NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
114 reportsClear category filterMileage unknown · Apr 11, 2024
Power Train
Concerned that my truck may be affected by the Aisin K1 snap ring failure problem currently being investigated by NHTSA. I have no way of knowing whether or not my transmission is reliable long term, nor can I prove to a future buyer that it is safe and reliable. Not only does this issue affect my trust in using the truck, but i…
Read full complaint
Concerned that my truck may be affected by the Aisin K1 snap ring failure problem currently being investigated by NHTSA. I have no way of knowing whether or not my transmission is reliable long term, nor can I prove to a future buyer that it is safe and reliable. Not only does this issue affect my trust in using the truck, but it also has a significant negative impact on the resale value of the truck. Buyers are aware that 2022 Aisin trucks have issues and this makes the vehicle harder to sell.
NHTSA ODI #11582271
Mileage unknown · Apr 6, 2024
Power Train
Driving south on [XXX] just south of Greenville, SC. With no warning the truck wouldn't go, upon quickly diagnosing I determined I had no transmission. Luckily was able to make it to the emergency lane and come to a safe stop. Also was pulling a fifth wheel camper at the time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF IN…
Read full complaint
Driving south on [XXX] just south of Greenville, SC. With no warning the truck wouldn't go, upon quickly diagnosing I determined I had no transmission. Luckily was able to make it to the emergency lane and come to a safe stop. Also was pulling a fifth wheel camper at the time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11581474
Mileage unknown · Apr 4, 2024
Power Train
February 19,2024. Towing a bumper pull toy hauler approximately 10,000 pounds, just merged onto a two lane highway when the check engine light came on and truck jerked a couple times, I pulled to side of highway where there is not much of a shoulder. I placed it in park, sat a few seconds then into drive when I noticed no forwar…
Read full complaint
February 19,2024. Towing a bumper pull toy hauler approximately 10,000 pounds, just merged onto a two lane highway when the check engine light came on and truck jerked a couple times, I pulled to side of highway where there is not much of a shoulder. I placed it in park, sat a few seconds then into drive when I noticed no forward motion in drive. I turned truck off a few minutes, restarted, check engine light still on, no movement in drive mode. I did have reverse functioning. This was very dangerous situation, high speed two lane highway, small shoulder, many large RVs and 18 wheeler trucks flying by. 5 weeks truck is at dealer, they say it’s done, they attempt to bring it to me at the shop, then tell me check engine light on, throwing multiple codes. They still have truck, tell me they will find out issue asap.
NHTSA ODI #11581198
Mileage unknown · Apr 4, 2024
Power TrainVehicle Speed Control
Sudden loss of forward gears. Failure happened on highway at highway speeds. Had to carefully maneuver the truck off the road. Failure in both towing and unloaded operation. Truck will not shift in or out of drive (1-4) but reverse is still functional. Diagnostic trouble code P0731-00 and P0734 "Gear 1 and 4 Shift Incorrect Rati…
Read full complaint
Sudden loss of forward gears. Failure happened on highway at highway speeds. Had to carefully maneuver the truck off the road. Failure in both towing and unloaded operation. Truck will not shift in or out of drive (1-4) but reverse is still functional. Diagnostic trouble code P0731-00 and P0734 "Gear 1 and 4 Shift Incorrect Ratio". Both the dealer and RAM confirm this transmission failure. RAM has realeased a TSB which covers this failure but hasn’t released a recall.
NHTSA ODI #11581178
17,000 miles · Apr 3, 2024
Power Train
The contact owns a 2022 Ram 3500. The contact stated while driving 30 MPH and towing an RV, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the failure persisted, after which the contact became aware that the vehicle was only able to shift into reverse. The check en…
Read full complaint
The contact owns a 2022 Ram 3500. The contact stated while driving 30 MPH and towing an RV, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the failure persisted, after which the contact became aware that the vehicle was only able to shift into reverse. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired due to parts not being available. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 17,000.
NHTSA ODI #11580929
Mileage unknown · Apr 2, 2024
Power Train
My vehicle was affected by the Customer Satisfaction Notice 71A: Aisin K1 Snap Ring Failure. I saw an article that an investigation was being opened into this issue. I can provide data from my experience if it is helpful.
