Electrical SystemFuel/propulsion SystemVehicle Speed Control
I WAS DRIVING APPROXIMATELY 30-35 MPH DOWN A FOUR LANE ROAD WHEN THE CAR STALLED LEAVING ME WITH NO POWER AT THE ACCELERATOR. IT BECAME VERY DIFFICULT TO STEER THE CAR AND THE BRAKE PEDAL BECAME VERY HARD TO DEPRESS. LUCKILY I WAS ABLE TO COAST OFF THE ROAD WHERE THE CAR CAME TO A COMPLETE STOP BLOCKING THE ENTRANCE/EXIT OF A …
Read full complaint
I WAS DRIVING APPROXIMATELY 30-35 MPH DOWN A FOUR LANE ROAD WHEN THE CAR STALLED LEAVING ME WITH NO POWER AT THE ACCELERATOR. IT BECAME VERY DIFFICULT TO STEER THE CAR AND THE BRAKE PEDAL BECAME VERY HARD TO DEPRESS. LUCKILY I WAS ABLE TO COAST OFF THE ROAD WHERE THE CAR CAME TO A COMPLETE STOP BLOCKING THE ENTRANCE/EXIT OF A GAS STATION. I WAS LESS THEN 200 FEET FROM WHERE I WAS TURNING ONTO THE ENTRANCE RAMP OF A HIGHWAY. THE GAS STATION ATTENDANT WAS VERY UPSET TELLING ME I CAN NOT LEAVE MY CAR THERE. THE CAR WOULD NOT START AFTER SEVERAL ATTEMPTS. THE CAR WAS TOWED TO THE MECHANIC. THE CAR HAS BEEN AT THE SERVICE STATION FOR OVER 2 WEEKS NOW. THE TECHNICIAN IS UNABLE TO FIND THE REASON THE CAR STALLED. HOWEVER HE EXPLAINED THAT THE FUEL PUMP AND THE FUEL PUMP RELAY ARE OPERATIONAL. HE ALSO EXPLAINED THAT THERE IS NO ELECTRICITY GETTING TO THE FUEL PUMP. HE HAS ALREADY REPLACED THE CRANKSHAFT POSITION SENSOR AND IS IN THE PROCESS OF CHECKING ALL SENSORS AND RELAYS. DURING MY OWN RESEARCH, I HAVE FOUND THAT THESE CARS HAVE FAULTY ELECTRICAL SYSTEMS WITH MANY RECALLS ON THE DIRECT IGNITION CASSETTE (DIC). AT THIS POINT, WE DO NOT KNOW WHAT CAUSED THE PROBLEM. I AM A SINGLE MOTHER WITH 2 YOUNG CHILDREN AND RELY ON THIS AUTOMOBILE ON A DAILY BASIS. IN FACT, I HAD JUST DROPPED MY DAUGHTER (9 YEARS OLD) OFF AT DANCING SCHOOL. I WAS JUST ON THE HIGHWAY 20 MINUTES PRIOR TO DROPPING MY DAUGHTER OFF AT DANCING SCHOOL. I AM EXTREMELY CONCERNED THAT THIS WILL HAPPEN AGAIN. I CAN NOT AFFORD TO HAVE THIS PROBLEM HAPPEN WITHOUT CAUSE AND WARNING. WOULD YOU PLEASE FORWARD ME ANY INFORMATION VIA E-MAIL OR REGULAR MAIL THAT WOULD HELP ASSURE ME THIS PROBLEM WILL NEVER HAPPEN AGAIN. IF YOU KNOW THIS CAR IS PROBLEMATIC THEN PLEASE INFORM ME TO SELL THE CAR SO I CAN GET A MORE RELIABLE CAR THAT WILL PREVENT THE RISK OF INJURY OR DEATH TO ME AND MY FAMILY. *TR
NHTSA ODI #10496946
3,000 miles · Dec 9, 2004
Electrical SystemEngine And Engine CoolingStructure
THE VEHICLE STALLED ON 4 SEPARATE OCCASIONS FROM VARIOUS SPEEDS OF 25 MPH OR MORE WHILE DRIVING. THE VEHICLE HAS BEEN TO THE DEALER ON 3 SEPARATE OCCASIONS. THE DEALER HAS CLEANED AND TIGHTENED THE BATTERY CABLES, THE FIRST TIME, THEY REPLACED THE CRANK SENSOR, T-7 AND THE IGNITION SWITCH, THE SECOND TIME AND THE THIRD TIME, T…
Read full complaint
THE VEHICLE STALLED ON 4 SEPARATE OCCASIONS FROM VARIOUS SPEEDS OF 25 MPH OR MORE WHILE DRIVING. THE VEHICLE HAS BEEN TO THE DEALER ON 3 SEPARATE OCCASIONS. THE DEALER HAS CLEANED AND TIGHTENED THE BATTERY CABLES, THE FIRST TIME, THEY REPLACED THE CRANK SENSOR, T-7 AND THE IGNITION SWITCH, THE SECOND TIME AND THE THIRD TIME, THEY WERE UNABLE TO DUPLICATE THE PROBLEM. *JB THE ECM WAS REPLACED BUT THE VEHICLE STALLED AGAIN, THE CUP HOLDER CRACK AND HAD BROKEN, THE BATTERY CABLES WERE LOOSE AND DIRTY, THE TRANSMISSION DID NOT SHIFT PROPERLY AND CAUSED A JERKING MOTION, THE ELECTRICAL GAUGES DROPPED AND THE VEHICLE LOST ACCELERATION. *SC
SAAB IS RECALLING 57,389 MY 2002-2008 9-5 SERIES VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING COMPLIANCE TESTING, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENTS.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL INSTALL A-PILLAR TRIM WITH IMPROVED ENERGY-ABSORBING CAPABILITY FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 25, 2008. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.
Consequence & remedy
Consequence: OVER TIME, THIS COULD CAUSE THE FUEL LINES TO LOOSEN FROM THE PUMP RESULTING IN FUEL LEAKAGE. IF AN IGNITION SOURCE WERE PRESENT, THE FUEL MAY IGNITE RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL DEVELOP A SECURING BRACKET THAT WILL SECURE THE FUEL LINES TO THE FUEL PUMP EVEN IF THE PLASTIC RETAINING TABS SHOULD BREAK. THE RECALL BEGAN ON JUNE 13, 2007. THIS IS AN EXPANSION OF PREVIOUS RECALL CAMPAIGNS - SEE 04V557 AND 06V126. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
CERTAIN PASSENGER VEHICLES EQUIPPED WITH B308 6-CYLINDER GASOLINE ENGINES MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IGNITION DISCHARGE MODULE (IDM) DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.
Consequence & remedy
Consequence: OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING. ENGINE STALLING MAY OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT TO SEE WHAT VERSION IDM IS IN THE VEHICLE AND REPLACE THE IDM IF IT IS A VERSION BUILT PRIOR TO JANUARY 2003. THE RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2005. OWNERS MAY CONTACT SAAB AT 1-800-955-9007. NOTE: THIS RECALL IS AN EXPANSION OF A PREVIOUS CAMPAIGN (PLEASE SEE 05V399).
ON CERTAIN PASSENGER VEHICLES, IF AN OWNER CHANGES THEIR WHEELS/TIRES BETWEEN SUMMER AND WINTER USING A STEEL WHEEL IN THE WINTER AND AN ALLOY WHEEL IN THE SUMMER, IT IS POSSIBLE FOR RUST AND CONTAMINATION TO BUILD UP ON THE WHEEL HUB DURING THE STEEL WHEEL USAGE. IF THIS OCCURS AND THE CONTAMINATION IS NOT REMOVED, IT IS POSSIBLE THAT AFTER THE TIRE CHANGE SERVICE, SOME OF THIS CONTAMINATION COULD FLAKE OR GRIND AWAY RESULTING IN REDUCED CLAMPING FORCE OF THE WHEEL TO THE HUB. OVER SEVERAL SEASONS, IT IS POSSIBLE THAT THIS REDUCED FORCE COULD RESULT IN FRACTURES DEVELOPING IN THE WHEEL BOLTS DUE TO WHEEL TO HUB MOVEMENT.
Consequence & remedy
Consequence: THESE FRACTURES WOULD RESULT IN WHEEL BOLT BREAKAGE, ALLOWING THE WHEEL TO DETACH FROM THE WHEEL HUB, INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE CONTACTED BY MAIL AND ASKED WHETHER THEY CHANGE BETWEEN STEEL AND ALLOY WHEELS. IF THEY DO ENGAGE IN THIS PRACTICE, THEY WILL BE INSTRUCTED TO BRING THEIR CARS TO AN AUTHORIZED DEALER. THE DEALER WILL REMOVE THE WHEELS, CLEAN ANY CONTAMINATION FROM THE WHEEL AND WHEEL HUB, AND REPLACE THE WHEELS USING NEW IMPROVED BOLTS WITH ATTACHED WASHERS. OWNER NOTIFICATION BEGAN MARCH 31, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAAB AT 1-800-955-9007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2003 Saab 9-5 Problems, Complaints & Recalls | Skip That Year
Illustration