NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
207 reports89,000 miles · Jul 26, 2011
Seat Belts
WHEN ATTEMPTING TO PUT ON SEAT BELT, THE RETRACTOR FAILED AND THE SEAT BELT IS EXTENDED TO IT'S LARGEST CAPACITY AND WILL NOT RETRACT. THIS HAPPENED WHEN THE CAR WAS NOT MOVING. I TOOK THE CAR TO BE REPAIRED AT A REPAIR SHOP FOR SWEDISH CARS AND WAS TOLD THAT FIXING IT WAS NOT COVERED UNDER THE CURRENT RECALL FOR THE DRIVER'S …
Read full complaint
WHEN ATTEMPTING TO PUT ON SEAT BELT, THE RETRACTOR FAILED AND THE SEAT BELT IS EXTENDED TO IT'S LARGEST CAPACITY AND WILL NOT RETRACT. THIS HAPPENED WHEN THE CAR WAS NOT MOVING. I TOOK THE CAR TO BE REPAIRED AT A REPAIR SHOP FOR SWEDISH CARS AND WAS TOLD THAT FIXING IT WAS NOT COVERED UNDER THE CURRENT RECALL FOR THE DRIVER'S SIDE SEAT BELT RETRACTOR. I WAS TOLD THAT RECALL APPLIED TO ONLY SEDANS. I WAS QUOTED A COST OF OVER $800 TO FIX THE PART. FROM WHAT I UNDERSTAND, THIS IS A COMMON OCCURRENCE IN THE 2004 SAABS. I WAS ALSO TOLD THAT IT WAS NOT COVERED UNDER WARRANTY.
NHTSA ODI #10415990
39,900 miles · Jul 8, 2011
Air Bags
THE SIDE SEAM OF THE FRONT DRIVER SEAT TORE WITH OUT WARNING. THE DRIVER'S SIDE AIRBAG IS LOCATED HERE AND MAY BECOME EXPOSED IN A DANGEROUS MANOR. CAR HAS ONLY 39,000 MILES IS VERY WELL MAINTAINED. DRIVER IS NOT OVERWEIGHT/FAT. THIS IS UNSAFE. I HAVE OWNED MANY OTHER CARS AND SEATS SHOULD NOT TEAR WHERE AIR BAG IS LOCATED.…
Read full complaint
THE SIDE SEAM OF THE FRONT DRIVER SEAT TORE WITH OUT WARNING. THE DRIVER'S SIDE AIRBAG IS LOCATED HERE AND MAY BECOME EXPOSED IN A DANGEROUS MANOR. CAR HAS ONLY 39,000 MILES IS VERY WELL MAINTAINED. DRIVER IS NOT OVERWEIGHT/FAT. THIS IS UNSAFE. I HAVE OWNED MANY OTHER CARS AND SEATS SHOULD NOT TEAR WHERE AIR BAG IS LOCATED. THIS IS DEFECT. GM WILL NOT REPAIR, "CAR OUT OF WARRANTY". INDEPENDENT SHOP WILL NOT STITCH "LIABILITY CONCERN DUE TO AIRBAG". HELP. *TR
NHTSA ODI #10411564
180,000 miles · Jul 7, 2011
Seat Belts
TL* THE CONTACT OWNS A 2004 SAAB 9-3. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THE DRIVERS SIDE SEAT BELT WOULD NOT RETRACT AFTER HAD BEEN EXTENDED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
NHTSA ODI #10410905
Mileage unknown · Jun 15, 2011
Engine And Engine CoolingFire
VEHICLE OWNER PULLED INTO A PARKING SPACE AND STOPPED, SAW SMOKE COMING FROM UNDER THE HOOD. OWNER REPORTED THAT THE SMOKE BECAME BLACK AND A FIRE ERUPTED. FIRE ORIGIN IN RIGHT REAR OF ENGINE COMPARTMENT, CAUSE UNDETERMINED. VEHICLE HAS 2.0 LITER TURBOCHARGED 4-CYLINDER ENGINE. *TR
NHTSA ODI #10406957
109,000 miles · Jun 8, 2011
Seat Belts
TL* THE CONTACT OWNS A 2004 SAAB 9-3 AERO. THE CONTACT STATED THAT WHILE ATTEMPTING TO FASTEN THE DRIVER SIDE SEAT BELT, THE SEAT BELT RETRACTOR FAILED. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER INSPECTED THE VEHICLE AND ADVISED THAT THE SEAT BELT ASSEMBLY WOULD NEED TO BE REPLACED. THE DEALER REPLACED THE DRIVER SIDE SEAT…
Read full complaint
TL* THE CONTACT OWNS A 2004 SAAB 9-3 AERO. THE CONTACT STATED THAT WHILE ATTEMPTING TO FASTEN THE DRIVER SIDE SEAT BELT, THE SEAT BELT RETRACTOR FAILED. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER INSPECTED THE VEHICLE AND ADVISED THAT THE SEAT BELT ASSEMBLY WOULD NEED TO BE REPLACED. THE DEALER REPLACED THE DRIVER SIDE SEAT BELT ASSEMBLY. THE MANUFACTURER WOULD NOT ASSIST WITH THE REPAIR BECAUSE THE VEHICLE WARRANTY WAS EXPIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 109,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10405542
92,000 miles · May 13, 2011
Suspension
WAS DRIVING 2004 SAAB 9-3 VEHICLE WHEN THE STRUT SPRING BROKE, AND STARTED DIGGING INTO THE TIRE CREATING A LOT OF SMOKE FROM BURNT RUBBER. UPON CLOSER INSPECTION IT APPEARS THAT THE STRUT STRINGS HAD BROKE ON BOTH SIDES, ONLY THE PASSENGER SIDE SPRING CAME OFF OF ITS 'MOUNT' AND DUG ITS WAY INTO THE TIRE. NOTHING WAS HIT TO C…
Read full complaint
WAS DRIVING 2004 SAAB 9-3 VEHICLE WHEN THE STRUT SPRING BROKE, AND STARTED DIGGING INTO THE TIRE CREATING A LOT OF SMOKE FROM BURNT RUBBER. UPON CLOSER INSPECTION IT APPEARS THAT THE STRUT STRINGS HAD BROKE ON BOTH SIDES, ONLY THE PASSENGER SIDE SPRING CAME OFF OF ITS 'MOUNT' AND DUG ITS WAY INTO THE TIRE. NOTHING WAS HIT TO CAUSE THIS REACTION. UPON SEARCHING THE INTERNET, THIS SEEMS TO BE A MORE COMMON, THAN NOT PROBLEM WITH THIS MODEL OF 9-3. SAAB HAS AGREED TO EXTEND THE WARRANTY TO FIX THE PROBLEM, BUT THIS IS A VERY SERIOUS SAFETY HAZARD AND THESE SPRINGS SHOULD BE RECALLED. A SIGNIFICANT AMOUNT OF DAMAGE WAS DONE TO THE TIRE BEFORE I STOPPED. IF THE VEHICLE HAD BEEN TRAVELING ANY FASTER, I BELIEVE THE CONSEQUENCES COULD HAVE BEEN SIGNIFICANTLY WORSE.
