRIC POWER STEERING ASSIST NEEDED TO REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000.
NHTSA ODI #10851637
62,000 miles · Jan 29, 2016
Steering
TL* THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING AT AN UNKNOWN SPEED, THE POWER STEERING WARNING LIGHT ILLUMINATED AND THE POWER STEERING FAILED. THE VEHICLE WAS TOWED TO THE DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THERE WAS AN INTERMITTENT ELECTRONIC CONTROL MODULE FAILURE. THE VEHICLE WAS REPAIRED. THE VEHIC…
Read full complaint
TL* THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING AT AN UNKNOWN SPEED, THE POWER STEERING WARNING LIGHT ILLUMINATED AND THE POWER STEERING FAILED. THE VEHICLE WAS TOWED TO THE DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THERE WAS AN INTERMITTENT ELECTRONIC CONTROL MODULE FAILURE. THE VEHICLE WAS REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 62,000. ..UPDATED 03/22/16 *BF THE CONSUMER STATED THE MANUFACTURER REFUSED TO OFFER ANY ASSISTANCE. *JS
NHTSA ODI #10823163
76,000 miles · Dec 10, 2015
Air BagsElectrical SystemService BrakesCrashInjury
TL* THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING 35 MPH AND ATTEMPTING TO AVOID A VEHICLE THAT WAS STOPPED IN THE ROADWAY, THE IGNITION KEY BECAME JARRED AND MOVED TO THE OFF POSITION, WHICH CAUSED THE VEHICLE TO STALL WITHOUT WARNING. THE CONTACT ATTEMPTED TO SWITCH LANES; HOWEVER, THE STEERING WHEEL SEIZED AND THE BRAKES …
Read full complaint
TL* THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING 35 MPH AND ATTEMPTING TO AVOID A VEHICLE THAT WAS STOPPED IN THE ROADWAY, THE IGNITION KEY BECAME JARRED AND MOVED TO THE OFF POSITION, WHICH CAUSED THE VEHICLE TO STALL WITHOUT WARNING. THE CONTACT ATTEMPTED TO SWITCH LANES; HOWEVER, THE STEERING WHEEL SEIZED AND THE BRAKES FAILED TO FUNCTION WHEN THE PEDAL WAS DEPRESSED. THE CONTACT STATED THAT THE VEHICLE CRASHED INTO THE REAR OF THE PARKED VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THERE WAS NO POLICE REPORT FILED. THE CONTACT SUSTAINED INJURIES TO THE NECK, SHOULDER, AND LOWER BACK THAT REQUIRED MEDICAL ATTENTION. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14E021000 (ELECTRICAL SYSTEM); HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO A DEALER TO BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 76,000.
NHTSA ODI #10809556
11,000 miles · Nov 2, 2015
Steering
TL* THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING 5 MPH, THE POWER STEERING WARNING LIGHT ILLUMINATED AND THE STEERING WHEEL WAS DIFFICULT TO MANEUVER. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAI…
Read full complaint
TL* THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING 5 MPH, THE POWER STEERING WARNING LIGHT ILLUMINATED AND THE STEERING WHEEL WAS DIFFICULT TO MANEUVER. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 11,000.
NHTSA ODI #10787855
50,900 miles · Oct 22, 2015
Steering
TL* THE CONTACT OWNS A 2007 SATURN ION. WHILE IN PARK, THE STEERING WHEEL SEIZED AND A POWER STEERING WARNING MESSAGE WAS DISPLAYED ACROSS THE MESSAGE BOARD. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSED THAT THE POWER STEERING CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2007 SATURN ION. WHILE IN PARK, THE STEERING WHEEL SEIZED AND A POWER STEERING WARNING MESSAGE WAS DISPLAYED ACROSS THE MESSAGE BOARD. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSED THAT THE POWER STEERING CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 50,900.
NHTSA ODI #10785414
84,000 miles · Sep 8, 2015
Air BagsSeat BeltsSteeringCrashInjury
THERE IS A BOSH/CDR REPORT FROM ESIS OF GENERAL MOTORS OUTLINING THE DATA RECEIVED FROM THE CRASH FOR NON-DEPLOYMENT OF THE AIRBAG. MR. SEGOVIA OF GM STATED THAT THE AIRBAG SHOULD NOT HAVE DEPLOYED BASED ON THE STATISTIC FROM THIS REPORT. I DO NOT BELIEVE WHAT HE HAS STATED. I NEED A REVIEW OF THE REPORT FOR COMPLIANCE REGARDIN…
Read full complaint
THERE IS A BOSH/CDR REPORT FROM ESIS OF GENERAL MOTORS OUTLINING THE DATA RECEIVED FROM THE CRASH FOR NON-DEPLOYMENT OF THE AIRBAG. MR. SEGOVIA OF GM STATED THAT THE AIRBAG SHOULD NOT HAVE DEPLOYED BASED ON THE STATISTIC FROM THIS REPORT. I DO NOT BELIEVE WHAT HE HAS STATED. I NEED A REVIEW OF THE REPORT FOR COMPLIANCE REGARDING THE NON-DEPLOYMENT OF THE AIRBAG TO MY 2007 SATURN ION. GM THROUGH ESIS HAS REFUSED TO SURRENDER THE REPORT TO THE DEFECTED SEATBELTS. MY GENERAL MOTORS PENDING CLAIM #816261. I HAVE NOTICED ANDREW SEGOVIA, ESQ., MS. MARY T. BARRA, CEO, MR. DANIEL AMMANN, PRESIDENT OF GM REGARDING THE SECOND HALF OF THE CLAIM OF THE DEFAULTED/RECALL OF THE POWER STEERING DURING THE CRASH. MR. SEGOVIA HAS CONFIRMED ESIS'S EMAIL STATING THAT THERE WAS A POWER STEERING RECALL/DEFECT TO MY CAR VIN NUMBER AND REMAINED OPEN. THERE WAS THE DEBRIS ON THE HIGHWAY THAT CAUSED THE ACCIDENT AND THEN THERE WAS THE DEFECTED POWER STEERING PROBLEM WITH MY 2007 SATURN ION WHICH CAUSED THE CRASH. I WAS NEVER NOTIFIED OF THIS RECALL BY GM. THE DEFAULTED POWER STEERING CAUSED THE CRASH. IN THE OUTSET OF THIS CLAIM, GENERAL MOTORS WAS AWARE THAT THE POWER STEERING OF THE VEHICLE WAS INOPERABLE. I TRIED TO TURN THE STEERING WHEEL SO THAT THE VEHICLE WOULD NOT CRASH INTO THE RAIL GUARD BUT FAILED. I COULD NOT STEER THE VEHICLE. IF I WOULD HAVE BEEN NOTIFIED OF THE POWER STEERING RECALL AND DEFECT, THE CAR WOULD HAVE BEEN REPAIRED AND OPERABLE AT THE TIME THE CAR CRASHED. BUT GENERAL MOTORS DEFECTED POWER STEERING CAUSED ME TO HAVE NO CONTROL OF THE POWER STEERING OF THE VEHICLE AWAY FROM THE RAIL GUARD SO THE CAR WOULD NOT CRASH INTO THE RAIL GUARD. THE POWER STEERING WAS INOPERABLE AND AS A RESULT CAUSED THE CRASH. I AM AWAITING A RESPONSE BACK FROM GENERAL MOTORS IN THE RESOLUTION/SETTLEMENT OF THIS MATTER AS WELL AND OTHER INFORMATION REGARDING THE LOANER VEHICLE.
NHTSA ODI #10762327
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Illustration