TL*THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT WHEN HE ATTEMPTED TO TURN THE VEHICLE OFF, IT WOULD NOT TURN OFF WHEN THE KEY WAS TURNED AND THE KEY WAS UNABLE TO BE REMOVED FROM THE IGNITION. THE CONTACT HAD TO UNHOOK THE BATTERY TO TURN THE VEHICLE OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE IGN…
Read full complaint
TL*THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT WHEN HE ATTEMPTED TO TURN THE VEHICLE OFF, IT WOULD NOT TURN OFF WHEN THE KEY WAS TURNED AND THE KEY WAS UNABLE TO BE REMOVED FROM THE IGNITION. THE CONTACT HAD TO UNHOOK THE BATTERY TO TURN THE VEHICLE OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE IGNITION SWITCH WAS REPLACED. THE FAILURE CONTINUED. THE VEHICLE WAS AT THE DEALER AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 94,000.
NHTSA ODI #10362236
62,000 miles · Oct 14, 2010
Electrical System
WHEN I PROCEEDED TO TURN MY KEY TO TURN OFF MY CAR, MY CAR WOULD NOT TURN OFF. MY KEY WOULD ONLY TURN HALF OF THE WAY BUT WOULD GET STUCK IN THE IGNITION AND MY CAR WOULD NOT TURN OFF. I THEN TURNED MY CAR BACK ON AND THEN TRIED TO TURN OFF MY CAR AGAIN. IT FINALLY WORKED AFTER JIGGLING MY KEY. SOMETIMES MY CAR WOULD TURN OFF FI…
Read full complaint
WHEN I PROCEEDED TO TURN MY KEY TO TURN OFF MY CAR, MY CAR WOULD NOT TURN OFF. MY KEY WOULD ONLY TURN HALF OF THE WAY BUT WOULD GET STUCK IN THE IGNITION AND MY CAR WOULD NOT TURN OFF. I THEN TURNED MY CAR BACK ON AND THEN TRIED TO TURN OFF MY CAR AGAIN. IT FINALLY WORKED AFTER JIGGLING MY KEY. SOMETIMES MY CAR WOULD TURN OFF FINE BUT MOST OF THE TIME, IT WOULD NOT. I BECAME FRIGHTENED AND VERY UNCOMFORTABLE WITH DRIVING MY CAR BECAUSE THE PROBLEM CONTINUED TO GET WORSE. I THEN DID RESEARCH ON THE INTERNET AND FOUND OUT SEVERAL OTHER SATURN ION OWNER ARE HAVING THE SAME PROBLEMS. SOME SATURN ION OWNERS EVEN HAVE NOT BE ABLE TO TURN THEIR CAR OFF AT ALL AND HAD TO LEAVE THERE CAR RUNNING UNTIL THE GAS RAN OUT. I DID NOT WANT THIS TO HAPPEN TO ME, SO I DECIDED TO TAKE MY CAR IN TO GET IT FIXED. THEY SAID THE PROBLEM WAS THE IGNITION LOCK CYLINDER AND THAT I WAS GOING TO HAVE TO GET IT REPLACED. I WAS VERY UPSET THAT THIS IS SATURN IONS FAULT AND I HAVE TO PAY FOR THEIR NEGLIGENCE. MY IGNITION LOCK CYLINDER WAS REPLACED WITH A BRAND NEW ONE FROM SATURN. NOT EVEN A DAY LATER THE SAME PROBLEMS STARTED ONCE AGAIN. MY CAR STILL TURNS OFF WITH A LITTLE JIGGLING OF THE KEY BUT I KNOW IT WILL NOT LAST. THIS IS NOT SAFE! I DO NOT FEEL I SHOULD HAVE TO PAY FOR SATURN'S CARELESSNESS. *TR
NHTSA ODI #10360567
59,838 miles · Oct 2, 2010
Electrical SystemLatches/locks/linkages
