IllustrationWHILE DRIVING HEARD A RADDLING NOISE, HAD IT CHECKED OUT. MAIN FRONT LEFT SPRING HAD FRACTURED. SPRING REPLACEMENT, 44 83-178.CONTACTED DEALER.*AK
1996 Saab 900
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all 900 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 6 of 48 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports3 fire reports0 injury reports
What owners actually said
48 reportsWILL NOT SHIFT INTO FIRST, FIFTH, OR REVERSE. KEY CANNOT BE REMOVED SINCE IT WILL NOT SHIFT INTO REVERSE. SAAB HAS REFUSED TO PAY FOR REPAIR.*AK
PLASTIC FUEL TANK IS LEAKING, DEALER AND THE MANUFACTURER WERE NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
S MODEL, CONSUMER SMELLED FUEL, DEALER DETERMINED THE PLASTIC FUEL TANK WAS LEAKING. PART WAS REPLACED, NEW FUEL TANK HAS LEAKED TWICE.*JB
INTERMITTENTLY GEARBOX LIGHT WILL LIGHT, CAUSING VEHICLE TO LOSE 1ST AND SECOND GEAR. THIS IS A SAFETY ISSUE AS VEHICLE MAY NOT GET UP TO HIGHTWAY SPEEDS AT RAMPS, ALMOST CAUSING A REAR END COLLISION. THIS IS A KNOW ISSUE W/ SAAB. I CONTACTED THEM REGARDING THIS PROBLEM. THEY STATED THERE ARE NO SAFETY ISSUES OPEN ON THIS VE…
Read full complaint
INTERMITTENTLY GEARBOX LIGHT WILL LIGHT, CAUSING VEHICLE TO LOSE 1ST AND SECOND GEAR. THIS IS A SAFETY ISSUE AS VEHICLE MAY NOT GET UP TO HIGHTWAY SPEEDS AT RAMPS, ALMOST CAUSING A REAR END COLLISION. THIS IS A KNOW ISSUE W/ SAAB. I CONTACTED THEM REGARDING THIS PROBLEM. THEY STATED THERE ARE NO SAFETY ISSUES OPEN ON THIS VEHICLE. OVER 25 POSTS FOR THIS SAME PROBLEM ON SAABNET.COM. DEALER HAS TRIED TO REPAIR VEHICLE TWICE WITHOUT SUCCESS. I HAVE SPENT OVER $800.00 TRYING TO REPAIR THIS SAFETY PROBLEM . PLEASE HELP. *AK
THIS CAR HAS BEEN NOTHING BUT A NIGHTMARE. IT HAS REQUIRED THREE TOWS FROM JUNE 2001 TO FEBRUARY 2002. THE MOST EXPENSIVE FAILURE OCCURRED THE DAY AFTER I HAD TAKEN THE CAR TO A LOCAL DEALER FOR A ROUTINE OIL CHANGE (INTERNATIONAL MOTORS, FALLS CHURCH, VA), AND THE TRANSMISSION AND CLUTCH FAILED BECAUSE THERE WAS A TRANSMISSION …
Read full complaint
THIS CAR HAS BEEN NOTHING BUT A NIGHTMARE. IT HAS REQUIRED THREE TOWS FROM JUNE 2001 TO FEBRUARY 2002. THE MOST EXPENSIVE FAILURE OCCURRED THE DAY AFTER I HAD TAKEN THE CAR TO A LOCAL DEALER FOR A ROUTINE OIL CHANGE (INTERNATIONAL MOTORS, FALLS CHURCH, VA), AND THE TRANSMISSION AND CLUTCH FAILED BECAUSE THERE WAS A TRANSMISSION FLUID LEAK THAT WAS NOT CAUGHT BY THEIR MECHANICS. I HAVE CONTACTED SAAB CORPORATE BY LETTER IN DECEMBER 2001 ABOUT MY MULTIPLE PROBLEMS WITH THIS CAR. THEIR RESPONSE BY TELEPHONE WAS THAT THERE WAS NOTHING THAT THEY COULD DO. *AK
WHILE TRAVELING 60MPH TRANSMISSION BECAME LOCKED IN GEAR. WAS NOT ABLE TO SHIFT INTO ANOTHER GEAR. HAD REMAINED IN 4TH GEAR UNTIL ABLE TO SHIFT. TOOK VEHICLE TO SERVICE STATION, AND MECHANIC COULD NOT LOCATE ANY PROBLEMS. TAKING VEHICLE TO DEALERSHIP.*AK
TIMING CHAIN HAS TO BE REPLACED AFTER 75,000 MILES. VEHICLE WAS MAKING A LOUD WARNING NOISE. SAAB DEALER FOUND PROBLEM AFTER DOING A ROUTINE SERVICE CHECK. ALTHOUGH THE PROBLEM HAS BEEN FOUND, DEALER HAS NEVER DONE REPAIRS. *AK
