TL* THE CONTACT OWNS A 2002 SAFARI COACH SAHARA. THE CONTACT STATED THAT BRAKE WARNING LIGHT ILLUMINATED AND THAT THE VEHICLE STALLED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 02V278000 (SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS…
Read full complaint
TL* THE CONTACT OWNS A 2002 SAFARI COACH SAHARA. THE CONTACT STATED THAT BRAKE WARNING LIGHT ILLUMINATED AND THAT THE VEHICLE STALLED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 02V278000 (SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE IGNITION SWITCH AND WIRING NEEDED TO BE REPLACED. THE REMEDY REPAIR FAILED. THE VEHICLE WAS TAKEN BACK TO AN INDEPENDENT MECHANIC WHERE TWO ABS SENSORS AND FOUR CALIPERS WERE REPLACED. THE CONTACT STATED THAT AFTER ALL THE REPAIRS THE BRAKE WARNING LIGHT CONTINUED TO ILLUMINATED AND THE BRAKES FAILED TO RESPOND. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN. UPDATED 9/11/14*CN UPDATED 1/15/15 *JS
NHTSA ODI #10608528
17,800 miles · Sep 11, 2012
Service Brakes
MY 2002 SAFARI SAHARA HAS ALREADY HAD THE BOSCH FRONT CALIPERS REPLACED IN 2004 OR 2005 BECAUSE OF STICKING AND CAUSING EXCESSIVE HEAT ON THE ROTORS WHICH COULD RESULT IN WHEEL FIRES. WHILE TRYING TO EVACUATE FROM NEW ORLEANS ON 9-3-12, THE FRONT BRAKES EXPERIENCED OVERHEATING AGAIN WHICH MEANT THAT I WAS UNABLE TO DRIVE MY MOTO…
Read full complaint
MY 2002 SAFARI SAHARA HAS ALREADY HAD THE BOSCH FRONT CALIPERS REPLACED IN 2004 OR 2005 BECAUSE OF STICKING AND CAUSING EXCESSIVE HEAT ON THE ROTORS WHICH COULD RESULT IN WHEEL FIRES. WHILE TRYING TO EVACUATE FROM NEW ORLEANS ON 9-3-12, THE FRONT BRAKES EXPERIENCED OVERHEATING AGAIN WHICH MEANT THAT I WAS UNABLE TO DRIVE MY MOTORHOME AWAY FROM THE PATH HURRICANE ISAAC. BOTH FRONT ROTORS GOT SO HOT THAT THE ABS SENSORS QUIT WORKING. I HAVE NOT CONTACTED MONACO BECAUSE I WILL MOST LIKELY GET ANOTHER RUN-AROUND LIKE LAST TIME THEY FIXED THE BRAKES. THE 1ST TIME THEY OVERHEATED WAS AFTER ONE OF THEIR AUTHORIZED MECHANICS TOOK BOTH CALIPERS APART AND PUT THEM BACK TOGETHER AGAIN STATING THERE WAS NOTHING WRONG WITH THEM. AFTER DRIVING ABOUT 5 MILES, BOTH FRONT WHEELS OVERHEATED. I DON'T KNOW WHAT KIND OF STATUTE OF LIMITATIONS RECALLS HAVE ON VEHICLES, BUT AFTER NOT DRIVING MY MOTOR HOME FOR ABOUT 1 YEAR, I SHOULD NOT HAVE TO WORRY ABOUT THE BRAKES OVERHEATING. *TR
ON CERTAIN CLASS A MOTOR HOMES, THE SPACER PLATE UNDER THE TRAILING ARMS HAD A TRANSVERSE WELD WHICH CREATES A HEAT RISER AND CAUSE THE TRAILING ARMS TO CRACK.
Consequence & remedy
Consequence: THIS COULD CREATE ROUGH DRIVING CONDITIONS AND DAMAGE TO REAR SUSPENSION SYSTEM. THE DRIVER COULD LOOSE CONTROL OF THE MOTORHOME AND A CRASH COULD OCCUR WITHOUT PRIOR NOTICE.
Remedy: DEALERS WILL INSPECT THE REPLACE THE TRAILING ARMS FOR CRACKS AND REPLACING THE TRAILING ARMS AND U-BOLTS IN THE REAR SUSPENSION OF THE MOTORHOMES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 29, 2005. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.
ON CERTAIN MOTOR HOMES, THE BRAKE ASSEMBLIES EXHIBIT ELEVATED TEMPERATURES THAT CAN LEAD TO CATASTROPHIC DETERIORATION OF THE WHEEL END COMPONENTS SUCH AS BEARINGS, RACES, SPINDLES, KNUCKLES, SEALS, HUBS, ROTORS, PATCH BOLTS, CALIPERS, BRAKE PADS, AND ABS SENSORS.
Consequence & remedy
Consequence: THIS COULD RESULT IN LOSS OF CONTROL, AND/OR THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSPECT THE FRONT AND REAR BRAKE CALIPERS FOR CORROSION AND REPLACE OR REBUILD THE CALIPERS AS NECESSARY. THE RECALL BEGAN ON AUGUST 18, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.
ON CERTAIN MOTOR HOMES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES, THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.
Consequence & remedy
Consequence: IF THE CLEVIS SEPARATED FROM THE PLATE WHILE THE VEHICLE WAS IN USE, THE VEHICLE WOULD RETURN TO IDLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THESE PEDALS. OWNER NOTIFICATION BEGAN SEPTEMBER 9, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-344-6332 OR WILLIAMS CONTROL AT 1-503-684-8600.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2002 Safari Coach Sahara Problems, Complaints & Recalls | Skip That Year
Illustration