NHTSA ODI #11580728
Mileage unknown · Apr 2, 2024
Power Train
On [XXX] I was driving my newly purchased 2022 Ram 3500 on [XXX] near Mead, CO when my check engine light illuminated and I immediately lost forward driving gears. I was able to coast safely to the side of the highway. I purchased this truck new on [XXX] from Perkins Motors in Colorado Springs. After stopping on the side of […
Read full complaint
On [XXX] I was driving my newly purchased 2022 Ram 3500 on [XXX] near Mead, CO when my check engine light illuminated and I immediately lost forward driving gears. I was able to coast safely to the side of the highway. I purchased this truck new on [XXX] from Perkins Motors in Colorado Springs. After stopping on the side of [XXX], I attempted to continue forward but had no power. I placed the truck in reverse and felt a sudden jerk. I then placed the truck in park and shut it off. The truck had 1,043 miles on the odometer when the transmission failed. I waited on the side of the highway for 15 hours to be towed 110 miles to the Ram dealership closest to my home. My truck spent 5 weeks at the dealership waiting on parts. Colorado Springs Ram service department informed me that the snap ring in the K1 clutch kit had failed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11580589
Mileage unknown · Feb 15, 2024
Power Train
Truck lost all forward gears while driving down the highway, only had 6418 miles on it
NHTSA ODI #11572228
32,000 miles · Jan 8, 2024
Power Train
The contact owns a 2022 Ram 3500. The contact stated that while driving at various speeds, the transmission suddenly downshifted, causing the vehicle to decelerate abruptly. Additionally, while driving the vehicle, the engine temperature gauge increased to high, with a burning plastic odor and smoke fumes entering the cabin of t…
Read full complaint
The contact owns a 2022 Ram 3500. The contact stated that while driving at various speeds, the transmission suddenly downshifted, causing the vehicle to decelerate abruptly. Additionally, while driving the vehicle, the engine temperature gauge increased to high, with a burning plastic odor and smoke fumes entering the cabin of the vehicle. The vehicle was taken to the local dealer and the PCM was reprogrammed, and the temperature sensor was replaced; however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was 32,000.
NHTSA ODI #11564226
Mileage unknown · Dec 22, 2023
Power Train
Aisin Transmission Failure at 10,462 miles. Date of failure 09/09/2023. No warning lights, messages or other symptoms Vehicle was towed to Dealership on 09/12/2023 Failure confirmed by Champion Dodge, 907 S Clinton Street, Athens, AL 35611 / 8002395692
NHTSA ODI #11561530
Official recalls
12Nov 6, 2025
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 1500, Ram 2500, Ram 3500, Ram 4500, and Ram 5500 vehicles. The steering column control module may cause the driver's side air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.
Remedy: Dealers will replace the steering column control module, free of charge. Owner notification letters were mailed beginning December 11, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 14C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning November 13, 2025.
Additional source detail variants (2)
Steering:steering Control Module
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 1500, Ram 2500, Ram 3500, Ram 4500, and Ram 5500 vehicles. The steering column control module may cause the driver's side air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.
Remedy: Dealers will replace the steering column control module, free of charge. Owner notification letters were mailed beginning December 11, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 14C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning November 13, 2025.
Air Bags:frontal
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 1500, Ram 2500, Ram 3500, Ram 4500, and Ram 5500 vehicles. The steering column control module may cause the driver's side air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.
Remedy: Dealers will replace the steering column control module, free of charge. Owner notification letters were mailed beginning December 11, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 14C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning November 13, 2025.
Jun 13, 2024
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Dodge Durango, 2021-2023 Chrysler Pacifica, Jeep Grand Cherokee L, 2022 Ram 1500, 2500, 3500, Chrysler Voyager, 2022-2023 Jeep Compass, Grand Cherokee, Wagoneer, Grand Wagoneer, and Ram Promaster vehicles. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash.
Remedy: Dealers will update the radio software or the software will be OTA, "Over-The-Air," free of charge. Owner notification letters were mailed beginning July 9, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 66B and 79B.
Jun 6, 2024
Chrysler (FCA US, LLC) is recalling certain 2022 Dodge Durango and Ram 2500 and 3500 vehicles. Due to a software malfunction, the ABS control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed beginning July 11, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 55B.
Additional source detail variants (2)
Service Brakes, Air:antilock:control Unit/module
Chrysler (FCA US, LLC) is recalling certain 2022 Dodge Durango and Ram 2500 and 3500 vehicles. Due to a software malfunction, the ABS control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed beginning July 11, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 55B.
Electronic Stability Control (esc):control Module
Chrysler (FCA US, LLC) is recalling certain 2022 Dodge Durango and Ram 2500 and 3500 vehicles. Due to a software malfunction, the ABS control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed beginning July 11, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 55B.
