Air Bags. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seats. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

10 crash reports0 fire reports3 injury reports

Fuel/propulsion System complaints

2 reports

Clear category filter

Mileage unknown · Sep 9, 2026

Electrical SystemFuel/propulsion SystemUnknown Or Other

Read full complaint

The specific failed component is UNKNOWN. My 2023 Rivian R1S has experienced recurring intermittent Limited Performance/loss-of-propulsion-type events since within months of delivery. The events involve unexpected reduction of available propulsion, reduced maximum speed, warnings, restarts, system/display restarts, and at times inability to move or change gears. Rivian documented Limited Performance while driving in January 2024. In March 2024, Rivian documented loss of propulsion and an approximately 10 mph maximum speed; a reset and sleep cycle did not correct the condition. Rivian later stated it could not reproduce the concern. In March 2026, Rivian documented Limited Performance while driving, the vehicle coming to a stop, and multiple restarts before it would move. On September 4, 2026, the vehicle again entered Limited Performance and would not exceed approximately 20 mph. After a restart, it operated normally. Rivian received the vehicle for service on September 7. On September 9, Rivian stated that initial testing did not duplicate the Limited Performance telltale, that it had no confirmed repair, and that it proposed an extended approximately 100-mile test drive to try to reproduce the issue. I retained photos and videos of additional events involving reduced speed, warnings, restarts, and inability to move. The intermittent loss or reduction of propulsion while driving can affect my ability to maintain safe speed and creates a potential crash risk. There was no crash, injury, or fire in the incidents described.

NHTSA ODI #11763244

Mileage unknown · Jul 30, 2026

Electrical SystemFuel/propulsion SystemVehicle Speed ControlCrash

Read full complaint

On XXX, at approximately 12:19 PM, I was in the drive-through lane at a Chick-fil-A in [XXX], with my child as a passenger. I was using one-pedal driving mode and had come to a complete stop with my foot off the accelerator. I turned briefly to hand my child an ice cream cup, and when I looked back at the road, the vehicle was accelerating at full power with no contact from either pedal. To avoid striking the vehicles stopped ahead of me in the drive-through line, I swerved left into the Chick-fil-A building, causing a collision with the building. This put myself, my child, and nearby pedestrians and drivers at serious risk of injury. Cedar Park Police Department responded to the scene and a report was filed. I have video footage of the incident. The vehicle is available for inspection upon request. I believe the accelerator pedal and/or its sensor malfunctioned, possibly related to a known issue some other Rivian owners have reported involving cabin temperature affecting the pedal sensor; this has not yet been confirmed by a dealer or manufacturer. I am requesting that the manufacturer pull the vehicle’s black box/EDR data and perform full diagnostics on the pedal and sensor. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11753900

Official recalls

26V009000 · Seat Belts:critical Fasteners; Seat Belts:rear/other:retractor

Jan 15, 2026

Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and 2022-2026 R1S vehicles. The bolts that secure the second-row driver and passenger side seat belt retractor assemblies may be improperly tightened.

Consequence & remedy

Consequence: An improperly secured seat belt retractor may not adequately restrain the seat occupant, increasing the risk of injury during a crash.

Remedy: Rivian will inspect and tighten the bolts as necessary, free of charge. Owner notification letters were mailed March 2, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1795.

Additional source detail variants (2)

Seat Belts:rear/other:retractor

Consequence: An improperly secured seat belt retractor may not adequately restrain the seat occupant, increasing the risk of injury during a crash.

Remedy: Rivian will inspect and tighten the bolts as necessary, free of charge. Owner notification letters were mailed March 2, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1795.

Seat Belts:critical Fasteners

Consequence: An improperly secured seat belt retractor may not adequately restrain the seat occupant, increasing the risk of injury during a crash.

26V003000 · Suspension:critical Fasteners

Jan 5, 2026

Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1S and R1T vehicles that previously had service performed. The toe link may have been reassembled incorrectly during service procedures performed before March 10, 2025.

Consequence & remedy

Consequence: The toe link joint may separate, increasing the risk of a crash.

Remedy: Rivian will replace the rear toe link bolts, free of charge. Owner notification letters were mailed February 17, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1794. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 24, 2026.

25V370000 · Seat Belts:front:anchorage

Jun 3, 2025

Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and R1S vehicles. The D-ring bolts for one or both front seat belt anchorage assemblies may not have been properly installed.

Consequence & remedy

Consequence: An improperly secured seat belt may not restrain an occupant as intended, increasing the risk of injury during a crash.

Remedy: Rivian will inspect and properly secure the seat belt anchorage assemblies as necessary, free of charge. Owner notification letters were mailed July 8, 2025. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1681.

24V458000 · Equipment:other:labels

Jun 20, 2024

Rivian Automotive, LLC. (Rivian) is recalling certain 2022-2023 R1S and R1T vehicles. The maximum vehicle capacity weight value on the tire placard label is incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Consequence & remedy

Consequence: A vehicle with an incorrect maximum capacity weight value may be overloaded, which can increase the risk of a crash.

Remedy: Rivian will mail owners a corrected overlay tire placard label, free of charge. Owner notification letters were mailed August 8, 2024. Owners may contact Rivian customer service at 1-888-748-4264. Rivian's number for this recall is FSAM-1491.

24V408000 · Air Bags:critical Fasteners; Air Bags:side/window:curtain

Jun 5, 2024

Rivian Automotive, LLC (Rivian) is recalling certain 2022-2024 R1T and R1S vehicles. The attachment clips on the upper B-pillar and/or C-pillar trim panels may have been damaged during a service procedure.

Consequence & remedy

Consequence: Damaged pillar trim panel clips can result in improper side curtain air bag deployment, increasing the risk of injury during a crash.

Remedy: Rivian will replace the pillar trim panels, free of charge. Owner notification letters were mailed July 16, 2024. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM 1464.

Additional source detail variants (2)

Air Bags:critical Fasteners

Consequence: Damaged pillar trim panel clips can result in improper side curtain air bag deployment, increasing the risk of injury during a crash.

Remedy: Rivian will replace the pillar trim panels, free of charge. Owner notification letters were mailed July 16, 2024. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM 1464.

Air Bags:side/window:curtain

Consequence: Damaged pillar trim panel clips can result in improper side curtain air bag deployment, increasing the risk of injury during a crash.

24V367000 · Exterior Lighting:headlights

May 23, 2024

Rivian Automotive, LLC. (Rivian) is recalling certain 2023-2024 EDV, R1S, and R1T vehicles. The headlights may be improperly aimed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamp, Reflective Devices and Associated Equipment."

Consequence & remedy

Consequence: Improperly aimed headlights can result in insufficient illumination of the road, decreasing the driver's visibility and increasing the risk of a crash.

Remedy: Rivian will inspect and adjust the headlight alignment as necessary, free of charge. Owner notification letters were mailed June 28, 2024. Owners may contact Rivian customer service at 1-888-748-4264. Rivian's number for this recall is FSAM-1445.

23V783000 · Equipment:electrical:infotainment:software; Visibility:defroster/defogger/hvac System

Nov 21, 2023

Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1T and R1S vehicles. A software update may have deactivated the defroster and defogger system controls.

Consequence & remedy

Consequence: The inability to operate the windshield defrosting and defogging system can decrease the driver's visibility, increasing the risk of a crash.

Remedy: Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1331.

Additional source detail variants (2)

Visibility:defroster/defogger/hvac System

Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1T and R1S vehicles. A software update may have deactivated the defroster and defogger system controls.

Consequence: The inability to operate the windshield defrosting and defogging system can decrease the driver's visibility, increasing the risk of a crash.

Remedy: Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1331.

Equipment:electrical:infotainment:software

Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1T and R1S vehicles. A software update may have deactivated the defroster and defogger system controls.

Consequence: The inability to operate the windshield defrosting and defogging system can decrease the driver's visibility, increasing the risk of a crash.

23V233000 · Exterior Lighting:back Up Lights

Mar 31, 2023

Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1S vehicles. The reverse light beam may not be visible from certain angles. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: Reduced visibility of the reverse lights increases the risk of a crash.

Remedy: Rivian will repair or replace the reverse lights, free of charge. Owner notification letters were mailed July 12, 2023. Owners may contact Rivian customer service at 1-855-748-4265. Rivian's number for this recall is FSAM-1216.

23V159000 · Air Bags:critical Fasteners; Air Bags:side/window:curtain

Mar 9, 2023

Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1S vehicles. The fasteners that secure the right and left side curtain air bags may be improperly secured.

Consequence & remedy

Consequence: Improperly secured side curtain air bags may not perform as intended, increasing the risk of injury during a crash.

Remedy: Dealers will secure or replace the side curtain air bags as necessary, free of charge. All owners have been notified and all vehicles will be repaired by March 15, 2023. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1185.

Additional source detail variants (2)

Air Bags:side/window:curtain

Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1S vehicles. The fasteners that secure the right and left side curtain air bags may be improperly secured.

Consequence: Improperly secured side curtain air bags may not perform as intended, increasing the risk of injury during a crash.

Remedy: Dealers will secure or replace the side curtain air bags as necessary, free of charge. All owners have been notified and all vehicles will be repaired by March 15, 2023. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1185.

Air Bags:critical Fasteners

Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1S vehicles. The fasteners that secure the right and left side curtain air bags may be improperly secured.

Consequence: Improperly secured side curtain air bags may not perform as intended, increasing the risk of injury during a crash.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE26004 · Rear Toe Link May Separate

Opened May 26, 2026 · No close date supplied

Status: open (inferred from source dates) · Suspension:rear

The Office of Defects Investigation (ODI) has received two Vehicle Owner Questionnaires (VOQs) reporting left rear toe link separation in certain Model Year (MY) 2023-2024 Rivian R1S vehicles. Both VOQs report component separation while driving, causing the vehicles to swerve across multiple lanes of traffic. One incident resulted in a collision with an adjacent vehicle and roadside barrier. In both separations, the bolt that maintains the integrity of the toe link fractured. Evidence collected from the complaint vehicles included repair histories, onboard video, imagery of the damaged components, and a police accident report. The two vehicles with reported separation have different vehicle histories. One vehicle received prior service and the other was involved in a previous collision. In both instances, the vehicles operated for multiple months and thousands of miles of usage with no apparent problems between the previous service or the previous collision and the failures that prompted this investigation. Rivian recognized the subject toe link joint’s sensitivity to service procedures in March of 2025 in its updated service procedures. In January 2026 through recall 26V-003, Rivian extended the improved repair procedure to vehicles that received toe link service prior to the March 2025 improvement. ODI is opening a Preliminary Evaluation (PE) to (1) assess the sensitivity of the rear toe link joint to foreseeable road and service conditions, (2) compare the physical failure evidence from the two VOQs to identify apparent similarities and potential differences, (3) evaluate Rivian’s current toe link repair procedure, and (4) assess the in-field subject population’s toe links conditions. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov