Electrical System. Review the 379 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 337 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 227 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

75 crash reports11 fire reports42 injury reports

Back Over Prevention complaints

19 reports

Clear category filter

Mileage unknown · Aug 23, 2026

Back Over PreventionElectrical SystemLane Departure

Read full complaint

My 2019 Ram 1500 Rebel has recurring electrical/communication failures that occur every day. The truck repeatedly displays “ParkSense Temporarily Unavailable,” “Service Shifter,” “Service Tire Pressure System,” and “Tire Pressure Unavailable.” The ParkSense sensors often do not activate at all, leaving me without parking assistance while backing up. The system also repeatedly pings with warnings throughout the day. When “Service Shifter” appears, the truck shifts roughly and the transmission does not feel like it is shifting correctly. I am concerned this could indicate an electrical or communication problem affecting the electronic shifter, transmission operation, gear selection, or vehicle control. The truck also has an ongoing water leak around the rear window, including the upper portion and near the sliding window. The electrical problems appear worse during high humidity, although they have also occurred during winter. I am concerned that water intrusion could cause corrosion, electrical shorts, module damage, or other safety hazards. A reputable independent repair shop inspected the vehicle and identified a U-code communication fault. The problems continue to occur daily. I am concerned about the risk of a collision from losing ParkSense, potential transmission/gear-selection problems, and water-related electrical damage. I am requesting that NHTSA investigate whether these recurring failures represent a safety defect affecting 2019 Ram 1500 vehicles. The vehicle is available for inspection.

NHTSA ODI #11758914

Mileage unknown · Aug 18, 2025

Back Over PreventionForward Collision Avoidance

Unkown, but while driving, I got these alarms all of sudden at the same time.

NHTSA ODI #11681456

Mileage unknown · Jun 2, 2025

Back Over Prevention

Read full complaint

The contact owns a 2019 Ram 1500. The contact stated that upon shifting the vehicle into reverse, the rearview camera failed to display an image on the screen. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 20V191000 (Back Over Prevention), but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was unknown.

NHTSA ODI #11664435

Mileage unknown · May 23, 2025

Back Over PreventionElectrical SystemLane Departure

Read full complaint

What component or system failed or malfunctioned, and is it available for inspection upon request? -The issue involved the truck’s parking and collision avoidance systems, which suddenly shut off. A warning message appeared on the dashboard stating "Service Shifter." This issue may be related to the electronic shifter module or associated control systems. The vehicle is currently available for inspection upon request. How was your safety or the safety of others put at risk? -The sudden deactivation of both the parking and collision systems while the vehicle was in motion created a serious safety hazard. Without collision avoidance functionality and the ability to securely park the vehicle, there was increased risk of unintentional vehicle movement or inability to avoid obstacles, which could have led to a crash or injury. Has the problem been reproduced or confirmed by a dealer or independent service center? -Yes, the truck was taken to an authorized dealer for assessment, and the issue was confirmed. Diagnostic tests found trouble codes starting with "U", which typically indicate a communication or control module fault within the vehicle’s network. The codes provided from the dealer are U0159, U0140, U0100, U0137, U0102, U10121, and U0101. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? -The issue has been inspected and documented by the dealership. There is no indication that police or insurance representatives have inspected it at this time, but the incident and diagnostics are recorded in the dealer’s service records. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? -Yes, a warning message "Service Shifter" appeared on the dashboard. This message coincided with the shutdown of the parking and collision systems. These symptoms appeared suddenly and without prior warning during regular vehicle operation.

NHTSA ODI #11662767

Mileage unknown · Apr 29, 2025

Back Over PreventionElectrical SystemPower Train

Read full complaint

The star connector on the CAN C BUS will start to have communication problems with the all the systems on that star connector approximately after about 15 to 20 min after driving. Systems that were constantly going in and out were the front and rear parking sense, ABS and traction would go out. Service shifter message, caused the transmission to up shift while driving at a constant speed. After getting a check engine light, I hooked up my code reader and had a code for the park sense control module. I proceeded to replace that module and was unable to get the code to go away. Upon further investigation, I found a history code for the CAN C BUS PERFORMANCE code and researched on this topic in the forums with other owners of the same truck and looked for any maintenance for this topic as well. These owners would have the same problem that my truck was having and the dealerships were unable to pin point the malfunction of all these systems. I did find video of an owner that had the same problem as my truck and he was able to pin point the problem down to the star connectors. The star connector would slowly over time while the vehicle was on would slowly take on more power then it was supposed to and overload the star connector. Upon learning about the star connectors, I learned how to replace them and after I replaced the star connectors for the exterior and interior components of the vehicle, everything went back to normal. I do still have the star connectors that were taken out incase I wanted to get them tested for the same issue the other guy found out