NHTSA ODI #10401749
124,000 miles · May 4, 2011
Suspension
TL* THE CONTACT OWNS A 2004 SAAB 9-3. WHILE DRIVING APPROXIMATELY 55 MPH THE FRONT PASSENGER SIDE TIRE BLEW OUT. THE CONTACT WAS ABLE TO PULL OFF TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIANS STATED THE FRONT PASSENGER SIDE COIL SPRING NEEDED TO BE REPLACED. THE CONTACT DECIDED TO REPLACE BOTH FRO…
Read full complaint
TL* THE CONTACT OWNS A 2004 SAAB 9-3. WHILE DRIVING APPROXIMATELY 55 MPH THE FRONT PASSENGER SIDE TIRE BLEW OUT. THE CONTACT WAS ABLE TO PULL OFF TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIANS STATED THE FRONT PASSENGER SIDE COIL SPRING NEEDED TO BE REPLACED. THE CONTACT DECIDED TO REPLACE BOTH FRONT DRIVER AND PASSENGER SIDE COIL SPRINGS. THE VEHICLE WAS REPAIRED. THE MANUFACTURER ISSUED AN EXTENDED WARRANTY FOR THE FAILURE BUT THE VEHICLE WAS NOT COVERED UNDER THE WARRANTY DUE TO THE MILEAGE. THE APPROXIMATE FAILURE MILEAGE WAS 124,000. UPDATED 05/18/11 *BF UPDATED 2/9/12 *CN
NHTSA ODI #10399084
130,000 miles · Apr 27, 2011
Seat Belts
TL* THE CONTACT OWNS A 2004 SAAB 9-3. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT ABRUPTLY DEPRESSED THE BRAKES TO AVOID A CRASH AND THE CONTACT STATED THAT THE SEAT BELT FAILED TO TIGHTEN AND RESTRAIN HIM PROPERLY. THE CONTACT WAS NOT INJURED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO INSPECTED THE VEHICLE AND FOUND THA…
Read full complaint
TL* THE CONTACT OWNS A 2004 SAAB 9-3. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT ABRUPTLY DEPRESSED THE BRAKES TO AVOID A CRASH AND THE CONTACT STATED THAT THE SEAT BELT FAILED TO TIGHTEN AND RESTRAIN HIM PROPERLY. THE CONTACT WAS NOT INJURED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO INSPECTED THE VEHICLE AND FOUND THAT THE SEAT BELT UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 10V043000 (SEAT BELTS:FRONT:RETRACTOR)BUT THE MANUFACTURER ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. SAAB OFFERED TO PAY FOR THE PARTS AS A GOODWILL GESTURE, BUT WOULD NOT ACKNOWLEDGE THE VEHICLE IDENTIFICATION NUMBER BEING INCLUDED IN THE RECALL. UPDATED EVOQ 06/14/11
NHTSA ODI #10398000
Mileage unknown · Mar 25, 2011
Seat Belts
I HAVE A 2004 SAAB 9-3; THE DRIVER SIDE FRONT SEATBELT RETRACTOR WAS REPLACED UNDER RECALL, BUT I BELIEVE THAT THE RETRACTORS FOR THE REMAINING THREE OUTER SEATBELTS DO NOT FUNCTION WELL, EVEN THOUGH THEY TECHNICALLY RECEIVE LESS USE THAN THE DRIVER'S. I HAVE TO HELP TAKE UP THE SLACK IN THE BELTS TO MAKE SURE THEY ARE SNUG FOR …
Read full complaint
I HAVE A 2004 SAAB 9-3; THE DRIVER SIDE FRONT SEATBELT RETRACTOR WAS REPLACED UNDER RECALL, BUT I BELIEVE THAT THE RETRACTORS FOR THE REMAINING THREE OUTER SEATBELTS DO NOT FUNCTION WELL, EVEN THOUGH THEY TECHNICALLY RECEIVE LESS USE THAN THE DRIVER'S. I HAVE TO HELP TAKE UP THE SLACK IN THE BELTS TO MAKE SURE THEY ARE SNUG FOR BACKSEAT PASSENGERS (IN BOOSTER SEATS), MUCH AS I HAD TO DO WITH THE DRIVER'S SEATBELT BEFORE THE RECALL. *TR
NHTSA ODI #10392859
Mileage unknown · Mar 17, 2011
Fuel System, GasolinePower Train
2004 SAAB 9-3 CONVERTIBLE. CONSUMER STATES ISSUES WITH FUEL TANK AND SENSOR *TGW THE CONSUMER STATED THE ENGINE LIGHT ILLUMINATED AS WELL AS THE GREENBOX MALFUNCTION LIGHT DUE TO THE VEHICLE NOT HAVING THE LATEST SOFTWARE. SO, THE DEALER HAD TO PERFORM THE SPS OF THE TRANSMISSION CONTROL MODULE TO UPDATE TO THE NEWEST SOFTWARE.…
Read full complaint
2004 SAAB 9-3 CONVERTIBLE. CONSUMER STATES ISSUES WITH FUEL TANK AND SENSOR *TGW THE CONSUMER STATED THE ENGINE LIGHT ILLUMINATED AS WELL AS THE GREENBOX MALFUNCTION LIGHT DUE TO THE VEHICLE NOT HAVING THE LATEST SOFTWARE. SO, THE DEALER HAD TO PERFORM THE SPS OF THE TRANSMISSION CONTROL MODULE TO UPDATE TO THE NEWEST SOFTWARE. THE CONSUMER WAS INFORMED THAT BECAUSE HE RAN THE VEHICLE ON LOW FUEL, IT SHORTED OUT THE FUEL SENSOR. THE CONSUMER ALSO STATED WHEN HE FIRST PURCHASED THE VEHICLE, THE ENGINE LIGHT ILLUMINATED DUE TO A FAULTY FUEL PUMP. *JB
NHTSA ODI #10391938
Official recalls
5Jun 12, 2014
General Motors LLC (GM) is recalling certain model year 2004-2011 Saab 9-3 Convertible vehicles manufactured July 30, 2003, to February 15, 2011. In the affected vehicles, the driver's side front seat belt retractor may break, causing the seat belt webbing not to retract.
Consequence & remedy
Consequence: In the event of a crash, a seat belt that has not retracted may not properly restrain the seat occupant, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will replace the driver's seat belt retractor, free of charge. The recall began on October 6, 2015. Owners may contact Saab customer service at 1-800-955-9007. GM's number for this recall is 14222. Note: Special Coverage 10086 will replace the passenger side seat belt retractor if it fails, free of charge, for the life of the vehicle.
Feb 18, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2004 SAAB 9-3 SEDANS. SOME OF THESE VEHICLES WERE PRODUCED WITH FRONT SEAT BELT RETRACTORS THAT, OVER TIME, COULD FAIL TO RETRACT.
Consequence & remedy
Consequence: USING A SEAT BELT THAT HAS NOT RETRACTED, AND IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE DRIVER SIDE RETRACTOR FREE OF CHARGE. IF THE FRONT PASSENGER RETRACTOR WERE TO FAIL TO RETRACT, GM WILL REPLACE THE FRONT PASSENGER RETRACTOR FREE OF CHARGE UNDER A SPECIAL COVERAGE THAT WILL BE RELEASED FOR THE SAME POPULATION FOR 10 YEARS FROM NEW VEHICLE DATE OF SALE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JULY 2010. OWNERS MAY CONTACT SAAB AT 1-800-955-9007 OR AT THE OWNER CENTER AT SAABPARTS.COM/US. Note: In June 2014, GM expanded the special coverage from 10 years to be for the lifetime of the vehicle.
May 19, 2005
CERTAIN SPORT SEDAN AND CONVERTIBLE PASSENGER VEHICLES WERE PRODUCED WITH A VACUUM PIPE CHECK VALVE FOR THE BRAKE BOOSTER THAT MAY FAIL FROM EXPOSURE TO ELEVATED TEMPERATURES. THIS COULD RESULT IN SUDDEN LOSS OF POWER BRAKE ASSIST, USUALLY WITH LITTLE OR NO WARNING.
Consequence & remedy
Consequence: IF THIS CONDITION WERE TO OCCUR WHEN MINIMUM STOPPING DISTANCE IS REQUIRED, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW REDESIGNED CHECK VALVE. THE RECALL BEGAN ON MARCH 17, 2006. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
May 11, 2004
SOME SPORT SEDANS WERE BUILT WITH SEAT BELT RETRACTORS THAT WERE DAMAGED DURING THE MANUFACTURING PROCESS. IF DAMAGED, OVER TIME, THE AUTOMATIC TENSIONING SYSTEM (ATS) CABLE IN THE SEAT BELT RETRACTOR COULD BREAK CAUSING THE BELT WEBBING TO NOT RETRACT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SEVERE INJURIES.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR ASSEMBLIES. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
Dec 10, 2003
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." THE BACKREST LOCKING MECHANISM ON SOME FRONT SEATS MAY HAVE BEEN INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE SEAT BACK TO FOLD FORWARD IN A FRONTAL CRASH, RESULTING IN INJURY TO THE DRIVER AND/OR FRONT SEAT PASSENGER.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S FRONT SEATS TO DETERMINE IF THEY ARE EQUIPPED WITH THE IMPROPERLY INSTALLED COMPONENT. IF EITHER OR BOTH OF THE SEATS HAVE THIS COMPONENT, THEY WILL BE REPLACED. THE DEALER MAY NEED TO ORDER A COMPLETE NEW SEAT OR SEATS (INCLUDING MATCHING UPHOLSTERY) AND THE PARTS MAY TAKE UP TO TWO TO FOUR WEEKS TO ARRIVE. SAAB WILL PROVIDE A RENTAL CAR FOR THE OWNER UNTIL THE NEW SEAT(S) IS (ARE) AVAILABLE AND INSTALLED BY THE DEALER. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING FEBRUARY 2004. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE09048 · Seat Belt Retractor
Opened Sep 30, 2009 · Closed Feb 25, 2010
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:retractor
ODI HAS RECEIVED EIGHT COMPLAINTS OF FRONT SEAT BELT RETRACTORS BREAKING ON MODEL YEAR 2004 SAAB 9-3 VEHICLES.A COMMON FAILURE SCENARIO INVOLVES THE DRIVER HEARING A NOISE AND THE BELT SUDDENLY LOSING TENSION.A NON-FUNCTIONING SEAT BELT INCREASES THE RISK AND SEVERITY OF INJURY IN THE EVENT OF A CRASH. GENERAL MOTORS INITIATED A RECALL IN MAY 2004 (04V226) TO REPLACE BOTH FRONT SEAT BELTS BECAUSE OF A SIMILAR PROBLEM IN 25,355 MODEL YEAR 2003 AND 5,980 MODEL YEAR 2004 SAAB 9-3 SEDANS.THE RETRACTORS CONTAINED AN AUTOMATIC TENSIONING SYSTEM (ATS), A DESIGN FEATURE AND MECHANISM TO ENHANCE OCCUPANT COMFORT BY REDUCING SHOULDER BELT PRESSURE.INVESTIGATION FOUND THAT THE CABLE IN THE ATS MECHANISM WAS DAMAGED DURING THE SUPPLIER'S MANUFACTURING PROCESS.THE FAILURES OCCURRED WHEN THE CABLE BROKE. RECALL 04V226 DID NOT COVER MODEL YEAR 2004 9-3 SEDANS MANUFACTURED AFTER SEPTEMBER 30, 2004, AND BEFORE MAY 10, 2004, WHICH INCORPORATED MODIFIED ATS MANUFACTURING PROCESSES.THE CURRENT INVESTIGATION FINDS THAT THE ATS ON THE DRIVERS' SEATS ON THE POST-RECALL POPULATION IS FAILING PREMATURELY.THIS IS A DIFFERENT PROBLEM THAN THE MANUFACTURING DEFECT THAT LED TO THE ORIGINAL RECALL.GENERAL MOTORS NOW WILL RECALL THE BALANCE OF 2004 SAAB 9-3 SEDAN DRIVER SEATS WITH THE ATS FEATURE.NOT ALL 2004 9-3 SEAT BELT RETRACTORS ARE SUBJECT TO RECALL.THE RETRACTORS ON 9-3 SEDAN PASSENGER SEATS, DUE TO THEIR LESS FREQUENT USE THAN DRIVERS' SEATS, DO NOT HAVE THE SAME RISK OF PREMATURE FAILURE AS THOSE ON THE DRIVERS' SEATS.SAAB WILL REPLACE THE PASSENGER SIDE RETRACTORS FOR 10 YEARS FROM NEW VEHICLE DATE OF SALE UNDER A SPECIAL COVERAGE PROGRAM.MODEL YEAR 2004 9-3 CONVERTIBLES HAVE A DIFFERENT SEAT/SEAT BELT DESIGN AND CONSTRUCTION.SAAB 9-3 VEHICLES MANUFACTURED ON AND AFTER MAY 10, 2004, DO NOT HAVE THE ATS FEATURE AND THEREFORE ARE NOT SUBJECT TO THIS PROBLEM.
