NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
757 reports98,000 miles · Feb 12, 2009
Engine And Engine Cooling
ON 3 OCCASIONS THIS WINTER, MY 2003 SATURN ION HAS FAILED TO START. AFTER THE FIRST 2, THE BATTERY WAS REPLACED. I NOW DOUBT THE BATTERY WAS FAULTY, BECAUSE THE PROBLEM SEEMS TO BE INTERMITTENT AND THE ENGINE WOULD ROLL OVER, BUT NOT START. THIS MORNING (ABOUT 35 DEGREES), I ATTEMPTED TO START THE CAR AND IT WAS VERY SLUGGISH…
Read full complaint
ON 3 OCCASIONS THIS WINTER, MY 2003 SATURN ION HAS FAILED TO START. AFTER THE FIRST 2, THE BATTERY WAS REPLACED. I NOW DOUBT THE BATTERY WAS FAULTY, BECAUSE THE PROBLEM SEEMS TO BE INTERMITTENT AND THE ENGINE WOULD ROLL OVER, BUT NOT START. THIS MORNING (ABOUT 35 DEGREES), I ATTEMPTED TO START THE CAR AND IT WAS VERY SLUGGISH AND WOULD NOT START. I ATTEMPTED TO CHARGE IT AND ENDED UP WALKING MY DAUGHTER 5 BLOCKS TO DAYCARE AND CALLING A RIDE TO WORK. WHEN I RETURNED HOME 3 HOURS LATER, IT STILL DID NOT WANT TO START AND THEN RAN SLUGGISH. ONLINE SEARCHES INDICATE HUNDREDS OF REPORTS OF A FAULTY IGNITION MODULE. THAT WILL BE MY NEXT REPAIR/REPLACEMENT. THE CAR HAS 98000 MILES. WE PREVIOUSLY OWNED A 1995 SATURN SC2 FOR 10 YEARS WITH 150000 MILES AND NO TROUBLE. *TR
NHTSA ODI #10258478
80,000 miles · Feb 11, 2009
Visibility
TL*THE CONTACT OWNS A 2003 SATURN ION. THE CONTACT STATED THAT THE DUCT PORT, WHERE AIR TRAVELS THROUGH THE VEHICLE, FAILS TO TRANSPORT CORRECTLY AND BECOMES STUCK. THE INSULATION BETWEEN THE VENT LOOSENS AND STOPS SWITCHING BETWEEN HEAT AND DEFROST. THE FAILURE BEGAN AT 36,000 MILES. THE FAILURE HAS NOT BEEN REPAIRED. THE …
Read full complaint
TL*THE CONTACT OWNS A 2003 SATURN ION. THE CONTACT STATED THAT THE DUCT PORT, WHERE AIR TRAVELS THROUGH THE VEHICLE, FAILS TO TRANSPORT CORRECTLY AND BECOMES STUCK. THE INSULATION BETWEEN THE VENT LOOSENS AND STOPS SWITCHING BETWEEN HEAT AND DEFROST. THE FAILURE BEGAN AT 36,000 MILES. THE FAILURE HAS NOT BEEN REPAIRED. THE CONTACT FEELS THAT THIS IS A SAFETY ISSUE BECAUSE THE WINDOWS COULD FOG UP AND REDUCE VISIBILITY. THE FAILURE OCCURS IN RAINY WEATHER CONDITIONS. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 80,000.
NHTSA ODI #10258402
60,000 miles · Feb 9, 2009
Electrical System
CAR FAILS TO START INTERMITTENTLY. WAIT 10 MIN, CAR TURNS OVER THEN DIES. WAIT 5 MIN CAR WILL START (HIGH RPM'S AT FIRST) W/O PROBLEM. *TR
NHTSA ODI #10258026
55,000 miles · Feb 7, 2009
Engine And Engine Cooling
I PURCHASED A USED 2003 SATURN ION LEVEL 1 IN APRIL OF 2006. BEGINNING THIS WINTER (APPROXIMATELY EARLY DECEMBER 2008), MY CAR DID NOT START. INITIALLY, IT WOULD SIMPLY CLICK, BUT ALL ELECTRICAL WAS WORKING PROPERLY, AND THERE WAS NO DRAIN OF POWER UPON ATTEMPTING TO START THE CAR. A FEW HOURS LATER, MY HUSBAND TRIED TO START…
Read full complaint
I PURCHASED A USED 2003 SATURN ION LEVEL 1 IN APRIL OF 2006. BEGINNING THIS WINTER (APPROXIMATELY EARLY DECEMBER 2008), MY CAR DID NOT START. INITIALLY, IT WOULD SIMPLY CLICK, BUT ALL ELECTRICAL WAS WORKING PROPERLY, AND THERE WAS NO DRAIN OF POWER UPON ATTEMPTING TO START THE CAR. A FEW HOURS LATER, MY HUSBAND TRIED TO START IT, AND IT TURNED OVER AS IF THERE WAS NO PROBLEM PRESENT. SINCE THEN, IT HAS VERY RANDOMLY DONE THE SAME THING - FIRST TRY, NOTHING BUT ELECTRICAL COMES ON, BUT AFTER WAITING ANYWHERE FROM 5 - 30 MINUTES, THE CAR WILL START ONLY TO DIE IMMEDIATELY, AND THEN FINALLY, THE ENGINE WILL TURN OVER, AND THE CAR WILL RUN PERFECTLY. THIS WINTER HAS BEEN BRUTALLY COLD, AND I HAVE A YOUNG SON. LUCKILY, HE HAS NEVER BEEN WITH ME WHEN I HAVE ENCOUNTERED THIS ISSUE WHILE AWAY FROM HOME - SITTING IN A NON-RUNNING VEHICLE FOR UP TO HALF AN HOUR IN BELOW-ZERO TEMPERATURES IS NOT ONLY DANGEROUS TO ME, BUT *EXTREMELY* DANGEROUS FOR HIM. I HAVE EVEN HAD OCCURRENCES OF THIS WHEN STOPPING AT THE STORE FOR A MERE 10 MINUTES (AFTER MY CAR STARTED PERFECTLY TO GET THERE), ONLY TO COME OUT AND FIND MY CAR COMPLETELY USELESS. THIS PARTICULAR NIGHT THE TEMPERATURE WAS LITERALLY 10-BELOW-ZERO), AND IT TOOK ME A SOLID HALF HOUR TO GET IT STARTED AGAIN. I HAVE DISCOVERED COUNTLESS COMPLAINTS REGARDING DUPLICATE SITUATIONS ONLINE FROM MANY, MANY ION OWNERS, AS WELL AS OTHER MODELS OF SATURNS. THE FACT THAT SATURN HAS NOT ISSUED A RECALL FOR WHAT IS APPARENTLY REMEDIED BY REPLACING THE IGNITION ASSEMBLY AND HOUSING APPALL ME, EVEN THOUGH THEY ADDRESS IT AS "NOT BEING A SAFETY ISSUE." WHEN TAKING INTO CONSIDERATION THAT I, AS WELL AS THOUSANDS OF OTHER ION OWNERS, COULD BE LEFT STRANDED FAR FROM ANY HELP OR MEANS TO ATTAIN ASSISTANCE, AT ANY RANDOM TIME OF DAY OR LOCATION, IN EVEN THE ABSOLUTE WORST OF WEATHER CONDITIONS MAKES ME DISAGREE COMPLETELY WITH THE ASSUMPTION THAT IT DOES NOT IMPACT THE SAFETY OF SATURN OWNERS AND THEIR FAMILIES. IT DESERVES A RECALL. *TR
NHTSA ODI #10257774
Mileage unknown · Feb 5, 2009
Electrical System
TL*THE CONTACT OWNS A 2003 SATURN ION. AT TEMPERATURES OF 30 DEGREES AND BELOW, THE VEHICLE FAILED TO START. THE CONTACT HAD TO MAKE SEVERAL ATTEMPTS BEFORE THE ENGINE WOULD TURN OVER. THE DEALER PERFORMED A DIAGNOSTIC AND DISCOVERED THAT THE IGNITION SWITCH WAS FAULTY. THE IGNITION SWITCH WAS REPLACED UNDER WARRANTY; HOWEVE…
Read full complaint
TL*THE CONTACT OWNS A 2003 SATURN ION. AT TEMPERATURES OF 30 DEGREES AND BELOW, THE VEHICLE FAILED TO START. THE CONTACT HAD TO MAKE SEVERAL ATTEMPTS BEFORE THE ENGINE WOULD TURN OVER. THE DEALER PERFORMED A DIAGNOSTIC AND DISCOVERED THAT THE IGNITION SWITCH WAS FAULTY. THE IGNITION SWITCH WAS REPLACED UNDER WARRANTY; HOWEVER, THE FAILURES CONTINUED TO OCCUR. THE DEALER PERFORMED ANOTHER DIAGNOSTIC AND FOUND THAT THE IGNITION SWITCH NEEDED TO BE REPLACED YET AGAIN AT THE CONTACT'S EXPENSE. THE VIN THAT WAS PROVIDED WAS NOT ACCEPTED BY THE SYSTEM. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS LESS THAN 65,000.
NHTSA ODI #10257627
Mileage unknown · Feb 5, 2009
Electrical System
I HAVE A 2003 SATURN THAT WILL NOT START WHEN IT GETS COLD, THIS HAS HAPPEN SINCE I HAVE HAD THE CAR. THIS CAN BE VERY FRUSTRATING AND COSTLY WHEN I MISS HOURS FROM WORK OR TRYING TO GET MY CHILD TO SCHOOL. I HAVE SEEN SEVERAL COMPLAINTS REGARDING THIS ISSUE. IS THERE ANYONE WILLING TO DO ANYTHING. WHY SHOULD WE CONTINUE TO …
Read full complaint
I HAVE A 2003 SATURN THAT WILL NOT START WHEN IT GETS COLD, THIS HAS HAPPEN SINCE I HAVE HAD THE CAR. THIS CAN BE VERY FRUSTRATING AND COSTLY WHEN I MISS HOURS FROM WORK OR TRYING TO GET MY CHILD TO SCHOOL. I HAVE SEEN SEVERAL COMPLAINTS REGARDING THIS ISSUE. IS THERE ANYONE WILLING TO DO ANYTHING. WHY SHOULD WE CONTINUE TO SUFFER FOR TRUSTING A PRODUCT WITH YOUR NAME ON IT FOR RELIABLE TRANSPORTATION.*TR KAREN
NHTSA ODI #10257571
37,000 miles · Feb 3, 2009
Electrical System
I HAVE A 2003 SATURN ION. I HAVE HAD IT IN 3 TIMES TO BE WORKED ON. SOME DAYS IT WILL START SOME DAYS IT WILL NOT. I HAVE HAD A FUSE REPLACED, MY STARTED, AND A CONNECTION TO THE STARTER. I KNOW 2 OTHER PEOPLE WHO HAVE HAD THE SAME ISSUE WITH THE SAME CAR. NOW I READ THIS ONLINE BLOG AND A TON OF PEOPLE HAVING THE SAME ISSUE. MY…
Read full complaint
I HAVE A 2003 SATURN ION. I HAVE HAD IT IN 3 TIMES TO BE WORKED ON. SOME DAYS IT WILL START SOME DAYS IT WILL NOT. I HAVE HAD A FUSE REPLACED, MY STARTED, AND A CONNECTION TO THE STARTER. I KNOW 2 OTHER PEOPLE WHO HAVE HAD THE SAME ISSUE WITH THE SAME CAR. NOW I READ THIS ONLINE BLOG AND A TON OF PEOPLE HAVING THE SAME ISSUE. MY CAR IS NO LONGER UNDER WARRANTY SO I WILL HAVE TO PAY FOR ALL OF THESE REPAIRS. *TR
NHTSA ODI #10257286
60,000 miles · Jan 30, 2009
Electrical System
CAR WILL NOT START IN COLD WEATHER (APPROXIMATELY 30 DEGREES OR LOWER). INITIAL ATTEMPT AT STARTING PUTS CAR INTO ANTI-THEFT MODE, AND YOU MUST WAIT ABOUT 10 MINUTES TO TRY AGAIN WITH NO GUARANTEE THE SAME THING WON'T HAPPEN AGAIN. *TR
NHTSA ODI #10256931
68,000 miles · Jan 30, 2009
Electrical System
I HAVE HAD NUMEROUS INCIDENT DURING THE LAST 14 MONTHS REGARDING MY SATURN ION III NOT WANTING TO START IN COLD WEATHER & THE IGNITION SWITCH NOT ALLOWING ME TO RELEASE THE KEY. THIS HAS CAUSED ME TO TAKE MY VEHICLE TO A MECHANIC TO TRY TO DIAGNOSE, NEW BATTERY, TOWING ETC. *TR
NHTSA ODI #10256921
73,000 miles · Jan 25, 2009
Electrical System
THIS FALL I WENT TO START MY 2005 SATURN ION S2 IT WOULD NOT START. I HAD THE IGNITION SWITCHED REPLACED. NOW IN JANUARY, I AM HAVING THE SAME PROBLEMS WITH THE CAR NOT STARTING. I HAVE RESEARCHED AND DETERMINED THAT THIS IS NOT A PROBLEM THAT CAN BE FIXED PERMANENTLY BECAUSE THE PART IS BAD FROM SATURN. I DO NOT WANT TO KEEP SP…
Read full complaint
THIS FALL I WENT TO START MY 2005 SATURN ION S2 IT WOULD NOT START. I HAD THE IGNITION SWITCHED REPLACED. NOW IN JANUARY, I AM HAVING THE SAME PROBLEMS WITH THE CAR NOT STARTING. I HAVE RESEARCHED AND DETERMINED THAT THIS IS NOT A PROBLEM THAT CAN BE FIXED PERMANENTLY BECAUSE THE PART IS BAD FROM SATURN. I DO NOT WANT TO KEEP SPENDING $200.00 WHENEVER I HAVE THIS PROBLEM. *TR
NHTSA ODI #10256289
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Nov 16, 2004
CERTAIN PASSENGER VEHICLES HAVE A CONDITION IN WHICH THE TURN SIGNAL LAMP AND DAYTIME RUNNING LAMP (DRL) ON EITHER FRONT SIDE CAN STOP WORKING BECAUSE OF LOSS OF CONTACT BETWEEN THE BULB AND SOCKET.
Consequence & remedy
Consequence: IF A FRONT TURN SIGNAL LAMP IS INOPERATIVE, OTHERS MAY REACT MORE SLOWLY TO A TURNING VEHICLE AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE DRL/TURN SIGNAL BULB ON BOTH THE LEFT AND RIGHT FRONT SIDE AND INSPECT FOR AND ADD A DRL JUMPER KIT IF NOT PRESENT. THE RECALL BEGAN NOVEMBER 17, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Jan 5, 2004
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L 4-CYLINDER (L61) ENGINES WERE BUILT WITH A FUEL FILTER THAT COULD CORRODE PREMATURELY ON THE EXTERIOR SURFACE.
Consequence & remedy
Consequence: IF CORROSION ON THE EXTERIOR SURFACE OF THE FUEL FILTER PROGRESSES TO THE POINT OF CREATING A HOLE IN THE SHELL, FUEL DROPLETS COULD FORM AND DROP TO THE GROUND. IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL REPLACE THE FUEL FILTER ASSEMBLY. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Jan 5, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, "POWER-OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS." THE POWER WINDOWS AND/OR SUNROOF MAY BE OPERABLE AFTER THE IGNITION HAS BEEN TURNED TO THE "OFF" POSITION AND THE FRONT PASSENGER DOOR IS OPENED.
Consequence & remedy
Consequence: IF UNSUPERVISED CHILDREN ARE LEFT UNATTENDED IN THE VEHICLE AND OPERATE THE POWER WINDOWS OR SUNROOF, THERE IS AN INCREASED RISK OF INJURY TO THE CHILD.
Remedy: DEALERS WILL UPGRADE THE BODY CONTROL MODULE (BCM) CALIBRATION. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE07011 · Windshied Wiper Linkage Failure
Opened Feb 28, 2007 · Closed Aug 9, 2007
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
INVESTIGATION DISCLOSED THAT THE MANUFACTURER ISSUED A SERVICE BULLETIN IN AUGUST 2003, REGARDING SERVICE THAT REQUIRED REMOVAL OF THE WIPER ARMS.GM ISSUED THE BULLETIN AT THAT TIME TO ADDRESS CUSTOMER COMMENTS ON WINDSHIELD WIPER CHATTERING OR HOPPING ACROSS THE WINDSHIELD DURING WIPER OPERATION.THE CORRECTION WAS TO REPLACE THE WIPER ARM AND BLADE.HOWEVER, THE BULLETIN DID NOT PLACE SPECIFIC EMPHASIS ON THE IMPORTANCE OF USING THE PROPER TOOL AND PROCEDURES TO REMOVE THE WIPER ARM AND TO PREVENT DAMAGE TO THE PIVOT SHAFT HOUSING.IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER, GM STATES, ...THE WIPER PIVOT HOUSING IN THE SUBJECT VEHICLE MAY CRACK AND/OR FRACTURE AS A RESULT OF AN OVERLOAD CONDITION APPLIED TO THE WIPER PIVOT HOUSING DURING IMPROPER REMOVAL OF THE WIPER ARMS.GM'S FIELD SURVEY FOUND THAT ...DEALERS DO NOT ROUTINELY USE THE WIPER ARM REMOVAL TOOL WHEN SERVICING THE WIPER ARMS.ODI CONCLUDES THAT THE FAILURE AND WARRANTY REPORTS IN THIS INVESTIGATION DO NOT IDENTIFY A SAFETY RELATED DEFECT TREND.ODI DOES HAVE CONCERN, HOWEVER, THAT PRIOR AND IMPROPERLY PERFORMED WIPER ARM REMOVAL MAY HAVE CONTRIBUTED TO THE FAILURES IDENTIFIED DURING THIS INVESTIGATION.IN AUGUST 2007, GM ISSUED A NEW TECHNICAL SERVICE BULLETIN (GM NUMBER 07-08-43-007) TO SPECIFICALLY EMPHASIZE THE IMPORTANCE OF USING THE PROPER TOOL FOR REMOVAL OF THE WIPER ARMS TO PREVENT PIVOT SHAFT DAMAGE DURING THE PROCEDURE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
INVESTIGATION DISCLOSED THAT THE MANUFACTURER ISSUED A SERVICE BULLETIN IN AUGUST 2003, REGARDING SERVICE THAT REQUIRED REMOVAL OF THE WIPER ARMS.GM ISSUED THE BULLETIN AT THAT TIME TO ADDRESS CUSTOMER COMMENTS ON WINDSHIELD WIPER CHATTERING OR HOPPING ACROSS THE WINDSHIELD DURING WIPER OPERATION.THE CORRECTION WAS TO REPLACE THE WIPER ARM AND BLADE.HOWEVER, THE BULLETIN DID NOT PLACE SPECIFIC EMPHASIS ON THE IMPORTANCE OF USING THE PROPER TOOL AND PROCEDURES TO REMOVE THE WIPER ARM AND TO PREVENT DAMAGE TO THE PIVOT SHAFT HOUSING.IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER, GM STATES, ...THE WIPER PIVOT HOUSING IN THE SUBJECT VEHICLE MAY CRACK AND/OR FRACTURE AS A RESULT OF AN OVERLOAD CONDITION APPLIED TO THE WIPER PIVOT HOUSING DURING IMPROPER REMOVAL OF THE WIPER ARMS.GM'S FIELD SURVEY FOUND THAT ...DEALERS DO NOT ROUTINELY USE THE WIPER ARM REMOVAL TOOL WHEN SERVICING THE WIPER ARMS.ODI CONCLUDES THAT THE FAILURE AND WARRANTY REPORTS IN THIS INVESTIGATION DO NOT IDENTIFY A SAFETY RELATED DEFECT TREND.ODI DOES HAVE CONCERN, HOWEVER, THAT PRIOR AND IMPROPERLY PERFORMED WIPER ARM REMOVAL MAY HAVE CONTRIBUTED TO THE FAILURES IDENTIFIED DURING THIS INVESTIGATION.IN AUGUST 2007, GM ISSUED A NEW TECHNICAL SERVICE BULLETIN (GM NUMBER 07-08-43-007) TO SPECIFICALLY EMPHASIZE THE IMPORTANCE OF USING THE PROPER TOOL FOR REMOVAL OF THE WIPER ARMS TO PREVENT PIVOT SHAFT DAMAGE DURING THE PROCEDURE.THIS INVESTIGATION IS CLOSED.
Visibility:windshield Wiper/washer:linkages
INVESTIGATION DISCLOSED THAT THE MANUFACTURER ISSUED A SERVICE BULLETIN IN AUGUST 2003, REGARDING SERVICE THAT REQUIRED REMOVAL OF THE WIPER ARMS.GM ISSUED THE BULLETIN AT THAT TIME TO ADDRESS CUSTOMER COMMENTS ON WINDSHIELD WIPER CHATTERING OR HOPPING ACROSS THE WINDSHIELD DURING WIPER OPERATION.THE CORRECTION WAS TO REPLACE THE WIPER ARM AND BLADE.HOWEVER, THE BULLETIN DID NOT PLACE SPECIFIC EMPHASIS ON THE IMPORTANCE OF USING THE PROPER TOOL AND PROCEDURES TO REMOVE THE WIPER ARM AND TO PREVENT DAMAGE TO THE PIVOT SHAFT HOUSING.IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER, GM STATES, ...THE WIPER PIVOT HOUSING IN THE SUBJECT VEHICLE MAY CRACK AND/OR FRACTURE AS A RESULT OF AN OVERLOAD CONDITION APPLIED TO THE WIPER PIVOT HOUSING DURING IMPROPER REMOVAL OF THE WIPER ARMS.GM'S FIELD SURVEY FOUND THAT ...DEALERS DO NOT ROUTINELY USE THE WIPER ARM REMOVAL TOOL WHEN SERVICING THE WIPER ARMS.ODI CONCLUDES THAT THE FAILURE AND WARRANTY REPORTS IN THIS INVESTIGATION DO NOT IDENTIFY A SAFETY RELATED DEFECT TREND.ODI DOES HAVE CONCERN, HOWEVER, THAT PRIOR AND IMPROPERLY PERFORMED WIPER ARM REMOVAL MAY HAVE CONTRIBUTED TO THE FAILURES IDENTIFIED DURING THIS INVESTIGATION.IN AUGUST 2007, GM ISSUED A NEW TECHNICAL SERVICE BULLETIN (GM NUMBER 07-08-43-007) TO SPECIFICALLY EMPHASIZE THE IMPORTANCE OF USING THE PROPER TOOL FOR REMOVAL OF THE WIPER ARMS TO PREVENT PIVOT SHAFT DAMAGE DURING THE PROCEDURE.THIS INVESTIGATION IS CLOSED.
PE06006 · Timing Chain Failure
Opened Jan 24, 2006 · Closed Jun 6, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON DECEMBER 12, 2005, ODI RECEIVED A DEFECT PETITION (DP05-008) REQUESTING THE INVESTIGATION OF TIMING CHAIN FAILURES THAT COULD CAUSE STALLING IN SATURN VEHICLES EQUIPPED WITH THE 2.2L (L61) ENGINE. ODI OPENED PE06-006 ON JANUARY 24, 2006, WITH 24 VEHICLE OWNER COMPLAINTS THAT ALLEGED A BROKEN TIMING CHAIN CAUSED THE VEHICLE TO STOP OPERATING.ON APRIL 12, 2006, ODI RECEIVED INFORMATION FROM GENERAL MOTORS (GM) CONCERNING TIMING CHAIN FAILURES IN APPROXIMATELY 412,000 MODEL YEAR (MY) 2000 THROUGH 2003 SATURN L-SERIES AND ION VEHICLES WITH 2.2L ENGINES. GM'S RESPONSE INCLUDED 1,020 OWNER COMPLAINTS AND FIELD REPORTS CONCERNING TIMING CHAIN FAILURE, INCLUDING 228 THAT ALLEGED THE FAILURE CAUSED THE VEHICLE TO STALL WHILE DRIVING.GM ALSO PROVIDED WARRANTY CLAIM DATA THAT SHOWED 1,902 SUBJECT VEHICLES RECEIVING TIMING CHAIN REPAIRS, INCLUDING 261 WHICH INDICATED THAT A STALL WHILE DRIVING RESULTED FROM THE FAILURE.THE GM COMPLAINTS, FIELD REPORTS AND WARRANTY CLAIMS THAT DID NOT CONTAIN SUFFICIENT INFORMATION TO DETERMINE THAT A STALL WHILE DRIVING OCCURRED WERE PROVIDED IN THE CATEGORY OTHER.GM STATED THAT THE MAJORITY OF THESE INCIDENTS PROBABLY OCCURRED WHILE THE VEHICLES WERE PARKED SINCE THE TIMING CHAIN IS MORE LIKELY TO BREAK DURING HIGH CHAIN LOAD SITUATIONS, SUCH AS ENGINE STARTUP.GM'S DATA SHOWED ELEVATED FAILURE RATES IN APPROXIMATELY 20,500 MY 2001 L-SERIES VEHICLES PRODUCED DURING A FOUR MONTH PERIOD FROM NOVEMBER 2000 THROUGH FEBRUARY 2001.OVER ONE-THIRD OF GM'S TOTAL COMPLAINTS AND FIELD REPORTS (34.3%) AND WARRANTY CLAIMS (38.2%) INVOLVED L-SERIES VEHICLES BUILT DURING THE 4-MONTH PERIOD, WHICH ARE ONLY ABOUT 5% OF SUBJECT VEHICLE PRODUCTION.THE TIMING CHAIN FAILURE RATE IN THE VEHICLES BUILT DURING THIS RANGE IS OVER 10 TIMES GREATER THAN THE REMAINING SUBJECT VEHICLE POPULATION. FOR THE MY 2001 L-SERIES VEHICLES BUILT DURING THE 4-MONTH PERIOD, THE 36-MONTH FAILURE RATE FOR REPAIRS INVOLVING STALL WHILE DRIVING IS SLIGHTLY UNDER ONE PERCENT.HOWEVER, IF THE INCIDENTS CODED AS OTHER ARE ADDED, THE 36-MONTH FAILURE RATE RISES TO NEARLY FIVE PERCENT FOR THOSE VEHICLES.ODI AND GM ARE CONTINUING TO ASSESS THE NUMBER OF COMPLAINTS AND WARRANTY CLAIMS CODED BY GM AS OTHER THAT INVOLVE INCIDENTS OF STALL WHILE DRIVING.GM'S STATISTICAL MODELING OF THE FAILURE DATA INITIALLY CONCLUDED THAT THE FAILURE RATES WERE DECLINING WITH AGE AND MILEAGE FOR ANY SET OF WARRANTY DATA ANALYZED (E.G., STALL WHILE DRIVING, OTHER OR COMBINED).HOWEVER, SUBSEQUENT ANALYSIS SHOWED THAT THE FAILURE RATES ARE INCREASING. BASED ON THE HIGH COMPLAINT AND WARRANTY RATES FOR TIMING CHAIN FAILURE IN THE 4-MONTH PRODUCTION PERIOD FOR THE MY 2001 L-SERIES VEHICLES, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE FREQUENCY OF STALL INCIDENTS DUE TO TIMING CHAIN FAILURES IN THOSE VEHICLES (EA06-009).
DP05008 · Timing Chain Failure
Opened Dec 20, 2005 · Closed Feb 6, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling
ANALYSIS UNDERTAKEN IN RESPONSE TO THE PETITION IDENTIFIED 26 COMPLAINTS ALLEGING TIMING CHAIN FAILURES IN MY 2000-2003 SATURN L-SERIES VEHICLE EQUIPPED WITH THE 2.2L L4 ENGINE.MOST COMPLAINTS OF TIMING CHAIN FAILURE REPORTEDLY RESULTED IN A SUDDEN LOSS OF ENGINE POWER AND STALLING.ODI ALSO NOTED THAT CERTAIN MY 2002-2003 SATURN VUE AND MY 2003 SATURN ION MODEL VEHICLES WITH THE 2.2L ENGINE VEHICLESCOVERED BY A TECHNICAL SERVICE BULLETIN (03-06-01-017) THAT ADDRESSED TIMING CHAIN DESIGN AND SERVICE PROCEDURE CHANGES, EXHIBITED NO COMPLAINTS OF TIMING CHAIN FAILURE.ODI WILL GRANT THE PETITION AND OPEN A PRELIMINARY EVALUATION TO ASSESS THE FREQUENCY, TREND, SCOPE AND SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.REFER TO PE06-006.
EA04035 · Front Turn Signal/drl Failure
Opened Dec 22, 2004 · Closed Oct 20, 2005
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
THE COMBINATION FRONT TURN SIGNAL/DRL IN MY 2003 SATURN ION COUPES EXPERIENCED SIGNIFICANT EARLY-LIFE FAILURES DUE TO VARIOUS BULB QUALITY ISSUES DUE TO INADEQUATE DESIGN AND MANUFACTURE.THIS PROBLEM TREND APPEARS TO HAVE DISAPPEARED AFTER THE FALL OF 2003.THE CHANGE OF LEAD WIRE MATERIAL NEAR THE START OF MY 2004 VEHICLE PRODUCTION APPEARS TO HAVE REDUCED THE FAILURE RATE FOR MY 2004 SATURN ION COUPES.ALTHOUGH OPERATING TEMPERATURES IN THE SUBJECT VEHICLES' LAMP ASSEMBLIES ARE BELOW THE SOCKET MATERIAL MAXIMUM TEMPERATURE SPECIFICATION, THEY ARE ONLY SLIGHTLY BELOW THE SPECIFICATION.IN DECEMBER 2004, GM REDUCED THE VOLTAGE TO THE LAMP ASSEMBLY IN ORDER TO REDUCE THE TEMPERATURE IN THE ASSEMBLY OF THE SUBJECT VEHICLES.WARRANTY CLAIMS ON THE SUBJECT VEHICLES DO NOT INDICATE AN INCREASING TREND OVER TIME.WARRANTY CLAIM RATE OF SUBJECT VEHICLES (EXCLUDING EARLY MY 2003 CLAIMS) IS NOT SIGNIFICANTLY HIGHER THAN OTHER GM VEHICLES THAT USE COMBINATION TURN SIGNAL/DRLS.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY REPORT.
PE04061 · Front Turn Signal/drl Failure
Opened Aug 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
ON NOVEMBER 16, 2004, GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF 178,798 MODEL YEAR (MY) 2003 AND 2004 SATURN ION SEDAN VEHICLES FOR INOPERATIVE FRONT TURN SIGNAL/DRL BULBS.GM STATED THAT TEMPERATURES IN THE LAMP ASSEMBLY EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKETS AND BULB BASE SLEEVES, WHICH CAUSE DEFORMATION.THE DEFORMED SOCKETS CAN CAUSE LOSS OF BULB AND SOCKET CONTACT.THE DEFORMED SLEEVES CAN CAUSE STRESS CRACKS TO FORM ON THE BULB THAT CAN LEAD TO PREMATURE BULB FAILURE.THE RECALL REMEDY IS TO REPLACE THE FRONT TURN SIGNAL/DRL BULBS AND INSPECT FOR VOLTAGE-REDUCING JUMPER (WHICH REDUCES TEMPERATURE IN LAMP ASSEMBLY) AND ADD IF NOT PRESENT.SEE NHTSA RECALL NO. 04V547 FOR DETAILS.THE BULBS FOR THE TURN SIGNAL/DRL IN THE SATURN ION SEDAN AND ION COUPE ARE IDENTICAL IN DESIGN AND MADE BY THE SAME SUPPLIER.BUT THE TURN SIGNAL/DRL SOCKETS, WIRING AND HOUSING ARE DIFFERENT IN DESIGN FOR THE SEDAN AND COUPE, AND WERE MADE BY DIFFERENT SUPPLIERS.GM'S DATA SHOWS A LOWER OPERATING TEMPERATURE FOR THE COUPE'S LAMP ASSEMBLY THAT DOES NOT EXCEED THE MATERIAL SPECIFICATION FOR THE BULB SOCKET AND THE BULB BASE SLEEVE.COMPLAINT AND WARRANTY RATE IS ALSO LOWER FOR THE COUPE.HOWEVER, GM'S WARRANTY DATA SHOWS A CONTINUING TREND FOR THE COUPE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-035) FOR FURTHER INVESTIGATION OF THE MY 2003 AND 2004 SATURN ION COUPE VEHICLES.
Illustration