NHTSA ODI #11657555

Mileage unknown · Jan 9, 2025

Back Over PreventionElectrical SystemSeats

Read full complaint

The issues started with the sunroof not closing. And the uconnect touch screen inoperable ( it went black and no options available ) It seemed to be a fluke and resolved itself. But within a few weeks the icons for the driver and passenger seat heaters were no longer on the screen. Now that the season has changed and temps have dropped, the drivers side heater will automatically come on when the truck is started and it’s below a certain degree outside. It gets crazy hot and will only shut off when the truck is turned off. This was followed by the icons for the radio options resorting themselves and the one for USB disappearing as well. The usb connection still works, but it has to automatically switch over when plugged in, it cannot be manually selected. Lastly the ParkAssist seems to have a mind of its own. Sometimes it will function as intended. Other times when I start the truck it flashes a warning that the park assist is unavailable and the lights on the switches are on showing it’s been disengaged. When pushed they will flash and then turn solid again. Other times it will happen while I’m driving. There will be a ding and the unavailable warning will flash on the screen. When the icons first disappeared I called mopar/uconnect customer service. They tried to walk me through some diagnostics but none of it worked. They suggested maybe getting a software update. But couldn’t tell me if that would fix it or not. When I asked if it didn’t they just said I’d have to replace the whole uconnect system.

NHTSA ODI #11635051

Mileage unknown · Nov 15, 2024

Back Over PreventionService BrakesUnknown Or Other

Read full complaint

To whom it may concern, I am making a safety complaint on a component that failed while operating the vehicle. My vehicle is a 2019 Ram 1500 Bighorn DT. The component that failed and almost cost me to crash my truck while in reverse and parking is called The Park Sense and The Rear Parking Assist . I started to have this problem back in the Summer around August 2024. I have brought the vehicle in to my dealer ( CHRYSLER, JEEP, DODGE OF PARAMUS N. J.) several times already, the first time they replaced the Park Sense Sensor Module and reset the computer. No sooner then I got home from the dealership and was reversing in my driveway the error messages came on and the truck did not sense the garage door and continued to back up thankfully I was able to brake hard and stop 6 inches from the door. Not only did the Park Sense warning come on but also The Rear Brake Assist did not stop the vehicle like it has in the past. I brought the vehicle back to the same dealership and they worked on it for about 6 hours gave it back to me and said they rerouted the wiring harness for the park sense module and it was working fine. As I get into my truck to leave the error messages came on the dashboard so I walked inside and showed the service manager and the tech that just finished working on my truck. They said to bring it back, they had no regards for my safety or the safety of others letting me leave the dealership with the truck acting up cause from time to time the brakes would suddenly come on causing the vehicle to stop abruptly. Nevertheless I strongly believe that there is a safety issue with the truck's Park sense sensor and Rear Brake Assist too. I do not know what to do can someone please help me? Thank you.

NHTSA ODI #11625411

Mileage unknown · Oct 15, 2024

Back Over Prevention

Collision sensors stoped vehicle approx.15 feet short when backing into my carport.

NHTSA ODI #11619940

Mileage unknown · Aug 9, 2024

Back Over PreventionElectrical SystemEngine

Read full complaint

I am receiving a warning light that reads: Service Shifter, Park sense not available, warning with no display, and the vehicle shifts from drive to neutral with a display message to put the truck in Park then shift to Drive while in motion. My safety is put at risk because when driving I have no warning the vehicle is going to shift itself into neutral and vehicles are driving behind me. I have to make a complete stop because I cannot accelerate in neutral. It has happened twice on a busy street in my city. I took the truck to Sierra RAM and they had the vehicle for 4-days and advised they could not replicate the issue. I drove off and immediately the Service Shifter warning came on. This is my second opinion the first dealer Envision RAM advised it is a software issue causing the warning lights to come on. I called RAM the manufacturer and they said to take it to a different dealership, and I did. NO others have checked the vehicle. I tried for RAM to come to dealership, I had a rep assisting me and they declined. There were warning lights coming on first time in April 2024, and I immediately called Envision RAM and took the truck into service. I drove off and the warning lights continued although I took the vehicle twice to Envision RAM they took my money and said it is fixed and it was not.

