IllustrationDIRECT IGNITION CASSETTE FAILED ON MY 1999 SAAB 9-3. A RECALL HAS BEEN ISSUED FOR 2000-2002 SAAB 9-3 AND I FEEL THIS RECALL SHOULD INCLUDE THE '99 MODEL AS WELL BECAUSE THIS PART HAS A LESS THAN REASONABLE LIFE. *JB
1999 Saab 9-3
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Saab 9-3 do not stand out strongly from the model-year median of 61.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all 9-3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
30–25K
525–50K
1150–75K
375–100K
12100–150K
6150K+
40 reports with mileage · 24 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports0 fire reports10 injury reports
What owners actually said
64 reportsTHE DIRECT IGNITION FAILED ON MY 1999 SAAB 93. IT IS NOT COVERED UNDER THE RECALL. THE "SERVICE ENGINE SOON" LIGHT CAME ON WHICH ALERTED US TO THE PROBLEM. MY AUTHORIZED SAAB MECHANIC INFORMED ME THAT IT WAS THE WISEST COURSE TO REPLACE THIS FAULTY PART BEFORE IT FAILED COMPLETELY. THE COST TO DO SO $500 OUT OF MY OWN POCKET…
Read full complaint
THE DIRECT IGNITION FAILED ON MY 1999 SAAB 93. IT IS NOT COVERED UNDER THE RECALL. THE "SERVICE ENGINE SOON" LIGHT CAME ON WHICH ALERTED US TO THE PROBLEM. MY AUTHORIZED SAAB MECHANIC INFORMED ME THAT IT WAS THE WISEST COURSE TO REPLACE THIS FAULTY PART BEFORE IT FAILED COMPLETELY. THE COST TO DO SO $500 OUT OF MY OWN POCKET TO REPLACE THIS INHERENTLY FAULTY PART. *JB
1999 SAAB 9-3 IGNITION CASSETTE FAILURE. *JB
I BELIEVE MY 1999 SAAB 9-3 SHOULD HAVE BEEN INCLUDED IN RECENT SAAB IGNITION MODULE RECALLS, MY IGNITION MODULE IS NO DIFFERENT THAN THE 2000 MODELS, THE RECENT FAILURE OF THIS PART INVOLVES SAFETY FACTORS SAME AS THE 2000 MODELS, REPLACEMENT COST IS OVER 400.00 AND SHOULD BE REIMBURSED. *JB
DIRECT IGNITION CASSETTE (IGNITION DISCHARGE MODULE) FAILED. ENGINE WOULD NOT START AFTER BEING TURNED OFF. CAR WAS TOWED, EVALUATED, AND THE IGNITION DISCHARGE MODULE WAS REPLACED. THE IGNITION DISCHARGE MODULE THAT FAILED WAS IDENTICAL TO THE IDM THAT IS CURRENTLY UNDER RECALL FOR 2000-2002 MODEL YEARS. I AM REQUESTING THA…
Read full complaint
DIRECT IGNITION CASSETTE (IGNITION DISCHARGE MODULE) FAILED. ENGINE WOULD NOT START AFTER BEING TURNED OFF. CAR WAS TOWED, EVALUATED, AND THE IGNITION DISCHARGE MODULE WAS REPLACED. THE IGNITION DISCHARGE MODULE THAT FAILED WAS IDENTICAL TO THE IDM THAT IS CURRENTLY UNDER RECALL FOR 2000-2002 MODEL YEARS. I AM REQUESTING THAT THE RECALL BE EXTENDED TO INCLUDE THE 1999 MODEL YEAR. I HAVE RETAINED THE FAILED PART. *NM
ON THURSDAY JAN 26 2006 AT APROX 12 PM I PARKED PUT CAR IN A PARKING LOT AND WENT INTO THE BANK IN CANTON, GEORGA. ON RETURNING I GOT INTO CAR, PUT THE KEY INTO THE IGNITION ,AND AS I TURNED THE KEY TO START THE CAR THE PASSENGER SIDE AIR BAG DEPLOYED, DESTROYING THE DASHBOARD/DAMAGING THE WINDSHIELD AND BLOWING OUT THE RADIO A…
