NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
408 reportsClear category filter27,000 miles · Jul 17, 2010
Electrical SystemExterior LightingFuel System, Gasoline
UNFORTUNATELY I HAVE A 2007 SATURN ION WHICH SOUNDS LIKE IT IS GOING TO BREAK IN HALF OVER EVEN THE SLIGHTEST SMALL BUMPS IN THE ROAD. I HAVE A WARRANTY ON THE VEHICLE WHICH EXPIRED IN JUNE 2010. ALTHOUGH THE CAR ONLY HAS 29000 MILES ON IT~ SATURN WOULD NOT HONOR THE WARRANTY WHEN I BROUGHT MY CAR IN FOR A CHECK ENGINE LIGHT~ …
Read full complaint
UNFORTUNATELY I HAVE A 2007 SATURN ION WHICH SOUNDS LIKE IT IS GOING TO BREAK IN HALF OVER EVEN THE SLIGHTEST SMALL BUMPS IN THE ROAD. I HAVE A WARRANTY ON THE VEHICLE WHICH EXPIRED IN JUNE 2010. ALTHOUGH THE CAR ONLY HAS 29000 MILES ON IT~ SATURN WOULD NOT HONOR THE WARRANTY WHEN I BROUGHT MY CAR IN FOR A CHECK ENGINE LIGHT~ IT WAS THE PURGE SENSOR. THEY WANTED TO CHARGE ME OVER $300 TO REPAIR THIS ISSUE. I WENT ONLINE AND SAW MANY OTHER'S HAD REPORTED THE SAME PROBLEM. I ALSO SAW THE PART FOR ONLY $26.00 ~HOWEVER AT THE SATURN DEALERSHIP THEY CHARGED ME $51.00 FOR THE PART. I ENDED UP FIXING THE REPAIR MYSELF TO AVOID BEING ROBBED BY THE SATURN DEALERSHIP!! I AM VERY DISPLEASED WITH MY CAR~ NOW THE STRUTS AND CONTROL ARM BUSHINGS ARE MAKING SIGNIFICANT RUMBLE WHEN DRIVING OVER THE SLIGHTEST BUMPS IN THE ROAD. AT 29000 MILES THE CAR SHOULD NOT BE MAKING ANY NOISE!! I FEEL VERY UNSAFE AND SCARED IN MY SATURN!! I'VE SEEN MANY REPORTS OF OTHER OWNER'S WITH THE SAME VEHICLE THAT ARE SIMILAR. EVEN THE GM COBALT WHICH HAS THE EXACT SAME PLATFORM AND STEERING HAS THE SAME ISSUES AND FOR THAT CAR POWER STEERING ISSUES HAVE BEEN RECALLED BUT NOT FOR THE ION WHICH ~I REPEAT HAS THE SAME COMPONENTS. I BOUGHT MY CAR WHEN FUEL COSTS SOARED AND THOUGHT IT WOULD AT LEAST LAST ME 5 YEARS WITH OUT ISSUES. I THINK GM NEEDS TO ADDRESS THESE ISSUES ESPECIALLY SINCE SO MANY CONSUMERS ARE EXPERIENCING ISSUES AT SUCH LOW MILEAGE. THERE ARE ALSO ISSUES WITH THE REAR DEFROST, POWER WINDOWS, STEERING, AND TRANSMISSION. I'M FROM MN. AND IT'S TERRIBLE WHEN YOU HAVE A NEWER CAR THAT WON'T EVEN TAKE YOU 30,000 MILES WITHOUT BREAKING DOWN!! I'M VERY DISAPPOINTED AND SATURN NEEDS TO RECALL EVERYTHING ON THESE UNSAFE VEHICLES BEFORE SOMEONE GETS SERIOUSLY HURT ~LIKE TOYOTA. I'M SURE YOU'VE HAD SEVERAL COMPLAINTS. THE CAR IS DEFECTIVE!! PLEASE HELP!! SATURN WON'T REPAIR UNLESS IT'S COMPLETELY BROKEN EVEN IF THE CAR IS SMOKIN THEY BLOW YOU OFF!!! ~HORRIBLE!!! *TR
NHTSA ODI #10343759
54,000 miles · Jul 15, 2010
Steering
TL* THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING AT APPROXIMATELY 20 MPH, THE POWER STEERING WARNING LIGHT ILLUMINATED ON THE DASHBOARD AS THE STEERING WHEEL BECAME EXTREMELY STIFF. THE CONTACT SHUT OFF THE ENGINE AND WHEN RESTARTING, THE VEHICLE RESUMED NORMAL OPERATION. THE FAILURE WOULD RECUR INTERMITTENTLY WHILE DRIVI…
Read full complaint
TL* THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING AT APPROXIMATELY 20 MPH, THE POWER STEERING WARNING LIGHT ILLUMINATED ON THE DASHBOARD AS THE STEERING WHEEL BECAME EXTREMELY STIFF. THE CONTACT SHUT OFF THE ENGINE AND WHEN RESTARTING, THE VEHICLE RESUMED NORMAL OPERATION. THE FAILURE WOULD RECUR INTERMITTENTLY WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE A NEW POWER STEERING MOTOR WAS INSTALLED. THE FAILURE DID NOT RECUR. AN AUTHORIZED DEALER WAS NOTIFIED AND INFORMED THE CONTACT THAT HER STEERING COLUMN MAY ALSO NEED TO BE REPLACED IN THE NEAR FUTURE. THE FAILURE MILEAGE WAS 54,000 AND THE CURRENT MILEAGE WAS 55,000. UPDATED 10/05/10. *LJ
NHTSA ODI #10343460
38,000 miles · Jul 13, 2010
Steering
TL* THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING AT AN UNKNOWN SPEED, THE STEERING WHEEL BECAME VERY STIFF AND THE POWER STEERING WARNING LIGHT ILLUMINATED ON THE DASHBOARD. THE CONTACT SHUT OFF THE ENGINE AND WHEN RESTARTING, THE VEHICLE RESUMED NORMAL OPERATION. THIS FAILURE RECURRED INTERMITTENTLY WHILE TRAVELING AT AN…
Read full complaint
TL* THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING AT AN UNKNOWN SPEED, THE STEERING WHEEL BECAME VERY STIFF AND THE POWER STEERING WARNING LIGHT ILLUMINATED ON THE DASHBOARD. THE CONTACT SHUT OFF THE ENGINE AND WHEN RESTARTING, THE VEHICLE RESUMED NORMAL OPERATION. THIS FAILURE RECURRED INTERMITTENTLY WHILE TRAVELING AT ANY SPEED. THE VEHICLE WAS NOT EXAMINED FOR THE CAUSE OF FAILURE. THE FAILURE MILEAGE WAS 38,000 AND THE CURRENT MILEAGE WAS 43,000.
NHTSA ODI #10342975
65,000 miles · Jul 13, 2010
Steering
POWER STEERING LIGHT FLASHES ON DASH COMPUTER DISPLAY RANDOMLY, MORE OFTEN WHEN THE CAR'S BEEN DRIVEN A LOT AND POWER STEERING IS LOST COMPLETELY. YOU CAN TURN CAR OFF AND RESTART AND ITS FINE. SOMETIMES DOES IT ONCE IN A DAY, SOMETIMES 15 TIMES. IF CAR IS IN PROCESS OF MAKING A TURN OR AVOIDING SOMETHING IN ROAD, THIS COULD …
Read full complaint
POWER STEERING LIGHT FLASHES ON DASH COMPUTER DISPLAY RANDOMLY, MORE OFTEN WHEN THE CAR'S BEEN DRIVEN A LOT AND POWER STEERING IS LOST COMPLETELY. YOU CAN TURN CAR OFF AND RESTART AND ITS FINE. SOMETIMES DOES IT ONCE IN A DAY, SOMETIMES 15 TIMES. IF CAR IS IN PROCESS OF MAKING A TURN OR AVOIDING SOMETHING IN ROAD, THIS COULD CAUSE A SEVERE CRASH AND BODILY HARM, IF NOT DEATH. YOU HAVE TO STOP CAR AND TURN OFF TO CLEAR THIS. TOOK CAR TO NAPA AND DISCOUNT AND NO CODES WOULD READ. CHECKED FUSE, IT WAS FINE. GM HAS ISSUED RECALLS ON 2 OF THEIR CARS FOR THIS SAME ISSUE WHERE THE SAME PARTS ARE USED BUT NOT SATURN. THIS IS A SAFETY ISSUE. I REFUSE TO FORK OUT MY MONEY ON A CAR THAT ISN'T BEING MADE ANYMORE BECAUSE GM WON'T ADDRESS THERE IS AN ISSUE. THERE ARE 95 OTHER COMPLAINTS SIMILAR TO MINE..........DO SOMETHING. *TR
