IllustrationALTORNATOR KEEP MALFUNCTIONING HAPPEND MULTIPLE TIME
2005 Saab 9-3
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Saab 9-3 do not stand out strongly from the model-year median of 61.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all 9-3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
1825–50K
2250–75K
975–100K
12100–150K
5150K+
78 reports with mileage · 17 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports2 fire reports3 injury reports
Electrical System complaints
9 reportsMY CAR WON'T START AND NO MECHANIC CAN FIGURE OUT EXACTLY WHY DUE TO THERE NOT BEING ANY SAAB DEALERS NEAR THE AREA I'M STUCK IN... I HAVE BEEN LIVING OUT OF MY CAR FOR 3 MONTHS CUZ I DON'T WANT ANYONE TO STEAL MY CAR
HORN DOES NOT BLOW, PLEASE WAIT LIGHT STAYS ON. AND BURNS THE BATTERY OUT OVER A DAY OR SO WHILE CAR IS STATIONARY HAVE TO RECHARGE.
VEHICLE STALLED DURING A RIGHT TURN AT SLOW SPEED. *TR
TL* THE CONTACT OWNS A 2005 SAAB 9-3. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED SEVERAL ELECTRICAL FAILURES. THE AIR CONDITIONAER, HEADLIGHTS AND THE MOTOR ON THE FRONT PASSENGER DOOR ALL FAILED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT A BURN OUT OCCURRED IN THE ELECTRICAL SOCKETS …
Read full complaint
TL* THE CONTACT OWNS A 2005 SAAB 9-3. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED SEVERAL ELECTRICAL FAILURES. THE AIR CONDITIONAER, HEADLIGHTS AND THE MOTOR ON THE FRONT PASSENGER DOOR ALL FAILED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT A BURN OUT OCCURRED IN THE ELECTRICAL SOCKETS FOR EACH COMPONENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 37,440.
ONGOING DURING ROUTINE DRIVING: THE HEADLIGHTS ON MY 2005 SAAB 9-3 BURN OUT ON APPROXIMATELY A MONTHLY BASIS REQUIRING REPLACEMENT OF THE BULB. ACCORDING TO KNOWLEDGEABLE SOURCES THIS IS DUE TO A CORROSION ISSUE WITH THE HEADLIGHT SOCKETS KNOWN TO THE MANUFACTURER AND SERVICE PROVIDERS. THIS IS A SAFETY CONCERN DUE TO THE FACT T…
Read full complaint
ONGOING DURING ROUTINE DRIVING: THE HEADLIGHTS ON MY 2005 SAAB 9-3 BURN OUT ON APPROXIMATELY A MONTHLY BASIS REQUIRING REPLACEMENT OF THE BULB. ACCORDING TO KNOWLEDGEABLE SOURCES THIS IS DUE TO A CORROSION ISSUE WITH THE HEADLIGHT SOCKETS KNOWN TO THE MANUFACTURER AND SERVICE PROVIDERS. THIS IS A SAFETY CONCERN DUE TO THE FACT THAT WHEN ONE HEADLIGHT BULB BURNS OUT - THE OTHER HEADLIGHT BULB BURNS OUT SHORTLY THEREAFTER EXPOSING ME TO FOUR OCCURRENCES WHERE I HAVE LOST ILLUMINATION IN BOTH HEADLIGHTS WHILE DRIVING AT NIGHT. IN ADDITION, THE HEADLIGHT SOCKETS ARE OF POOR CONSTRUCTION AS I HAVE HAD TWO OCCURRENCES OF ONE OF THE THREE TABS WHICH SECURE THE HEADLIGHT SOCKET INTO THE HEADLIGHT ASSEMBLY BREAK OFF. THIS INITIALLY CREATES A SITUATION WHERE THE HEADLIGHT BULB MOVES OUT OF ALIGNMENT CAUSING IMPROPER ILLUMINATION OF THE ROADWAY AHEAD. ULTIMATELY, THE BROKEN TAB ON THE SOCKET LEADS TO BULB FAILURE DUE TO VIBRATION ASSOCIATED WITH VEHICLE OPERATION. REPLACEMENT SOCKETS AVAILABLE FROM THE MANUFACTURER ARE OF THE SAME CONSTRUCTION AND THE UNDERLYING ISSUES HAVE NOT BEEN ADDRESSED. *TR
LOSS OF POWER AT HIGHWAY SPEED 4 TIMES ON 5/17/2006, 4/17/2006. 04/7/2006/AND 4/03/2006. SERVICED EACH TIME BY SAAB DEALER WITH ASSISTANCE FROM NATIONAL TECHNICAL. PROBLEMS CONTINUED. MADE REQUEST FOR RE-PURCHASE UNDER LEMON LAWS OF ST OF WA. CAR RE-PURCHASED BY SAAB USA. *JB
THE ENGINE IN MY 2005 SAAB 9'3 LINEAR HAS FAILED MANY TIMES WITHIN THE FIRST 4000 MILES. THE SAAB DEALERSHIP ON EACH OF THE THREE OCCASIONS COULD NOT FIND THE PROBLEM. THIS APPEARS TO BE A SERIOUS CONCERN TO ME AND TO THE OTHER DRIVERS AROUND ME, I HOPE THAT SAAB RECALLS THIS MODEL! *JB
SINCE I HAVE PURCHASED MY SAAB 9-3 CONVERTIBLE THE DIGITAL COMPASS ALWAYS READS NORTH AND CALIBRATED. WENT IN FOR SERVICE AND DEALERSHIP SAYS THEY CANNOT FIX IT. THEY ADVISED ME THE SAAB REPRESENTATIVE IS AWARE OF THE PROBLEM, AND ALL OF THE CONVERTIBLE ARE HAVING THE SAME PROBLEM, SECONDARY TO A MAGNETIC FIELD CREATED DURING …
Read full complaint
SINCE I HAVE PURCHASED MY SAAB 9-3 CONVERTIBLE THE DIGITAL COMPASS ALWAYS READS NORTH AND CALIBRATED. WENT IN FOR SERVICE AND DEALERSHIP SAYS THEY CANNOT FIX IT. THEY ADVISED ME THE SAAB REPRESENTATIVE IS AWARE OF THE PROBLEM, AND ALL OF THE CONVERTIBLE ARE HAVING THE SAME PROBLEM, SECONDARY TO A MAGNETIC FIELD CREATED DURING THE MANUFACTURING PROCESS.*AK
Official recalls
214V318000 · Seat Belts:front:retractor
Jun 12, 2014
General Motors LLC (GM) is recalling certain model year 2004-2011 Saab 9-3 Convertible vehicles manufactured July 30, 2003, to February 15, 2011. In the affected vehicles, the driver's side front seat belt retractor may break, causing the seat belt webbing not to retract.