Read full complaint
ON THURSDAY JAN 26 2006 AT APROX 12 PM I PARKED PUT CAR IN A PARKING LOT AND WENT INTO THE BANK IN CANTON, GEORGA. ON RETURNING I GOT INTO CAR, PUT THE KEY INTO THE IGNITION ,AND AS I TURNED THE KEY TO START THE CAR THE PASSENGER SIDE AIR BAG DEPLOYED, DESTROYING THE DASHBOARD/DAMAGING THE WINDSHIELD AND BLOWING OUT THE RADIO AND VARIOUS CONTROL KNOBS.*AK
NOTE: THIS IS THE EXACT PART AND SYMPTOM DESCRIBED IN NHTSA CAMPAIGN ID NUMBER : 05V399000 FOR 2000-2003 YEARS. 1) I WAS DRIVING UP A HILL, AND THE CAR STOPPED DRIVING. 2) ONCE IT CAME TO A STOP, I COULD NOT RESTART THE CAR. ) THE IGNITION WAS REPLACED, AND THE SERVICE CENTER CONFIRMED THAT IT WAS THE SAME PART THAT IS COVE…
Read full complaint
NOTE: THIS IS THE EXACT PART AND SYMPTOM DESCRIBED IN NHTSA CAMPAIGN ID NUMBER : 05V399000 FOR 2000-2003 YEARS. 1) I WAS DRIVING UP A HILL, AND THE CAR STOPPED DRIVING. 2) ONCE IT CAME TO A STOP, I COULD NOT RESTART THE CAR. ) THE IGNITION WAS REPLACED, AND THE SERVICE CENTER CONFIRMED THAT IT WAS THE SAME PART THAT IS COVERED IN THE 2000-2003 RECALL. *AK
DIC (DIRECT IGNITION CASSETTE) FAILURE, ALSO KNOWN AS THE IDM CASSETTE OR IGNITION COIL. I HAVE READ SEVERAL OTHER COMPLAINTS OF THE IGNITION CASSETTE FAILING AND THIS IS A MAJOR SAFETY ISSUE. IT IS AN EXPENSIVE REPAIR, AS WELL. APPEARS THAT THERE IS A PENDING RECALL ON THE 2000-2002 MODELS AND I WOULD LIKE TO SEE THE RECALL …
Read full complaint
DIC (DIRECT IGNITION CASSETTE) FAILURE, ALSO KNOWN AS THE IDM CASSETTE OR IGNITION COIL. I HAVE READ SEVERAL OTHER COMPLAINTS OF THE IGNITION CASSETTE FAILING AND THIS IS A MAJOR SAFETY ISSUE. IT IS AN EXPENSIVE REPAIR, AS WELL. APPEARS THAT THERE IS A PENDING RECALL ON THE 2000-2002 MODELS AND I WOULD LIKE TO SEE THE RECALL EXTEND TO THE 1999 MODELS; SAME MODULE. I WOULD NOT HAVE BEEN AWARE OF THE PENDING RECALL ON THE 2000-2002 MODELS EXCEPT THAT I HAVE A FRIEND WHO RECEIVED A LETTER AND I DECIDED TO INVESTIGATE. PLEASE ADVISE WHY THE DEFECT INVESTIGATION PE05017 WAS CLOSED PENDING GM'S ACTIONS ON THE 2000-2002 MODELS. THE 1999 MODEL AND ANY OTHER AFFECTED MODELS SHOULD BE COVERED BY ANY RECALL, AS WELL. I'M SURE MANY PEOPLE ARE NOT AWARE OF ABILITY TO REPORT ISSUE AND REALIZE THAT IT IS A MAJOR DEFECT. PLEASE ADVISE. *NM
DT: THE CONTACT STATED VEHICLE STALLED, AND HAD TO BE TOWED TO THE DEALERSHIP. THE IGNITION CASSETTE WAS REPLACED. THE VEHICLE IS WORKING PROPERLY AT THIS TIME. *AK
DT: THE CONTACT STATED VEHICLE STALLED WHILE IN A PARKING LOT. HE TRIED TO RESTART IT TEN MINUTES LATER BUT IT WOULD NOT START. THE VEHICLE WAS TOWED TO THE DEALERSHIP, AND THEY REPLACED THE DIRECT IGNITION CASSETTE. THERE WAS A RECALL FOR LATER MODEL VEHICLES AND THE PART WAS THE SAME UNIT THAT WAS IN THIS VEHICLE. *AK …
