NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
225 reportsClear category filterMileage unknown · Jun 26, 2025
Electrical SystemPower TrainSteering
The electronic power steering component itself is failing. When turning the steering wheel one way the wheel will jerk the opposite direction and be very difficult to turn due to the power steering failing. An indicator light on the instrument panel comes on that states to service the steering control system and then shuts off b…
Read full complaint
The electronic power steering component itself is failing. When turning the steering wheel one way the wheel will jerk the opposite direction and be very difficult to turn due to the power steering failing. An indicator light on the instrument panel comes on that states to service the steering control system and then shuts off by itself. This impacts the safety of all those in or around the vehicle when in motion due to steering becoming impossible or next to impossible to control. The vehicle has never been under water nor in the snow to cause any such damage. The problem is continuous and can be reproduced and inspected at any time supporting this claim. The factory has a recall in place for this year model and month range for when this truck was produced but my vin is not showing up as being part of the troubled load. It however does fit all of the criteria outlined by the manufacture and current issued recall.
NHTSA ODI #11669552
Mileage unknown · Jun 25, 2025
EnginePower TrainVehicle Speed Control
The concern is a rear end collision. At road speeds, vehicle changed to neutral (popped out of gear). Engine continued to run. Vehicle had to cost to a safe spot. At stop the vehicle was turned completely off and restarted with no issue. This is a repeatable but intermittent issue. This issue has also occurred at stop sign…
Read full complaint
The concern is a rear end collision. At road speeds, vehicle changed to neutral (popped out of gear). Engine continued to run. Vehicle had to cost to a safe spot. At stop the vehicle was turned completely off and restarted with no issue. This is a repeatable but intermittent issue. This issue has also occurred at stop signs and slow speeds. The engine check light and ABS Light did come on. The following stored codes were present: P0340, P1DD2 and U1424. The following pending codes were present: P1DD2, U017E-70, P0340-30, U1424, U0415. Camshaft Position Sensor was changed; but didn't fix the issue.
NHTSA ODI #11669169
Mileage unknown · Jun 17, 2025
Power Train
While driving down the highway suddenly loss of power with MIL light. Pulled over contacted dealer. Codes p200a and p200b. Set up appointment. Delivered vehicle to dealer. Inspection shows excessive soot buildup inside intake. Loss of power on road could cause vehicle accident and/or leave people stranded.
NHTSA ODI #11667482
Mileage unknown · Apr 16, 2025
EngineFuel/propulsion SystemPower Train
On about [XXX], I was driving and my engine felt like it missed and my check engine light came on and a message appeared telling me to get remote throttle serviced. The truck began to drive badly and lack of acceleration made it difficult to maneuver in traffic. The truck was very difficult to start and unsafe to pull into tra…
Read full complaint
On about [XXX], I was driving and my engine felt like it missed and my check engine light came on and a message appeared telling me to get remote throttle serviced. The truck began to drive badly and lack of acceleration made it difficult to maneuver in traffic. The truck was very difficult to start and unsafe to pull into traffic due to lagging ability to accelerate. I took it to a Firestone and they pulled the codes and said the crankshaft sensor and crank tone wheel had failed and needed replacing. I decided to take it to a RAM dealer in Franklin TN to confirm the diagnosis. After about a week, they confirmed and said crankshaft sensor and reluctor wheel needed to be replaced. I asked them if it would be covered under the recall (FCA W58) on the known defect of the crank tone wheel delaminating. When the recall occurred, I had the temporary solution of a computer flash done back in 2021, but the actual defective part was not replaced. They reported back to me that the cost of the repair would not be covered. They said my truck was too old, but the defect was discovered while my truck was still under warranty. Also, under a previous FCA lawsuit, they were made to pay truck owners money and extend their warranty. How can they get away with not having to rectify a known defect without fixing the problem? The computer flash simply allowed the vehicle to continue to operate, but it was by no means safe to operate on public streets in traffic. Will the NHTSA make FCA actually fix this problem? Thank you for your time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11655078
Mileage unknown · Mar 22, 2025
EnginePower Train
Rear Axle Shaft replacement Rear axle bearing & axle seal replacement Low compression cylinder 3 - not fixed It stalled out while driving and I made it to the side of the road and I had to have it towed. It was determined it is low compression on cylinder 3. Possible internal valve in the engine. Engine light came on rig…
Read full complaint
Rear Axle Shaft replacement Rear axle bearing & axle seal replacement Low compression cylinder 3 - not fixed It stalled out while driving and I made it to the side of the road and I had to have it towed. It was determined it is low compression on cylinder 3. Possible internal valve in the engine. Engine light came on right before it stalled.
