← New search

2006 Saturn Ion

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2006 Saturn Ion do not stand out strongly from the model-year median of 816.5.

About this comparison →

When problems were reported

Mileage at the reported incident

1,073 reports with mileage · 162 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Steering. Review the 544 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 392 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Gasoline. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

44 crash reports7 fire reports23 injury reports

Air Bags complaints

61 reports
Clear category filter
Mileage unknown · Jun 23, 2014
Air BagsElectrical System

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBERS: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) AND 14V171000 (ELECTRICAL SYSTEM); HOWEVER, THE PARTS WERE UNAVAILABLE TO REPAIR THE VEHICLE. NEITHER THE DEALER NOR THE MANUFACTURER COULD SPECIFY WHEN THE PARTS WOULD ARRIVE. THE …

Read full complaint

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBERS: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) AND 14V171000 (ELECTRICAL SYSTEM); HOWEVER, THE PARTS WERE UNAVAILABLE TO REPAIR THE VEHICLE. NEITHER THE DEALER NOR THE MANUFACTURER COULD SPECIFY WHEN THE PARTS WOULD ARRIVE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ODI #10605152

Mileage unknown · Jun 19, 2014
Air BagsElectrical System

2006 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH REIMBURSEMENT. *SMD

NHTSA ODI #10598213

79,826 miles · Jun 16, 2014
Air BagsElectrical System

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THERE WERE NUMEROUS ATTEMPTS BEFORE THE VEHICLE WOULD START. ADDITIONALLY, THE VEHICLE STALLED AND THE FAILURE RECURRED FIVE TIMES. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 14V047000 (AIR BAGS , ELECTRICAL SYSTEM. THE FAILURE OCCURRED AFTER THE RECALL …

Read full complaint

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THERE WERE NUMEROUS ATTEMPTS BEFORE THE VEHICLE WOULD START. ADDITIONALLY, THE VEHICLE STALLED AND THE FAILURE RECURRED FIVE TIMES. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 14V047000 (AIR BAGS , ELECTRICAL SYSTEM. THE FAILURE OCCURRED AFTER THE RECALL REPAIR WAS PERFORMED. THE VEHICLE WAS NOT REPAIRED FOR THE RECENT FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 79,826.

NHTSA ODI #10598489

79,000 miles · Jun 15, 2014
Air BagsElectrical SystemSteering

THE STEERING COLUMN ASSEMBLY (INCLUDING KEY SWITCH, TURN SIGNAL, WIPER CONTROL, ETC.) WAS LOOSE UPON GETTING THE VEHICLE BACK FROM THE REPAIRS FOR THE KEY SWITCH RECALL. THIS WAS NOT LIKE THIS PRIOR TO THE RECALL REPAIRS AND REPRESENTS SLOPPY WORKMANSHIP BY DEALERSHIP EMPLOYEES REPAIRING THE VEHICLE OR POOR DESIGN THAT WON'T STA…

Read full complaint

THE STEERING COLUMN ASSEMBLY (INCLUDING KEY SWITCH, TURN SIGNAL, WIPER CONTROL, ETC.) WAS LOOSE UPON GETTING THE VEHICLE BACK FROM THE REPAIRS FOR THE KEY SWITCH RECALL. THIS WAS NOT LIKE THIS PRIOR TO THE RECALL REPAIRS AND REPRESENTS SLOPPY WORKMANSHIP BY DEALERSHIP EMPLOYEES REPAIRING THE VEHICLE OR POOR DESIGN THAT WON'T STAY TIGHT. BY THIS BEING LOOSE, THERE COULD BE DAMAGE TO THE WIRES OR THE WIRES COULD COME UNPLUGGED INSIDE THE STEERING COLUMN. THIS WOULD INCLUDE AIR BAG WIRES, KEY SWITCH WIRES, ETC. THERE WOULD ALSO BE A POSSIBILITY OF FIRE IF THIS PROBLEM ISN'T CORRECTED AS THE WIRES COULD SHORT OUT. I BELIEVE ALL THE VEHICLES THAT HAVE BEEN REPAIRED SHOULD BE RECALLED AGAIN TO CHECK FOR THIS PROBLEM AND REPAIR THEM IF IT IS FOUND THAT IT IS LOOSE. *JS