Additional source detail variants (3)
Seat Belts:front
ODI HAS RECEIVED EIGHT COMPLAINTS OF FRONT SEAT BELT RETRACTORS BREAKING ON MODEL YEAR 2004 SAAB 9-3 VEHICLES.A COMMON FAILURE SCENARIO INVOLVES THE DRIVER HEARING A NOISE AND THE BELT SUDDENLY LOSING TENSION.A NON-FUNCTIONING SEAT BELT INCREASES THE RISK AND SEVERITY OF INJURY IN THE EVENT OF A CRASH. GENERAL MOTORS INITIATED A RECALL IN MAY 2004 (04V226) TO REPLACE BOTH FRONT SEAT BELTS BECAUSE OF A SIMILAR PROBLEM IN 25,355 MODEL YEAR 2003 AND 5,980 MODEL YEAR 2004 SAAB 9-3 SEDANS.THE RETRACTORS CONTAINED AN AUTOMATIC TENSIONING SYSTEM (ATS), A DESIGN FEATURE AND MECHANISM TO ENHANCE OCCUPANT COMFORT BY REDUCING SHOULDER BELT PRESSURE.INVESTIGATION FOUND THAT THE CABLE IN THE ATS MECHANISM WAS DAMAGED DURING THE SUPPLIER'S MANUFACTURING PROCESS.THE FAILURES OCCURRED WHEN THE CABLE BROKE. RECALL 04V226 DID NOT COVER MODEL YEAR 2004 9-3 SEDANS MANUFACTURED AFTER SEPTEMBER 30, 2004, AND BEFORE MAY 10, 2004, WHICH INCORPORATED MODIFIED ATS MANUFACTURING PROCESSES.THE CURRENT INVESTIGATION FINDS THAT THE ATS ON THE DRIVERS' SEATS ON THE POST-RECALL POPULATION IS FAILING PREMATURELY.THIS IS A DIFFERENT PROBLEM THAN THE MANUFACTURING DEFECT THAT LED TO THE ORIGINAL RECALL.GENERAL MOTORS NOW WILL RECALL THE BALANCE OF 2004 SAAB 9-3 SEDAN DRIVER SEATS WITH THE ATS FEATURE.NOT ALL 2004 9-3 SEAT BELT RETRACTORS ARE SUBJECT TO RECALL.THE RETRACTORS ON 9-3 SEDAN PASSENGER SEATS, DUE TO THEIR LESS FREQUENT USE THAN DRIVERS' SEATS, DO NOT HAVE THE SAME RISK OF PREMATURE FAILURE AS THOSE ON THE DRIVERS' SEATS.SAAB WILL REPLACE THE PASSENGER SIDE RETRACTORS FOR 10 YEARS FROM NEW VEHICLE DATE OF SALE UNDER A SPECIAL COVERAGE PROGRAM.MODEL YEAR 2004 9-3 CONVERTIBLES HAVE A DIFFERENT SEAT/SEAT BELT DESIGN AND CONSTRUCTION.SAAB 9-3 VEHICLES MANUFACTURED ON AND AFTER MAY 10, 2004, DO NOT HAVE THE ATS FEATURE AND THEREFORE ARE NOT SUBJECT TO THIS PROBLEM.
Seat Belts:front:retractor
ODI HAS RECEIVED EIGHT COMPLAINTS OF FRONT SEAT BELT RETRACTORS BREAKING ON MODEL YEAR 2004 SAAB 9-3 VEHICLES.A COMMON FAILURE SCENARIO INVOLVES THE DRIVER HEARING A NOISE AND THE BELT SUDDENLY LOSING TENSION.A NON-FUNCTIONING SEAT BELT INCREASES THE RISK AND SEVERITY OF INJURY IN THE EVENT OF A CRASH. GENERAL MOTORS INITIATED A RECALL IN MAY 2004 (04V226) TO REPLACE BOTH FRONT SEAT BELTS BECAUSE OF A SIMILAR PROBLEM IN 25,355 MODEL YEAR 2003 AND 5,980 MODEL YEAR 2004 SAAB 9-3 SEDANS.THE RETRACTORS CONTAINED AN AUTOMATIC TENSIONING SYSTEM (ATS), A DESIGN FEATURE AND MECHANISM TO ENHANCE OCCUPANT COMFORT BY REDUCING SHOULDER BELT PRESSURE.INVESTIGATION FOUND THAT THE CABLE IN THE ATS MECHANISM WAS DAMAGED DURING THE SUPPLIER'S MANUFACTURING PROCESS.THE FAILURES OCCURRED WHEN THE CABLE BROKE. RECALL 04V226 DID NOT COVER MODEL YEAR 2004 9-3 SEDANS MANUFACTURED AFTER SEPTEMBER 30, 2004, AND BEFORE MAY 10, 2004, WHICH INCORPORATED MODIFIED ATS MANUFACTURING PROCESSES.THE CURRENT INVESTIGATION FINDS THAT THE ATS ON THE DRIVERS' SEATS ON THE POST-RECALL POPULATION IS FAILING PREMATURELY.THIS IS A DIFFERENT PROBLEM THAN THE MANUFACTURING DEFECT THAT LED TO THE ORIGINAL RECALL.GENERAL MOTORS NOW WILL RECALL THE BALANCE OF 2004 SAAB 9-3 SEDAN DRIVER SEATS WITH THE ATS FEATURE.NOT ALL 2004 9-3 SEAT BELT RETRACTORS ARE SUBJECT TO RECALL.THE RETRACTORS ON 9-3 SEDAN PASSENGER SEATS, DUE TO THEIR LESS FREQUENT USE THAN DRIVERS' SEATS, DO NOT HAVE THE SAME RISK OF PREMATURE FAILURE AS THOSE ON THE DRIVERS' SEATS.SAAB WILL REPLACE THE PASSENGER SIDE RETRACTORS FOR 10 YEARS FROM NEW VEHICLE DATE OF SALE UNDER A SPECIAL COVERAGE PROGRAM.MODEL YEAR 2004 9-3 CONVERTIBLES HAVE A DIFFERENT SEAT/SEAT BELT DESIGN AND CONSTRUCTION.SAAB 9-3 VEHICLES MANUFACTURED ON AND AFTER MAY 10, 2004, DO NOT HAVE THE ATS FEATURE AND THEREFORE ARE NOT SUBJECT TO THIS PROBLEM.
Seat Belts
ODI HAS RECEIVED EIGHT COMPLAINTS OF FRONT SEAT BELT RETRACTORS BREAKING ON MODEL YEAR 2004 SAAB 9-3 VEHICLES.A COMMON FAILURE SCENARIO INVOLVES THE DRIVER HEARING A NOISE AND THE BELT SUDDENLY LOSING TENSION.A NON-FUNCTIONING SEAT BELT INCREASES THE RISK AND SEVERITY OF INJURY IN THE EVENT OF A CRASH. GENERAL MOTORS INITIATED A RECALL IN MAY 2004 (04V226) TO REPLACE BOTH FRONT SEAT BELTS BECAUSE OF A SIMILAR PROBLEM IN 25,355 MODEL YEAR 2003 AND 5,980 MODEL YEAR 2004 SAAB 9-3 SEDANS.THE RETRACTORS CONTAINED AN AUTOMATIC TENSIONING SYSTEM (ATS), A DESIGN FEATURE AND MECHANISM TO ENHANCE OCCUPANT COMFORT BY REDUCING SHOULDER BELT PRESSURE.INVESTIGATION FOUND THAT THE CABLE IN THE ATS MECHANISM WAS DAMAGED DURING THE SUPPLIER'S MANUFACTURING PROCESS.THE FAILURES OCCURRED WHEN THE CABLE BROKE. RECALL 04V226 DID NOT COVER MODEL YEAR 2004 9-3 SEDANS MANUFACTURED AFTER SEPTEMBER 30, 2004, AND BEFORE MAY 10, 2004, WHICH INCORPORATED MODIFIED ATS MANUFACTURING PROCESSES.THE CURRENT INVESTIGATION FINDS THAT THE ATS ON THE DRIVERS' SEATS ON THE POST-RECALL POPULATION IS FAILING PREMATURELY.THIS IS A DIFFERENT PROBLEM THAN THE MANUFACTURING DEFECT THAT LED TO THE ORIGINAL RECALL.GENERAL MOTORS NOW WILL RECALL THE BALANCE OF 2004 SAAB 9-3 SEDAN DRIVER SEATS WITH THE ATS FEATURE.NOT ALL 2004 9-3 SEAT BELT RETRACTORS ARE SUBJECT TO RECALL.THE RETRACTORS ON 9-3 SEDAN PASSENGER SEATS, DUE TO THEIR LESS FREQUENT USE THAN DRIVERS' SEATS, DO NOT HAVE THE SAME RISK OF PREMATURE FAILURE AS THOSE ON THE DRIVERS' SEATS.SAAB WILL REPLACE THE PASSENGER SIDE RETRACTORS FOR 10 YEARS FROM NEW VEHICLE DATE OF SALE UNDER A SPECIAL COVERAGE PROGRAM.MODEL YEAR 2004 9-3 CONVERTIBLES HAVE A DIFFERENT SEAT/SEAT BELT DESIGN AND CONSTRUCTION.SAAB 9-3 VEHICLES MANUFACTURED ON AND AFTER MAY 10, 2004, DO NOT HAVE THE ATS FEATURE AND THEREFORE ARE NOT SUBJECT TO THIS PROBLEM.