NHTSA ODI #11649930
Mileage unknown · Feb 28, 2025
EnginePower Train
I am reporting a defective tone wheel on my 2015 RAM 1500 Pickup equipped with a 3.0L engine ("RAM") while accelerating into congested rush hour Interstate traffic. The RAM experienced an unexpected significant loss of power due to loss of crankshaft position. Subsequent inspection by the Chrysler Jeep Dodge Ram dealership confi…
Read full complaint
I am reporting a defective tone wheel on my 2015 RAM 1500 Pickup equipped with a 3.0L engine ("RAM") while accelerating into congested rush hour Interstate traffic. The RAM experienced an unexpected significant loss of power due to loss of crankshaft position. Subsequent inspection by the Chrysler Jeep Dodge Ram dealership confirmed that the RAM suffered a loss of crankshaft position due to a missing section of the magnetic material attached to the tone wheel and that as many as 14 cracks in the magnetic material are visible. For an undisclosed reason, FCA US did not include the RAM in Important Safety Recall W68/NHTSA 20V-475 (replacement of defective tone wheel) but rather kicked the can down the road and reprogrammed the software in the Powertrain Control Module under Safety Recall W58/NHTSA 20V-475. Based on material evidence of the failed tone wheel, it is clear that the RAM should have been included in the tone wheel replacement recall. FCA US refuses to cover the replacement of the defective tone wheel under Recall W68/NHTSA 20V-475 and extend the tone wheel warranty under FCA US Extended Warranty Letter X94. I am hopeful that NHTSA will compel FCA US aka Stellantis to include the vehicle(s) excluded from Recall W68/NHTSA 20V-475 and reimburse the owner(s) the cost(s) associated with the replacement of the defective tone wheel under Letter X94.
NHTSA ODI #11645531
Mileage unknown · Feb 22, 2025
EnginePower Train
Tone wheel delaminating while driving. I was passing a vehicle in a passing zone and the truck lost power. Safety was definitely put at risk luckily there was no one in the on coming lane. Problem was confirmed by independent shop. Has an appt with manufacturer March 10th 2025. No prior warning lamps or other symptoms. I know t…
Read full complaint
Tone wheel delaminating while driving. I was passing a vehicle in a passing zone and the truck lost power. Safety was definitely put at risk luckily there was no one in the on coming lane. Problem was confirmed by independent shop. Has an appt with manufacturer March 10th 2025. No prior warning lamps or other symptoms. I know there was recall about this certain issue, but the recall only changed the computer software, and didn’t actually fix the defective part.
NHTSA ODI #11644270
92,000 miles · Jan 13, 2025
Power TrainService Brakes
The contact owns a 2015 Ram 1500. The contact stated while driving at approximately 65 MPH, the ETC warning light illuminated, and the vehicle lost motive power. The contact pulled over to the side of the road and restarted the vehicle. The ETC light disappeared and then the check engine warning light, ABS, and ETC warning light…
Read full complaint
The contact owns a 2015 Ram 1500. The contact stated while driving at approximately 65 MPH, the ETC warning light illuminated, and the vehicle lost motive power. The contact pulled over to the side of the road and restarted the vehicle. The ETC light disappeared and then the check engine warning light, ABS, and ETC warning lights illuminated. The manufacturer was notified of the failure. The failure mileage was approximately 92,000.
NHTSA ODI #11635654
Mileage unknown · Nov 12, 2024
EnginePower Train
Subject: Complaint Regarding Camshaft and Lifter Failure in 2015 Ram 1500 5.7L V8 To Whom It May Concern, I am writing to formally submit a complaint regarding the camshaft and lifter failure in my 2015 Ram 1500 5.7L V8, which has only 141,000 miles. This issue began as a faint ticking sound—known commonly as the “Hemi tick”—a…
Read full complaint
Subject: Complaint Regarding Camshaft and Lifter Failure in 2015 Ram 1500 5.7L V8 To Whom It May Concern, I am writing to formally submit a complaint regarding the camshaft and lifter failure in my 2015 Ram 1500 5.7L V8, which has only 141,000 miles. This issue began as a faint ticking sound—known commonly as the “Hemi tick”—and has progressively worsened, leading to severe internal engine damage. Now, I am faced with the need for a complete engine replacement. The “Hemi tick” is a widely recognized issue that often starts with a minor noise but is known to develop into serious mechanical failure in Hemi engines. Despite its prevalence, this issue is frequently dismissed until it causes significant and costly engine damage. In my situation, what began as a ticking noise has led to camshaft and lifter failure, which I now understand is a recurring defect in these vehicles. This situation presents a major safety concern. With these parts deteriorating from what appears to be a design flaw, there is a high risk of sudden engine failure while driving. The failure of the camshaft and lifters can lead to immediate loss of power, which could leave drivers stranded or in dangerous situations on highways and busy roads. Additionally, sudden engine failure at higher speeds could lead to loss of vehicle control, endangering not only the driver and passengers but also other motorists. I recently experienced this firsthand. Luckily, my family and I, were able to maintain control and get to safety. I believe that this widespread defect requires attention to ensure the safety of those on the road. I respectfully request that the NHTSA investigate the durability and reliability of the camshaft and lifters in Dodge Ram vehicles with Hemi engines and take appropriate action to address this safety risk. Thank you for your attention to this matter. I trust that the NHTSA will act in the best interest of all drivers affected by this issue.
