NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
41 reportsClear category filter20,000 miles · Jun 18, 2014
Electrical SystemEngineSuspension
I FIRST BOUGHT MY 2006 SATURN ION IN MARCH OF 2013. THREE DAYS LATER I NOTICE THAT WHEN I WOULD GET ON THE HIGHWAY MY CAR WOULD SWAY EXTREMELY BAD. OUR HWY SPEED IS 75. GOING 70MPH WAS TOO MUCH AND IT WOULD SWAY A LOT. MIND YOU I WAS PREGNANT AT THE TIME. THE CAR SPUN OUT AS I WAS EXITING THE HIGHWAY. I WAS TERRIFIED BECAUSE CAR…
Read full complaint
I FIRST BOUGHT MY 2006 SATURN ION IN MARCH OF 2013. THREE DAYS LATER I NOTICE THAT WHEN I WOULD GET ON THE HIGHWAY MY CAR WOULD SWAY EXTREMELY BAD. OUR HWY SPEED IS 75. GOING 70MPH WAS TOO MUCH AND IT WOULD SWAY A LOT. MIND YOU I WAS PREGNANT AT THE TIME. THE CAR SPUN OUT AS I WAS EXITING THE HIGHWAY. I WAS TERRIFIED BECAUSE CARS WERE RIGHT BEHIND ME. THANK GOD I GOT OUT OF THE WAY BEFORE I GOT HIT. YOU CAN UNDERSTAND HOW UPSET I WAS DUE TO THE FACT THAT I WAS 4MONTHS PREGNANT AT THE TIME. SINCE THEN MY HUSBAND HAS SPUN OUT 5 TIMES DRIVING OUR CAR. WE'VE TAKING IT TO THE MECHANICS MULTIPLE TIMES AND THEY DON'T EVEN KNOW WHAT TO DO WITH IT. OUR WHEEL ALIGNMENTS ARE FINE. ALSO, OUR KEY GETS STUCK IN THE IGNITION A LOT UPON TURNING IT OFF. SO WE HAVE TO USE THE BUTTON WHICH IS IN THE STEERING WHEEL JUST TO GET THEM OUT. ALSO, LATELY THE CAR PICKS AND CHOOSES WHEN IT WANTS TO ACCELERATE. LATELY I CAN FLOOR IT AND THE CAR WILL STILL BE GOING 30MPH. ALSO, LATELY WHEN WE GO TO TURN ON THE CAR, IT TAKES AWHILE AND MAKES A SOUND AS IF THE BATTERY IS DEAD, BUT THEN IT SOON COMES ON. I HAVE HAD NOTHING BUT PROBLEMS WITH THIS CAR FROM THE START. I THOUGHT THIS WAS A GOOD BUY, BUT EVERYDAY I REGRET IT AND I FEAR FOR ME, MY HUSBAND, AND MY CHILD'S SAFETY. PLEASE DO SOMETHING ABOUT THIS ISSUE. MATTER OF FACT JUST TAKE OUR CARS. WE DON'T NEED THEM FIXED. JUST TAKE THEM PLEASE! *TR
NHTSA ODI #10599104
Mileage unknown · Jun 10, 2014
Air BagsElectrical SystemEngine
2006 SATURN ION. CONSUMER WRITES IN REGARDS TO VEHICLE ELECTRICAL SYSTEM ISSUES. *SMD RECENTLY, THE EMERGENCY BRAKE THE CONSUMER STATED THE CHECK ENGINE LIGHT ILLUMINATED TWICE AND FINALLY, THE FUEL INJECTORS WERE REPLACED. RECENTLY, THE EMERGENCY BRAKE LIGHT ILLUMINATED AND STAYED ON WITHOUT THE EMERGENCY BRAKE BEING PULLED…
Read full complaint