Consequence & remedy
Consequence: In the event of a crash, a seat belt that has not retracted may not properly restrain the seat occupant, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will replace the driver's seat belt retractor, free of charge. The recall began on October 6, 2015. Owners may contact Saab customer service at 1-800-955-9007. GM's number for this recall is 14222. Note: Special Coverage 10086 will replace the passenger side seat belt retractor if it fails, free of charge, for the life of the vehicle.
05V236000 · Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
May 19, 2005
CERTAIN SPORT SEDAN AND CONVERTIBLE PASSENGER VEHICLES WERE PRODUCED WITH A VACUUM PIPE CHECK VALVE FOR THE BRAKE BOOSTER THAT MAY FAIL FROM EXPOSURE TO ELEVATED TEMPERATURES. THIS COULD RESULT IN SUDDEN LOSS OF POWER BRAKE ASSIST, USUALLY WITH LITTLE OR NO WARNING.
Consequence & remedy
Consequence: IF THIS CONDITION WERE TO OCCUR WHEN MINIMUM STOPPING DISTANCE IS REQUIRED, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW REDESIGNED CHECK VALVE. THE RECALL BEGAN ON MARCH 17, 2006. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08026 · Front Suspension Coil Spring Fracture
Opened Dec 22, 2008 · Closed Jun 4, 2010
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
To date, ODI is aware of 142 non-duplicative complaints related to the alleged defect.In addition, ODI is aware of 2,626 subject vehicles with one or more warranty claims related to the alleged defect.In total, ODI is aware of 2,714 unique subject vehicles that have experienced one or more front suspension coil spring fractures.ODI is not aware of any crashes or injuries related to the alleged defect.The engineering design and testing data supplied by GM, along with the frequency of consumer complaints and warranty claims related to the alleged defect, tends to support the position that, in general, the coil springs that fractured on many subject vehicles did not achieve the expected service life.However, in regard to the subject vehicles, a front suspension coil spring fracture itself has little safety consequence, as evidenced by the minimal impact on vehicle ride and handling and by the number of drivers who were unaware of the failure condition for some time until alerted by service personnel.The ratio of tire punctures to coil spring fractures appears low and there are no reports of crashes, deaths or injuries related to the alleged defect. A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor this issue and will take further action if warranted by the circumstances.See the EA08-026 Engineering Analysis Closing Report for more details.
PE08051 · Front Suspension Coil Spring Fracture
Opened Aug 28, 2008 · Closed Dec 23, 2008
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
ON AUGUST 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE08-051) TO INVESTIGATE ALLEGED FRONT SUSPENSION COIL SPRING FRACTURES IN CERTAIN MODEL YEAR (MY) 2003-2004 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES.(NOTE: FOR PURPOSES OF THIS INVESTIGATION, THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).SUBSEQUENT ANALYSIS OF DATA PROVIDED BY GENERAL MOTORS CORP. (GM) HAS LED THE AGENCY TO EXPAND THE SCOPE OF THIS INVESTIGATION TO INCLUDE ALL MY 2003-2006 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES. TO DATE, ODI IS AWARE OF 53 NON-DUPLICATIVE COMPLAINTS AND/OR FIELD REPORTS THAT ALLEGE COIL SPRING FRACTURE IN THE SUBJECT VEHICLES, INCLUDING 23 ALLEGING THE FRACTURED SPRING DAMAGED A TIRE, WITH 16 OF THOSE INVOLVING A TIRE PUNCTURE.ANALYSIS OF WARRANTY DATA PROVIDED BY GM IDENTIFIED 1,218 CLAIMS PAID TO REPAIR SUBJECT VEHICLES THAT EXPERIENCED THE ALLEGED DEFECT, OF WHICH 138 VEHICLES ALSO SUFFERED DAMAGE TO THE ADJACENT TIRE AND OF THOSE, 79 VEHICLES EXPERIENCED A TIRE PUNCTURE.ODI IS NOT AWARE OF ANY CRASHES OR INJURIES RELATED TO THE ALLEGED DEFECT. GM MADE SEVERAL DESIGN CHANGES TO THE COIL SPRINGS AND/OR MCPHERSON STRUT ASSEMBLIES USED IN THE SUBJECT VEHICLES IN AN APPARENT EFFORT TO ADDRESS THE ALLEGED DEFECT CONDITION.HOWEVER, GM MAINTAINS THAT THE SUBJECT VEHICLES REMAIN WELL CONTROLLED IN THE EVENT OF TIRE PUNCTURE, THAT THE RATE OF TIRE PUNCTURE INCIDENTS RELATED TO COIL SPRING FRACTURES IS LOW, AND THAT THE ALLEGED DEFECT DOES NOT POSE AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-026) TO FURTHER STUDY THE SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.