NHTSA ODI #11624651
Mileage unknown · Sep 16, 2024
Power Train
The crankshaft sensor and turn wheel had a recall of 2015. My Vin.# Did not make the list. Every where on line said the turn wheel magnets started breaking just after 100,000 miles. Mine broke just under 108,000 miles. It cost $2,969.33 to fix this. I want re-embursed!!!! The year, the millage, the problem all match up for this …
Read full complaint
The crankshaft sensor and turn wheel had a recall of 2015. My Vin.# Did not make the list. Every where on line said the turn wheel magnets started breaking just after 100,000 miles. Mine broke just under 108,000 miles. It cost $2,969.33 to fix this. I want re-embursed!!!! The year, the millage, the problem all match up for this truck to be on the recall. They said Mine just needed an update. Wrong! It broke just like the others and cost me almost $3000. The mechanic called the magnetic piece that broke in the transmission the (turn wheel ) I think. Please look into this.
NHTSA ODI #11614931
Official recalls
17Jun 8, 2023
Chrysler (FCA US, LLC) is recalling certain 2014-2019 Ram 1500 and 2014-2020 Jeep Grand Cherokee vehicles equipped with 3.0L Diesel engines. The crankshaft position sensor tone wheel may delaminate, causing the engine to lose its ability to synchronize the fuel injector pulses and cam shaft timing, possibly resulting in an engine stall.
Consequence & remedy
Consequence: An engine stall can increase the risk of a crash.
Remedy: Dealers will update the powertrain control module software to maintain vehicle propulsion, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed August 3, 2023. Some owner notification letters were mailed October 31, 2023. The remaining owner notification letters will be mailed at a future date, anticipated July 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 66A. This recall is an expansion of recall 20V-475.
Jun 9, 2022
Chrysler (FCA US, LLC) is recalling certain 2014-2020 Jeep Grand Cherokee, and 2014-2019 Ram 1500 vehicles equipped with 3.0L diesel engines. A high pressure fuel pump (HPFP) failure may introduce internal debris into the fuel system, potentially resulting in fuel starvation.
Consequence & remedy
Consequence: Fuel starvation may result in an unexpected loss of drive power, increasing the risk of a crash.
Remedy: Dealers will replace the HPFP, and inspect and replace, if necessary, additional fuel system components, free of charge. Interim notification letters informing owners of the safety risk were mailed July 21, 2022. Owner notification letters for were mailed for Jeep Grand Cherokee owners starting January 11, 2024. Owner notification letters for Ram 1500 owners were mailed March 7, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLS's number for this recall is Z46.
Aug 12, 2021
Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y55.
Additional source detail variants (2)
Air Bags:side/window:curtain:inflator
Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y55.
Air Bags:side/window:curtain
Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y55.
Aug 13, 2020
Chrysler (FCA US LLC) is recalling certain 2014-2018 Ram 1500 and 2014-2016 Jeep Grand Cherokee vehicles equipped with 3.0L diesel engines. The crankshaft position sensor tone wheel may delaminate causing the engine to lose its ability to synchronize the fuel injector pulses and cam shaft timing, possibly resulting in an engine stall.
Consequence & remedy
Consequence: An engine stall can increase the risk of a crash.
Remedy: FCA US will notify owners, and dealers will update the powertrain control module software to maintain vehicle propulsion by reading the camshaft position signal in the event that the crankshaft position signal is lost, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact FCA US customer service at 1-800-853-2002. FCA US's number for this recall is W58.
Oct 24, 2019
Chrysler (FCA US LLC) is recalling certain 2014-2019 Ram 1500 and 1500 Classic Pickup trucks equipped with 3.0L Eco Diesel engines. The Exhaust Gas Recirculation (EGR) cooler may crack and allow pre-heated vaporized coolant to enter the EGR system. This mixture may combust inside the intake manifold.