Read full complaint
DT: THE CONTACT STATED VEHICLE STALLED WHILE IN A PARKING LOT. HE TRIED TO RESTART IT TEN MINUTES LATER BUT IT WOULD NOT START. THE VEHICLE WAS TOWED TO THE DEALERSHIP, AND THEY REPLACED THE DIRECT IGNITION CASSETTE. THERE WAS A RECALL FOR LATER MODEL VEHICLES AND THE PART WAS THE SAME UNIT THAT WAS IN THIS VEHICLE. *AK UPDATED 11/29/05. *JB UPDATED 11/29/2005. *NM
Official recalls
399V362000 · Equipment:other:labels
Dec 29, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BRAKE RESERVOIR LABEL WAS OMITTED. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 135, "PASSENGER CAR BRAKE SYSTEMS."
Consequence & remedy
Consequence: WITHOUT THIS LABEL, SOMEONE MAY USE THE INCORRECT SPECIFICATION BRAKE FLUID, GET DIRT INTO THE RESERVOIR, OR ALLOW MOISTURE INTO THE BRAKE FLUID, RESULTING IN LESS EFFECTIVE BRAKING AND POSSIBLY A CRASH.
Remedy: OWNERS WILL BE MAILED LABELS AND INSTALLATION INSTRUCTIONS.
99V246000 · Seats
Sep 13, 1999
VEHICLE DESCRIPTION: PASSSENGER VEHICLES. FAILURES OF THE "EASY ENTRY" CABLE IN THE FRONT DRIVER OR PASSENGER MANUAL SEATS CAN CAUSE THE SEAT FORE/AFT ADJUSTABLE MECHANISM TO BE UNLOCKED.
Consequence & remedy
Consequence: SINCE THE ANCHOR POINTS FOR THE LAP PORTION OF THE FRONT SAFETY BELTS ARE ATTACHED TO THE SEAT ASSEMBLY, RELEASE OF THE FORE/AFT LOCKING MECHANISM REDUCES THE RESTRAINT CAPABILITY OF THE SAFETY BELTS IN A CRASH.
Remedy: DEALERS WILL INSTALL A NEW CABLE AND SPRING ASSEMBLY.
98V139000 · Equipment:other:labels
Jun 23, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG ALERT LABEL ON THE DRIVER SIDE VISOR WAS OMITTED. THIS DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: THE VEHICLE OCCUPANT MAY NOT PROPERLY UNDERSTAND THE OPERATION OF THE AIR BAG SYSTEM AND THE NEED TO USE SEAT BELTS.
Remedy: OWNERS WILL BE PROVIDED WITH AN ALERT LABEL TO BE INSTALLED ON THE VISIBLE SIDE OF THE DRIVER'S SUN VISOR. IF AN OWNER SO DESIRES, THEIR DEALER CAN INSTALL THE LABEL FOR THEM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE05017 · Engine Stall/ Engine Compartment Fires
Opened Apr 7, 2005 · Closed Sep 23, 2005
Status: closed (inferred from source dates) · Electrical System; Electrical System:ignition; Electrical System:ignition:module
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (6)
Electrical System:ignition:module
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System:ignition:module
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System:ignition
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System:ignition
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.