The vehicle experienced a loss or severe reduction of power steering assist. The steering became very difficult to turn, creating a safety concern while operating or maneuvering the vehicle. The issue appears to involve the electric power steering system, steering rack/rack-and-pinion, and/or related electrical harness or connec…
Read full complaint
The vehicle experienced a loss or severe reduction of power steering assist. The steering became very difficult to turn, creating a safety concern while operating or maneuvering the vehicle. The issue appears to involve the electric power steering system, steering rack/rack-and-pinion, and/or related electrical harness or connector. The problem occurred on or about 05/21/2026 at approximately 49000 miles.While driving. The vehicle was inspected by dealer, The diagnosis was harness/connector issue, corrosion/water intrusion, power steering module connector issue. The repair estimate/repair involved $4800. I am concerned this may be related to NHTSA investigation PE26002 involving 2022–2023 Ram ProMaster power steering assist failure and possible water intrusion into the power steering module connector.
The contact owns a 2023 RAM PROMASTER. The contact stated while driving the vehicle at an undisclosed speed, while changing lanes the steering wheel is trying to drive the vehicle into another lane and barriers at times without the Collison avoidance system activating. The contact stated the collision avoidance system is very de…
Read full complaint
The contact owns a 2023 RAM PROMASTER. The contact stated while driving the vehicle at an undisclosed speed, while changing lanes the steering wheel is trying to drive the vehicle into another lane and barriers at times without the Collison avoidance system activating. The contact stated the collision avoidance system is very delayed or sometimes does not show up at all, he also stated that the Collison avoidance waring states it needs maintenance, the contact stated that the vehicle feels like it is close to tipping over and requiring a "death grip" on the steering wheel enable to keep it in control. The vehicle was taken to multiple dealers were they would not diagnose the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 43,518.
NHTSA ODI #11736123
Mileage unknown · Apr 1, 2026
Electrical SystemEngineFire
On December 23, 2025, a 2023 RAM ProMaster 2500 Van used as a commercial fleet delivery vehicle in [XXX] suffered an engine compartment fire. The vehicle was declared a total loss by the insurance carrier. At the time of the fire, the vehicle was subject to open Safety Recall 25V-720 / Manufacturer Recall 67C, issued by FCA US…
Read full complaint
On December 23, 2025, a 2023 RAM ProMaster 2500 Van used as a commercial fleet delivery vehicle in [XXX] suffered an engine compartment fire. The vehicle was declared a total loss by the insurance carrier. At the time of the fire, the vehicle was subject to open Safety Recall 25V-720 / Manufacturer Recall 67C, issued by FCA US LLC for a defective cooling fan module with premature bearing wear and inadequate fuse protection on the 400W fan circuit — the exact defect identified as a known fire risk. No remedy was available at the time of the incident. The interim recall notification letter had been received but the vehicle could not be repaired as FCA had not yet developed or made available a fix. The vehicle was inspected by insurance representatives and declared a total loss. No warning lamps or prior symptoms were observed before the fire occurred, consistent with NHTSA's own warning that affected vehicles may fail suddenly with no prior dashboard alert. The component believed to have failed is the cooling fan module. It is unknown whether the component remains available for inspection as the vehicle has been transferred to the insurance carrier as part of the total loss settlement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11728539
Mileage unknown · Mar 18, 2026
Electrical System
EcoFlow unit wires crimped, may be inadequate on size of wire from alternator to EcoFlow unit . Leading to overheating and potential fire danger .
NHTSA ODI #11725329
Mileage unknown · Mar 6, 2026
Electrical System
Emergency call system has never worked. Dealership and Chrysler have done nothing to resolve the issue
NHTSA ODI #11722555
Mileage unknown · Mar 6, 2026
Electrical SystemFire
12v DC outlet caught fire
NHTSA ODI #11722552
Mileage unknown · Mar 4, 2026
Electrical SystemPower TrainSteering
Moisture in the air has corroded the wiring harness and connections to the Rack and Pinion causing the power steering to freak out and jerk the sheen all over the place and then cut out while driving.
Without any warning my steering wheel locked up and started jerking resulting in lack of steering and drivability. I was backing out of my driveway and started to turn onto the street when this happened. This could have been very dangerous if I had been driving on regular roads. The van is currently parked on the street and avai…
Read full complaint
Without any warning my steering wheel locked up and started jerking resulting in lack of steering and drivability. I was backing out of my driveway and started to turn onto the street when this happened. This could have been very dangerous if I had been driving on regular roads. The van is currently parked on the street and available for inspection as I was able to gently maneuver it to a safe spot. This has been looked at by a mobile mechanic who put an OBD2 scanner on it and couldn't bring up any codes. It has not been taken to a shop at this point. The dealer said over the phone that this is not a powertrain warranty because it is not engine or transmission. It has not been inspected by the manufacturer, police, insurance. There were warning lights on the panel when this happened but they didn't stay on. Checking the internet for answers I discovered that a power connection to the rack for power steering was getting corroded from not being sealed properly and water was entering the connection. Today I removed the black battery cable and checked on the connector to the rack myself and discovered the same issue many people are having. below is a photo from today January 9, 2026. The connector looks corroded and burnt. Why is this not a recall? This is not safe.