Consequence & remedy
Consequence: Combustion in the intake manifold can increase the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will replace the EGR cooler, free of charge. Dealers will also inspect and, as necessary, replace the intake manifold. The recall began April 16, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VB1.
May 9, 2019
Chrysler (FCA US LLC) is recalling certain 2015-2017 Ram 1500, 2500 and 3500 pickup trucks equipped with an 8 foot bed and a power locking tailgate. Chrysler is also recalling all 2013-2014 and 2018 Ram 1500, 2500 and 3500 pickup trucks built before April 1, 2018 with a 6 or 8 foot bed and a power locking tailgate. On August 29, 2019 Chrysler expanded the recall to include an additional 693,128 model year 2013-2014 Ram 1500, 2500 and 3500 pickup trucks. The tailgate actuator limiter tab may fracture and cause the tailgate to unlatch and open while driving.
Consequence & remedy
Consequence: If the tailgate opens while the vehicle is being driven, cargo may fall out the vehicle and create a road hazard, increasing the risk of crash.
Remedy: Chrysler will notify owners, and dealers will repair the tailgate latch, free of charge. The recall began May 23, 2019. Chrysler is expected to notify owners of the expanded population on October 18, 2019. Owners may contact FCA US customer service at 1-800-853-1403. FCA US's number for this recall is V44. Note: 2015-2017 MY Ram 1500 pickup trucks with truck beds other than 8 foot, are currently covered under NHTSA recall 18V-486 for this issue.
Jul 27, 2018
Chrysler (FCA US LLC) is recalling certain 2015-2017 RAM 1500, 2500, and 3500 pickup trucks equipped with a power locking tailgate and either a 5 foot, 7 inch or 6 foot, 4 inch bed. The tailgate actuator limiter tab may fracture and cause the tailgate to unlatch and open while driving.
Consequence & remedy
Consequence: If the tailgate latch releases and the tailgate opens while driving, cargo may fall out, creating a road hazard and increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will repair the vehicle, free of charge. The recall began September 17, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U74.
Additional source detail variants (2)
Latches/locks/linkages:tailgate:latch
Chrysler (FCA US LLC) is recalling certain 2015-2017 RAM 1500, 2500, and 3500 pickup trucks equipped with a power locking tailgate and either a 5 foot, 7 inch or 6 foot, 4 inch bed. The tailgate actuator limiter tab may fracture and cause the tailgate to unlatch and open while driving.
Consequence: If the tailgate latch releases and the tailgate opens while driving, cargo may fall out, creating a road hazard and increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will repair the vehicle, free of charge. The recall began September 17, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U74.
Structure:body:tailgate
Chrysler (FCA US LLC) is recalling certain 2015-2017 RAM 1500, 2500, and 3500 pickup trucks equipped with a power locking tailgate and either a 5 foot, 7 inch or 6 foot, 4 inch bed. The tailgate actuator limiter tab may fracture and cause the tailgate to unlatch and open while driving.
Consequence: If the tailgate latch releases and the tailgate opens while driving, cargo may fall out, creating a road hazard and increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will repair the vehicle, free of charge. The recall began September 17, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U74.
May 17, 2018
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence & remedy
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Additional source detail variants (3)
Electrical System:software
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Vehicle Speed Control:cruise Control
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Dec 21, 2017
Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.
Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.
Dec 20, 2017
Chrysler (FCA US LLC) is recalling certain 2016-2017 Ram 3500 Cab Chassis with a Gross Vehicle Weight Rating (GVWR) of less than 10,000 lbs, 2011-2017 Ram 3500, 4500 and 5500 Cab Chassis vehicles, 2009-2017 Ram 1500 and 2010-2017 Ram 2500 and 3500 pickup trucks, all equipped with a column shifter. Pushing the brake pedal for prolonged periods when the vehicle is running and in PARK may cause the Brake Transmission Shift Interlock (BTSI) pin to stick in the open position. With the pin in the open position, the transmission can be shifted out of PARK into any gear without pushing the brake pedal or having the key in the ignition.
Consequence & remedy
Consequence: Being able to shift the transmission without pushing the brake pedal and/or without a key in the ignition can increase the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Chrysler will notify owners, and dealers will update the vehicle software, inspect the BTSI, and, as necessary, replace it, free of charge. The recall began February 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T79.
May 9, 2017
Chrysler (FCA US LLC) is recalling certain model year 2013-2016 Ram 1500, Ram 2500, and 2014-2016 Ram 3500 vehicles. Certain driving conditions, such as driving off-road or debris striking the vehicle may cause the roll rate sensor to trigger a fault within the Occupant Restraint Controller (ORC). If this fault occurs, the rollover side curtain air bag and the seat belt pretensioner will be disabled from deploying.