SAAB CARS USA REFUSES TO PAY FOR A MANUFACTURER DEFECT. I HAVE HAD THE CLUTCH PLATE EXAMINED BY SPECIALISTS AND THEY ALL THINK THIS IS AN OBVIOUS MANUFACTURER DEFECT. MOST EXPERTS HAVE NEVER SEEN A CLUTCH PLATE SPLIT IN HALF LIKE THIS. THE DEBRIS FROM THE CLUTCH DISINTEGRATING BLEW INTO THE TRANSMISSION HOUSING CAUSING A HOLE…
Read full complaint
SAAB CARS USA REFUSES TO PAY FOR A MANUFACTURER DEFECT. I HAVE HAD THE CLUTCH PLATE EXAMINED BY SPECIALISTS AND THEY ALL THINK THIS IS AN OBVIOUS MANUFACTURER DEFECT. MOST EXPERTS HAVE NEVER SEEN A CLUTCH PLATE SPLIT IN HALF LIKE THIS. THE DEBRIS FROM THE CLUTCH DISINTEGRATING BLEW INTO THE TRANSMISSION HOUSING CAUSING A HOLE. THE EXTENDED WARRANTY COMPANY REFUSES TO PAY FOR THE TRANSMISSION BECAUSE IT WAS CAUSED BY THE CLUTCH EXPLODING. I SENT PHOTOS TO SAAB AND THREE SEPARATE LETTERS REQUESTING THEY FIX THIS PROBLEM TO NO AVAIL. I HAVE ALL THE DOCUMENTATION TO SUPPORT THESE FACTS.*AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
Official recalls
398V038000 · Exterior Lighting:headlights
Feb 24, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE INSTRUCTIONS FOR PROPERLY AIMING THE HEADLIGHTING SYSTEM WERE OMITTED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY NOT BE ABLE TO PROPERLY AIM THE HEADLIGHTS.
Remedy: OWNERS WILL BE SENT AIMING INSTRUCTIONS, AND DIRECTIONS FOR AFFIXING THESE INSERTS TO THE OWNER GUIDES. IF AN OWNER SO DESIRES, A DEALER CAN AFFIX THE INSERTS IN THEIR OWNER GUIDE FOR THEM.
97V046000 · Vehicle Speed Control
Mar 21, 1997
CORROSION AROUND THE ZINC-COATED THROTTLE CONTROL LEVER BUSHING CAN CAUSE THE THROTTLE LEVER TO BIND.
Consequence & remedy
Consequence: THIS BINDING CAN RESULT IN THE THROTTLE PLATE NOT RETURNING TO THE CLOSED POSITION WHEN THE THROTTLE PEDAL IS RELEASED AND A SUBSEQUENT LOSS OF THROTTLE CONTROL.
Remedy: DEALERS WILL REPLACE THE ZINC-COATED THROTTLE CONTROL LEVER BUSHING WITH A NICKEL-COATED BUSHING AND BOLT.
96V077000 · Seat Belts:front:anchorage
May 3, 1996
DURING STATIC TESTING OF BELT ANCHORAGE POINTS, THE OUTBOARD ATTACHMENT PLATE BEING USED IN THE TESTING DEFORMED AND DETACHED FROM THE SEAT ANCHORAGE. THIS DOES NOT COMPLY WITH FMVSS NO. 209, "SEAT BELT ASSEMBLIES" AND NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE BELT MAY NOT LATCH PROPERLY INCREASING THE RISK OF INJURY TO AN OCCUPANT SHOULD A VEHICLE CRASH OCCUR.
Remedy: DEALERS WILL INSPECT THE SAFETY BELT ASSEMBLIES FOR THE DATE OF MANUFACTURE. ANY ASSEMBLY WITH DATE YEAR 96 WEEK 10 DAY 2 WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP00008 · Defective Water Pump Pulley
Opened Sep 25, 2000 · Closed Nov 19, 2001
Status: closed (inferred from source dates) · Engine And Engine Cooling
a
SQ98018 · New Wheel Bolts
Opened Oct 9, 1998 · Closed Oct 27, 1998
Status: closed (inferred from source dates) · Wheels
saab issued a tsb informing dealers about a new wheel mounting bolt.If the issue is loosening of the lug nut, this could lead to bolt fatigue and the potential for a wheel separation.