NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
392 reportsClear category filter50,000 miles · Oct 14, 2011
Electrical SystemSteering
FOR THE PAST 5 MONTHS, THE SATURN ION 3 POWER STEERING WILL INTERMITENTLY GO OUT. WHEN I FIRST START THE CAR THE POWER STEERING WORKS FINE, AND THEN AT ANY RANDOM TIME THE CAR MAKES A DING,DING NOISE AND THEN THERE IS NO POWER STEERING. IF THE CAR IS SHUT OFF AND TURNED BACK ON THE POWER STEERING IS FINE. THEN A FEW MILES DOWN …
Read full complaint
FOR THE PAST 5 MONTHS, THE SATURN ION 3 POWER STEERING WILL INTERMITENTLY GO OUT. WHEN I FIRST START THE CAR THE POWER STEERING WORKS FINE, AND THEN AT ANY RANDOM TIME THE CAR MAKES A DING,DING NOISE AND THEN THERE IS NO POWER STEERING. IF THE CAR IS SHUT OFF AND TURNED BACK ON THE POWER STEERING IS FINE. THEN A FEW MILES DOWN THE ROAD IT TURNS OFF AGAIN, ALMOST EVERY DAY. THIS MAKES IT VERY DIFFICULT TO TURN CORNERS. THE NEXT PROBLEM IS IF IT IS DAMP OR COLD (BELOW 60) IN THE MORNING AT 8AM THE CAR WILL NOT TURN OVER OR START, UNTIL THE SUN COMES OUT AND WARMS UP THE CAR, BY NOON THE CAR STARTS JUST FINE. I CAN GET IT STARTED IF I PLACE TWO WARM BLANKETS ON THE BATTERY AND MOTOR AND WAIT A FEW MINUTES, THEN THE CAR WILL START. THE DRIVERS SIDE WINDOWS HAVE ALSO STOPPED WORKING. *TR
NHTSA ODI #10430235
91,490 miles · Oct 6, 2011
Electrical SystemSteering
I AM BEGINNING TO BELIEVE THAT THE ISSUE WITH THE SATURN ION IS AN ELECTRICAL OR COMPUTER BASED. I PUT IN A COMPLAINT EARLIER ABOUT HOW THE CAR SHUTS OFF IN THE MIDDLE OF MAKING TURNS. THIS MORNING AS I WENT TO WORK I WAS MET WITH THE AUTOMATIC STEERING NOT WORKING. AT FIRST I THOUGHT THAT MAYBE THE EMERGENCY BREAK WAS STILL…
Read full complaint
I AM BEGINNING TO BELIEVE THAT THE ISSUE WITH THE SATURN ION IS AN ELECTRICAL OR COMPUTER BASED. I PUT IN A COMPLAINT EARLIER ABOUT HOW THE CAR SHUTS OFF IN THE MIDDLE OF MAKING TURNS. THIS MORNING AS I WENT TO WORK I WAS MET WITH THE AUTOMATIC STEERING NOT WORKING. AT FIRST I THOUGHT THAT MAYBE THE EMERGENCY BREAK WAS STILL UP. I CHECKED MY STEERING FLUID AND IT IS FULL. I TURNED THE CAR OFF AND THEN ON AGAIN AND TRIED TO MOVE THE WHEEL. NO DICE. I DROVE THE CAR TO WORK FIGHTING WITH THE STEERING ALL THE WAY THERE. WHEN I GOT TO WORK I CALLED FOR ASSISTANCE TO GET MY CAR TO A SHOP. AFTER MAKING THE ARRANGEMENTS, I WENT TO TRY TO STRAIGHTEN UP THE VEHICLE SOMEWHAT SO THAT OTHERS COULD PARK BESIDE ME AND SO THE TOWING COMPANY COULD GET IT OUT. TO MY AMAZEMENT THE CAR STEERING WORKED FINE. THERE ARE SEVERAL COMPLAINTS ON THE WEB ABOUT THIS ISSUE, THE KEY GETTING STUCK IN THE IGNITION, THE KEY BEING REMOVED FROM THE IGNITION AND THE CAR ENGINE CONTINUING TO RUN ANYWAY, AND THE SHUTTING OFF WHILE GOING OVER TRACKS AND MAKING TURNS WITH THE SATURN ION 2004-2007. PLEASE GET GMC TO FIX THESE ISSUES. WHAT MAKES ME REALLY ANGRY IS THAT THE COMPANY KNOWS, THEY SIMPLY ARE AVOIDING FIXING THE PROBLEMS AND ONLY FOCUS ON THE FUEL PUMP PROBLEM. SOMEBODY IS GOING TO GET KILLED SOONER OR LATER BTW THE SHUTTING OFF ISSUE OR THE STEERING WHEEL ISSUES. I HOPE YOU GUYS LOOK INTO THESE ISSUES AND DEMAND THAT GMC FIXES THEM BEFORE THEN. THANKS. *TR
NHTSA ODI #10428916
50,067 miles · Sep 28, 2011
Electrical SystemSteering
ON SUNDAY, SEPTEMBER 25TH, 2011, I WAS DRIVING ON A FAMILIAR ROAD IN TOWN WHEN ALL OF THE WARNING LIGHTS ON MY VEHICLE SUDDENLY ILLUMINATED AND BEGAN BLINKING. THE SPEEDOMETER, FUEL GAGE, TEMPERATURE GAGE, AND RPM INDICATOR ALL WENT DOWN TO ZERO AND THE MESSAGE CENTER BEGAN SAYING "TRAC OFF" AND "PWR STR." AS THIS HAPPENED, MY P…
Read full complaint
ON SUNDAY, SEPTEMBER 25TH, 2011, I WAS DRIVING ON A FAMILIAR ROAD IN TOWN WHEN ALL OF THE WARNING LIGHTS ON MY VEHICLE SUDDENLY ILLUMINATED AND BEGAN BLINKING. THE SPEEDOMETER, FUEL GAGE, TEMPERATURE GAGE, AND RPM INDICATOR ALL WENT DOWN TO ZERO AND THE MESSAGE CENTER BEGAN SAYING "TRAC OFF" AND "PWR STR." AS THIS HAPPENED, MY POWER STEERING WENT OUT. I PULLED OVER AND TURNED MY CAR OFF. MY CAR WOULD NOT TURN BACK ON. AFTER ABOUT ONE MINUTE, I WAS ABLE TO START MY CAR AGAIN AND RESUME DRIVING AS NORMAL. THIS HAS HAPPENED ON FOUR OTHER OCCASIONS SINCE THE FIRST TIME, THREE DAYS AGO. THE LAST TIME IT HAPPENED I WAS GOING AROUND A CURVE AND I ALMOST WENT INTO THE DITCH. IN ADDITION, IT IS ALSO IMPORTANT TO NOTE THAT AT 40,000 MILES, THE VEHICLE BEGAN HAVING THE SAME ISSUE (MESSAGE CENTER OCCASIONALLY FLASHING "TRAC OFF" AND "PWR STR", AND THE ABS AND EMERGENCY BREAK LIGHTS GOING ON). THE DEALER FOUND THAT THE STEERING COLUMN WAS SHORTING OUT AND HAD TO REPLACE THE STEERING COLUMN IN THE VEHICLE. THIS LEADS ME TO BELIEVE THAT THIS IS AN ELECTRICAL PROBLEM... *TT
NHTSA ODI #10427821
80,000 miles · Sep 28, 2011
Electrical SystemUnknown Or Other
ON 9/27/2011 I WAS UNABLE TO TURN THE KEY TO THE OFF IN MY IGNITION. THE CAR STAYED ON AND I CANNOT REMOVE THE KEY FROM THE ON POSITION. THERE ARE THOUSANDS OF COMPLAINTS ONLINE REGARDING THE VERY SAME PROBLEM WITH THE SATURN ION. THIS IS A SAFETY PROBLEM AND IS VERY DANGEROUS. THIS VEHICLE AND/ OR PART MUST BE RECALLED. …
Read full complaint
ON 9/27/2011 I WAS UNABLE TO TURN THE KEY TO THE OFF IN MY IGNITION. THE CAR STAYED ON AND I CANNOT REMOVE THE KEY FROM THE ON POSITION. THERE ARE THOUSANDS OF COMPLAINTS ONLINE REGARDING THE VERY SAME PROBLEM WITH THE SATURN ION. THIS IS A SAFETY PROBLEM AND IS VERY DANGEROUS. THIS VEHICLE AND/ OR PART MUST BE RECALLED. *TT
NHTSA ODI #10427788
35,256 miles · Sep 23, 2011
Electrical System
TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY WOULD NOT TURN IN THE IGNITION TO SHUT OFF THE VEHICLE AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS IMMEDIATELY TAKEN TO AN AUTHORIZED DEALER WHERE THE BATTERY WAS DISCONNECTED AND A DIAGNOSTIC TEST WAS PERFORMED. A PART WAS ORDERED AND THE VEHICLE WOULD BE REPAI…
Read full complaint
TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY WOULD NOT TURN IN THE IGNITION TO SHUT OFF THE VEHICLE AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS IMMEDIATELY TAKEN TO AN AUTHORIZED DEALER WHERE THE BATTERY WAS DISCONNECTED AND A DIAGNOSTIC TEST WAS PERFORMED. A PART WAS ORDERED AND THE VEHICLE WOULD BE REPAIRED UPON AVAILABILITY. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 35,256. UPDATED 10/27/11*BF UPDATED 3/30/12 *CN
NHTSA ODI #10426948
43,500 miles · Sep 21, 2011
Electrical System
TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY COULD NOT BE REMOVED FROM THE IGNITION. THE VEHICLE WAS LEFT PARKED AND RUNNING UNTIL THE BATTERY DIED. THE VEHICLE WAS LATER TOWED TO THE DEALER AND THEY ADVISED HER THAT THE HOUSING IGNITION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE R…
Read full complaint
TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY COULD NOT BE REMOVED FROM THE IGNITION. THE VEHICLE WAS LEFT PARKED AND RUNNING UNTIL THE BATTERY DIED. THE VEHICLE WAS LATER TOWED TO THE DEALER AND THEY ADVISED HER THAT THE HOUSING IGNITION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED APPROXIMATLEY TEN MONTHS LATER. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 43,500.
NHTSA ODI #10426581
75,862 miles · Aug 25, 2011
Electrical SystemEngine And Engine CoolingSteering
DRIVING WITH TRAFFIC, THE CAR DIES AND THE STEERING GETS VERY HARD TO TURN THEN BATTERY LIGHT COMES ON. CAR WILL RESTART WITH NO FURTHER PROBLEMS. THIS WILL HAPPEN AT LEAST ONCE A WEEK. TOOK TO THE DEALER THEY FIXED THE GAS TANK LEAK AND OTHER RECALL PARTS. THIS CONTINUES TO HAPPEN ALMOST CAUSED SEVERAL ACCIDENTS. DO NOT KNOW IF…
Read full complaint
DRIVING WITH TRAFFIC, THE CAR DIES AND THE STEERING GETS VERY HARD TO TURN THEN BATTERY LIGHT COMES ON. CAR WILL RESTART WITH NO FURTHER PROBLEMS. THIS WILL HAPPEN AT LEAST ONCE A WEEK. TOOK TO THE DEALER THEY FIXED THE GAS TANK LEAK AND OTHER RECALL PARTS. THIS CONTINUES TO HAPPEN ALMOST CAUSED SEVERAL ACCIDENTS. DO NOT KNOW IF IT IS THE STEERING OR ELECTRICAL. IT DOESN'T MATTER WHAT SPEED YOUR GOING OR IF YOUR GOING STRAIGHT OR TURNING. PLEASE LOOK INTO THIS PROBLEM. I HAVE HAD THE BATTERY CHECKED THE THERMOSTAT, CHECKED THE FUSE BOX CHECKED. THE DEALER CHECKED AND FIXED THE OTHER 3 THINGS FROM RECALL AS STATED. THE IGNITION SOMETIMES GETS STUCK WHEN THE STEERING GOES OUT YOU CAN NOT GET THE KEY TO DO ANYTHING UNTIL YOU TURN THE STEERING WHEEL THAT HAS NO POWER THEN YOU CAN RESTART THE CAR. ALSO THE CAR HEAT GAUGE NEVER GOES ABOVE HALF WAY SO CAR IS NOT OVER HEATING.
NHTSA ODI #10423368
81,000 miles · Aug 24, 2011
Electrical System
POWER STEERING AND IGNITION PROBLEM. WENT IN TO HAVE THE POWER STEERING CHECKED THEN THE IGNITION FAILED ON ME AND THE COMPUTER IN THE ENGINE WENT NUTS. *TR
NHTSA ODI #10421282
71,935 miles · Aug 14, 2011
Electrical SystemLatches/locks/linkages
IGNITION STUCK IN "ON" POSITION, CAN'T REMOVE KEY. *TR
NHTSA ODI #10419385
69,000 miles · Aug 12, 2011
Electrical SystemSuspension
MY KEY HAS GOTTEN STUCK IN THE IGNITION IN THE "ON" POSITION THREE TIMES NOW. I HAVE HAD TO PURCHASE THE PAY FOR PARTS AND LABOR THREE TIMES. MY BALL JOINTS HAVE GONE OUT. MECHANICS SAY THIS IS VERY ODD FOR A NEWER VEHICLE (2006 SATURN). *TR
NHTSA ODI #10419154
Official recalls
4Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Illustration