← New search

2006 Saturn Ion

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2006 Saturn Ion do not stand out strongly from the model-year median of 816.5.

About this comparison →

When problems were reported

Mileage at the reported incident

1,073 reports with mileage · 162 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Steering. Review the 544 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 392 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Gasoline. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

44 crash reports7 fire reports23 injury reports

Steering complaints

544 reports
Clear category filter
32,000 miles · Nov 2, 2009
Steering

TL* THE CONTACT OWNS A 2006 SATURN ION. INTERMITTENTLY THE POWER STEERING WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL, AND THEN THERE WAS A LOST OF POWER STEERING. THE VEHICLE WAS TAKEN TO THE DEALER, AND A TECHNICIAN STATED THAT HE WOULD HAVE TO PAY $900.00 TO REPAIR THE STEERING COLUMN AND GEAR BOX. NO REPAIRS W…

Read full complaint

TL* THE CONTACT OWNS A 2006 SATURN ION. INTERMITTENTLY THE POWER STEERING WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL, AND THEN THERE WAS A LOST OF POWER STEERING. THE VEHICLE WAS TAKEN TO THE DEALER, AND A TECHNICIAN STATED THAT HE WOULD HAVE TO PAY $900.00 TO REPAIR THE STEERING COLUMN AND GEAR BOX. NO REPAIRS WERE MADE. THE MANUFACTURER WAS NOTIFIED, AND HE WAS REFERRED TO THE DEALER. THE FAILURE AND CURRENT MILEAGES WERE 32,000. UPDATED 12/07/09. *LJ UPDATED 12/08/09.*JB

NHTSA ODI #10290578

37,500 miles · Oct 10, 2009
Steering

I WAS DRIVING DOWN ROUTE 1 IN KEY WEST, FLORIDA WHEN A BELL BEEPED AND MY POWER STEERING LIGHT CAME ON AND I ALMOST GOT IN AN ACCIDENT WHEN I TRIED TO GET OFF THE ROAD TO CHECK & SEE IF THE FLUID HAD LEAKED OUT. NO ONE COULD FIND THE FLUID CONTAINER. WHEN WE RESTARTED THE CAR, THE LIGHT WENT OUT FOR AWHILE AND IT WAS OK BUT IT C…

Read full complaint

I WAS DRIVING DOWN ROUTE 1 IN KEY WEST, FLORIDA WHEN A BELL BEEPED AND MY POWER STEERING LIGHT CAME ON AND I ALMOST GOT IN AN ACCIDENT WHEN I TRIED TO GET OFF THE ROAD TO CHECK & SEE IF THE FLUID HAD LEAKED OUT. NO ONE COULD FIND THE FLUID CONTAINER. WHEN WE RESTARTED THE CAR, THE LIGHT WENT OUT FOR AWHILE AND IT WAS OK BUT IT CONTINUED TO COME ON TILL I GOT IT HOME & PARKED IT. *TR

NHTSA ODI #10286966

30,000 miles · Oct 6, 2009
Steering

ELECTRIC ASSIST POWER STEERING STOPS WORKING WHILE DRIVING. STOP THE CAR AND SHUT IT OFF. THE STEERING WORKS WHEN THE CAR IS RESTARTED. *TR

NHTSA ODI #10286511

96,000 miles · Sep 30, 2009
Steering

TL*THE CONTACT OWNS A 2006 SATURN ION. WHILE DRIVING 55 MPH THE POWER STEERING WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL, AND THEN THERE WAS A LOSS OF POWER STEERING. THE VEHICLE WAS TAKEN TO THE DEALER AND THE STEERING COLUMN WAS REPLACED AT AN EXPENSE OF $950.00 THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILAB…

Read full complaint

TL*THE CONTACT OWNS A 2006 SATURN ION. WHILE DRIVING 55 MPH THE POWER STEERING WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL, AND THEN THERE WAS A LOSS OF POWER STEERING. THE VEHICLE WAS TAKEN TO THE DEALER AND THE STEERING COLUMN WAS REPLACED AT AN EXPENSE OF $950.00 THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 96,000.