NHTSA ODI #10342963
31,110 miles · Jul 12, 2010
Steering
TL*THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING APPROXIMATELY 15 MPH, THE CONTACT HEARD A WARNING CHIME AND NOTICED THAT THE POWER STEERING WARNING LIGHT WAS ILLUMINATED. WITHIN SECONDS, THE POWER STEERING ASSIST FAILED AND THE STEERING WHEEL BECAME INCREASINGLY DIFFICULT TO STEER. THE CONTACT WAS ABLE TO MAKE AN APPOINTMEN…
Read full complaint
TL*THE CONTACT OWNS A 2007 SATURN ION. WHILE DRIVING APPROXIMATELY 15 MPH, THE CONTACT HEARD A WARNING CHIME AND NOTICED THAT THE POWER STEERING WARNING LIGHT WAS ILLUMINATED. WITHIN SECONDS, THE POWER STEERING ASSIST FAILED AND THE STEERING WHEEL BECAME INCREASINGLY DIFFICULT TO STEER. THE CONTACT WAS ABLE TO MAKE AN APPOINTMENT WITH THE DEALER FOR DIAGNOSTIC TESTING AND REPAIRS. THE FAILURE MILEAGE WAS 31,110 AND THE CURRENT MILEAGE WAS 31,120.
NHTSA ODI #10342700
67,400 miles · Jul 12, 2010
Electrical SystemSteering
CAR WILL NOT SHUT OFF, AFTER CONTACTING DEALER WAS ADVISED TO DISCONNECT THE WIRING HARNESS FROM THE BATTERY. WHEEL SPORADICALLY LOCKS UP WHILE DRIVING WHICH CAN CAUSES YOU TO LOOSE CONTROL OF THE VEHICLE. NO WARNING LIGHTS COME ON AT ALL. PREVIOUSLY HAD THIS SAME ISSUE WITH POWER STEERING IN DECEMBER WHICH WENT OUT AND ALMOS…
Read full complaint
CAR WILL NOT SHUT OFF, AFTER CONTACTING DEALER WAS ADVISED TO DISCONNECT THE WIRING HARNESS FROM THE BATTERY. WHEEL SPORADICALLY LOCKS UP WHILE DRIVING WHICH CAN CAUSES YOU TO LOOSE CONTROL OF THE VEHICLE. NO WARNING LIGHTS COME ON AT ALL. PREVIOUSLY HAD THIS SAME ISSUE WITH POWER STEERING IN DECEMBER WHICH WENT OUT AND ALMOST CAUSED AN ACCIDENT. GM HAS RECALLED SEVERAL VEHICLES FOR THIS SAME SAFETY HAZARD HOWEVER DID NOT INCLUDE SATURNS IN THE RECALL. *TR
NHTSA ODI #10342634
46,121 miles · Jul 12, 2010
Steering
VIN # [XXX] 2007 SATURN ION HAS A POWER STEERING PROBLEM. THE POWER STEERING MOTOR IS A DEFECTIVE PART AND GM IS AWARE OF THE PROBLEM IN THESE VEHICLES AND THEY AREN'T DOING ANYTHING ABOUT THIS. I HAVEN'T HAD A CRASH OR ANYTHING LIKE THAT YET BUT THE POWERSTEERING JUST GOES OUT WHEN U ARE DRIVING MAKING IT HARD TO TURN OR ST…
Read full complaint
VIN # [XXX] 2007 SATURN ION HAS A POWER STEERING PROBLEM. THE POWER STEERING MOTOR IS A DEFECTIVE PART AND GM IS AWARE OF THE PROBLEM IN THESE VEHICLES AND THEY AREN'T DOING ANYTHING ABOUT THIS. I HAVEN'T HAD A CRASH OR ANYTHING LIKE THAT YET BUT THE POWERSTEERING JUST GOES OUT WHEN U ARE DRIVING MAKING IT HARD TO TURN OR STEER. MY NAME IS [XXX] MY NUMBER IS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10342566
67,400 miles · Jul 8, 2010
Electrical SystemSteering