NHTSA ODI #11607656

Mileage unknown · Jul 15, 2024

Back Over PreventionElectrical SystemForward Collision Avoidance

service shifter, park sense unavailable, auto start stop unavailable warning lights came on ever time truck are in slow speed or stopped. sometimes cancel the cruise control and turn on the check engine light

NHTSA ODI #11602317

Official recalls

26V495000 · Seat Belts:rear/other:anchorage

Jul 30, 2026

Chrysler (FCA US, LLC) is recalling certain 2019-2026 Ram 1500 vehicles. The second-row center and left-side seat belt buckle anchors may have been improperly installed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."

Consequence & remedy

Consequence: An improperly installed seat belt buckle anchor may fail to properly restrain occupants, increasing the risk of injury during a crash.

Remedy: Dealers will inspect and attach the seat belt buckle anchor to the body structure as necessary, free of charge. Owner notification letters are expected to be mailed August 18, 2026. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is 67D. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov on August 6, 2026.

25V824000 · Air Bags:side/window:curtain:inflator

Dec 1, 2025

Chrysler (FCA US, LLC) is recalling certain 2019 Ram 1500 Classic, Ram 2500, and Ram 3500 vehicles. The right and left side curtain air bag inflators may rupture due to a manufacturing defect.

Consequence & remedy

Consequence: An inflator rupture may result in sharp metal fragments striking occupants, resulting in injury.

Remedy: Dealers will replace one or both side curtain air bags, as necessary, free of charge. Owner notification letters were mailed December 18, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's numbers for this recall are C2C, C7C, and C8C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning December 4, 2025.

25V298000 · Air Bags; Electrical System:wiring

May 8, 2025

Chrysler (FCA US, LLC) is recalling certain 2019-2024 Ram 1500 vehicles. The driver's side air bag may not be connected properly, which can cause the air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.

Remedy: Dealers secured the connectors for the air bag, free of charge. All vehicles have been remedied. Owner notification letters were mailed May 27, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 08C.

Additional source detail variants (2)

Air Bags

Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.

Remedy: Dealers secured the connectors for the air bag, free of charge. All vehicles have been remedied. Owner notification letters were mailed May 27, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 08C.

Electrical System:wiring

Consequence: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.

25V010000 · Air Bags:side/window:curtain:inflator

Jan 16, 2025

Chrysler (FCA US, LLC) is recalling certain 2016-2019 Ram 3500, Ram 1500, 2016-2020 Ram 2500, and 2016 Ram 3500 Cab Chassis vehicles. The right and left side curtain air bag inflators may rupture due to a manufacturing defect.

Consequence & remedy

Consequence: An inflator rupture may result in sharp metal fragments striking occupants, resulting in injury.

Remedy: Dealers will replace one or both side curtain air bags, as necessary, free of charge. Owner notification letters were mailed February 13, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's numbers for this recall are 05C, 09C, and 10C.

24V653000 · Electronic Stability Control (esc):control Module; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Sep 5, 2024

Chrysler (FCA US, LLC) is recalling certain 2019, 2021-2024 Ram 1500 vehicles. Due to a software malfunction, the anti-lock brake system (ABS) control module may disable the electronic stability control system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."

Consequence & remedy

Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.

Remedy: Dealers will update the ABS control module software, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed October 10, 2024. Owner notification letters were mailed beginning September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 85B.

Additional source detail variants (2)

Electronic Stability Control (esc):control Module

Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.

Remedy: Dealers will update the ABS control module software, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed October 10, 2024. Owner notification letters were mailed beginning September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 85B.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Consequence: Driving with a disabled electronic stability control system can increase the risk of a crash.

23V411000 · Engine And Engine Cooling

Jun 8, 2023

Chrysler (FCA US, LLC) is recalling certain 2014-2019 Ram 1500 and 2014-2020 Jeep Grand Cherokee vehicles equipped with 3.0L Diesel engines. The crankshaft position sensor tone wheel may delaminate, causing the engine to lose its ability to synchronize the fuel injector pulses and cam shaft timing, possibly resulting in an engine stall.