NHTSA ODI #10285867

61,000 miles · Sep 25, 2009
Steering

TL*THE CONTACT OWNS A 2006 SATURN ION. HE STATED THAT INTERMITTENTLY THE POWER STEERING WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL, AND THEN HE LOST POWER STEERING. AS A CONSEQUENCE HE EXPERIENCED DIFFICULTY WHILE STEERING. OCCASIONALLY HE CAN RESTART THE VEHICLE AND RESUME NORMAL OPERATION. THE DEALER WAS NOTIF…

Read full complaint

TL*THE CONTACT OWNS A 2006 SATURN ION. HE STATED THAT INTERMITTENTLY THE POWER STEERING WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL, AND THEN HE LOST POWER STEERING. AS A CONSEQUENCE HE EXPERIENCED DIFFICULTY WHILE STEERING. OCCASIONALLY HE CAN RESTART THE VEHICLE AND RESUME NORMAL OPERATION. THE DEALER WAS NOTIFIED; HOWEVER, NO REPAIRS HAVE BEEN MADE. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 61,000. THE CURRENT MILEAGE WAS 62,453.

NHTSA ODI #10285264

71,909 miles · Sep 1, 2009
Steering

POWER STEERING ON 2006 SATURN ION 3 RANDOMLY SHUTS OFF WHILE DRIVING. IT HAPPENS AT UNSUSPECTED TIMES, AND DRIVERS ARE NOT PREPARED FOR HOW HARD IT IS TO TURN THE STEERING WHEEL. I HAVE NOT HAD AN ACCIDENT AS OF YET BECAUSE OF THIS PROBLEM, BUT IT NEEDS TO BE CORRECTED. DURING INTERNET RESEARCH, I FOUND THAT THIS IS A VERY C…

Read full complaint

POWER STEERING ON 2006 SATURN ION 3 RANDOMLY SHUTS OFF WHILE DRIVING. IT HAPPENS AT UNSUSPECTED TIMES, AND DRIVERS ARE NOT PREPARED FOR HOW HARD IT IS TO TURN THE STEERING WHEEL. I HAVE NOT HAD AN ACCIDENT AS OF YET BECAUSE OF THIS PROBLEM, BUT IT NEEDS TO BE CORRECTED. DURING INTERNET RESEARCH, I FOUND THAT THIS IS A VERY COMMON OCCURRENCE WITH THE SATURN ION MODELS. A 16 YEAR OLD IS NOT GOING TO BE ABLE TO CONTROL THE CAR IF THIS HAPPENS TO THEM. *TR

NHTSA ODI #10282565

54,065 miles · Aug 29, 2009
Steering

ELECTRIC POWER STEERING UNIT WILL INTERMITTENTLY GO OUT, CAUSING IMMEDIATE LOSS OF POWER STEERING. SOMETIMES THE PROBLEM WILL OCCUR JUST AFTER STARTING THE CAR, SOMETIMES IT WILL WAIT UNTIL AFTER 30 MINUTES OF CONTINUOUS DRIVING. IT USUALLY HAPPENS AFTER A TURN, BUT HAS HAPPENED IN THE MIDDLE OF A TURN, ALMOST PUTTING ME INTO …

Read full complaint

ELECTRIC POWER STEERING UNIT WILL INTERMITTENTLY GO OUT, CAUSING IMMEDIATE LOSS OF POWER STEERING. SOMETIMES THE PROBLEM WILL OCCUR JUST AFTER STARTING THE CAR, SOMETIMES IT WILL WAIT UNTIL AFTER 30 MINUTES OF CONTINUOUS DRIVING. IT USUALLY HAPPENS AFTER A TURN, BUT HAS HAPPENED IN THE MIDDLE OF A TURN, ALMOST PUTTING ME INTO A WALL ON THE FREEWAY ON-RAMP. DEALER SAYS STEERING COLUMN NEEDS REPLACED, WITH EXPENSIVE PARTS, AND MORE EXPENSIVE LABOR CHARGES. *TR

