IllustrationBRAKES LEAKED AIR PRESSURE WHICH CAUSED THEM TO SEIZE. *PH WHEN THIS OCCURRED THE STEERING WHEEL BECAME VERY LOOSE AND THE VEHICLE WAS VERY HARD TO CONTROL. THE CAUSE OF THE AIR PRESSURE LEAK WAS UNDETERMINED. *NM
2004 Safari Coach Sahara
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sahara years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 3 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Air. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports0 injury reports
Service Brakes, Air complaints
1 reportsOfficial recalls
305V053000 · Suspension:rear:springs:leaf Spring Assembly
Feb 14, 2005
ON CERTAIN CLASS A MOTOR HOMES, THE SPACER PLATE UNDER THE TRAILING ARMS HAD A TRANSVERSE WELD WHICH CREATES A HEAT RISER AND CAUSE THE TRAILING ARMS TO CRACK.
Consequence & remedy
Consequence: THIS COULD CREATE ROUGH DRIVING CONDITIONS AND DAMAGE TO REAR SUSPENSION SYSTEM. THE DRIVER COULD LOOSE CONTROL OF THE MOTORHOME AND A CRASH COULD OCCUR WITHOUT PRIOR NOTICE.
Remedy: DEALERS WILL INSPECT THE REPLACE THE TRAILING ARMS FOR CRACKS AND REPLACING THE TRAILING ARMS AND U-BOLTS IN THE REAR SUSPENSION OF THE MOTORHOMES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 29, 2005. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.
04V038000 · Suspension:front
Jan 28, 2004
ON CERTAIN MOTORHOMES, THE I-BEAM LEAF IMITATOR IN THE FRONT AXLE SUSPENSION COULD CRACK AND BREAK DUE TO AN INADEQUATE WELDING PROCESS.
Consequence & remedy
Consequence: THE I-BEAMS ON THE FRONT AXLE AND THE PANARD BRACKET ON THE REAR AXLE COULD CRACK AND BREAK CAUSING THE DRIVER TO LOSE CONTROL OF THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ORIGINAL I-BEAM. ALSO, DEALERS WILL WELD THE STIFFENERS FROM THE PANARD BAR BRACKET TO THE CENTER DIFFERENTIAL OF THE REAR AXLE HOUSING. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT MONACO AT 1-877-466-6226.
03V526000 · Equipment:other:labels
Dec 12, 2003
CERTAIN 36', 38', AND 40' MOTOR HOMES FAIL TO COMPLY WITH REQUIREMENTS OF PART 567, "CERTIFICATION." THE REAR PSI STATES 85 OR 115 LBS. THE CORRECT REAR PSI IS 95 LBS.
Consequence & remedy
Consequence: UNDER OR OVER-INFLATED TIRES CAN CAUSE PREMATURE TIRE FAILURE AND COULD RESULT IN A SUDDEN BLOWOUT OR OTHER FAILURE RESULTING IN A LOSS OF CONTROL OF THE MOTORHOME.
Remedy: DEALERS WILL INSTALL THE CORRECT LABELS AT NO CHARGE. OWNER NOTIFICATION BEGAN JANUARY 7, 2004. OWNERS SHOULD CONTACT MONACO AT 1-877-477-6226.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.