Sep 28, 2023
Chrysler (FCA US, LLC) is recalling certain 2022-2023 Ram 1500, Ram 3500 Cab Chassis with GVWR less than 10,000 lbs., and 2022-2024 Ram 2500 vehicles. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will update the radio software, free of charge. Owner notification letters were mailed October 24, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 97A.
Feb 9, 2023
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Ram 2500, 3500, 3500 Cab Chassis, and 4500, 5500 Cab Chassis vehicles equipped with a Cummins 6.7L Turbo Diesel engine. An electrical short may occur in the heater grid relay with the ignition on or off.
Consequence & remedy
Consequence: An electrical short in the relay can result in an engine compartment fire with the ignition on or off, increasing the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the relay, free of charge. This will be a Phased campaign. Phase 1 will include 2023 model year vehicles. FCA US will notify dealers on or about 3/23/2023 and begin notifying owners on or about 4/5/2023. Phase 2 will include 2022 model year vehicles and Phase 3 will include 2021 model year vehicles. FCA US will notify dealers and owners on or about 4/27/2023 for Phase 2 and 5/11/2023 for Phase 3. Interim owner notification letters informing owners of the safety risk were mailed March 28, 2023. Owner notification letters are expected to be mailed April 5, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 13A. This recall is an expansion of and supersedes recall number 21V-798.
Dec 8, 2022
Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 1500, 2500, and 3500 pickup trucks. The tailgate may not latch properly due to misaligned tailgate strikers, which could result in the tailgate opening while driving.
Consequence & remedy
Consequence: An unintended tailgate opening while driving may result in a loss of unsecured cargo, possibly creating a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect the tailgate striker alignment to the box latch and adjust, if necessary, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is ZB8.
Nov 10, 2022
FCA US, LLC (Chrysler) is recalling certain 2020-2023 Ram 2500 and 2020-2022 Ram 3500 vehicles. A build-up of pressure and heat inside the transmission may result in a transmission fluid leak from the dipstick tube.
Consequence & remedy
Consequence: Leaking transmission fluid may contact an ignition source within the engine compartment, increasing the risk of a fire.
Remedy: Dealers will replace the transmission dipstick and transmission vent assembly, free of charge. Owner notification letters were mailed December 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. Chrysler's number for this recall is ZA3.
Aug 26, 2022
Chrysler (FCA US, LLC) is recalling certain 2022 Ram 3500, 3500 Cab Chassis, Ram 2500, and 4500 and 5500 Cab Chassis vehicles equipped with Cummins 6.7L turbo diesel engines. The engine control module (ECM) may have been built with a misaligned capacitor that can short-circuit, resulting in an internal loss of communication.
Consequence & remedy
Consequence: An internal loss of communication can result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will replace the ECM, free of charge. Owner notification letters were mailed October 20, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z87.
Jun 9, 2022
Chrysler (FCA US, LLC) is recalling certain 2022 Ram 1500, 2500 pickup trucks, and 3500 Cab Chassis vehicles with GVWR less than 10,000 lbs. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will reprogram the radio software, free of charge. Owner notification letters were mailed July 5, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLS's number for this recall is Z47.
Mar 10, 2022
Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 2500 and 2021-2022 Dodge Durango vehicles, and 2019-2022 3500 cab chassis with GVWR less than 10,000 lbs. The ABS control module software may prevent the electronic stability control (ESC) malfunction indicator light from illuminating during certain conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: An ESC malfunction indicator light that fails to illuminate during an electronic stability control problem can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed March 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z20.
Additional source detail variants (2)
Electronic Stability Control (esc)
Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 2500 and 2021-2022 Dodge Durango vehicles, and 2019-2022 3500 cab chassis with GVWR less than 10,000 lbs. The ABS control module software may prevent the electronic stability control (ESC) malfunction indicator light from illuminating during certain conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence: An ESC malfunction indicator light that fails to illuminate during an electronic stability control problem can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed March 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z20.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 2500 and 2021-2022 Dodge Durango vehicles, and 2019-2022 3500 cab chassis with GVWR less than 10,000 lbs. The ABS control module software may prevent the electronic stability control (ESC) malfunction indicator light from illuminating during certain conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence: An ESC malfunction indicator light that fails to illuminate during an electronic stability control problem can increase the risk of a crash.
Remedy: Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed March 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z20.
Nov 24, 2021
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 2500, Ram 3500, and 2021 Ram 1500 Classic pickup trucks. The side air bag inflatable curtain (SABIC) assemblies may have been manufactured with the incorrect amount of compressed gas, which can result in an improper air bag deployment.