NHTSA ODI #10282232

48,000 miles · Aug 26, 2009
Steering

TL*THE CONTACT OWNS A 2006 SATURN ION. HE STATES WHILE DRIVING AT ANY SPEED THE POWER STEERING GOES OUT AND A WARNING LIGHT ILLUMINATES ON THE INSTRUMENT PANEL AND IT REACTIVATES WHEN YOU TURN THE VEHICLE BACK ON . THE FAILURE HAS OCCURRED APPROXIMATELY 20 TO 25 TIMES WITHIN THE LAST MONTH. THE DEALER WAS CONTACTED AND THEY INF…

Read full complaint

TL*THE CONTACT OWNS A 2006 SATURN ION. HE STATES WHILE DRIVING AT ANY SPEED THE POWER STEERING GOES OUT AND A WARNING LIGHT ILLUMINATES ON THE INSTRUMENT PANEL AND IT REACTIVATES WHEN YOU TURN THE VEHICLE BACK ON . THE FAILURE HAS OCCURRED APPROXIMATELY 20 TO 25 TIMES WITHIN THE LAST MONTH. THE DEALER WAS CONTACTED AND THEY INFORMED HIM TO CONTACT NHTSA TO FILE A COMPLAINT SO THAT A RECALL CAN BE ISSUED. HE HAS RESEARCHED THAT MANY CONSUMERS ARE HAVING THIS SAME PROBLEM. THE VEHICLE WILL BE TAKEN IN TO THE DEALER TO HAVE THE REPAIRS DONE UNDER OWNERS EXPENSE. THE FAILURE MILEAGE WAS 48000 AND CURRENT MILEAGE WAS 51000. BL UPDATED 10/5/09 *CN THERE WAS A SHORT IN THE STEERING MOTOR. UPDATED 10/07/09

NHTSA ODI #10281865

43,000 miles · Aug 4, 2009
Steering

WHILE ENTERING THE HIGHWAY ON A CURVED RAMP THE POWER STEERING SUDDENLY AND COMPLETELY WENT OUT. IT WAS VERY VERY HARD TO STEER. AFTER TURNING THE CAR OFF AND RESTARTING IT THE POWER STEERING STARTING WORKING AGAIN. AFTER DRIVING THE CAR A SHORT DISTANCE, AGAIN SUDDENLY NO POWER STEERING. EVERY TIME THE CAR IS TURNED OFF IT RESE…

Read full complaint

WHILE ENTERING THE HIGHWAY ON A CURVED RAMP THE POWER STEERING SUDDENLY AND COMPLETELY WENT OUT. IT WAS VERY VERY HARD TO STEER. AFTER TURNING THE CAR OFF AND RESTARTING IT THE POWER STEERING STARTING WORKING AGAIN. AFTER DRIVING THE CAR A SHORT DISTANCE, AGAIN SUDDENLY NO POWER STEERING. EVERY TIME THE CAR IS TURNED OFF IT RESETS THE POWER STEERING. IT WILL GO OUT ANYTIME, ANYWHERE AND IN ANY CIRCUMSTANCE. THIS SHOULD BE COMPLETELY UNACCEPTABLE BY THE SATURN MANUFACTURER. WILL PEOPLE HAVE TO DIE BEFORE A RECALL IS ISSUED TO SOLVE THIS PROBLEM? I BET IF THE CEO OF SATURN/GM OWNED A CAR WITH THIS PROBLEM AND HIS WIFE,DAUGHTER,SON OR MOTHER WAS DRIVING IT, A RECALL WOULD BE DONE IMMEDIATELY. THE CAR HAS NOT BEEN REPAIRED YET. THE COST OF REPAIR IS OVER $1000.00 FOR PARTS AND LABOR. HOW CONVENIENT FOR THE DEALER TO MAKE MONEY FROM A POSSIBLE DEADLY SITUATION. *TR

NHTSA ODI #10279414

56,000 miles · Jul 31, 2009
Steering

ELECTRIC POWER STEERING HAS BEEN INTERMITTENT FINALLY WENT OUT COMPLETELY. I TOOK IT THE SATURN DEALER A WHILE BACK AND WAS TOLD THE STEERING COLUMN ASSEMBLY HAD A PINCHED WIRE AND BAD FUSE $200.00 AND THE NEXT DAY SAME THING HAPPENED TOOK BACK TO DEALER THAT'S WHEN THEY TOLD ME $1500.00 PLUS TO CHANGE COLUMN I AM AN ELECTRONICS…

Read full complaint

ELECTRIC POWER STEERING HAS BEEN INTERMITTENT FINALLY WENT OUT COMPLETELY. I TOOK IT THE SATURN DEALER A WHILE BACK AND WAS TOLD THE STEERING COLUMN ASSEMBLY HAD A PINCHED WIRE AND BAD FUSE $200.00 AND THE NEXT DAY SAME THING HAPPENED TOOK BACK TO DEALER THAT'S WHEN THEY TOLD ME $1500.00 PLUS TO CHANGE COLUMN I AM AN ELECTRONICS TECH AT LOCKED THERE WAS NO BAD FUSE BEFORE OR AFTER THEY SAID THEY FIXED IT AND NO PINCHED WIRE WITH TAPE THAT THEY SAID THEY REPAIRED I HAVE SEARCHED THE INTERNET FOR INFORMATION ON THIS PROBLEM AND FOUND MANY PEOPLE HAVE THE SAME PROBLEM THIS IS ALSO THE SAME SYSTEM USED ON THE COBOLT, MALIBU AND PONTIAC ALL HAVING THE SAME PROBLEM I CALLED G.M. AND WAS TOLD THEY AREN'T HAVING ANY PROBLEMS WITH THEIR STEERING SO NO RECALLS WERE MADE , I TOLD THEM ABOUT THE INTERNET POSTINGS BUT THEY HUNG UP ON ME I JUST GOT A PHONE CALL FROM A NEPHEW WITH A 2006 SATURN ION 2 HAS EXACT SAME PROBLEM HE'S ASKING FOR MY HELP TOLD HIM I'M IN SAME PROBLEM COULD NOT HELP IF G.M IS HAVING THIS MUCH ELECTRIC POWER STEERING WITH THEIR CARS THEY SHOULD MAKE A RECALL AND TAKE CARE OF IT I OWN SEVERAL OTHER G.M PRODUCTS BUT I'M READY TO CHANGE TO JAPANESE MADE PRODUCTS MORE RELIABLE THIS IS A SAFETY PROBLEM WHEN YOU LOSE STEERING UNEXPECTEDLY CHECK THE INTERNET AS I DID HUNDREDS OF PEOPLE WITH SMALL G.M MADE CARS ARE HAVING THIS PROBLEM AND SOME PAY TO HAVE IT REPAIRED ONLY TO HAVE IT HAPPEN AGAIN. THANKS *TR

NHTSA ODI #10278999

Official recalls

4

14V171000 · Electrical System:ignition

Apr 10, 2014

General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

Consequence & remedy

Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

14V153000 · Steering:electric Power Assist System

Mar 31, 2014

General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Consequence & remedy

Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

14V047000 · Air Bags; Electrical System:ignition:switch

Feb 10, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Additional source detail variants (2)

Air Bags

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Electrical System:ignition:switch

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

09V419000 · Fuel System, Gasoline:delivery:fuel Pump

Oct 29, 2009

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.

Consequence & remedy

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

EA11014 · Electric Power Steering Failure

Opened Sep 29, 2011 · Closed Apr 15, 2014

Status: closed (inferred from source dates) · Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Additional source detail variants (2)

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

RQ10004 · Electric Power Steering Failure

Opened Dec 15, 2010 · Closed Oct 5, 2011

Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Additional source detail variants (2)

Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Steering

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.