NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
127 reportsClear category filter105,864 miles · Aug 21, 2014
Electrical SystemFuel System, Gasoline
MY SATURN WAS AT THE DEALER FOR THE GM IGNITION RECALL. THE DEALER TOLD ME MY FUEL LINES WERE ROTTED AND LEAKING. I THOUGHT THIS ODD SINCE THE CAR WAS AT THE MECHANIC'S FOR A RUSTED EXHAUST THE WEEK BEFORE. I CALLED MY MECHANIC FROM THE DEALER AND HE SAID TO BRING THE CAR BACK THAT DAY. HE FOUND THE LEAKING LINES. TOTAL COS…
Read full complaint
MY SATURN WAS AT THE DEALER FOR THE GM IGNITION RECALL. THE DEALER TOLD ME MY FUEL LINES WERE ROTTED AND LEAKING. I THOUGHT THIS ODD SINCE THE CAR WAS AT THE MECHANIC'S FOR A RUSTED EXHAUST THE WEEK BEFORE. I CALLED MY MECHANIC FROM THE DEALER AND HE SAID TO BRING THE CAR BACK THAT DAY. HE FOUND THE LEAKING LINES. TOTAL COST OF REPAIRS $567.42 SINCE ALL GM PARTS WERE PURCHASED. THE DEALER HAD TO HAVE KNOWN TO LOOK FOR THIS PROBLEM, LEADING ME TO BELIEVE IT'S A KNOWN ISSUE. *TR
NHTSA ODI #10626975
89,915 miles · Aug 6, 2014
Fuel System, Gasoline
HAVE FUEL LEAK FUEL LEAK FROM FUEL PUMP MODULE TOP OF TANK DRIPPING AHEADOF LEFT REAR WHEEL. *TR
NHTSA ODI #10619359
88,105 miles · Jul 23, 2014
Fuel System, Gasoline
VERY STRONG FUEL SMELL COMING FROM REAR OF VEHICLE. NO SIGN OF FUEL UNDERNEATH VEHICLE. THERE IS A FUEL SYSTEM RECALL (GM # 090226) DESCRIBING THESE SAME SYMPTOMS FOR 2006 SATURN IONS PURCHASED IN CALIFORNIA. RECALL WARNS OF FIRE DANGER. GM REPRESENTATIVE REPORTS MY VEHICLE IS NOT COVERED BASED ON VIN NUMBER, BUT ALL SYMPTOMS…
Read full complaint
VERY STRONG FUEL SMELL COMING FROM REAR OF VEHICLE. NO SIGN OF FUEL UNDERNEATH VEHICLE. THERE IS A FUEL SYSTEM RECALL (GM # 090226) DESCRIBING THESE SAME SYMPTOMS FOR 2006 SATURN IONS PURCHASED IN CALIFORNIA. RECALL WARNS OF FIRE DANGER. GM REPRESENTATIVE REPORTS MY VEHICLE IS NOT COVERED BASED ON VIN NUMBER, BUT ALL SYMPTOMS MATCH RECALL AND I DON'T THINK THAT THE CAR IS SAFE TO DRIVE, ESPECIALLY SINCE WE HAVE A THREE-YEAR-OLD IN A CAR SEAT IN THE BACK MUCH OF THE TIME. *TR
NHTSA ODI #10615643
119,000 miles · Jun 27, 2014
Electrical SystemEngineFuel System, Gasoline
I PURCHASED MY 2006 SATURN ION 3 IN 2008 FROM A DEALERSHIP. I HAVE HAD ALL THE RECALL ISSUES HAPPEN TO MY VEHICLE. 1) I HAVE REPLACED THE IGNITION SWITCH AND CYLINDER TWICE DUE TO THE CAR BEING UNABLE TO SHUT OFF. THIS HAPPENED IN 2008 AND AGAIN IN 2012. BOTH TIMES IT WAS COVERED UNDER WARRANTY AND REPAIRS WERE DONE BY GM DEALER…
Read full complaint