NHTSA ODI #10598343

Mileage unknown · Jun 10, 2014
Air BagsElectrical SystemEngine

2006 SATURN ION. CONSUMER WRITES IN REGARDS TO VEHICLE ELECTRICAL SYSTEM ISSUES. *SMD RECENTLY, THE EMERGENCY BRAKE THE CONSUMER STATED THE CHECK ENGINE LIGHT ILLUMINATED TWICE AND FINALLY, THE FUEL INJECTORS WERE REPLACED. RECENTLY, THE EMERGENCY BRAKE LIGHT ILLUMINATED AND STAYED ON WITHOUT THE EMERGENCY BRAKE BEING PULLED…

Read full complaint

2006 SATURN ION. CONSUMER WRITES IN REGARDS TO VEHICLE ELECTRICAL SYSTEM ISSUES. *SMD RECENTLY, THE EMERGENCY BRAKE THE CONSUMER STATED THE CHECK ENGINE LIGHT ILLUMINATED TWICE AND FINALLY, THE FUEL INJECTORS WERE REPLACED. RECENTLY, THE EMERGENCY BRAKE LIGHT ILLUMINATED AND STAYED ON WITHOUT THE EMERGENCY BRAKE BEING PULLED. ALSO, WHEN SHE PUSHED THE SHIFTER KNOB, THERE WAS A NOISE IN THE STEERING COLUMN. THERE WAS AN ISSUE WITH THE ELECTRICAL POWER STEERING. IT WOULD GO OUT AND RESUME NORMAL OPERATION, WHILE DRIVING. *JB THE CONSUMER STATED SHE HEARD A KNOCKING NOISE, WHEN SHE DROVE OVER A BUMP AND THE CHECK ENGINE LIGHT ILLUMINATED AGAIN. UPDATED 08/06/14

NHTSA ODI #10593030

Mileage unknown · Jun 2, 2014
Air BagsElectrical System

I AM THE UNFORTUNATELY OWNER OF A GOVERNMENT MOTORS PRODUCTS THAT IS SUBJECT TO A RECALL. I HAVE RECEIVED NOW 10 NOTIFICATIONS IN ALMOST 90 DAYS DEMANDING I HAVE THIS RECALL PERFORMED IMMEDIATELY. IN THE COURSE OF NEARLY 90 DAYS, I HAVE CONTACTED 5 DIFFERENT DEALERS AND HAVE BEEN TOLD THE SAME THING; ?WE WILL TAKE YOUR NAME AND …

Read full complaint

I AM THE UNFORTUNATELY OWNER OF A GOVERNMENT MOTORS PRODUCTS THAT IS SUBJECT TO A RECALL. I HAVE RECEIVED NOW 10 NOTIFICATIONS IN ALMOST 90 DAYS DEMANDING I HAVE THIS RECALL PERFORMED IMMEDIATELY. IN THE COURSE OF NEARLY 90 DAYS, I HAVE CONTACTED 5 DIFFERENT DEALERS AND HAVE BEEN TOLD THE SAME THING; ?WE WILL TAKE YOUR NAME AND NUMBER AND CONTACT YOU WHEN WE CAN PERFORM THE RECALL?. WHILE I UNDERSTAND WITH AN INFERIOR PRODUCT, MADE WORSE BY GOVERNMENT INTERVENTION INTO A PRIVATE BUSINESS, REQUIRES RECALLS AND DUE TO THE HIGH VOLUME OF CARS SUBJECT TO THE RECALL DUE TO THE GOVERNMENT PICKING GM AS A COMPANY TO PROMOTE, PART PRODUCTION MAY BE LIMITED, I DO NOT UNDERSTAND WHY I GET THESE LETTERS. I WOULD HAPPILY COMPLY WITH THE RECALL, AS A MATTER OF SAFETY, BUT WHEN THE DEALER REFUSES TO PROVIDE THE RECALL, I CANNOT COMPLY. THE LAST LETTER I RECEIVED WAS A POST CARD THAT IMPLIED SERIOUS CONSEQUENCES COULD RESULT AND EVEN HAD A DATE ?AS OF MAY 24TH THIS HAS NOT BEEN PERFORMED.? I AM FULLY AWARE AND I HAVE NOT SPENT OVER 3 HOURS BETWEEN CALLS AND LETTERS TRYING TO COMPLY WITH THIS PSEUDO-GOVERNMENT DEMAND. PLEASE PROVIDE GUIDANCE ON HOW TO PROCEED. THE LAST AGENT AT GM I SPOKE WITH SAID THAT THEY WOULD CONTINUE TO MAIL LETTERS AS THEY ARE DIRECTED BY THE GOVERNMENT TO DO SO. SO I ASK YOU, THE GOVERNMENT AGENCY PARTIALLY RESPONSIBLE, PLEASE STOP SENDING ME LETTERS TO DO WHAT IS NOT POSSIBLE TO DO. I AM AWARE OF THE RECALL. I HAVE DONE WHAT I HAVE BEEN INSTRUCTED TO DO BY EACH LETTER I HAVE RECEIVED AND I HAVE BEEN ASSURED MY NAME AND NUMBER IS ON A LIST TO CONTACT ME WHEN THEY CAN PROVIDE THE RECALL. UNLIKE THE AVERAGE AMERICAN I DO HAVE A LITTLE BIT OF COMMON SENSE AND TAKE PERSONAL RESPONSIBILITY FOR MY VEHICLES.

NHTSA ODI #10595613

80,000 miles · May 12, 2014
Air Bags

WHILE DRIVING THE AIR BAG SERVICE LIGHT APPEARED. I WAS TOLD BY THE DEALERSHIP THAT IF IN A CRASH THE AIRBAGS WOULD NOT DEPLOY. THIS PROBLEM NEEDS IMMEDIATE ATTENTION. MY VEHICLE IS GOING IN TODAY TO FIND THE EXACT PROBLEM. DIAGNOSTICS IS RIGHT AROUND $100. *TR

NHTSA ODI #10587793

Mileage unknown · May 8, 2014
Air BagsElectrical SystemVisibility

2006 SATURN ION. CONSUMER WRITES IN REGARDS TO VEHICLE IGNITION RECALL REPAIRS AND SEEKS REIMBURSEMENT. *SMD THE CONSUMER STATED 2 YEARS AGO, THE IGNITION COMPLETELY FROZE AND THE VEHICLE HAD TO BE TOWED TO A LOCAL GARAGE. THE CONSUMER BELIEVED THE IGNITION PROBLEM HE EXPERIENCED WAS RELATED TO THE CURRENT RECALL. ALSO, THE A…

Read full complaint

2006 SATURN ION. CONSUMER WRITES IN REGARDS TO VEHICLE IGNITION RECALL REPAIRS AND SEEKS REIMBURSEMENT. *SMD THE CONSUMER STATED 2 YEARS AGO, THE IGNITION COMPLETELY FROZE AND THE VEHICLE HAD TO BE TOWED TO A LOCAL GARAGE. THE CONSUMER BELIEVED THE IGNITION PROBLEM HE EXPERIENCED WAS RELATED TO THE CURRENT RECALL. ALSO, THE AIR BAG LIGHT ILLUMINATED AND THE MOONROOF WOULDN'T CLOSE. *JB

NHTSA ODI #10586957

Mileage unknown · May 8, 2014
Air BagsElectrical System

2006 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE. *SMD THE CONSUMER STATED THE VEHICLE HAS BEEN AT THE DEALER FOR 3 WEEKS, DUE TO LACK OF PARTS. LAST YEAR, THE CONSUMER'S WIFE EXPERIENCED THE EXACT FAILURE, THE VEHICLE WAS BEING RECALLED FOR. *JB

NHTSA ODI #10586948

Mileage unknown · May 6, 2014
Air BagsElectrical System

2006 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE REPAIRS. *SMD THE CONSUMER STATED THE KEY WOULD NOT TURN, TO SHUT THE VEHICLE OFF. *JB

NHTSA ODI #10585922

Official recalls

4

14V171000 · Electrical System:ignition

Apr 10, 2014

General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

Consequence & remedy

Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

14V153000 · Steering:electric Power Assist System

Mar 31, 2014

General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Consequence & remedy

Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

14V047000 · Air Bags; Electrical System:ignition:switch

Feb 10, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Additional source detail variants (2)

Air Bags

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Electrical System:ignition:switch

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

09V419000 · Fuel System, Gasoline:delivery:fuel Pump

Oct 29, 2009

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.

Consequence & remedy

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

EA11014 · Electric Power Steering Failure

Opened Sep 29, 2011 · Closed Apr 15, 2014

Status: closed (inferred from source dates) · Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Additional source detail variants (2)

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

RQ10004 · Electric Power Steering Failure

Opened Dec 15, 2010 · Closed Oct 5, 2011

Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Additional source detail variants (2)

Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Steering

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.