I GET TO WORK TODAY AND I CAN'T CUT OFF MY 2007 SATURN ION. CONTACT THE DEALERSHIP AND ONLY REMEDY PROVIDED IS TO DANGEROUSLY DISCONNECT THE WIRE HARNESS UNDER THE WHEEL FROM THE BATTERY TO TURN THE CAR OFF AND THEN PAY $300-500 DOLLARS TO HAVE IT REPAIRED WITH NO REASON WHY IT FAILED OR THAT IT WON'T GO OUT AGAIN. THIS IS DAN…
Read full complaint
I GET TO WORK TODAY AND I CAN'T CUT OFF MY 2007 SATURN ION. CONTACT THE DEALERSHIP AND ONLY REMEDY PROVIDED IS TO DANGEROUSLY DISCONNECT THE WIRE HARNESS UNDER THE WHEEL FROM THE BATTERY TO TURN THE CAR OFF AND THEN PAY $300-500 DOLLARS TO HAVE IT REPAIRED WITH NO REASON WHY IT FAILED OR THAT IT WON'T GO OUT AGAIN. THIS IS DANGEROUS AND THE PARTS ARE DEFECTIVE AND SHOULD BE RECALLED BY SATURN. *TR
NHTSA ODI #10342055
41,538 miles · Jul 8, 2010
Steering
TL*THE CONTACT OWNS A 2000 SATURN ION. WHEN THE CONTACT STARTED THE VEHICLE SHE SAW A PWRSTR CODE ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE FUNCTIONED NORMALLY WHEN SHE DROVE IT, HOWEVER, AFTER SHE TURNED IT OFF AND RESTARTED IT THE POWER STEERING FAILED COMPLETELY. THE DEALER WAS NOTIFIED AND STATED THAT THERE WERE NO …
Read full complaint
TL*THE CONTACT OWNS A 2000 SATURN ION. WHEN THE CONTACT STARTED THE VEHICLE SHE SAW A PWRSTR CODE ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE FUNCTIONED NORMALLY WHEN SHE DROVE IT, HOWEVER, AFTER SHE TURNED IT OFF AND RESTARTED IT THE POWER STEERING FAILED COMPLETELY. THE DEALER WAS NOTIFIED AND STATED THAT THERE WERE NO RECALLS RELATED TO STEERING. HE ALSO STATED THAT THE VEHICLE WOULD BE REPAIRED AT THE HER EXPENSE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 41,538.
NHTSA ODI #10341966
60,500 miles · Jul 7, 2010
Steering
TL*THE CONTACT OWNS A 2007 SATURN ION. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH, THE POWER STEERING WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL WITH A LOSS OF POWER STEERING. THE CONTACT WAS ABLE TO CONTINUE IN OPERATION. THE FAILURE OCCURRED INTERMITTENTLY AND PROGRESSED OVER A PERIOD OF TIME WHEN TRAVELING …
Read full complaint
TL*THE CONTACT OWNS A 2007 SATURN ION. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH, THE POWER STEERING WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL WITH A LOSS OF POWER STEERING. THE CONTACT WAS ABLE TO CONTINUE IN OPERATION. THE FAILURE OCCURRED INTERMITTENTLY AND PROGRESSED OVER A PERIOD OF TIME WHEN TRAVELING AT ANY SPEED. THE FAILURE COULD BE TEMPORARILY CORRECTED WHENEVER THE ENGINE WAS TURNED OFF AND RESTARTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN WAS UNABLE TO LOCATE THE CAUSE OF FAILURE. THE CONTACT WAS IN THE PROCESS OF TAKING THE VEHICLE TO A AN AUTHORIZED DEALER TO BE REPAIRED. THE FAILURE MILEAGE WAS 60,500.
NHTSA ODI #10341742
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Illustration