NHTSA ODI #11709820
30,000 miles · Oct 30, 2025
Electrical SystemEngineFire
The contact owned a 2023 Ram Promaster 2500. The contact stated that the employee had reported that the front end of the vehicle had caught on fire immediately after parking the vehicle. The vehicle was unoccupied at the time of the incident. The fire was extinguished by the fire department, which reported that the fire origina…
Read full complaint
The contact owned a 2023 Ram Promaster 2500. The contact stated that the employee had reported that the front end of the vehicle had caught on fire immediately after parking the vehicle. The vehicle was unoccupied at the time of the incident. The fire was extinguished by the fire department, which reported that the fire originated from the front end of the vehicle. There was no injury sustained. The contact stated that the front end of the vehicle had completely burned. The contact stated that the fire seemed to have originated near the engine compartment. The vehicle was towed to the residence and was totaled. No police report was filed. The dealer and the manufacturer were notified of the failure. The manufacturer informed the contact that they were not liable for the failure. The failure mileage was approximately 30,000.
NHTSA ODI #11696578
Mileage unknown · Apr 14, 2025
Electrical SystemUnknown Or Other
R/F signal light not working properly upon delivery. Fast flashing on instrument panel. Same issues of recall on the 2021/22 Promaster. Vech/camper is at Lakeland Dodge, FL. Harness replaced still with problem. Now they are ordering a mirror part hoping this resolves. Vech purchased from RV General, Dover FL
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
Chrysler (FCA US, LLC) is recalling certain 2018-2026 Ram ProMaster vehicles. The electrical circuit for the radiator fan may overheat.
Consequence & remedy
Consequence: Electrical circuits that overheat increase the risk of a fire.
Remedy: Dealers will replace the cooling fan module and fuse. In addition dealers will provide an addendum for the manual and label for the power distribution center. Some interim notification letters, notifying owners of the safety risk, were mailed December 11, 2025. Some owner notification letters were mailed beginning December 11, 2025. Additional owner notification letters were mailed in January, March, and June 2026. Remaining owner notification letters are expected to be mailed July 2026. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's numbers for this recall are 67C, B3C, and C9C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning October 30, 2025.
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Dodge Durango, 2021-2023 Chrysler Pacifica, Jeep Grand Cherokee L, 2022 Ram 1500, 2500, 3500, Chrysler Voyager, 2022-2023 Jeep Compass, Grand Cherokee, Wagoneer, Grand Wagoneer, and Ram Promaster vehicles. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash.
Remedy: Dealers will update the radio software or the software will be OTA, "Over-The-Air," free of charge. Owner notification letters were mailed beginning July 9, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 66B and 79B.
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Ram Promaster vehicles. The vehicles are missing a side door beam, and the tire placard contains incorrect seating capacity information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: A missing side door beam may not provide adequate occupant protection in a crash, increasing the risk of injury. Incorrect seating capacity information can result in an improperly loaded vehicle, increasing the risk of injury in a crash.
Remedy: Dealers will install a door beam and apply an overlay label, free of charge. Owner notification letters were mailed August 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 53B.
Additional source detail variants (3)
Structure:body:door
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Ram Promaster vehicles. The vehicles are missing a side door beam, and the tire placard contains incorrect seating capacity information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 110, "Tire Selection and Rims."
Consequence: A missing side door beam may not provide adequate occupant protection in a crash, increasing the risk of injury. Incorrect seating capacity information can result in an improperly loaded vehicle, increasing the risk of injury in a crash.
Remedy: Dealers will install a door beam and apply an overlay label, free of charge. Owner notification letters were mailed August 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 53B.
Seats:mid/rear Assembly
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Ram Promaster vehicles. The vehicles are missing a side door beam, and the tire placard contains incorrect seating capacity information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 110, "Tire Selection and Rims."
Consequence: A missing side door beam may not provide adequate occupant protection in a crash, increasing the risk of injury. Incorrect seating capacity information can result in an improperly loaded vehicle, increasing the risk of injury in a crash.
Remedy: Dealers will install a door beam and apply an overlay label, free of charge. Owner notification letters were mailed August 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 53B.
Equipment:other:labels
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Ram Promaster vehicles. The vehicles are missing a side door beam, and the tire placard contains incorrect seating capacity information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 110, "Tire Selection and Rims."
Consequence: A missing side door beam may not provide adequate occupant protection in a crash, increasing the risk of injury. Incorrect seating capacity information can result in an improperly loaded vehicle, increasing the risk of injury in a crash.
Remedy: Dealers will install a door beam and apply an overlay label, free of charge. Owner notification letters were mailed August 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 53B.
Chrysler (FCA US, LLC) is recalling certain 2022-2023 Ram Promaster vehicles. The driver seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: A malfunctioning seat belt warning system can result in improper seat belt use, increasing the risk of injury in a crash.
Remedy: Dealers will inspect and replace the driver seat belt buckle as necessary, free of charge. Owner notification letters were mailed April 9, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 02B.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE26002 · Loss Of Power Steering Assist
Opened Mar 2, 2026 · No close date supplied
Status: open (inferred from source dates) · Electrical System:wiring:connectors/plugs/receptacles; Steering; Steering:electric Power Assist System; Steering:rack And Pinion:rack
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering:electric Power Assist System
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering:rack And Pinion:rack
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
2023 RAM Promaster Problems, Complaints & Recalls | Skip That Year
Illustration