2003 Saab 9-5

I HAVE BEEN GETTING CONSTANT CHECK ENGINE CODES THAT RELATE TO THE DI CASSETTE. THE DIRECT IGNITION CASSETTE RECALL THAT SAAB HAS INITIALLY CONDUCTED FOR 2000-2002 MODEL 4 CYL CARS NEEDS TO BE EXPANDED TO INCLUDE 2003, AS I HAVE THE SAME PROBLEM WITH THE DI CASSETTE AS SAAB HAS EXPRESSED HAPPENING IN THE 2002 MODELS. I WISH TO HAVE MY DI CASSETTE REPLACED WITHOUT CHARGE AND TO BE INCLUDED IN THE PRE EXISTING RECALL FOR 2002 DRIVERS. *TR

SAAB INFORMATION DISPLAY PIXEL FAILURE. THE PIXELS ON THE INFORMATION DISPLAY HAVE BEEN FAILING, AND NOW ARE TO THE POINT WHERE ALMOST UNUSABLE DISPLAY. SAAB SERVICE SAID IT IS A COMMON ISSUE, BUT SINCE THE WARRANTY HAS PASSED, WOULD HAVE TO BUY A NEW DISPLAY UNIT(APPROX. $500) SEARCHING ON THE INTERNET, I HAVE FOUND MANY PEOPLE HAVE THE SAME ISSUE. THERE ARE EVEN SITES SET-UP TO SEND UNIT IN FOR REPAIR.(EX. WWW.SIDREPAIR.COM) *JB

DRIVING ON THE INTERSTATE - EXITED ONTO AN INTERCHANGE RAMP AT 50 MPH - AND THE ENGINE STALLED WITHOUT WARNING. VEHICLE AT REAR NEARLY REAR-ENDED MINE - BUT MISSED BY A HAIRS WHISKER. ANOTHER PIECE OF LUCK WAS THAT I WAS AT THE CREST OF THE RAMP SO MANAGED TO "COAST" TOWARDS THE SHOULDER. WAITED FOR A BIT - THE CAR WOULDN'T RESTART. HAD TO SPEND PERILOUS TIME ON THE LEFT SHOULDER BEFORE GETTING MY CAR TOWED. AT THE TIME OF WRITING - THE CAR IS SITTING IN THE DEALERS LOT. NOTHING SPECIAL HAPPENED PRIOR TO THIS INCIDENT. PREVIOUSLY A SIMILAR INCIDENT HAD OCCURRED JUST OUTSIDE MY RESIDENCE - AND THE DEALER CHECKED IT OUT AND SAID IT MIGHT JUST BE "BAD GAS". SAAB'S CUSTOMER ASSISTANCE PROGRAM WAS USELESS. BASED ON THE OTHER INCIDENTS REPORTED - REFER TO ODI #S: 10162804, 10137685, 10097342 - THERE IS SOMETHING DEFINITELY WRONG WITH THIS VEHICLE. PLEASE TAKE ACTION BEFORE SOMEONE LOSES THEIR LIFE.*JB

CHECK ENGINE LIGHT ON 2003 SAAB 9-5 AERO DIAGNOSED AS FAILING IGNITION CASSETTE WHICH IS THE SAME FAULTY PART FOR RECALL ON THE 2000-2002 CARS ONLY. A COMPLETE FAILURE WHILE DRIVING WOULD HAVE CAUSED THE ENGINE TO TOTALLY SHUTDOWN. THIS PART WAS REPLACED AT MY COST, BUT THE ORIGINAL PART NUMBER WAS INSTALLED VS. THE NEWER UPGRADED VERSION TO HOPEFULLY PREVENT FUTURE FAILURES. RE: CAMPAIGN ID# 05V399000. SHOULDN'T THE FAULTY "ORIGINAL" PART BE PULLED FROM DEALER STOCK AND WHY HAS THE 2003 MODEL YEAR AND OTHER YEARS BEEN EXCLUDED SINCE THE FAULTY PART IS EXACTLY THE SAME? *NM

THE VEHICLE STALLED ON 4 SEPARATE OCCASIONS FROM VARIOUS SPEEDS OF 25 MPH OR MORE WHILE DRIVING. THE VEHICLE HAS BEEN TO THE DEALER ON 3 SEPARATE OCCASIONS. THE DEALER HAS CLEANED AND TIGHTENED THE BATTERY CABLES, THE FIRST TIME, THEY REPLACED THE CRANK SENSOR, T-7 AND THE IGNITION SWITCH, THE SECOND TIME AND THE THIRD TIME, THEY WERE UNABLE TO DUPLICATE THE PROBLEM. *JB THE ECM WAS REPLACED BUT THE VEHICLE STALLED AGAIN, THE CUP HOLDER CRACK AND HAD BROKEN, THE BATTERY CABLES WERE LOOSE AND DIRTY, THE TRANSMISSION DID NOT SHIFT PROPERLY AND CAUSED A JERKING MOTION, THE ELECTRICAL GAUGES DROPPED AND THE VEHICLE LOST ACCELERATION. *SC