Consequence & remedy

Consequence: An engine stall can increase the risk of a crash.

Remedy: Dealers will update the powertrain control module software to maintain vehicle propulsion, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed August 3, 2023. Some owner notification letters were mailed October 31, 2023. The remaining owner notification letters will be mailed at a future date, anticipated July 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 66A. This recall is an expansion of recall 20V-475.

22V904000 · Structure:body:tailgate:hinge And Attachments

Dec 8, 2022

Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 1500, 2500, and 3500 pickup trucks. The tailgate may not latch properly due to misaligned tailgate strikers, which could result in the tailgate opening while driving.

Consequence & remedy

Consequence: An unintended tailgate opening while driving may result in a loss of unsecured cargo, possibly creating a road hazard and increasing the risk of a crash.

Remedy: Dealers will inspect the tailgate striker alignment to the box latch and adjust, if necessary, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is ZB8.

22V406000 · Fuel System, Diesel:delivery:fuel Pump

Jun 9, 2022

Chrysler (FCA US, LLC) is recalling certain 2014-2020 Jeep Grand Cherokee, and 2014-2019 Ram 1500 vehicles equipped with 3.0L diesel engines. A high pressure fuel pump (HPFP) failure may introduce internal debris into the fuel system, potentially resulting in fuel starvation.

Consequence & remedy

Consequence: Fuel starvation may result in an unexpected loss of drive power, increasing the risk of a crash.

Remedy: Dealers will replace the HPFP, and inspect and replace, if necessary, additional fuel system components, free of charge. Interim notification letters informing owners of the safety risk were mailed July 21, 2022. Owner notification letters for were mailed for Jeep Grand Cherokee owners starting January 11, 2024. Owner notification letters for Ram 1500 owners were mailed March 7, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLS's number for this recall is Z46.

21V632000 · Air Bags:side/window:curtain; Air Bags:side/window:curtain:inflator

Aug 12, 2021

Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.

Consequence & remedy

Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.

Remedy: Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y55.

Additional source detail variants (2)

Air Bags:side/window:curtain:inflator

Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.

Remedy: Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y55.

Air Bags:side/window:curtain

20V580000 · Seat Belts; Seat Belts:front:retractor

Sep 24, 2020

Chrysler (FCA US LLC) is recalling certain 2019 Jeep Wrangler and Ram 2500, 2019-2020 Ram 1500 and 2020 Jeep Gladiator vehicles. In the event of a crash, a front seat belt retractor may not properly slow the occupant's forward movement after locking.

Consequence & remedy

Consequence: In the event of a crash, if the front seat belts fail to lock, there is an increased risk of injury.

Remedy: Chrysler will notify owners, and dealers will replace the front seat belt retractors, free of charge. The recall began November 12, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W67.

Additional source detail variants (2)

Seat Belts:front:retractor

Consequence: In the event of a crash, if the front seat belts fail to lock, there is an increased risk of injury.

Remedy: Chrysler will notify owners, and dealers will replace the front seat belt retractors, free of charge. The recall began November 12, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W67.

Seat Belts

Consequence: In the event of a crash, if the front seat belts fail to lock, there is an increased risk of injury.

20V191000 · Back Over Prevention: Sensing System: Camera

Sep 10, 2020

Chrysler (FCA US LLC) is recalling certain 2020 Jeep Gladiator and Jeep Cherokee, 2019-2020 Ram 1500 Pickup, Ram 2500 Pickup, Ram 3500 Pickup, Chrysler Pacifica, Dodge Durango, Jeep Grand Cherokee, Jeep Wrangler, and Jeep Renegade and 2019 Dodge Challenger vehicles equipped with 8.4" or 12" radio displays. A software error can cause the rearview camera image to remain displayed after the vehicle has been shifted out of reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."

Consequence & remedy

Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.

Remedy: Chrysler has notified owners, and dealers will update the radio display software, free of charge. Optionally, owners can choose to remotely update their software via an Over-The-Air (OTA) update available as of May 1, 2020. The recall began April 27, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W30-W37.