EA08026 · Front Suspension Coil Spring Fracture
Opened Dec 22, 2008 · Closed Jun 4, 2010
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
To date, ODI is aware of 142 non-duplicative complaints related to the alleged defect.In addition, ODI is aware of 2,626 subject vehicles with one or more warranty claims related to the alleged defect.In total, ODI is aware of 2,714 unique subject vehicles that have experienced one or more front suspension coil spring fractures.ODI is not aware of any crashes or injuries related to the alleged defect.The engineering design and testing data supplied by GM, along with the frequency of consumer complaints and warranty claims related to the alleged defect, tends to support the position that, in general, the coil springs that fractured on many subject vehicles did not achieve the expected service life.However, in regard to the subject vehicles, a front suspension coil spring fracture itself has little safety consequence, as evidenced by the minimal impact on vehicle ride and handling and by the number of drivers who were unaware of the failure condition for some time until alerted by service personnel.The ratio of tire punctures to coil spring fractures appears low and there are no reports of crashes, deaths or injuries related to the alleged defect. A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor this issue and will take further action if warranted by the circumstances.See the EA08-026 Engineering Analysis Closing Report for more details.
PE08051 · Front Suspension Coil Spring Fracture
Opened Aug 28, 2008 · Closed Dec 23, 2008
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
ON AUGUST 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE08-051) TO INVESTIGATE ALLEGED FRONT SUSPENSION COIL SPRING FRACTURES IN CERTAIN MODEL YEAR (MY) 2003-2004 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES.(NOTE: FOR PURPOSES OF THIS INVESTIGATION, THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).SUBSEQUENT ANALYSIS OF DATA PROVIDED BY GENERAL MOTORS CORP. (GM) HAS LED THE AGENCY TO EXPAND THE SCOPE OF THIS INVESTIGATION TO INCLUDE ALL MY 2003-2006 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES. TO DATE, ODI IS AWARE OF 53 NON-DUPLICATIVE COMPLAINTS AND/OR FIELD REPORTS THAT ALLEGE COIL SPRING FRACTURE IN THE SUBJECT VEHICLES, INCLUDING 23 ALLEGING THE FRACTURED SPRING DAMAGED A TIRE, WITH 16 OF THOSE INVOLVING A TIRE PUNCTURE.ANALYSIS OF WARRANTY DATA PROVIDED BY GM IDENTIFIED 1,218 CLAIMS PAID TO REPAIR SUBJECT VEHICLES THAT EXPERIENCED THE ALLEGED DEFECT, OF WHICH 138 VEHICLES ALSO SUFFERED DAMAGE TO THE ADJACENT TIRE AND OF THOSE, 79 VEHICLES EXPERIENCED A TIRE PUNCTURE.ODI IS NOT AWARE OF ANY CRASHES OR INJURIES RELATED TO THE ALLEGED DEFECT. GM MADE SEVERAL DESIGN CHANGES TO THE COIL SPRINGS AND/OR MCPHERSON STRUT ASSEMBLIES USED IN THE SUBJECT VEHICLES IN AN APPARENT EFFORT TO ADDRESS THE ALLEGED DEFECT CONDITION.HOWEVER, GM MAINTAINS THAT THE SUBJECT VEHICLES REMAIN WELL CONTROLLED IN THE EVENT OF TIRE PUNCTURE, THAT THE RATE OF TIRE PUNCTURE INCIDENTS RELATED TO COIL SPRING FRACTURES IS LOW, AND THAT THE ALLEGED DEFECT DOES NOT POSE AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-026) TO FURTHER STUDY THE SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Illustration