2006 SATURN ION. CONSUMER WRITES IN REGARDS TO VEHICLE ELECTRICAL SYSTEM ISSUES. *SMD RECENTLY, THE EMERGENCY BRAKE THE CONSUMER STATED THE CHECK ENGINE LIGHT ILLUMINATED TWICE AND FINALLY, THE FUEL INJECTORS WERE REPLACED. RECENTLY, THE EMERGENCY BRAKE LIGHT ILLUMINATED AND STAYED ON WITHOUT THE EMERGENCY BRAKE BEING PULLED. ALSO, WHEN SHE PUSHED THE SHIFTER KNOB, THERE WAS A NOISE IN THE STEERING COLUMN. THERE WAS AN ISSUE WITH THE ELECTRICAL POWER STEERING. IT WOULD GO OUT AND RESUME NORMAL OPERATION, WHILE DRIVING. *JB THE CONSUMER STATED SHE HEARD A KNOCKING NOISE, WHEN SHE DROVE OVER A BUMP AND THE CHECK ENGINE LIGHT ILLUMINATED AGAIN. UPDATED 08/06/14
NHTSA ODI #10593030
108,244 miles · May 25, 2014
Electrical SystemEngineVehicle Speed Control
I WAS DRIVING THE 2006 SATURN ION IN MY NEIGHBORHOOD. I REACHED THE INTERSECTION AT THE END OF MY STREET AND CAME TO A STOP/YIELD. AS I TOOK MY FOOT OFF THE BRAKE TO SHIFT TO THE GAS AND BEGAN STEERING TO TURN LEFT, THE ENGINE SUDDENLY TURNED OFF. THE BATTERY LIGHT ON THE DASH APPEARED. I WAS ABLE TO PUT THE CAR IN PARK, TURN OF…
Read full complaint
I WAS DRIVING THE 2006 SATURN ION IN MY NEIGHBORHOOD. I REACHED THE INTERSECTION AT THE END OF MY STREET AND CAME TO A STOP/YIELD. AS I TOOK MY FOOT OFF THE BRAKE TO SHIFT TO THE GAS AND BEGAN STEERING TO TURN LEFT, THE ENGINE SUDDENLY TURNED OFF. THE BATTERY LIGHT ON THE DASH APPEARED. I WAS ABLE TO PUT THE CAR IN PARK, TURN OFF THE VEHICLE, AND RESTART IT. I RETURNED HOME INSTEAD OF CONTINUING MY TRIP. MY VEHICLE IS AFFECTED BY THE RECALL WITH CAMPAIGN ID NUMBER 14V-047. I HAD REMOVED ALL ADDITIONAL KEYS FROM MY KEYRING AS RECOMMENDED IN THE THREE RECALL LETTERS I RECEIVED, BUT I STILL BELIEVE THAT THIS ISSUE WAS RELATED TO THE ISSUE THE IGNITION SWITCH. I HAVE CHOSEN TO FILE THIS COMPLAINT BECAUSE ONE OF THE LETTERS I RECEIVED FROM [XXX]OF GM ASSERTED THAT THE VEHICLE WAS SAFE TO DRIVE AS LONG AS THERE WERE NO ADDITIONAL KEYS ON THE KEYRING. A LINK TO THE LETTER IN QUESTION IS: HTTP://WWW-ODI.NHTSA.DOT.GOV/ACMS/CS/JAXRS/DOWNLOAD/DOC/UCM454782/RCORRD-14V047-1697.PDF INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10593971
80,000 miles · Apr 28, 2014
Engine
VEHICLE DOESN'T TURN ON IN BELOW FREEZING TEMPERATURES. HAS HAPPENED ON MULTIPLE OCCASIONS. ELECTRICAL WORKS, BUT ENGINE WON'T TURN OVER, JUST MAKES A CLICKING NOISE. AFTER TEMPERATURE WARMS, VEHICLE WILL START. *JS
NHTSA ODI #10585216
65,000 miles · Apr 28, 2014
Electrical SystemEngine