I PURCHASED MY 2006 SATURN ION 3 IN 2008 FROM A DEALERSHIP. I HAVE HAD ALL THE RECALL ISSUES HAPPEN TO MY VEHICLE. 1) I HAVE REPLACED THE IGNITION SWITCH AND CYLINDER TWICE DUE TO THE CAR BEING UNABLE TO SHUT OFF. THIS HAPPENED IN 2008 AND AGAIN IN 2012. BOTH TIMES IT WAS COVERED UNDER WARRANTY AND REPAIRS WERE DONE BY GM DEALERSHIP. EVEN THOUGH THESE HAVE BEEN REPLACED I WAS TOLD THEY NEED TO BE REPLACED AGAIN UNDER THE RECALL BECAUSE THOSE PARTS ARE FAULTY AS WELL. I HAVE BEEN IN CONTACT WITH THE DEALERSHIP AND WAS TOLD THEY DO NOT HAVE THE PARTS YET AND WILL LET ME KNOW WHEN THEY ARE AVAILABLE. 2) IN NOVEMBER 2013 MY VEHICLE SMELLED OF GAS AND WAS MAKING ME AND MY CHILDREN SICK. I HAD IT CHECKED OUT AT THE DEALERSHIP AND IT WAS THE FUEL MODULE. THIS WAS COVERED BY A NTSB WARRANTY EXTENSION. 3) MY VEHICLE WILL INTERMITTENTLY SHUT OFF OR LOSE POWER STEERING. WHEN I TOOK IT INTO THE DEALERSHIP IN 2013 THEY TOLD ME THEY WOULD NOT TOUCH IT IF THEY COULD NOT REPLICATE THE PROBLEM. IT HAS NOT BEEN FIXED. 4) THIS ISSUE IS NOT MENTIONED IN ANY OF THE COMPLAINTS I HAVE READ HERE, BUT I HAVE SEEN OTHERS COMPLAIN ON THE INTERNET. BEGINNING IN JANUARY OF 2014 THERE IS A STRONG ODOR OF EXHAUST FUMES IN MY VEHICLE. MY PERSONAL MECHANIC SAID THERE IS A LEAK THAT IS GOING INTO THE CABIN. MY VEHICLE IS SLOW TO ACCELERATE AND FEELS SHAKY. THERE IS ALSO A LOUD NOISE COMING FROM THE ENGINE COMPARTMENT. I HAVE TO DRIVE WITH THE WINDOWS DOWN AT ALL TIMES. I HAVE HAD NOTHING BUT PROBLEMS WITH THIS VEHICLE SINCE RIGHT AFTER I PURCHASED IT. I DO NOT HAVE A SECOND VEHICLE NOR THE MEANS TO BUY ONE. I RELY ON IT TO GET ME TO WORK AND TO TRANSPORT MY FAMILY. IT IS VERY DISAPPOINTING TO HAVE TO DEAL WITH THESE ISSUES OVER AND OVER AGAIN. *TR
NHTSA ODI #10606578
Mileage unknown · Jun 10, 2014
Air BagsElectrical SystemEngine
2006 SATURN ION. CONSUMER WRITES IN REGARDS TO VEHICLE ELECTRICAL SYSTEM ISSUES. *SMD RECENTLY, THE EMERGENCY BRAKE THE CONSUMER STATED THE CHECK ENGINE LIGHT ILLUMINATED TWICE AND FINALLY, THE FUEL INJECTORS WERE REPLACED. RECENTLY, THE EMERGENCY BRAKE LIGHT ILLUMINATED AND STAYED ON WITHOUT THE EMERGENCY BRAKE BEING PULLED…
Read full complaint
2006 SATURN ION. CONSUMER WRITES IN REGARDS TO VEHICLE ELECTRICAL SYSTEM ISSUES. *SMD RECENTLY, THE EMERGENCY BRAKE THE CONSUMER STATED THE CHECK ENGINE LIGHT ILLUMINATED TWICE AND FINALLY, THE FUEL INJECTORS WERE REPLACED. RECENTLY, THE EMERGENCY BRAKE LIGHT ILLUMINATED AND STAYED ON WITHOUT THE EMERGENCY BRAKE BEING PULLED. ALSO, WHEN SHE PUSHED THE SHIFTER KNOB, THERE WAS A NOISE IN THE STEERING COLUMN. THERE WAS AN ISSUE WITH THE ELECTRICAL POWER STEERING. IT WOULD GO OUT AND RESUME NORMAL OPERATION, WHILE DRIVING. *JB THE CONSUMER STATED SHE HEARD A KNOCKING NOISE, WHEN SHE DROVE OVER A BUMP AND THE CHECK ENGINE LIGHT ILLUMINATED AGAIN. UPDATED 08/06/14
