CAR RUNS PERFECTLY AND AT HIGHWAY SPEEDS WILL RANDOMLY STALL. IF YOU CAN MANAGE TO NOT GET INTO AN ACCIDENT THE CAR WILL START RIGHT BACK UP AFTER YOU TURN OFF THE KEY AND RESTART. SOMETIMES EVERY COUPLE OF MILES, AND CAN GO SEVERAL MILES WITHOUT THE STALL. SEEMS TO ONLY HAPPEN AT CONSTANT SPEEDS. THIS IS A VERY DANGEROUS PR…
Read full complaint
CAR RUNS PERFECTLY AND AT HIGHWAY SPEEDS WILL RANDOMLY STALL. IF YOU CAN MANAGE TO NOT GET INTO AN ACCIDENT THE CAR WILL START RIGHT BACK UP AFTER YOU TURN OFF THE KEY AND RESTART. SOMETIMES EVERY COUPLE OF MILES, AND CAN GO SEVERAL MILES WITHOUT THE STALL. SEEMS TO ONLY HAPPEN AT CONSTANT SPEEDS. THIS IS A VERY DANGEROUS PROBLEM. DIAGNOSTIC CODES ARE P1230 AND P1261, BUT I THINK THESE ARE RESULTS OF THE SUDDEN STALL, AND NOT THE PROBLEM. *TR UPDATED 03/10/09. *LJ
NHTSA ODI #10257023
54,000 miles · Nov 4, 2008
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2003 SAAB 9-5. WHILE THE CONTACT'S DAUGHTER WAS DRIVING APPROXIMATELY 65 MPH, THE VEHICLE SHUT OFF AND WOULD NOT RESTART. THE VEHICLE WAS TOWED TO A MECHANIC AND THEY STATED THAT THE FUEL PUMP FAILED AND NEEDED TO BE REPLACED. THREE WEEKS LATER, THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID …
Read full complaint
TL*THE CONTACT OWNS A 2003 SAAB 9-5. WHILE THE CONTACT'S DAUGHTER WAS DRIVING APPROXIMATELY 65 MPH, THE VEHICLE SHUT OFF AND WOULD NOT RESTART. THE VEHICLE WAS TOWED TO A MECHANIC AND THEY STATED THAT THE FUEL PUMP FAILED AND NEEDED TO BE REPLACED. THREE WEEKS LATER, THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V087000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS). APPROXIMATELY ONE YEAR LATER, THE MECHANIC STATED THAT THE FUEL PUMP FAILED AGAIN. THE CURRENT MILEAGE WAS 60,000 AND FAILURE MILEAGE WAS 54,000.
NHTSA ODI #10247639
Mileage unknown · Jul 6, 2007
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2003 SAAB 9-5. ON JULY 6, 2007, THE CONTACT RECEIVED RECALL NOTICE # 07V087000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS). THE VEHICLE IS CURRENTLY LOCATED IN SPAIN. THE MANUFACTURER STATED THAT THEY ARE NOT OBLIGATED TO REPAIR THE VEHICLE FOR FREE BECAUSE IT IS LOCATED OUTSIDE OF…
Read full complaint
TL*THE CONTACT OWNS A 2003 SAAB 9-5. ON JULY 6, 2007, THE CONTACT RECEIVED RECALL NOTICE # 07V087000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS). THE VEHICLE IS CURRENTLY LOCATED IN SPAIN. THE MANUFACTURER STATED THAT THEY ARE NOT OBLIGATED TO REPAIR THE VEHICLE FOR FREE BECAUSE IT IS LOCATED OUTSIDE OF THE UNITED STATES. THE MANUFACTURER ALSO REFUSED TO PROVIDE THE CONTACT WITH A COPY OF THE RECALL NOTICE IN SPANISH. THE CURRENT MILEAGE WAS 48,063 AND THERE HAD BEEN NO FAILURE TO DATE.
NHTSA ODI #10195511
32,200 miles · Mar 10, 2007
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
DRIVING ON THE INTERSTATE - EXITED ONTO AN INTERCHANGE RAMP AT 50 MPH - AND THE ENGINE STALLED WITHOUT WARNING. VEHICLE AT REAR NEARLY REAR-ENDED MINE - BUT MISSED BY A HAIRS WHISKER. ANOTHER PIECE OF LUCK WAS THAT I WAS AT THE CREST OF THE RAMP SO MANAGED TO "COAST" TOWARDS THE SHOULDER. WAITED FOR A BIT - THE CAR WOULDN'T…
Read full complaint
DRIVING ON THE INTERSTATE - EXITED ONTO AN INTERCHANGE RAMP AT 50 MPH - AND THE ENGINE STALLED WITHOUT WARNING. VEHICLE AT REAR NEARLY REAR-ENDED MINE - BUT MISSED BY A HAIRS WHISKER. ANOTHER PIECE OF LUCK WAS THAT I WAS AT THE CREST OF THE RAMP SO MANAGED TO "COAST" TOWARDS THE SHOULDER. WAITED FOR A BIT - THE CAR WOULDN'T RESTART. HAD TO SPEND PERILOUS TIME ON THE LEFT SHOULDER BEFORE GETTING MY CAR TOWED. AT THE TIME OF WRITING - THE CAR IS SITTING IN THE DEALERS LOT. NOTHING SPECIAL HAPPENED PRIOR TO THIS INCIDENT. PREVIOUSLY A SIMILAR INCIDENT HAD OCCURRED JUST OUTSIDE MY RESIDENCE - AND THE DEALER CHECKED IT OUT AND SAID IT MIGHT JUST BE "BAD GAS". SAAB'S CUSTOMER ASSISTANCE PROGRAM WAS USELESS. BASED ON THE OTHER INCIDENTS REPORTED - REFER TO ODI #S: 10162804, 10137685, 10097342 - THERE IS SOMETHING DEFINITELY WRONG WITH THIS VEHICLE. PLEASE TAKE ACTION BEFORE SOMEONE LOSES THEIR LIFE.*JB
SAAB IS RECALLING 57,389 MY 2002-2008 9-5 SERIES VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING COMPLIANCE TESTING, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENTS.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL INSTALL A-PILLAR TRIM WITH IMPROVED ENERGY-ABSORBING CAPABILITY FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 25, 2008. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.
Consequence & remedy
Consequence: OVER TIME, THIS COULD CAUSE THE FUEL LINES TO LOOSEN FROM THE PUMP RESULTING IN FUEL LEAKAGE. IF AN IGNITION SOURCE WERE PRESENT, THE FUEL MAY IGNITE RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL DEVELOP A SECURING BRACKET THAT WILL SECURE THE FUEL LINES TO THE FUEL PUMP EVEN IF THE PLASTIC RETAINING TABS SHOULD BREAK. THE RECALL BEGAN ON JUNE 13, 2007. THIS IS AN EXPANSION OF PREVIOUS RECALL CAMPAIGNS - SEE 04V557 AND 06V126. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
CERTAIN PASSENGER VEHICLES EQUIPPED WITH B308 6-CYLINDER GASOLINE ENGINES MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IGNITION DISCHARGE MODULE (IDM) DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.
Consequence & remedy
Consequence: OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING. ENGINE STALLING MAY OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT TO SEE WHAT VERSION IDM IS IN THE VEHICLE AND REPLACE THE IDM IF IT IS A VERSION BUILT PRIOR TO JANUARY 2003. THE RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2005. OWNERS MAY CONTACT SAAB AT 1-800-955-9007. NOTE: THIS RECALL IS AN EXPANSION OF A PREVIOUS CAMPAIGN (PLEASE SEE 05V399).
ON CERTAIN PASSENGER VEHICLES, IF AN OWNER CHANGES THEIR WHEELS/TIRES BETWEEN SUMMER AND WINTER USING A STEEL WHEEL IN THE WINTER AND AN ALLOY WHEEL IN THE SUMMER, IT IS POSSIBLE FOR RUST AND CONTAMINATION TO BUILD UP ON THE WHEEL HUB DURING THE STEEL WHEEL USAGE. IF THIS OCCURS AND THE CONTAMINATION IS NOT REMOVED, IT IS POSSIBLE THAT AFTER THE TIRE CHANGE SERVICE, SOME OF THIS CONTAMINATION COULD FLAKE OR GRIND AWAY RESULTING IN REDUCED CLAMPING FORCE OF THE WHEEL TO THE HUB. OVER SEVERAL SEASONS, IT IS POSSIBLE THAT THIS REDUCED FORCE COULD RESULT IN FRACTURES DEVELOPING IN THE WHEEL BOLTS DUE TO WHEEL TO HUB MOVEMENT.
Consequence & remedy
Consequence: THESE FRACTURES WOULD RESULT IN WHEEL BOLT BREAKAGE, ALLOWING THE WHEEL TO DETACH FROM THE WHEEL HUB, INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE CONTACTED BY MAIL AND ASKED WHETHER THEY CHANGE BETWEEN STEEL AND ALLOY WHEELS. IF THEY DO ENGAGE IN THIS PRACTICE, THEY WILL BE INSTRUCTED TO BRING THEIR CARS TO AN AUTHORIZED DEALER. THE DEALER WILL REMOVE THE WHEELS, CLEAN ANY CONTAMINATION FROM THE WHEEL AND WHEEL HUB, AND REPLACE THE WHEELS USING NEW IMPROVED BOLTS WITH ATTACHED WASHERS. OWNER NOTIFICATION BEGAN MARCH 31, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAAB AT 1-800-955-9007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2003 Saab 9-5 Problems, Complaints & Recalls | Skip That Year
Illustration