IllustrationAFTER DRIVING MY CAR TO MY DESTINATION, I PUT THE CAR IN PARK BUT THE CAR WON'T STAY IN PARK. THE CAR POPS OUT OF PARK INTO REVERSE, THEN IT WON'T START WHEN I GET BACK INTO MY CAR. *TR
2003 Saab 9-5
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all 9-5 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
40–25K
525–50K
750–75K
975–100K
6100–150K
0150K+
31 reports with mileage · 16 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports1 injury reports
Power Train complaints
3 reportsMY CAR WAS BUILT IN 2002 AS WELL AS OTHERS REPORTED, I PURCHASED IT USED 3 YEARS AGO WITH 64K MILES. MY DIRECT IGNITION CONTROL IN 2003 9-5 LINEAR SEDAN 2.3T CEASED. UPON RESEARCH, MY DIC IS THE ORIGINAL PART 9197559 TK3.6 2000-2002 ARE RECALLED AND 'SOME' 2003 VIN'S. WITH THE OVER ABUNDANCE OF DIC FAILURES WITH THE EXACT SAM…
Read full complaint
MY CAR WAS BUILT IN 2002 AS WELL AS OTHERS REPORTED, I PURCHASED IT USED 3 YEARS AGO WITH 64K MILES. MY DIRECT IGNITION CONTROL IN 2003 9-5 LINEAR SEDAN 2.3T CEASED. UPON RESEARCH, MY DIC IS THE ORIGINAL PART 9197559 TK3.6 2000-2002 ARE RECALLED AND 'SOME' 2003 VIN'S. WITH THE OVER ABUNDANCE OF DIC FAILURES WITH THE EXACT SAME PART NUMBER, THESE NEED TO BE RECALLED AS A WHOLE. UPON REMOVAL OF THE DIC, THE ENGINE IS LEAKING AT THE SEAMS OF THE HEAD FROM WHERE THE BOLTS ARE LOCATED, INSIDE THE DIC AND ENGINE SECTION IS PERFECTLY CLEAN. BOLTS IN THE HEAD OF THE ENGINE LOOSE, 1 WAS LIFTED OUT ENOUGH TO JUST REMOVE STRAIGHT OUT. CAR BLOWS BLUEISH SMOKE WHEN IT WAS STARTING, SWITCHES ARE DEFECTIVE (GM KNOWN ISSUE), OIL / ENGINE / HEAD KNOWN ISSUES, SUSPENSION KNOWN ISSUES (AMONG OTHER SERIOUS SAAB FAILURES). I HAVE SPENT THOUSANDS OF DOLLARS ON THIS VEHICLE SINCE PURCHASE. THE KNOWN RECALLS MUST BE EXPANDED TO INCLUDE THE PARTS, NOT JUST 'YEAR' OR 'SPECIFIC VIN'. THIS WAS SUPPOSED TO BE A SAFE, RELIABLE CAR BUT INSTEAD IS CAUSING SERIOUS FINANCIAL ISSUES. PLEASE HELP THE OWNERS ALL OVER THE WORLD, WE SHOULD NOT HAVE TO PAY FOR ALL OF THIS.. WE ALREADY PAID FOR THEIR 'BAILOUT'! SINCERELY~ CAN NOT TAKE ANY MORE REPAIRS!!! *TT
2003 SAAB 9-5 AERO TRANSMISSION LEAKING DIRECTLY THROUGH PORES IN METAL CASING (NOT SEAM OR GASKET) AT LESS THAN 51000 MILES (LESS THAN 1000 MILES OVER WARRANTY) REQUIRING FULL TRANSMISSION REPLACEMENT. SAAB USA OFFERS TO PAY ONE THIRD ($1700) OF $5100 ESTIMATED COST. ALTHOUGH CAR HAD BEEN IN A WRECK WHEN IT WAS ABOUT A YEAR O…
Read full complaint
2003 SAAB 9-5 AERO TRANSMISSION LEAKING DIRECTLY THROUGH PORES IN METAL CASING (NOT SEAM OR GASKET) AT LESS THAN 51000 MILES (LESS THAN 1000 MILES OVER WARRANTY) REQUIRING FULL TRANSMISSION REPLACEMENT. SAAB USA OFFERS TO PAY ONE THIRD ($1700) OF $5100 ESTIMATED COST. ALTHOUGH CAR HAD BEEN IN A WRECK WHEN IT WAS ABOUT A YEAR OLD, THIS COULD NOT BE RELATED. ALL RECOMMENDED MAINTENANCE WAS PERFORMED BY THE DEALER AT OR BEFORE THE PRESCRIBED MILEAGE WAS REACHED.*JB
Official recalls
408V160000 · Seats:front Assembly:head Restraint
Apr 9, 2008
SAAB IS RECALLING 57,389 MY 2002-2008 9-5 SERIES VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING COMPLIANCE TESTING, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENTS.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL INSTALL A-PILLAR TRIM WITH IMPROVED ENERGY-ABSORBING CAPABILITY FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 25, 2008. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
07V087000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Mar 7, 2007
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.
Consequence & remedy
Consequence: OVER TIME, THIS COULD CAUSE THE FUEL LINES TO LOOSEN FROM THE PUMP RESULTING IN FUEL LEAKAGE. IF AN IGNITION SOURCE WERE PRESENT, THE FUEL MAY IGNITE RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL DEVELOP A SECURING BRACKET THAT WILL SECURE THE FUEL LINES TO THE FUEL PUMP EVEN IF THE PLASTIC RETAINING TABS SHOULD BREAK. THE RECALL BEGAN ON JUNE 13, 2007. THIS IS AN EXPANSION OF PREVIOUS RECALL CAMPAIGNS - SEE 04V557 AND 06V126. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
06V410000 · Electrical System:ignition:module
Oct 26, 2006
CERTAIN PASSENGER VEHICLES EQUIPPED WITH B308 6-CYLINDER GASOLINE ENGINES MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IGNITION DISCHARGE MODULE (IDM) DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.
Consequence & remedy
Consequence: OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING. ENGINE STALLING MAY OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT TO SEE WHAT VERSION IDM IS IN THE VEHICLE AND REPLACE THE IDM IF IT IS A VERSION BUILT PRIOR TO JANUARY 2003. THE RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2005. OWNERS MAY CONTACT SAAB AT 1-800-955-9007. NOTE: THIS RECALL IS AN EXPANSION OF A PREVIOUS CAMPAIGN (PLEASE SEE 05V399).
03V006000 · Wheels:hub
Jan 13, 2003
ON CERTAIN PASSENGER VEHICLES, IF AN OWNER CHANGES THEIR WHEELS/TIRES BETWEEN SUMMER AND WINTER USING A STEEL WHEEL IN THE WINTER AND AN ALLOY WHEEL IN THE SUMMER, IT IS POSSIBLE FOR RUST AND CONTAMINATION TO BUILD UP ON THE WHEEL HUB DURING THE STEEL WHEEL USAGE. IF THIS OCCURS AND THE CONTAMINATION IS NOT REMOVED, IT IS POSSIBLE THAT AFTER THE TIRE CHANGE SERVICE, SOME OF THIS CONTAMINATION COULD FLAKE OR GRIND AWAY RESULTING IN REDUCED CLAMPING FORCE OF THE WHEEL TO THE HUB. OVER SEVERAL SEASONS, IT IS POSSIBLE THAT THIS REDUCED FORCE COULD RESULT IN FRACTURES DEVELOPING IN THE WHEEL BOLTS DUE TO WHEEL TO HUB MOVEMENT.
Consequence & remedy
Consequence: THESE FRACTURES WOULD RESULT IN WHEEL BOLT BREAKAGE, ALLOWING THE WHEEL TO DETACH FROM THE WHEEL HUB, INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE CONTACTED BY MAIL AND ASKED WHETHER THEY CHANGE BETWEEN STEEL AND ALLOY WHEELS. IF THEY DO ENGAGE IN THIS PRACTICE, THEY WILL BE INSTRUCTED TO BRING THEIR CARS TO AN AUTHORIZED DEALER. THE DEALER WILL REMOVE THE WHEELS, CLEAN ANY CONTAMINATION FROM THE WHEEL AND WHEEL HUB, AND REPLACE THE WHEELS USING NEW IMPROVED BOLTS WITH ATTACHED WASHERS. OWNER NOTIFICATION BEGAN MARCH 31, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAAB AT 1-800-955-9007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.