NHTSA ODI #10593030
73,165 miles · May 16, 2014
Fuel System, Gasoline
THE FUEL PUMP WAS LEAKING, AND I HAD TO DEAL WITH THE GASOLINE SMELL EVERY TIME THAT I USED MY CAR. I PAID $798.94 TO HAVE THIS ISSUE FIXED AT CAR-X IN DES MOINES, WHO FAILED TO TELL ME THAT THIS ISSUE WAS UNDER RECALL. (RECALL ID # 66616, GM RECALL ID # 090226). I AM NOW GOING TO REQUEST REIMBURSEMENT FOR THIS FIX. *TR
NHTSA ODI #10592077
182,000 miles · May 16, 2014
Fuel System, Gasoline
ON MAY 14TH, I PARKED MY VEHICLE AND THE WINDOWS WERE DOWN. WE SMELT A STRONG ORDER OF GAS COMING FROM THE REAR OF MY SATURN. MY FRIEND LAID UNDER THE CAR WITH A FLASH LIGHT AND NOTICED GAS COMING DOWN THE SIDE OF THE FUEL TANK. HE HAD ME BRING IT IN TO HIM ON THE 15TH TO HIS AUTO HOBBY SHOP AND HE PLACED IT ON THE LIFT ONLY TO …
Read full complaint
ON MAY 14TH, I PARKED MY VEHICLE AND THE WINDOWS WERE DOWN. WE SMELT A STRONG ORDER OF GAS COMING FROM THE REAR OF MY SATURN. MY FRIEND LAID UNDER THE CAR WITH A FLASH LIGHT AND NOTICED GAS COMING DOWN THE SIDE OF THE FUEL TANK. HE HAD ME BRING IT IN TO HIM ON THE 15TH TO HIS AUTO HOBBY SHOP AND HE PLACED IT ON THE LIFT ONLY TO DISCOVER THAT ALL SIDES OF THE TANK HAVE PRESENCE OF GAS. HE TOLD ME HE NEEDS TO DROP THE TANK BECAUSE HE CAN'T SEE THE DIRECT SOURCE OF WHERE THE GAS IS COMING FROM. I WENT ONLINE AND SAW THAT THERE WAS A RECALL WITH SIMILAR DESCRIPTION OF SYMPTOMS I HAVE NOTICED. WHEN I CALLED MY LOCAL DEALER, HE SAID THAT MY PROBLEM WAS ADDRESSED AND ALREADY HANDLED WHEN THE RECALL FIRST CAME OUT. I AM HAVING THE SAME PROBLEM IT MAY SEEM. IF IT IS THE SAME ISSUE WITH THE FUEL PUMP AND IT WAS REPLACED BY A DEALERSHIP AS STATED IT NEEDED TO BE, WOULDN'T IT BE GM'S RESPONSIBILITY IF THE FUEL PUMP THEY REPLACED IT WITH WAS ALSO FAULTY? I DRIVE 3 GRAND BABIES AROUND ON A DAILY BASIS AND THIS IS NOT SAFE. I COULD UNDERSTAND IF IT WAS NOT ON RECALL AND THERE WAS JUST A RANDOM THING THAT HAPPENED. COULD YOU PLEASE ADVISE ME ON STEPS TO FOLLOW? *TR
NHTSA ODI #10588918
105,100 miles · Apr 29, 2014
Fuel System, GasolineSteeringCrash
WITHIN AN HOUR OF BRINGING THE VEHICLE HOME FROM GETTING THE FUEL PUMP REPLACED ON APRIL 25, 2014, I RECEIVED A FRANTIC CALL FROM MY DAUGHTER, PANICKED SHE HAD JUST BEEN INVOLVED IN AN ACCIDENT. SHE STATES SHE WAS DRIVING HOME IN A RESIDENTIAL AREA AND THE CAR STARTED VEERING BACK AND FORTH UNCONTROLLABLY. THE CAR CAREENED INT…
Read full complaint
WITHIN AN HOUR OF BRINGING THE VEHICLE HOME FROM GETTING THE FUEL PUMP REPLACED ON APRIL 25, 2014, I RECEIVED A FRANTIC CALL FROM MY DAUGHTER, PANICKED SHE HAD JUST BEEN INVOLVED IN AN ACCIDENT. SHE STATES SHE WAS DRIVING HOME IN A RESIDENTIAL AREA AND THE CAR STARTED VEERING BACK AND FORTH UNCONTROLLABLY. THE CAR CAREENED INTO THE CURB DAMAGING THE FRONT PASSENGER SIDE AND TIRE. IT HIT WITH SUCH FORCE, THE VEHICLE RICOCHET BACK INTO THE MIDDLE OF THE ROAD. MY DAUGHTER THEN SHIFTED IT INTO PARK, TURNED IT OFF AND ATTEMPTED TO EXIT. THE DOORS WOULD NOT OPEN AND COULD NOT BE UNLOCKED, MANUALLY OR WITH THE KEY FOB. 2 MEN DRIVING BY STOPPED AND ATTEMPTED TO HELP HER OUT OF THE VEHICLE, WITH NO LUCK. AS A LAST RESORT, SHE HAD TO BREAK OUT THE DRIVER SIDE FRONT WINDOW TO ESCAPE. I THEN CALLED DAYL GRAVES DEALERSHIP, AND WAS INSTRUCTED TO HAVE THE VEHICLE TOWED BACK TO THEIR DEALERSHIP SO THEY COULD EVALUATE THE VEHICLE. IT IS CURRENTLY STILL AT THEIR DEALERSHIP. AFTER KEVIN, THE MECHANIC, LOOKED AT THE VEHICLE, HE DETERMINED IT WAS AN ISSUE WITH THE POWER STEERING MOTOR & COLUMN. UPDATED 08/20/14
NHTSA ODI #10585902
90,878 miles · Apr 28, 2014
Fuel System, Gasoline
SMELLED GAS INSIDE CAR. FUEL PUMP MODULE REPLACED. *JS
NHTSA ODI #10585209
160,000 miles · Feb 26, 2014
Fuel System, Gasoline
THE SAME PARTS LISTED IN THE BELOW RECALL ALL AFFECT THE 2006 SATURN ION 2 IN ILLINIOS. REPORT RECEIPT DATE: OCT 29, 2009 NHTSA CAMPAIGN NUMBER: 09V419000 COMPONENT(S): FUEL SYSTEM, GASOLINE ALL PRODUCTS ASSOCIATED WITH THIS RECALL EXPAND DETAILS CLOSE 15 ASSOCIATED DOCUMENTS EXPAND MANUFACTURER: GENERAL MOTORS CORP.…
Read full complaint
THE SAME PARTS LISTED IN THE BELOW RECALL ALL AFFECT THE 2006 SATURN ION 2 IN ILLINIOS. REPORT RECEIPT DATE: OCT 29, 2009 NHTSA CAMPAIGN NUMBER: 09V419000 COMPONENT(S): FUEL SYSTEM, GASOLINE ALL PRODUCTS ASSOCIATED WITH THIS RECALL EXPAND DETAILS CLOSE 15 ASSOCIATED DOCUMENTS EXPAND MANUFACTURER: GENERAL MOTORS CORP. SUMMARY: GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED. CONSEQUENCE: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE. REMEDY: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. NOTES: GM RECALL NO. 090226. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV . *TR
NHTSA ODI #10565945
Official recalls
4Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Illustration