VEHICLE'S ENGINE SHUT OFF WHILE OPERATING, HOWEVER ELECTRICAL REMAINS ON. USUALLY HAPPENS GOING OVER SPEED BUMPS AT LOW SPEEDS. HAD TO TURN OFF AND RESTART ENGINE TO OPERATE. INCIDENT OCCURRED 2 TIMES IN 2009. DIDN'T GIVE MUCH THOUGHT UNTIL IT STARTED TO RECUR IN 2012. HAS HAPPENED 3-4 TIMES SINCE. ALSO KEY GETS STUCK WHEN TRYIN…
Read full complaint
VEHICLE'S ENGINE SHUT OFF WHILE OPERATING, HOWEVER ELECTRICAL REMAINS ON. USUALLY HAPPENS GOING OVER SPEED BUMPS AT LOW SPEEDS. HAD TO TURN OFF AND RESTART ENGINE TO OPERATE. INCIDENT OCCURRED 2 TIMES IN 2009. DIDN'T GIVE MUCH THOUGHT UNTIL IT STARTED TO RECUR IN 2012. HAS HAPPENED 3-4 TIMES SINCE. ALSO KEY GETS STUCK WHEN TRYING TO SHUT VEHICLE OFF. THE KEY GETTING STUCK WHEN TRYING TO SHUT OFF HAS OCCURRED ALMOST DAILY FOR THE PAST 4 MONTHS. DIDN'T REALIZE THE INCIDENTS WERE RELATED UNTIL I HEARD ABOUT THE SATURN RECALL ON IGNITION SWITCHES AND HEARD ABOUT SIMILAR PROBLEMS. *JS
NHTSA ODI #10585214
88,000 miles · Apr 11, 2014
EnginePower Train
THE CAR WILL OCCASIONALLY START RIGHT UP OR IT SOMETIMES TAKE ANYWHERE FROM 2 MINUTES TO 10 MINUTES TO GET STARTED. HAVE HAD THE ALTERNATOR LOOKED AT AND THAT IS FINE. CARS LIGHTS AND EVERYTHING TURNS ON AND TESTED THE BATTERY THAT IS FINE. CAR SIMPLY WON'T GO INTO THE RUN POSITION. MAYBE THE NEW FIX WILL CHANGE THIS WITH TH…
Read full complaint
THE CAR WILL OCCASIONALLY START RIGHT UP OR IT SOMETIMES TAKE ANYWHERE FROM 2 MINUTES TO 10 MINUTES TO GET STARTED. HAVE HAD THE ALTERNATOR LOOKED AT AND THAT IS FINE. CARS LIGHTS AND EVERYTHING TURNS ON AND TESTED THE BATTERY THAT IS FINE. CAR SIMPLY WON'T GO INTO THE RUN POSITION. MAYBE THE NEW FIX WILL CHANGE THIS WITH THE RECALL BUT JUST ANOTHER PROBLEM THAT I HAVE SEEN DOCUMENTED ONLINE AND HAVE EXPERIENCED CONSTANTLY. *JS
NHTSA ODI #10579293
30,000 miles · Mar 13, 2014
EngineSteeringCrash
MY DAUGHTER WAS GOING TO WORK - SHE BACKED OUT OF OUR DRIVEWAY - PUT THE CAR IN DRIVE - STARTED FORWARD AND THE CAR ENGINE CUT OFF - SHE COULD NOT STEER THE CAR AND RAN INTO TWO OTHER CARS ON OUR STREET - HIT ONE IN THE SIDE AND THE OTHER VEHICLE IN THE FRONT ON ITS DRIVER SIDE - WE CALLED SATURN AND NOTIFIED THEM OF THE ISSUE -…
Read full complaint