20V513000 · Vehicle Speed Control:accelerator Pedal

Aug 27, 2020

Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles equipped with adjustable pedals. In certain accelerator pedal positions, the floormats may prevent the pedal from returning to the normal resting (idle) position.

Consequence & remedy

Consequence: A pedal that does not return as expected may affect the vehicle's deceleration, thereby increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will modify the driver's floormat to remove the potential for pedal interference, free of charge. The recall began September 10, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W63.

20V208000 · Visibility:windshield Wiper/washer:linkages

Apr 9, 2020

Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500, 1500 Classic and Jeep Compass vehicles. The windshield wiper arm or arms may loosen, possibly causing the wipers to not operate properly and reduce the driver's visibility in certain weather conditions.

Consequence & remedy

Consequence: Reduced visibility increases the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will tighten the wiper nuts, free of charge. The recall began April 27, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W25.

20V080000 · Power Train:transfer Case (4-WHEEL Drive)

Feb 13, 2020

Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 pickup trucks equipped with four-wheel drive. A gear within the transfer case may not have been installed correctly, possibly causing the vehicle to become stuck in neutral. If this occurs while driving, there could be a sudden loss of power. Additionally, a loss of 'PARK' function may occur.

Consequence & remedy

Consequence: A sudden loss of power or a loss of 'PARK' function may increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the transfer case, free of charge. The recall began March 10, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W06.

19V887000 · Tires:pressure Monitoring And Regulating Systems

Dec 12, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 trucks. An incorrect Tire Pressure Monitoring System (TPMS) sensor could have been installed during production causing the sensor to not display the low tire pressure warning indicator. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."

Consequence & remedy

Consequence: Without a warning indicator, the driver will be unaware if low tire pressure occurs, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the TPMS sensor, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VE1.

19V812000 · Steering:electric Power Assist System

Nov 14, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 trucks. These vehicles may have been built with a contaminated electric power steering (EPS) gear that may short circuit, potentially resulting in an intermittent loss of power steering assist.

Consequence & remedy

Consequence: An intermittent loss of power steering assist may cause an inconsistent steering effort, especially during lower speed maneuvers, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the EPS gear assembly, free of charge. The recall began December 12, 2019. Owners may contact FCA US customer service at 1-800-853-1403. FCA's number for this recall is VB8.

19V757000 · Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)

Oct 24, 2019

Chrysler (FCA US LLC) is recalling certain 2014-2019 Ram 1500 and 1500 Classic Pickup trucks equipped with 3.0L Eco Diesel engines. The Exhaust Gas Recirculation (EGR) cooler may crack and allow pre-heated vaporized coolant to enter the EGR system. This mixture may combust inside the intake manifold.

Consequence & remedy

Consequence: Combustion in the intake manifold can increase the risk of a fire.

Remedy: Chrysler will notify owners, and dealers will replace the EGR cooler, free of charge. Dealers will also inspect and, as necessary, replace the intake manifold. The recall began April 16, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VB1.

19V556000 · Electrical System: Instrument Cluster/panel

Jul 26, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 vehicles. The instrument cluster may not properly illuminate driver warnings. As such, these vehicles fails to conform with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Control and Displays."

Consequence & remedy

Consequence: Failure of the instrument cluster to properly illuminate may prevent the driver from receiving warnings about the vehicle's systems and increase the risk of crash.

Remedy: Chrysler will notify owners, and dealers will replace the instrument cluster, free of charge. The recall began August 8, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V83.

19V448000 · Tires:temporary/emergency Spare Tire

Jun 13, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 trucks. The spare tire provided may differ in size and required inflation pressure from the information on the tire placard label. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Consequence & remedy

Consequence: The driver, referencing the tire placard label, may incorrectly inflate the spare tire, increasing the risk of a crash.

Remedy: Chrysler has notified owners, and dealers will replace the incorrect size spare tire with the correct size spare tire, free of charge. The recall began June 27, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V67.

19V407000 · Air Bags; Air Bags: Air Bag/restraint Control Module; Seat Belts:pretensioner

May 31, 2019

Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 1500 vehicles. The flash memory of the Occupant Restraint Controller (ORC) may become corrupted, disabling the vehicle's air bags and seat belt pretensioners.

Consequence & remedy

Consequence: Disabled air bags and seat belt pretensioners increase the risk of injury in the event of a crash.

Remedy: Chrysler will notify owners, and dealers will reprogram the ORC or replace it as necessary, free of charge. The recall began June 20, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbers for this recall are V61 and V71.

Additional source detail variants (3)

Air Bags: Air Bag/restraint Control Module

Consequence: Disabled air bags and seat belt pretensioners increase the risk of injury in the event of a crash.

Remedy: Chrysler will notify owners, and dealers will reprogram the ORC or replace it as necessary, free of charge. The recall began June 20, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbers for this recall are V61 and V71.

Seat Belts:pretensioner

Consequence: Disabled air bags and seat belt pretensioners increase the risk of injury in the event of a crash.

Air Bags

Consequence: Disabled air bags and seat belt pretensioners increase the risk of injury in the event of a crash.

19V324000 · Power Train:driveline:driveshaft

Apr 25, 2019

Chrysler (FCA US LLC) is recalling certain 2018-2019 Ram 1500 pickup trucks. The rear driveshaft may have an incomplete weld fusion between the tube and tube yoke, which may lead to weld cracking or the driveshaft fracturing.

Consequence & remedy

Consequence: A fractured rear driveshaft could detach from the vehicle and become a road hazard, or it may result in a loss of drive power, both of which can increase the risk of a crash.

Remedy: FCA US will notify owners, and dealers will replace the rear driveshaft, free of charge. The recall began June 13, 2019. Owners may contact FCA US customer service at 1-800-853-1403. The FCA US recall number is V48.

19V201000 · Steering

Mar 14, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Jeep Wrangler and 2019 Ram 1500 vehicles. These vehicles have improperly machined steering column stub shafts that may break, possibly causing the steering wheel to detach from the steering column.

Consequence & remedy

Consequence: If the steering wheel detaches from the steering column, the driver may lose control of the vehicle, increasing the risk of crash.

Remedy: Chrysler will notify owners, and dealers will inspect the steering column, replacing it, as necessary, free of charge. The recall began April 5, 2019. Owners may contact FCA US customer service at 1-800-853-1403. Chrysler's number for this recall is V29.

19V142000 · Electrical SYSTEM:12V/24V/48V Battery

Feb 28, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 vehicles equipped with a 48v auxiliary battery system located behind the rear seat (sales code: XBZ). Due to an incorrect assembly repair process, the auxiliary battery wire terminal connection may overheat.

Consequence & remedy

Consequence: If the auxiliary battery system overheats, there is an increased risk of a fire within the cabin even if the ignition is off.

Remedy: FCA US has notified owners, and dealers will properly secure the auxiliary battery fasteners, free of charge. The recall began March 15, 2019. Owners may contact Chrysler's customer service at 1-800-853-1403. The Chrysler number for this recall is V17.

19V067000 · Service Brakes, Hydraulic:pedals And Linkages

Feb 5, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 vehicles equipped with adjustable pedals. The affected vehicles have a brake pedal that may move too far and separate from pedal assembly.

Consequence & remedy

Consequence: If the brake pedal separates from the pedal assembly, the driver may be unable to brake the vehicle, increasing the risk of crash.

Remedy: Chrysler will notify owners, and dealers will repair the adjustable pedal assembly, free of charge. The recall began on February 25, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V07.

19V020000 · Steering:electric Power Assist System

Jan 24, 2019

Chrysler (FCA US LLC) is recalling certain 2019 Ram 1500 vehicles. The battery ground fastener on the driver-side front fender may have been improperly secured, possibly resulting in a loss of power steering assist.

Consequence & remedy

Consequence: A loss of power steering could vary the steering effort required, possibly causing vehicle oversteer or understeer, increasing the risk of crash.

Remedy: Chrysler has notified owners, and dealers will properly secure the ground fastener, free of charge. The recall began on February 11, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V04.

19V051000 · Visibility:defroster/defogger/hvac System

Jan 24, 2019

Chrysler (FCA US LLC) is recalling certain 2019 RAM 1500 vehicles equipped with a 12" touchscreen display and a base-level heating, ventilation and air conditioning ("HVAC") system. Vehicles with this combination do not have a functioning windshield defrosting and defogging system. As a result, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 103, "Windshield defrosting and defogging systems."

Consequence & remedy

Consequence: The lack of a functioning windshield defrosting and defogging system may decrease the driver's visibility, increasing the risk of crash.

Remedy: Chrysler will notify owners, and dealers will repurchase the affected vehicles. The recall began March 7, 2019. Owners may contact FCA US customer service at 1-800-853-1403. Chrysler's number for this recall is V12.

18V822000 · Seats

Nov 20, 2018

Chrysler (FCA US LLC) is recalling certain 2019 RAM 1500 trucks. The seat track position sensor on the manually-adjusted passenger seats may come loose and out of position, preventing the sensor from detecting if the seat is in the full-forward position.

Consequence & remedy

Consequence: If the sensor cannot identify that the seat is in the full-forward position and adjust the frontal air bag deployment accordingly, there would be an increased the risk of a injury in the event of a crash.

Remedy: Chrysler will notify owners and dealers will inspect the passenger seat track position sensor bracket, replacing it as necessary, free of charge. The recall began December 20, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is UB7.

18V556000 · Power Train:axle Assembly

Aug 23, 2018

Chrysler (FCA US LLC) is recalling certain 2018-2019 RAM 1500 trucks. The rear differential may have been insufficiently filled, possibly resulting in its failure.

Consequence & remedy

Consequence: If the rear axle assembly fails, it can cause a loss of drive or the rear wheels may lock up. Either scenario increases the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the rear axle oil level. Rear axles with an insufficient amount of oil will be replaced, free of charge. The recall began September 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U88.

18V332000 · Electrical System:software; Electrical System:wiring; Vehicle Speed Control:cruise Control

May 17, 2018

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence & remedy

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Additional source detail variants (3)

Electrical System:software

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Vehicle Speed Control:cruise Control

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Electrical System:wiring

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA23001 · High Pressure Fuel Pump Failure

Opened Mar 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Fuel System, Diesel:delivery:fuel Pump

The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021, to investigate incidents alleging a stall/loss of motive power as a result of high-pressure fuel pump failures in certain model year (MY) 2019-2020 Ram 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines. During the investigation, ODI sought to determine if the related defect allegation was limited in scope to the recalled population. After review of information request response materials from both FCA and BMW, NHTSA determined that sufficient information to identify a comprehensive recall population could not be produced by FCA and BMW.During the investigation FCA filed recalls 22V406, 22E048, 22V767, and 22E087 which include vehicles not identified in the initial subject population by ODI. ODI also received recall 21V586, involving loss of motive power due to failed CP4 fuel pumps on certain BMW manufactured vehicles. An information request letter response received from BMW indicated that failed pumps on their vehicles were caused by an interaction between pump internal components and US market diesel fuel, leading to increased slip and eventual particle-generating wear surface. Additional work will be done to identify whether a similar root cause is associated with the FCA recalled population and if similar wear dynamics occur on pumps supplied to vehicle manufacturers other than those included in the recalled population.ODI has upgraded this investigation to an EA in order to 1) determine engineering specifications of internal pump components that are correlated with pump failure leading to loss of motive power or other safety related hazards, 2) identify vehicle populations equipped with alleged defective pump variants, 3) assess if vehicles equipped with alleged defective pump variants result in an unreasonable risk to motor vehicle safety and 4) gather and review any other relevant information related to high pressure fuel pump failure associated with the subject populations of recalls 21V586, 21V880, 21E094, 22V406, 22E048, 22V767, and 22E087.Review of the above information will allow NHTSA to confirm root cause and recall remedy viability, and identify and evaluate vehicle populations equipped with pump components that may pose an unreasonable risk to motor vehicle safety.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 11257550, 11351441, 11361603, 11361616, 11365300, 11365426, 11365858, 11366401, 11372337, 11373793, 11374797, 11376793, 11377871, 11378173, 11384377, 11386063, 11387018, 11399710, 11402550, 11415339, 11418868, 11418870, 11427075, 11434276, 11436807, 11437226, 11437249, 11437273, 11437292, 11437294, 11437394, 11437399, 11437403, 11437405, 11437423, 11437528, 11437565, 11437579, 11437580, 11437590, 11437679, 11437744, 11437781, 11437842, 11437993, 11438006, 11438008, 11438121, 11438138, 11438155, 11438392, 11438629, 11439359, 11439879, 11440397, 11443030, 11446542, 11448163, 11453556, 11458918, 11460558, 11469337