Consequence & remedy
Consequence: An air bag that deploys improperly can increase the risk of injury in a crash.
Remedy: Dealers will replace the SABIC assemblies, free of charge. Owner notification letters were mailed January 17, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y99.
Oct 14, 2021
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 3500, 2500 pickup trucks, and Ram 3500, 4500, and 5500 cab chassis vehicles equipped with Cummins 6.7L Turbo Diesel engines. An electrical short in the relay may cause a vehicle fire with the ignition on or off.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised to park these vehicles outside of buildings or structures, and not near other vehicles, until the vehicle has been remedied. Dealers will inspect and, if needed, replace the Solid State Intake Heater Grid Relay ("Relay"); if FCA US Recall ID Y08 (NHTSA Recall ID 21V-163) is open, then insulating material will be applied to the Relay after inspection. Owner notification letters were mailed November 10, 2021. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y76. This recall has been superseded by 23V060.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE26002 · Loss Of Power Steering Assist
Opened Mar 2, 2026 · No close date supplied
Status: open (inferred from source dates) · Electrical System:wiring:connectors/plugs/receptacles; Steering; Steering:electric Power Assist System; Steering:rack And Pinion:rack
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Electrical System:wiring:connectors/plugs/receptacles
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering:electric Power Assist System
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering:rack And Pinion:rack
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE24009 · 2022 RAM Transmission Snap Ring Failure
Opened Mar 27, 2024 · No close date supplied
Status: open (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:internal:clutches/bands
The Office of Defect Investigations (ODI) has received 82 complaints alleging loss of motive power due to an internal transmission failure of the K1 snap ring in model year 2022 Ram 3500, 4500, and 5500 vehicles. Of these complaints, 16 describe a complete loss of motive power at speeds greater than 25 miles per hour, without the ability for the vehicle to resume normal operation. The subject vehicles can be up-fit as an ambulance and other emergency response vehicle or may be heavily loaded when used for towing. During the failure event, the snap ring becomes dislodged and forward gears 1-4 are no longer functional, potentially leaving the vehicle disabled in or near the roadway and/or negatively affect the emergency mission. ODI contacted the manufacturer, FCA US, LLC d/b/a Stellantis North America (FCA), and learned that technical service bulletin (TSB) TSB-21-002-23 is related to the alleged defect condition. Additionally, FCA has conducted dynamometer and field testing and has explained to ODI that during the event a warning message will display to the operator, and gear 5 and reverse will remain available. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Power Train:automatic Transmission
The Office of Defect Investigations (ODI) has received 82 complaints alleging loss of motive power due to an internal transmission failure of the K1 snap ring in model year 2022 Ram 3500, 4500, and 5500 vehicles. Of these complaints, 16 describe a complete loss of motive power at speeds greater than 25 miles per hour, without the ability for the vehicle to resume normal operation. The subject vehicles can be up-fit as an ambulance and other emergency response vehicle or may be heavily loaded when used for towing. During the failure event, the snap ring becomes dislodged and forward gears 1-4 are no longer functional, potentially leaving the vehicle disabled in or near the roadway and/or negatively affect the emergency mission. ODI contacted the manufacturer, FCA US, LLC d/b/a Stellantis North America (FCA), and learned that technical service bulletin (TSB) TSB-21-002-23 is related to the alleged defect condition. Additionally, FCA has conducted dynamometer and field testing and has explained to ODI that during the event a warning message will display to the operator, and gear 5 and reverse will remain available. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:automatic Transmission:internal:clutches/bands
The Office of Defect Investigations (ODI) has received 82 complaints alleging loss of motive power due to an internal transmission failure of the K1 snap ring in model year 2022 Ram 3500, 4500, and 5500 vehicles. Of these complaints, 16 describe a complete loss of motive power at speeds greater than 25 miles per hour, without the ability for the vehicle to resume normal operation. The subject vehicles can be up-fit as an ambulance and other emergency response vehicle or may be heavily loaded when used for towing. During the failure event, the snap ring becomes dislodged and forward gears 1-4 are no longer functional, potentially leaving the vehicle disabled in or near the roadway and/or negatively affect the emergency mission. ODI contacted the manufacturer, FCA US, LLC d/b/a Stellantis North America (FCA), and learned that technical service bulletin (TSB) TSB-21-002-23 is related to the alleged defect condition. Additionally, FCA has conducted dynamometer and field testing and has explained to ODI that during the event a warning message will display to the operator, and gear 5 and reverse will remain available. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration