TAKATA RECALL, PARTS NOT AVAILABLE; PASSENGER SIDE OUTSIDE MIRROR FELL OFF WHILE CAR WAS PARKED; FUEL DOOR WILL NOT UNLOCK; AIR CONDITIONER MAKES A SQUEALING AND RATTLING NOISE; CAR IS SLOW TO ACCELERATE WHEN AIR CONDITIONER IS ON; OCCASIONALLY UNABLE TO TURN KEY IN IGNITION BECAUSE STEERING WHEEL LOCKS UP; ONE TIRE LOSES PRESSU…
Read full complaint
TAKATA RECALL, PARTS NOT AVAILABLE; PASSENGER SIDE OUTSIDE MIRROR FELL OFF WHILE CAR WAS PARKED; FUEL DOOR WILL NOT UNLOCK; AIR CONDITIONER MAKES A SQUEALING AND RATTLING NOISE; CAR IS SLOW TO ACCELERATE WHEN AIR CONDITIONER IS ON; OCCASIONALLY UNABLE TO TURN KEY IN IGNITION BECAUSE STEERING WHEEL LOCKS UP; ONE TIRE LOSES PRESSURE AND HAS TO HAVE AIR EVERY WEEK OR TWO; REPEATED PROBLEMS WITH LOUD EXHAUST. I AM THE ORIGINAL OWNER OF THE 2008 SATURN ASTRA AND IT HAS 48,600 MILES. I STARTED HAVING TROUBLE WITH THE CAR AFTER OWNING IT FOR 4 YEARS AND HAVE HAD BOTH NEW AND ONGOING PROBLEMS SINCE.
NHTSA ODI #10873459
Mileage unknown · Jun 6, 2016
Air Bags
TL* TAKATA RECALL. THE CONTACT OWNS A 2008 SATURN ASTRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS); HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED O…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2008 SATURN ASTRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS); HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #10872678
Mileage unknown · Jun 2, 2016
Air Bags
TL* TAKATA RECALL. THE CONTACT OWNS A 2008 SATURN ASTRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIF…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2008 SATURN ASTRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #10872069
Mileage unknown · May 31, 2016
Air Bags
2008 SATURN ASTRA. CONSUMER WRITES IN REGARDS TO CUSTOMER SERVICE DOES NOT HAVE A RESOLUTION TO REPAIR AIRBAG RECALL NOTICE AND REFUSAL TO PROVIDE A RENTAL VEHICLE. *SMD
NHTSA ODI #10870980
Mileage unknown · May 23, 2016
Air Bags
TL* THE CONTACT OWNS A 2008 SATURN ASTRA. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS) WAS RECEIVED IN MARCH OF 2016. AFTER CONTACTING THE DEALER AND THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REPAIR THE VEHICLE WERE STILL NOT AVAILABLE A…
Read full complaint
TL* THE CONTACT OWNS A 2008 SATURN ASTRA. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS) WAS RECEIVED IN MARCH OF 2016. AFTER CONTACTING THE DEALER AND THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REPAIR THE VEHICLE WERE STILL NOT AVAILABLE AND NO ESTIMATED TIME FOR RECEIVING THE PARTS COULD BE GIVEN. THE VIN WAS INVALID. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10870280
Mileage unknown · May 19, 2016
Air Bags
TL* THE CONTACT OWNS A 2008 SATURN ASTRA. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS) WAS RECEIVED IN FEBRUARY OF 2016. AFTER CONTACTING THE DEALER AND THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REPAIR THE VEHICLE WERE STILL NOT AVAILABL…
Read full complaint
TL* THE CONTACT OWNS A 2008 SATURN ASTRA. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS) WAS RECEIVED IN FEBRUARY OF 2016. AFTER CONTACTING THE DEALER AND THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REPAIR THE VEHICLE WERE STILL NOT AVAILABLE AND NO ESTIMATED TIME FOR RECEIVING THE PARTS COULD BE GIVEN. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10865755
Mileage unknown · May 17, 2016
Air Bags
TL* THE CONTACT OWNS A 2008 SATURN ASTRA. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS) WAS RECEIVED IN MARCH OF 2016. AFTER CONTACTING THE DEALER AND THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REPAIR THE VEHICLE WERE STILL NOT AVAILABLE A…
Read full complaint
TL* THE CONTACT OWNS A 2008 SATURN ASTRA. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS) WAS RECEIVED IN MARCH OF 2016. AFTER CONTACTING THE DEALER AND THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REPAIR THE VEHICLE WERE STILL NOT AVAILABLE AND NO ESTIMATED TIME FOR RECEIVING THE PARTS COULD BE GIVEN. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10865382
130,000 miles · Apr 19, 2016
Air Bags
TAKATA RECALL ON 4-14-16 I RECEIVED A RECALL NOTICE FROM SATURN WITH A DATE OF MARCH 2016. I CALLED SATURN AND THEY TOLD ME THERE IS NO REMEDY. I ASKED TO HAVE MY DEFECTIVE AIRBAG REMOVED. THEY CALLED THE DEALER WHILE I WAS ON THE PHONE AND SET UP APPOINTMENT ON 4-19-16 AT 9 AM AT HILTON HEAD AUTOMOTIVE. THE SERVICE MANAGER AT …
Read full complaint
TAKATA RECALL ON 4-14-16 I RECEIVED A RECALL NOTICE FROM SATURN WITH A DATE OF MARCH 2016. I CALLED SATURN AND THEY TOLD ME THERE IS NO REMEDY. I ASKED TO HAVE MY DEFECTIVE AIRBAG REMOVED. THEY CALLED THE DEALER WHILE I WAS ON THE PHONE AND SET UP APPOINTMENT ON 4-19-16 AT 9 AM AT HILTON HEAD AUTOMOTIVE. THE SERVICE MANAGER AT THE DEALER, MICHAEL CULP, TOLD ME THEY COULD NOT REMOVE MY DEFECTIVE AIR BAG BECAUSE IT WOULD PRESENT A LIABILITY FOR GM. HE STATED THAT SHOULD MY AIRBAG DEPLOY AND INJURE OR KILL ME, IT WOULD BE A LIABILITY FOR TAKATA AND NOT THEM. I OBTAINED A SIGNED WORK ORDER FROM SERVICE MANAGER, MICHAEL CULP SAYING THAT GM WILL NOT ALLOW THEM TO REMOVE THE AIR BAG.HE SAID THEY COULD TAKE THE CAR ON TRADE AS IS AND THAT THEY WOULD RESELL TO ANOTHER PERSON WITH THE DEFECTIVE AIR BAG. HE SAID IT IS NOT ILLEGAL TO RESELL. THIS IS APPALLING TO ME. THEY ADVISED THAT THERE IS NO REMEDY FOR MY AIRBAG AND CANNOT SAY IF OR WHEN A REPLACEMENT AIR BAG WILL BE AVAILABLE. I WANT TO KEEP MY CAR AND I WANT THE AIR BAG REMOVED UNTIL THEY CAN REINSTALL A SAFE AIRBAG.
NHTSA ODI #10860261
Mileage unknown · Apr 13, 2016
Air Bags
TAKATA RECALL. IT IS UNACCEPTABLE TO INFORM ME THAT MY CAR NEEDS TO BE RECALLED TO FIX THIS POTENTIALLY FATAL PROBLEM BUT TELL ME THE PARTS ARE UNAVAILABLE. EVERY DAY THEY DON'T HAVE THE PARTS, SOMEONE COULD BE KILLED.
NHTSA ODI #10855208
Mileage unknown · Apr 5, 2016
Air Bags
TL* TAKATA RECALL. THE CONTACT OWNS A 2008 SATURN ASTRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2008 SATURN ASTRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
General Motors LLC (GM) is recalling certain model year 2006-2011 Saab 9-3 vehicles manufactured May 31, 2002, to February 15, 2011, 2006-2009 Saab 9-5 vehicles manufactured June 7, 2005, to May 28, 2009, and 2008-2009 Saturn Astra vehicles manufactured April 11, 2007, to July 24, 2008. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the driver's frontal air bag inflator on Saab 9-3 and 9-5 vehicles and will replace the driver's frontal airbag module on Saturn Astra vehicles, free of charge. The recall began on March 1, 2017. Owners may contact Saab customer service at 1-800-955-9007 or Saturn customer service at 1-800-553-6000. GM's number for this recall is 28810.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
2008 Saturn Astra Problems, Complaints & Recalls | Skip That Year
Illustration