MY DAUGHTER WAS GOING TO WORK - SHE BACKED OUT OF OUR DRIVEWAY - PUT THE CAR IN DRIVE - STARTED FORWARD AND THE CAR ENGINE CUT OFF - SHE COULD NOT STEER THE CAR AND RAN INTO TWO OTHER CARS ON OUR STREET - HIT ONE IN THE SIDE AND THE OTHER VEHICLE IN THE FRONT ON ITS DRIVER SIDE - WE CALLED SATURN AND NOTIFIED THEM OF THE ISSUE - THEY SENT A TOW TRUCK AND TOOK IT 70 MILES TO THE NEAREST DEALERSHIP - THEY SAID THAT THEY HAD TO CALL IN A SPECIAL REPRESENTATIVE TO CHECK IT OUT - HE CALLED US BACK AND SAID THAT HE COULD NOT FIND ANYTHING IN THE COMPUTER THAT WOULD HAVE CAUSED THE ISSUE AND TOLD US TO COME BACK AND GET THE CAR (ABOUT A 140 MILE TRIP TO PICK UP A CAR WE WERE AFRAID OF WHICH WE PAID OVER $15000.00 FOR) THIS CAUSED OVER $2000.00 OF DAMAGE TO HER CAR IT CAUSED OUR INSURANCE COMPANY TO PAY OUT A UNKNOWN AMOUNT FOR THE DAMAGE TO THE OTHER 2 VEHICLES THE ISSUE ALSO WENT ON HER DRIVING RECORD AS HER FAULT (WHICH IT WAS NOT) AND CAUSED MY INSURANCE TO GO UP - WE ARE AFRAID TO DRIVE THIS CAR - ALWAYS WAIT UNTIL THERE IS NO ONE COMING BEFORE WE USE IT TO GO ANYWHERE BECAUSE IT HESITATES - LATER THE CAR STARTED SMELLING LIKE GAS - AND A MESSAGE (PWR STR) WOULD COME UP ON THE DASH - THE KEY WOULD NOT COME OUT OF THE IGNITION AND YOU COULD NOT GET IT TO TURN OFF - ALSO ON COLD MORNINGS IT WOULD NOT EVEN START - ANY HELP OR INFORMATION ON THIS WOULD BE GREATLY APPRECIATED. THANKS . *TR
NHTSA ODI #10569204
84,709 miles · Mar 13, 2014
Electrical SystemEngine
A NEW IGN LOCK CYLINDER WAS REPLACED AT FIRESTONE IN DUBUQUE, IOWA, BECAUSE THE CAR WOULD NOT TURN OFF EVEN WITH THE KEY EXTRACTED FROM THE IGNITGION. THE CAR HAD BEEN SHUTTING DOWN WHILE OUR DAUGHTER WAS DRIVING THE CAR FOR ABOUT A WEEK. REPAIR COST $374.26 OUR DAUGHTER BEING AT COLLEGE DID NOT DRIVE THE CAR MUCH THE REST OF T…
Read full complaint
A NEW IGN LOCK CYLINDER WAS REPLACED AT FIRESTONE IN DUBUQUE, IOWA, BECAUSE THE CAR WOULD NOT TURN OFF EVEN WITH THE KEY EXTRACTED FROM THE IGNITGION. THE CAR HAD BEEN SHUTTING DOWN WHILE OUR DAUGHTER WAS DRIVING THE CAR FOR ABOUT A WEEK. REPAIR COST $374.26 OUR DAUGHTER BEING AT COLLEGE DID NOT DRIVE THE CAR MUCH THE REST OF THE MONTH AND CAME HOME TO DECORAH, IOWA, AND ON THE WAY HOME AND WHILE HOME THE CAR CONTINUED TO SHUT ITSELF OFF, WITH THE LAST TIME BEING ON A HILL SHE WAS ABLE TO COAST INTO A PARKING SPACE, BUT THE CAR HAD TO BE TOWED TO THE DEALERSHIP IN DECORAH, WHERE REPORT SHOWS: CHECKED FOR CODES B1443 DEVISE IGNITION OFF, RUN AND CRANK, B2957; SECURITY SYSTEM SENSOR CIRCUIT LOW VOLTAGE, B2958 SECURITY SYSTEM; DATA HIGH, B1441, CHECKED FUSES AND WIRING( ALL WORKED AT THIS TIME);REMOVED AND REPLACED BODY CONTROL MODULE, PROGRAMMED MODULE, AND RELEARNED THEFT DETERENT, CLEARED COADES AND TEST DROVE, $852.50 COST OF REPAIR. *TR
