When it rains, or water is allowed to collect on top of the roof, water seeps in through the hinges of the driver and passenger sun visors. Depending on how much water is allowed to collect, it can trickle in or gush right inside the interior of the vehicle. Not only can it come in thru the sun visor hinges, but water also came …
Read full complaint
When it rains, or water is allowed to collect on top of the roof, water seeps in through the hinges of the driver and passenger sun visors. Depending on how much water is allowed to collect, it can trickle in or gush right inside the interior of the vehicle. Not only can it come in thru the sun visor hinges, but water also came out of my center roof console where my hazards and SOS button are at, causing me to worry about a water + electricity issue. Furthermore, the water obviously gets the carpeted floor wet. My truck is in the Van Nuys Rivian service center for the 2nd time for this issue. This is a well known issue on Rivian forums and on the Rivian subreddit.
NHTSA ODI #11708829
Mileage unknown · Oct 29, 2025
Unknown Or Other
My truck was recently upgraded to software version 2050.38.0. After the upgrade, I drove my truck about 3 miles in about 5 minutes. When I arrived at my destination, I exited the truck to get something out of the rear seat. The rear door was locked; this is normal. I returned to the front seat to unlock the door via the contr…
Read full complaint
My truck was recently upgraded to software version 2050.38.0. After the upgrade, I drove my truck about 3 miles in about 5 minutes. When I arrived at my destination, I exited the truck to get something out of the rear seat. The rear door was locked; this is normal. I returned to the front seat to unlock the door via the control panel, but the unlock function did not work. The button is in the center touchscreen of the truck. I check the screen on the center console. It appeared the unlock button was disabled due to the information screen from the code update. This screen was not there when I exited the truck. After I acknowledged the screen, the unlock button was working. If I were trying to unlock the doors due to an emergency, this delay would be an issue. I feel the unlock door button should always work. Disabling the button for a verification screen is a safety hazard.
NHTSA ODI #11696263
Mileage unknown · Aug 21, 2025
Unknown Or Other
I was shifting my truck from park to reverse when the shift handle snapped off. There was no warning and I had just driven the vehicle a couple hours earlier. The truck only has 13k miles on it.
NHTSA ODI #11682044
Mileage unknown · Sep 5, 2024
Unknown Or Other
The horn in the car is very weak and not heard by 3d party when used. Had several occurrences when I needed to use the horn and the 3d party never mentioned it. It is a by far weaker than any other of my cars.
NHTSA ODI #11612796
Mileage unknown · Apr 20, 2023
Electrical SystemUnknown Or Other
I picked up this vehicle brand new from a Rivian service center. On the way home after approximately 90 miles, the screens lit up with a message saying Critical Battery Issue: Service Vehicle Immediately. In addition to the warnings on the console, there was a very loud beeping sound that did not stop. My understanding of the …
Read full complaint
I picked up this vehicle brand new from a Rivian service center. On the way home after approximately 90 miles, the screens lit up with a message saying Critical Battery Issue: Service Vehicle Immediately. In addition to the warnings on the console, there was a very loud beeping sound that did not stop. My understanding of the issue from speaking to Service and reading forums is that there is a software issue interacting with the battery which can cause this issue and eventually the vehicle to brick. It could cause a safety issue because in my case, it happened out of nowhere and forced me to pull over to the side of the road to protect myself and my family and the vehicle. In attempts to tow it to the service center, we also discovered that it was not possible to place the car in neutral which made it difficult to place on the tow truck. Had the car shut down entirely, I am not sure what the option would have been. To the best of my knowledge, Service has not officially diagnosed or determined the issue with my vehicle. Some of the information I have provided comes from research in online forums where others were encountering this problem at least back in 2022. It concerns me that there is still an issue especially as this was a brand new car and this manufacturer is attempting to ramp up production. It seems plausible there could be many more cars on the road soon and many/all contain this issue. There were no indications whatsoever before the message and noise began and I was driving down the highway at a normal and constant rate of speed.
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and 2022-2026 R1S vehicles. The bolts that secure the second-row driver and passenger side seat belt retractor assemblies may be improperly tightened.
Consequence & remedy
Consequence: An improperly secured seat belt retractor may not adequately restrain the seat occupant, increasing the risk of injury during a crash.
Remedy: Rivian will inspect and tighten the bolts as necessary, free of charge. Owner notification letters were mailed March 2, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1795.
Additional source detail variants (2)
Seat Belts:rear/other:retractor
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and 2022-2026 R1S vehicles. The bolts that secure the second-row driver and passenger side seat belt retractor assemblies may be improperly tightened.
Consequence: An improperly secured seat belt retractor may not adequately restrain the seat occupant, increasing the risk of injury during a crash.
Remedy: Rivian will inspect and tighten the bolts as necessary, free of charge. Owner notification letters were mailed March 2, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1795.
Seat Belts:critical Fasteners
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and 2022-2026 R1S vehicles. The bolts that secure the second-row driver and passenger side seat belt retractor assemblies may be improperly tightened.
Consequence: An improperly secured seat belt retractor may not adequately restrain the seat occupant, increasing the risk of injury during a crash.
Remedy: Rivian will inspect and tighten the bolts as necessary, free of charge. Owner notification letters were mailed March 2, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1795.
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1S and R1T vehicles that previously had service performed. The toe link may have been reassembled incorrectly during service procedures performed before March 10, 2025.
Consequence & remedy
Consequence: The toe link joint may separate, increasing the risk of a crash.
Remedy: Rivian will replace the rear toe link bolts, free of charge. Owner notification letters were mailed February 17, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1794. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 24, 2026.
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and R1S vehicles. The D-ring bolts for one or both front seat belt anchorage assemblies may not have been properly installed.
Consequence & remedy
Consequence: An improperly secured seat belt may not restrain an occupant as intended, increasing the risk of injury during a crash.
Remedy: Rivian will inspect and properly secure the seat belt anchorage assemblies as necessary, free of charge. Owner notification letters were mailed July 8, 2025. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1681.
Rivian Automotive, LLC. (Rivian) is recalling certain 2022-2023 R1S and R1T vehicles. The maximum vehicle capacity weight value on the tire placard label is incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: A vehicle with an incorrect maximum capacity weight value may be overloaded, which can increase the risk of a crash.
Remedy: Rivian will mail owners a corrected overlay tire placard label, free of charge. Owner notification letters were mailed August 8, 2024. Owners may contact Rivian customer service at 1-888-748-4264. Rivian's number for this recall is FSAM-1491.
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2024 R1T and R1S vehicles. The attachment clips on the upper B-pillar and/or C-pillar trim panels may have been damaged during a service procedure.
Consequence & remedy
Consequence: Damaged pillar trim panel clips can result in improper side curtain air bag deployment, increasing the risk of injury during a crash.
Remedy: Rivian will replace the pillar trim panels, free of charge. Owner notification letters were mailed July 16, 2024. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM 1464.
Additional source detail variants (2)
Air Bags:critical Fasteners
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2024 R1T and R1S vehicles. The attachment clips on the upper B-pillar and/or C-pillar trim panels may have been damaged during a service procedure.
Consequence: Damaged pillar trim panel clips can result in improper side curtain air bag deployment, increasing the risk of injury during a crash.
Remedy: Rivian will replace the pillar trim panels, free of charge. Owner notification letters were mailed July 16, 2024. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM 1464.
Air Bags:side/window:curtain
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2024 R1T and R1S vehicles. The attachment clips on the upper B-pillar and/or C-pillar trim panels may have been damaged during a service procedure.
Consequence: Damaged pillar trim panel clips can result in improper side curtain air bag deployment, increasing the risk of injury during a crash.
Remedy: Rivian will replace the pillar trim panels, free of charge. Owner notification letters were mailed July 16, 2024. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM 1464.
Rivian Automotive, LLC. (Rivian) is recalling certain 2023-2024 EDV, R1S, and R1T vehicles. The headlights may be improperly aimed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamp, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: Improperly aimed headlights can result in insufficient illumination of the road, decreasing the driver's visibility and increasing the risk of a crash.
Remedy: Rivian will inspect and adjust the headlight alignment as necessary, free of charge. Owner notification letters were mailed June 28, 2024. Owners may contact Rivian customer service at 1-888-748-4264. Rivian's number for this recall is FSAM-1445.
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1T and R1S vehicles. A software update may have deactivated the defroster and defogger system controls.
Consequence & remedy
Consequence: The inability to operate the windshield defrosting and defogging system can decrease the driver's visibility, increasing the risk of a crash.
Remedy: Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1331.
Additional source detail variants (2)
Equipment:electrical:infotainment:software
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1T and R1S vehicles. A software update may have deactivated the defroster and defogger system controls.
Consequence: The inability to operate the windshield defrosting and defogging system can decrease the driver's visibility, increasing the risk of a crash.
Remedy: Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1331.
Visibility:defroster/defogger/hvac System
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1T and R1S vehicles. A software update may have deactivated the defroster and defogger system controls.
Consequence: The inability to operate the windshield defrosting and defogging system can decrease the driver's visibility, increasing the risk of a crash.
Remedy: Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE26004 · Rear Toe Link May Separate
Opened May 26, 2026 · No close date supplied
Status: open (inferred from source dates) · Suspension:rear
The Office of Defects Investigation (ODI) has received two Vehicle Owner Questionnaires (VOQs) reporting left rear toe link separation in certain Model Year (MY) 2023-2024 Rivian R1S vehicles. Both VOQs report component separation while driving, causing the vehicles to swerve across multiple lanes of traffic. One incident resulted in a collision with an adjacent vehicle and roadside barrier. In both separations, the bolt that maintains the integrity of the toe link fractured. Evidence collected from the complaint vehicles included repair histories, onboard video, imagery of the damaged components, and a police accident report. The two vehicles with reported separation have different vehicle histories. One vehicle received prior service and the other was involved in a previous collision. In both instances, the vehicles operated for multiple months and thousands of miles of usage with no apparent problems between the previous service or the previous collision and the failures that prompted this investigation. Rivian recognized the subject toe link joint’s sensitivity to service procedures in March of 2025 in its updated service procedures. In January 2026 through recall 26V-003, Rivian extended the improved repair procedure to vehicles that received toe link service prior to the March 2025 improvement. ODI is opening a Preliminary Evaluation (PE) to (1) assess the sensitivity of the rear toe link joint to foreseeable road and service conditions, (2) compare the physical failure evidence from the two VOQs to identify apparent similarities and potential differences, (3) evaluate Rivian’s current toe link repair procedure, and (4) assess the in-field subject population’s toe links conditions. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov
2023 Rivian R1T Problems, Complaints & Recalls | Skip That Year
Illustration