Illustration2005 SAAB 9-3 ARC, FRONT RIGHT SPRING BROKE AND DESTROYED FRONT RIGHT TIRES. APPROXIMATELY 38K MILE ON VEHICLE. *TR
2005 Saab 9-3
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Saab 9-3 do not stand out strongly from the model-year median of 61.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all 9-3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
1825–50K
2250–75K
975–100K
12100–150K
5150K+
78 reports with mileage · 17 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports2 fire reports3 injury reports
Suspension complaints
29 reportsMY 2005 SAAB 93 44,500 MILES. WHILE DRIVING TO WORK ON A SIX LANE DIVIDED HIGHWAY (I495) IN THE RIGHT TRAVEL LANE THE RIGHT FRONT COIL SPRING BROKE AND SHRED THE TIRE CAUSING A BLOW OUT. THE DRIVER HAD NEVER BEFORE EXPERIENCED A TIRE BLOW OUT AND WAS STARTLED AND JERKED THE STEERING WHEEL TO THE LEFT IN A MOMENT OF PANIC AND TH…
Read full complaint
MY 2005 SAAB 93 44,500 MILES. WHILE DRIVING TO WORK ON A SIX LANE DIVIDED HIGHWAY (I495) IN THE RIGHT TRAVEL LANE THE RIGHT FRONT COIL SPRING BROKE AND SHRED THE TIRE CAUSING A BLOW OUT. THE DRIVER HAD NEVER BEFORE EXPERIENCED A TIRE BLOW OUT AND WAS STARTLED AND JERKED THE STEERING WHEEL TO THE LEFT IN A MOMENT OF PANIC AND THE CAR BEGAN TO SLIDE SIDEWAYS WHILE SCRUBBING OFF SPEED. THE CAR REMAINED MOSTLY IN THE RIGHT TRAVEL LANE. THERE WASN'T MUCH TRAFFIC ON THE ROAD AT 5AM AND THE CAR DID NOT HIT ANY OTHER VEHICLES OR OBJECTS. THE DRIVER REGAINED CONTROL OF THE VEHICLE AND PULLED OFF THE RIGHT SHOULDER OF THE ROAD AND GOT OUT OF THE VEHICLE TO EXAMINE THE DAMAGE. THE RIGHT FRONT TIRE WAS FLAT SO THE DRIVER JACKED THE CAR UP AND REMOVED THE TIRE. IMMEDIATELY APPARENT WAS THE BROKEN COIL SPRING. THE DRIVER DID NOT WANT TO SPEND THE MONEY FOR A TOW TRUCK. INSTEAD, THE DRIVER DECIDED TO INSTALL THE TEMPORARY SPACE SAVER SPARE TIRE AND LIMP THE CAR HOME BY DRIVING ON THE SHOULDER FOR ABOUT 10 MINUTES AT 30MPH WITH THE HAZARD WARNING LIGHTS FLASHING. THE CAR WAS PARKED IN THE DRIVEWAY AND ANOTHER VEHICLE WAS DRIVEN TO WORK. LATER A MECHANIC WAS HIRED TO REPAIR THE VEHICLE WHERE IT WAS PARKED IN THE OWNER'S DRIVEWAY. BOTH FRONT COIL SPRINGS AND THE DAMAGED TIRE WERE REPLACED AT A TOTAL COST OF APPROXIMATELY $600.
NORMAL DRIVING. BOTTOM SIX INCHES OF FRONT RIGHT STRUT COIL SPRING JUST BROKE. I HAVE NEVER SEEN A COIL SPRING JUST BREAK BEFORE. THIS PART IS STILL ON THE CAR AND I HAVE THE BROKEN SIX INCH SEMI-CIRCULAR PIECE. IT TOOK ALMOST THREE MONTHS BEFORE I DISCOVERED WHERE A CLICKING SOUND WAS COMING FROM IN THE FRONT RIGHT SUSPENSI…
Read full complaint
NORMAL DRIVING. BOTTOM SIX INCHES OF FRONT RIGHT STRUT COIL SPRING JUST BROKE. I HAVE NEVER SEEN A COIL SPRING JUST BREAK BEFORE. THIS PART IS STILL ON THE CAR AND I HAVE THE BROKEN SIX INCH SEMI-CIRCULAR PIECE. IT TOOK ALMOST THREE MONTHS BEFORE I DISCOVERED WHERE A CLICKING SOUND WAS COMING FROM IN THE FRONT RIGHT SUSPENSION. *TR
FRONT COIL SPRING FRACTURE. *TR
2005 SAAB 9-3 ARC SEDAN FRONT COIL SPRING FRACTURED. BROKEN SPRING CONTACTED TIRE SIDE WALL AND CAUSED IRREPARABLE DAMAGE. *TR
BROKEN FRONT COIL SPRINGS. *TR
PASSENGER SIDE FRONT COIL SPRING CRACKED AND BROKE APPROX. 4-5 INCHES FROM STRUT MOUNT. THIS CAUSED THE COIL TO BOUNCE AGAINST THE STRUT. *TR
TL*THE CONTACT OWNS A 2005 SAAB 9-3. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE COIL SPRING FAILED. WHILE DRIVING 45 MPH, SHE HEARD A NOISE AS HER FRONT PASSENGER SIDE TIRE BLEW OUT. THE VEHICLE WAS PULLED TO THE SIDE OF THE ROAD AND TOWED TO A REPAIR SHOP. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CONTACT CALLED HE…
Read full complaint
TL*THE CONTACT OWNS A 2005 SAAB 9-3. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE COIL SPRING FAILED. WHILE DRIVING 45 MPH, SHE HEARD A NOISE AS HER FRONT PASSENGER SIDE TIRE BLEW OUT. THE VEHICLE WAS PULLED TO THE SIDE OF THE ROAD AND TOWED TO A REPAIR SHOP. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CONTACT CALLED HER INSURANCE COMPANY. THE FAILURE MILEAGE WAS 48,000.
I HAVE A 2005 SAAB 9-3 WITH 56,000 MILES ON IT. RECENTLY I EXPERIENCED A BROKEN RIGHT FRONT COIL SPRING WHICH POSES A SIGNIFICANT SAFETY ISSUE NOT LIMITED TO THE POTENTIAL FOR A SHREDDED TIRE. LUCKILY THIS ISSUE WAS CAUGHT QUICKLY AND BEFORE CAUSING AN ACCIDENT. THE WARRANTY ON THIS VEHICLE LAPSED AT 50,000 MILES AND SAAB IS …
Read full complaint
I HAVE A 2005 SAAB 9-3 WITH 56,000 MILES ON IT. RECENTLY I EXPERIENCED A BROKEN RIGHT FRONT COIL SPRING WHICH POSES A SIGNIFICANT SAFETY ISSUE NOT LIMITED TO THE POTENTIAL FOR A SHREDDED TIRE. LUCKILY THIS ISSUE WAS CAUGHT QUICKLY AND BEFORE CAUSING AN ACCIDENT. THE WARRANTY ON THIS VEHICLE LAPSED AT 50,000 MILES AND SAAB IS UNWILLING TO REPLACE THE PART. AFTER RESEARCHING THIS ISSUE I HAVE FOUND NUMEROUS REPORTS OF SIMILAR CASES - SOME BREAKAGES HAPPENING AT SPEED AND SHREDDING TIRES. SIMILAR ISSUES CAN BE FOUND AT: HTTP://WWW.SAABSCENE.COM/FORUM/INDEX.PHP?SHOWTOPIC=31635698. *TR
Official recalls
214V318000 · Seat Belts:front:retractor
Jun 12, 2014
General Motors LLC (GM) is recalling certain model year 2004-2011 Saab 9-3 Convertible vehicles manufactured July 30, 2003, to February 15, 2011. In the affected vehicles, the driver's side front seat belt retractor may break, causing the seat belt webbing not to retract.
Consequence & remedy
Consequence: In the event of a crash, a seat belt that has not retracted may not properly restrain the seat occupant, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will replace the driver's seat belt retractor, free of charge. The recall began on October 6, 2015. Owners may contact Saab customer service at 1-800-955-9007. GM's number for this recall is 14222. Note: Special Coverage 10086 will replace the passenger side seat belt retractor if it fails, free of charge, for the life of the vehicle.
05V236000 · Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
May 19, 2005
CERTAIN SPORT SEDAN AND CONVERTIBLE PASSENGER VEHICLES WERE PRODUCED WITH A VACUUM PIPE CHECK VALVE FOR THE BRAKE BOOSTER THAT MAY FAIL FROM EXPOSURE TO ELEVATED TEMPERATURES. THIS COULD RESULT IN SUDDEN LOSS OF POWER BRAKE ASSIST, USUALLY WITH LITTLE OR NO WARNING.
Consequence & remedy
Consequence: IF THIS CONDITION WERE TO OCCUR WHEN MINIMUM STOPPING DISTANCE IS REQUIRED, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW REDESIGNED CHECK VALVE. THE RECALL BEGAN ON MARCH 17, 2006. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08026 · Front Suspension Coil Spring Fracture
Opened Dec 22, 2008 · Closed Jun 4, 2010
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
To date, ODI is aware of 142 non-duplicative complaints related to the alleged defect.In addition, ODI is aware of 2,626 subject vehicles with one or more warranty claims related to the alleged defect.In total, ODI is aware of 2,714 unique subject vehicles that have experienced one or more front suspension coil spring fractures.ODI is not aware of any crashes or injuries related to the alleged defect.The engineering design and testing data supplied by GM, along with the frequency of consumer complaints and warranty claims related to the alleged defect, tends to support the position that, in general, the coil springs that fractured on many subject vehicles did not achieve the expected service life.However, in regard to the subject vehicles, a front suspension coil spring fracture itself has little safety consequence, as evidenced by the minimal impact on vehicle ride and handling and by the number of drivers who were unaware of the failure condition for some time until alerted by service personnel.The ratio of tire punctures to coil spring fractures appears low and there are no reports of crashes, deaths or injuries related to the alleged defect. A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor this issue and will take further action if warranted by the circumstances.See the EA08-026 Engineering Analysis Closing Report for more details.
PE08051 · Front Suspension Coil Spring Fracture
Opened Aug 28, 2008 · Closed Dec 23, 2008
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
ON AUGUST 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE08-051) TO INVESTIGATE ALLEGED FRONT SUSPENSION COIL SPRING FRACTURES IN CERTAIN MODEL YEAR (MY) 2003-2004 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES.(NOTE: FOR PURPOSES OF THIS INVESTIGATION, THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).SUBSEQUENT ANALYSIS OF DATA PROVIDED BY GENERAL MOTORS CORP. (GM) HAS LED THE AGENCY TO EXPAND THE SCOPE OF THIS INVESTIGATION TO INCLUDE ALL MY 2003-2006 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES. TO DATE, ODI IS AWARE OF 53 NON-DUPLICATIVE COMPLAINTS AND/OR FIELD REPORTS THAT ALLEGE COIL SPRING FRACTURE IN THE SUBJECT VEHICLES, INCLUDING 23 ALLEGING THE FRACTURED SPRING DAMAGED A TIRE, WITH 16 OF THOSE INVOLVING A TIRE PUNCTURE.ANALYSIS OF WARRANTY DATA PROVIDED BY GM IDENTIFIED 1,218 CLAIMS PAID TO REPAIR SUBJECT VEHICLES THAT EXPERIENCED THE ALLEGED DEFECT, OF WHICH 138 VEHICLES ALSO SUFFERED DAMAGE TO THE ADJACENT TIRE AND OF THOSE, 79 VEHICLES EXPERIENCED A TIRE PUNCTURE.ODI IS NOT AWARE OF ANY CRASHES OR INJURIES RELATED TO THE ALLEGED DEFECT. GM MADE SEVERAL DESIGN CHANGES TO THE COIL SPRINGS AND/OR MCPHERSON STRUT ASSEMBLIES USED IN THE SUBJECT VEHICLES IN AN APPARENT EFFORT TO ADDRESS THE ALLEGED DEFECT CONDITION.HOWEVER, GM MAINTAINS THAT THE SUBJECT VEHICLES REMAIN WELL CONTROLLED IN THE EVENT OF TIRE PUNCTURE, THAT THE RATE OF TIRE PUNCTURE INCIDENTS RELATED TO COIL SPRING FRACTURES IS LOW, AND THAT THE ALLEGED DEFECT DOES NOT POSE AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-026) TO FURTHER STUDY THE SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.