NHTSA ODI #10569153
192,000 miles · Feb 17, 2014
EngineFire
WHILE TRAVELING BETWEEN 70-75MPH ON I-35 SOUTHBOUND BETWEEN 2ND ST. MERGE AND 15TH STREET EXIT IN EDMOND OK, WE WENT TO CHANGE LANES (MIDDLE LANE TO RIGHT LANE) AND THERE WAS A SUDDEN BOOM, THE CAR LOST CONTROL, BEGAN TO SPIN OUT OF CONTROL (NUMEROUS SLIDES AND 2-360 DEG TURNS AND BEING FLUNG IN A BACKWARDS MOTION). AS WE AT…
Read full complaint
WHILE TRAVELING BETWEEN 70-75MPH ON I-35 SOUTHBOUND BETWEEN 2ND ST. MERGE AND 15TH STREET EXIT IN EDMOND OK, WE WENT TO CHANGE LANES (MIDDLE LANE TO RIGHT LANE) AND THERE WAS A SUDDEN BOOM, THE CAR LOST CONTROL, BEGAN TO SPIN OUT OF CONTROL (NUMEROUS SLIDES AND 2-360 DEG TURNS AND BEING FLUNG IN A BACKWARDS MOTION). AS WE ATTEMPTED TO GET TO THE SIDE OF THE ROAD, OUR CAR BEGAN TO SPIN OUT OF CONTROL - WE SPUN INTO A 360 DEGREE TURN, CAR CAUGHT FIRE AS THE OIL WAS DUMPED FROM MY CAR AND SPRAYED ALL ALONG THE UNDERNEATH OF MY CAR AND TIRES, WE SLID SIDEWAYS TOWARDS CONCRETE BARRIER SEPARATING N-S BOUND TRAFFIC, WENT INTO A SECOND 360 DEGREE TURN, SLID SIDEWAYS - AS WE STARTED HEADING ONCE AGAIN FORWARD TOWARDS ONCOMING TRAFFIC THE VEHICLE SUDDENLY STARTED GOING BACKWARDS (EVEN THOUGH CAR WAS IN DRIVE)... WE FINALLY STOPPED FACING ONCOMING TRAFFIC IN SIDEWAYS MOTION. TOW/MECHANIC INSPECTED THE CAR AND FOUND 3-4INCH HOLE IN THE ENGINE BLOCK - DIAGNOSIS - THAT PUSH PIN BROKE WITHOUT WARNING AND BLEW THE HOLE. NO WARNING WAS GIVEN OF ANY KIND OF ENGINE MALFUNCTION ISSUE - NO WARNING LIGHTS, NOTHING. WE COULD OF / SHOULD OF BEEN KILLED (PER THE EYE WITNESSES WHO STOPPED TO HELP US), OUR ONLY SAVING GRACE WAS THE OIL WHICH SPRAYED THE ROAD AND OUR TIRES KEEPING US UPRIGHT AND NOT ROLLING. THIS NEEDS TO BE INVESTIGATED, RECALLED AND FIXED BEFORE SOMEONE IS NOT AS LUCKY AS US. *TR
NHTSA ODI #10564714
115,000 miles · Feb 13, 2014
Engine
TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT WAS DRIVING 65 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MERGED OFF ROAD AND RESTARTED THE VEHICLE. THE VEHICLE WAS NOT TAKEN FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000. *TR
NHTSA ODI #10564163
Official recalls
4Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Illustration