IllustrationFOR MY 1999 SAAB 9-3, BASE ENGINE, I REPLACED THE DIRECT IGNITION CASSETTE, AT 128,800 MILES ON THE ODOMETER. THE PART ALONE WAS $488 AND THE TOTAL INSTALLATION COST AND PARTS (INCLUDING A HOSE AND FOUR SPARK PLUGS) WAS $760. MODEL YEARS 2000 THROUGH 2002 WERE RECALLED FOR THIS PART. *TR
1999 Saab 9-3
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Saab 9-3 do not stand out strongly from the model-year median of 61.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all 9-3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
30–25K
525–50K
1150–75K
375–100K
12100–150K
6150K+
40 reports with mileage · 24 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports0 fire reports10 injury reports
Electrical System complaints
22 reportsTL*THE CONTACT OWNS A 1999 SAAB 9-3. WHILE DRIVING APPROXIMATELY 55 MPH IN THE SNOW, THE DRIVER'S SIDE AIR BAG SUDDENLY DEPLOYED WITHOUT AN IMPACT OR CRASH OCCURRING. THERE WERE NO INJURIES. LATER THAT DAY, THE AIR BAG INDICATOR ILLUMINATED. HER MECHANIC STATED THAT THE AIR BAGS WOULD NOT FUNCTION PROPERLY AND ENSURE MAXIMUM…
Read full complaint
TL*THE CONTACT OWNS A 1999 SAAB 9-3. WHILE DRIVING APPROXIMATELY 55 MPH IN THE SNOW, THE DRIVER'S SIDE AIR BAG SUDDENLY DEPLOYED WITHOUT AN IMPACT OR CRASH OCCURRING. THERE WERE NO INJURIES. LATER THAT DAY, THE AIR BAG INDICATOR ILLUMINATED. HER MECHANIC STATED THAT THE AIR BAGS WOULD NOT FUNCTION PROPERLY AND ENSURE MAXIMUM PROTECTION IN THE EVENT OF A CRASH. THE VEHICLE WAS TAKEN TO A CERTIFIED MECHANIC FOR DIAGNOSTIC TESTING AND THE WIRING WAS DETERMINED TO BE THE CAUSE OF THE FAILURE. THE MANUFACTURER WOULD NOT ASSIST BECAUSE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE CURRENT MILEAGE WAS APPROXIMATELY 141,000 AND FAILURE MILEAGE WAS APPROXIMATELY 138,000.
TL*THE CONTACT OWNS A 1999 SAAB 9-3. THE CONTACT ATTEMPTED TO START HIS VEHICLE, BUT WAS UNSUCCESSFUL. THE VEHICLE CRANKED, BUT HE RECEIVED NO SPARK. HE ATTEMPTED TO CHANGE THE FUEL PUMP, WHICH DID NOT REPAIR THE FAILURE. HE ALSO REMOVED THE SPARK PLUG WIRES AND NOTICED THAT VARIOUS PARTS WERE CRACKED UNDERNEATH THE IGNITION…
Read full complaint
TL*THE CONTACT OWNS A 1999 SAAB 9-3. THE CONTACT ATTEMPTED TO START HIS VEHICLE, BUT WAS UNSUCCESSFUL. THE VEHICLE CRANKED, BUT HE RECEIVED NO SPARK. HE ATTEMPTED TO CHANGE THE FUEL PUMP, WHICH DID NOT REPAIR THE FAILURE. HE ALSO REMOVED THE SPARK PLUG WIRES AND NOTICED THAT VARIOUS PARTS WERE CRACKED UNDERNEATH THE IGNITION. A JUNKYARD MECHANIC STATED THAT THE IGNITION WAS THE CAUSE OF THE MALFUNCTION. THE CONTACT DISCOVERED NHTSA CAMPAIGN ID NUMBER 05V399000 (ELECTRICAL SYSTEM:IGNITION:MODULE), WHICH PERTAINED TO THE 2000-2002 SAAB 9-3'S. THE DEALER STATED THAT THE REPAIR WOULD COST $464. THE FAILURE MILEAGE WAS 118,356.
I HAVE A 1999 SAAB 9-3 WITH MANUAL CLIMATE CONTROL. THE BLOWER SWITCH WAS ERRATIC FOR A FEW WEEKS (ON/OFF POSITION SHIFTED) BUT LAST NIGHT DURING A SHORT JOURNEY THE BLOWER WOULD NOT TURN OFF AND A BAD ODOR BECAME PRESENT IN THE CABIN. THIS MORNING I INVESTIGATED AND FOUND THAT THE BLOWER SWITCH AND WIRING CONNECTOR AND WIRES …
Read full complaint
I HAVE A 1999 SAAB 9-3 WITH MANUAL CLIMATE CONTROL. THE BLOWER SWITCH WAS ERRATIC FOR A FEW WEEKS (ON/OFF POSITION SHIFTED) BUT LAST NIGHT DURING A SHORT JOURNEY THE BLOWER WOULD NOT TURN OFF AND A BAD ODOR BECAME PRESENT IN THE CABIN. THIS MORNING I INVESTIGATED AND FOUND THAT THE BLOWER SWITCH AND WIRING CONNECTOR AND WIRES HAVE MELTED. IT IS LIKELY THAT IF THE JOURNEY HAD BEEN LONGER A FIRE WOULD HAVE RESULTED. THE SWITCH AND CONNECTOR AND WIRES NEED TO BE REPLACED, AND THE REASON FOR THE BLOWER SWITCH ERRATIC BEHAVIOR NEEDS TO BE INVESTIGATED. *JB
WHILE DRIVING AT FREEWAY SPEEDS FOR ABOUT 20 MINUTES, MY 1999 SAAB 9-3 EXPERIENCED A LOSS OF POWER AND THE ENGINE STOPPED RUNNING. THERE WAS NO WARNING OF A PROBEM UNTIL A SINGLE "CLUNKING NOISE" WAS DETECTED AND THEN THERE WAS NO POWER IN 5TH OR 4TH GEAR. BY THE TIME I DOWNSHIFTED TO 3RD GEAR, THE ENGINE HAD STALLED AND THE …
Read full complaint
WHILE DRIVING AT FREEWAY SPEEDS FOR ABOUT 20 MINUTES, MY 1999 SAAB 9-3 EXPERIENCED A LOSS OF POWER AND THE ENGINE STOPPED RUNNING. THERE WAS NO WARNING OF A PROBEM UNTIL A SINGLE "CLUNKING NOISE" WAS DETECTED AND THEN THERE WAS NO POWER IN 5TH OR 4TH GEAR. BY THE TIME I DOWNSHIFTED TO 3RD GEAR, THE ENGINE HAD STALLED AND THE CHECK ENGINE, BATTERY/ALTERNATOR, AND OIL PRESSURE WARNING LIGHTS LIT. THE CAR WAS NOT ABLE TO BE RESARTED. I WAS ABLE TO BRING THE CAR TO THE DISTRESS LANE AND SUMMON HELP (911). THE CAR NEEDED TO BE TOWED FOR REPAIRS. THE LOCAL SAAB DEALER DETERMINED THE IGNITION DISCHARGE MODULE (IDM) HAD FAILED (BURNED UP). THE DEALER ALSO INFORMED ME OF A RECENT RECALL (I BELIEVE IT'S 05V-399) FOR THE 2000 - 2002 MODEL YEARS AND THAT PERHAPS THE IDM ON MY CAR HAD A SIMILAR DEFECT. THE DEALER INSTALLED A NEW IDM (REPLACEMENT PART 55-561-132) AND 4 NEW SPARK PLUGS WHICH HAD BEEN FOULED FROM MY REPEATED EFFORTS TO RESTART THE CAR. I DID NOT RECEIVE OLD PARTS BACK.
DT*: THE CONTACT STATED THE VEHICLE STALLED WHILE DRIVING 45-50 MPH ON A SNOW COVERED HIGHWAY. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DETERMINED THE RECOGNITION CASSETTE MODULE FAILED. THE DEALERSHIP WAS NOT NOTIFIED. THERE WERE NO PRIOR PROBLEMS WITH THE VEHICLE. THE CHECK ENGINE LIGHT ILLUMINATED AT THE TIME…
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE STALLED WHILE DRIVING 45-50 MPH ON A SNOW COVERED HIGHWAY. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DETERMINED THE RECOGNITION CASSETTE MODULE FAILED. THE DEALERSHIP WAS NOT NOTIFIED. THERE WERE NO PRIOR PROBLEMS WITH THE VEHICLE. THE CHECK ENGINE LIGHT ILLUMINATED AT THE TIME OF THE INCIDENT. UPDATED 11/3/2006 - ON 11/24/05 THE VEHICLE'S DIRECT IGNITION CASSETTE FAILED WITHOUT WARNING WHICH CAUSED THE VEHICLE TO STALL WHILE BEING DRIVEN IN THE SNOW. AFTER REPLACEMENT OF THE DIRECT IGNITION CASSETTE THE REPAIR FACILITY ALSO HAD TO REPLACE TWO OXYGEN SENSORS AND THE CATALYTIC CONVERTER. THE TECHNICIAN SAID IT WAS POSSIBLE THAT RAW FUEL DAMAGED THE CATALYTIC CONVERTER DURING THE INITIAL FAILURE OF THE DIRECT IGNITION CASSETTE. *NM
DIRECT IGNITION CASSETTE FAILED ON MY 1999 SAAB 9-3. A RECALL HAS BEEN ISSUED FOR 2000-2002 SAAB 9-3 AND I FEEL THIS RECALL SHOULD INCLUDE THE '99 MODEL AS WELL BECAUSE THIS PART HAS A LESS THAN REASONABLE LIFE. *JB
THE DIRECT IGNITION FAILED ON MY 1999 SAAB 93. IT IS NOT COVERED UNDER THE RECALL. THE "SERVICE ENGINE SOON" LIGHT CAME ON WHICH ALERTED US TO THE PROBLEM. MY AUTHORIZED SAAB MECHANIC INFORMED ME THAT IT WAS THE WISEST COURSE TO REPLACE THIS FAULTY PART BEFORE IT FAILED COMPLETELY. THE COST TO DO SO $500 OUT OF MY OWN POCKET…
Read full complaint
THE DIRECT IGNITION FAILED ON MY 1999 SAAB 93. IT IS NOT COVERED UNDER THE RECALL. THE "SERVICE ENGINE SOON" LIGHT CAME ON WHICH ALERTED US TO THE PROBLEM. MY AUTHORIZED SAAB MECHANIC INFORMED ME THAT IT WAS THE WISEST COURSE TO REPLACE THIS FAULTY PART BEFORE IT FAILED COMPLETELY. THE COST TO DO SO $500 OUT OF MY OWN POCKET TO REPLACE THIS INHERENTLY FAULTY PART. *JB
1999 SAAB 9-3 IGNITION CASSETTE FAILURE. *JB
I BELIEVE MY 1999 SAAB 9-3 SHOULD HAVE BEEN INCLUDED IN RECENT SAAB IGNITION MODULE RECALLS, MY IGNITION MODULE IS NO DIFFERENT THAN THE 2000 MODELS, THE RECENT FAILURE OF THIS PART INVOLVES SAFETY FACTORS SAME AS THE 2000 MODELS, REPLACEMENT COST IS OVER 400.00 AND SHOULD BE REIMBURSED. *JB
Official recalls
399V362000 · Equipment:other:labels
Dec 29, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BRAKE RESERVOIR LABEL WAS OMITTED. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 135, "PASSENGER CAR BRAKE SYSTEMS."
Consequence & remedy
Consequence: WITHOUT THIS LABEL, SOMEONE MAY USE THE INCORRECT SPECIFICATION BRAKE FLUID, GET DIRT INTO THE RESERVOIR, OR ALLOW MOISTURE INTO THE BRAKE FLUID, RESULTING IN LESS EFFECTIVE BRAKING AND POSSIBLY A CRASH.
Remedy: OWNERS WILL BE MAILED LABELS AND INSTALLATION INSTRUCTIONS.
99V246000 · Seats
Sep 13, 1999
VEHICLE DESCRIPTION: PASSSENGER VEHICLES. FAILURES OF THE "EASY ENTRY" CABLE IN THE FRONT DRIVER OR PASSENGER MANUAL SEATS CAN CAUSE THE SEAT FORE/AFT ADJUSTABLE MECHANISM TO BE UNLOCKED.
Consequence & remedy
Consequence: SINCE THE ANCHOR POINTS FOR THE LAP PORTION OF THE FRONT SAFETY BELTS ARE ATTACHED TO THE SEAT ASSEMBLY, RELEASE OF THE FORE/AFT LOCKING MECHANISM REDUCES THE RESTRAINT CAPABILITY OF THE SAFETY BELTS IN A CRASH.
Remedy: DEALERS WILL INSTALL A NEW CABLE AND SPRING ASSEMBLY.
98V139000 · Equipment:other:labels
Jun 23, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG ALERT LABEL ON THE DRIVER SIDE VISOR WAS OMITTED. THIS DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: THE VEHICLE OCCUPANT MAY NOT PROPERLY UNDERSTAND THE OPERATION OF THE AIR BAG SYSTEM AND THE NEED TO USE SEAT BELTS.
Remedy: OWNERS WILL BE PROVIDED WITH AN ALERT LABEL TO BE INSTALLED ON THE VISIBLE SIDE OF THE DRIVER'S SUN VISOR. IF AN OWNER SO DESIRES, THEIR DEALER CAN INSTALL THE LABEL FOR THEM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE05017 · Engine Stall/ Engine Compartment Fires
Opened Apr 7, 2005 · Closed Sep 23, 2005
Status: closed (inferred from source dates) · Electrical System; Electrical System:ignition; Electrical System:ignition:module
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (6)
Electrical System:ignition:module
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System:ignition:module
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System:ignition
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System:ignition
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.