WE HAVE A SATURN ION 2006 WHICH IS NOW EXPERIENCING IGNITION ISSUES. FIRST THE CAR WOULD NOT STOP RUNNING (HAZARD!) IN MY DRIVEWAY. THIS WAS DUE TO THE KEY BEING STUCK IN THE ON POSITION IN THE IGNITION! WE HAD TO ALLOW IT TO RUN OUT OF GAS PRIOR TO FINDING THE EMERGENCY KEY RELEASE THAT SATURN HAS NOTED. NOW THE CAR WILL NOT…
Read full complaint
WE HAVE A SATURN ION 2006 WHICH IS NOW EXPERIENCING IGNITION ISSUES. FIRST THE CAR WOULD NOT STOP RUNNING (HAZARD!) IN MY DRIVEWAY. THIS WAS DUE TO THE KEY BEING STUCK IN THE ON POSITION IN THE IGNITION! WE HAD TO ALLOW IT TO RUN OUT OF GAS PRIOR TO FINDING THE EMERGENCY KEY RELEASE THAT SATURN HAS NOTED. NOW THE CAR WILL NOT EVEN START AND WHEN I CALLED THE CUSTOMER SERVICE LINE, THE RESPONSE WAS HARDLY COMFORTING. LOOKING ONLINE IT APPEARS THAT THERE ARE NUMEROUS COMPLAINTS LOGGING THIS ISSUE. IT APPEARS THAT THERE ARE QUITE A FEW PEOPLE THAT WOULD LIKE TO PURSUE A CLASS ACTION LAWSUIT AGAINST SATURN/GM AS THERE HAVE BEEN ABSOLUTELY NO INVESTIGATIONS, RECALLS, OR EVEN AN ACKNOWLEDGEMENT OF SAID ISSUE. THIS IS THE FIRST TIME THE IGNITION HAS CAUSED US ISSUES, BUT LOOKING AT THE ONLINE COMPLAINTS, IT WON'T BE THE LAST. WHEN WILL IT BE INVESTIGATED? WILL IT BE INVESTIGATED AFTER AN ACCIDENT HAPPENS PERHAPS WITH MY 2 CHILDREN IN THE CAR? WILL IT BE CLASSIFIED AS AN URGENT ISSUE THEN? SEE HOW MANY PEOPLE HAVE HAD THE ISSUE BELOW VIA THE LINK EMBEDDED. HTTP://WWW.CONSUMERAFFAIRS.COM/AUTOMOTIVE/SATURN.HTM. *TR
VEHICLE WAS UNABLE TO BE SHUT OFF, KEY WAS STUCK IN THE IGNITION, I UNHOOKED THE BATTERY AND THE VEHICLE WAS STILL RUNNING. THIS SAME VEHICLE HAD A RECALL ON THE FUEL PUMP MODULE AND WAS LEAKING GAS, HAD THIS OCCURRED AT THE SAME TIME IT WOULD HAVE BEEN VERY UNSAFE FOR THE CAR TO HAVE BEEN RUNNING THE ENTIRE TIME WITH A GAS LEAK…
Read full complaint
VEHICLE WAS UNABLE TO BE SHUT OFF, KEY WAS STUCK IN THE IGNITION, I UNHOOKED THE BATTERY AND THE VEHICLE WAS STILL RUNNING. THIS SAME VEHICLE HAD A RECALL ON THE FUEL PUMP MODULE AND WAS LEAKING GAS, HAD THIS OCCURRED AT THE SAME TIME IT WOULD HAVE BEEN VERY UNSAFE FOR THE CAR TO HAVE BEEN RUNNING THE ENTIRE TIME WITH A GAS LEAK. FORTUNATELY I HAD JUST REPAIRED THE FUEL PUMP MODULE 1 WEEK PRIOR TO THIS ISSUE WITH THE IGNITION. *TR
NHTSA ODI #10355914
100,000 miles · Sep 13, 2010
Electrical System
TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION AND COULD NOT BE EXTRACTED. A FUSE WAS REMOVED IN ORDER TO TURN THE VEHICLE OFF. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS AWAITING DIAGNOSIS OF THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE VIN W…
Read full complaint
TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION AND COULD NOT BE EXTRACTED. A FUSE WAS REMOVED IN ORDER TO TURN THE VEHICLE OFF. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS AWAITING DIAGNOSIS OF THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 100,000.
NHTSA ODI #10355186
40,000 miles · Sep 10, 2010
Electrical System
KEY STUCK IN IGNITION SWITCH IN THE RUN POSITION OF 2006 SATURN ION, 40,000 MILES, COULD NOT SAFELY TURN OFF VEHICLE. *TR
NHTSA ODI #10354936
70,000 miles · Sep 10, 2010
Electrical System
TL*THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION AND SHE WAS UNABLE TO TURN THE KEY IN ORDER TO TURN OFF THE VEHICLE. THE DEALER REMOVED A FUSE UNDERNEATH THE HOOD WHICH MADE IT POSSIBLE TO TURN OFF THE VEHICLE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 70…
Read full complaint
TL*THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION AND SHE WAS UNABLE TO TURN THE KEY IN ORDER TO TURN OFF THE VEHICLE. THE DEALER REMOVED A FUSE UNDERNEATH THE HOOD WHICH MADE IT POSSIBLE TO TURN OFF THE VEHICLE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 70000.
NHTSA ODI #10354871
59,500 miles · Sep 9, 2010
Electrical System
TL* THE CONTACT OWNS A 2006 SATURN ION . THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH ,GOING OVER A SMALL BUMP ON THE ROAD THE VEHICLE WOULD STALL. THE VEHICLE WOULD HAVE TO BE PUT INTO NEUTRAL SO THAT IT CAN BE RESTARTED . THE CONTACT ALSO STATES THAT SHE CAN REMOVE THE KEYS OUT OF THE IGNITION WHEN THE VEHICLE IS STILL…
Read full complaint
TL* THE CONTACT OWNS A 2006 SATURN ION . THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH ,GOING OVER A SMALL BUMP ON THE ROAD THE VEHICLE WOULD STALL. THE VEHICLE WOULD HAVE TO BE PUT INTO NEUTRAL SO THAT IT CAN BE RESTARTED . THE CONTACT ALSO STATES THAT SHE CAN REMOVE THE KEYS OUT OF THE IGNITION WHEN THE VEHICLE IS STILL IDLING . THE DEALER HAD NOT BEEN CONTACTED AND THERE HAD BEEN NO DIAGNOSIS AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 59500 AND THE CURRENT MILEAGE WAS 59560.
NHTSA ODI #10354739
33,349 miles · Sep 7, 2010
Electrical SystemSteering
KEY WILL GET STUCK IN THE IGNITION AND WILL NOT COME OUT. IT WAS A SAFETY CONCERN BECAUSE THE VEHICLE COULD NOT BE TURNED OFF WITH THE KEY. THE ONLY WAY TO TURN OFF THE VEHICLE WAS TO PULL THE IGNITION FUSE OUT. THERE WAS NO IMPROPER USE OF THE IGNITION OR THE KEY PRIOR TO THE EVENT. THE DEALERSHIP REPLACED THE CYLINDER CASE …
Read full complaint
KEY WILL GET STUCK IN THE IGNITION AND WILL NOT COME OUT. IT WAS A SAFETY CONCERN BECAUSE THE VEHICLE COULD NOT BE TURNED OFF WITH THE KEY. THE ONLY WAY TO TURN OFF THE VEHICLE WAS TO PULL THE IGNITION FUSE OUT. THERE WAS NO IMPROPER USE OF THE IGNITION OR THE KEY PRIOR TO THE EVENT. THE DEALERSHIP REPLACED THE CYLINDER CASE AND KEY CYLINDER. THEY CHARGED FOR THE REPAIR IT WAS 800 DOLLARS FOR THE REPAIR. THE VEHICLE WAS OUT OF WARRANTY WITH ONLY 33000 MILES ON IT. THEIR SEEMS TO BE ALOT OF COMPLAINTS/BLOGS RELATING TO THIS ISSUE WITH THE ION. *TR
NHTSA ODI #10354381
50,000 miles · Aug 24, 2010
Electrical System
TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START DUE TO THE IGNITION PASS LOCK SECURITY FEATURE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILE…
Read full complaint
TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START DUE TO THE IGNITION PASS LOCK SECURITY FEATURE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 62,000.
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
2006 Saturn Ion Problems, Complaints & Recalls | Skip That Year
Illustration