Consequence & remedy
Consequence: If the rollover side curtain air bags and seat belt pretensioners are disabled, there is an increased risk of injury to the vehicle occupants in the event of a crash that necessitates activation of these safety systems.
Remedy: Chrysler will notify owners, and dealers will update the ORC software, free of charge. The recall began June 26, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T25.
Additional source detail variants (2)
Air Bags:side/window:curtain
Chrysler (FCA US LLC) is recalling certain model year 2013-2016 Ram 1500, Ram 2500, and 2014-2016 Ram 3500 vehicles. Certain driving conditions, such as driving off-road or debris striking the vehicle may cause the roll rate sensor to trigger a fault within the Occupant Restraint Controller (ORC). If this fault occurs, the rollover side curtain air bag and the seat belt pretensioner will be disabled from deploying.
Consequence: If the rollover side curtain air bags and seat belt pretensioners are disabled, there is an increased risk of injury to the vehicle occupants in the event of a crash that necessitates activation of these safety systems.
Remedy: Chrysler will notify owners, and dealers will update the ORC software, free of charge. The recall began June 26, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T25.
Air Bags
Chrysler (FCA US LLC) is recalling certain model year 2013-2016 Ram 1500, Ram 2500, and 2014-2016 Ram 3500 vehicles. Certain driving conditions, such as driving off-road or debris striking the vehicle may cause the roll rate sensor to trigger a fault within the Occupant Restraint Controller (ORC). If this fault occurs, the rollover side curtain air bag and the seat belt pretensioner will be disabled from deploying.
Consequence: If the rollover side curtain air bags and seat belt pretensioners are disabled, there is an increased risk of injury to the vehicle occupants in the event of a crash that necessitates activation of these safety systems.
Remedy: Chrysler will notify owners, and dealers will update the ORC software, free of charge. The recall began June 26, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T25.
Mar 23, 2016
Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Ram 1500 trucks manufactured January 22, 2015, to September 13, 2015. Contamination on the Electric Power Steering (EPS) control circuit board may cause a short and result in the loss of power steering assist.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required, especially at lower speeds, increasing the risk of a vehicle crash.
Remedy: Chrysler will notify owners, and dealers will replace the EPS unit, free of charge. The recall is expected to begin on May 16, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S19.
Oct 15, 2015
Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Ram 1500 trucks manufactured June 17, 2015, to September 28, 2015. The affected vehicles may have been built with rear axles that were incorrectly heat treated.
Consequence & remedy
Consequence: If the rear axle shaft was not properly heated treated, it may fracture and a wheel separation could occur, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the vehicles and replace the axle assemblies, as necessary, free of charge. The recall began on November 23, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R59.
Aug 21, 2015
Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Ram 1500 Quad Cab trucks manufactured August 26, 2013, to August 8, 2015. The affected vehicles are equipped with side air bag inflatable curtains (SABIC) that may not fully overlap the C-pillars in the event of a vehicle crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."
Consequence & remedy
Consequence: In the event of a vehicle crash, if a SABIC does not inflate as intended, there is an increased risk of injury to the rear seat occupant.
Remedy: Chrysler will notify owners, dealers will inspect the right and left side air bag inflatable curtains (SABIC) for proper orientation and a foil patch will be installed on both sides of the headliner. One or both of the air bag inflatable curtains (SABIC) will be replaced if necessary. The recall began on October 7, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R47.
Aug 14, 2015
Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Ram 1500 diesel 4x2 trucks manufactured August 8, 2013, to July 2, 2015. The affected vehicles have a battery harness that may rub against the frame bracket for the right engine mount resulting in an electrical short.
Consequence & remedy
Consequence: If the harness shorts, the vehicle may stall and there is an increased risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the vehicles to confirm that the battery harness is correctly routed and secured. Any harness that shows evidence of wear will be replaced. These repairs will be performed free of charge. The recall began on October 8, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R43.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery:cables
Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Ram 1500 diesel 4x2 trucks manufactured August 8, 2013, to July 2, 2015. The affected vehicles have a battery harness that may rub against the frame bracket for the right engine mount resulting in an electrical short.
Consequence: If the harness shorts, the vehicle may stall and there is an increased risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the vehicles to confirm that the battery harness is correctly routed and secured. Any harness that shows evidence of wear will be replaced. These repairs will be performed free of charge. The recall began on October 8, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R43.
Engine And Engine Cooling:engine:diesel
Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Ram 1500 diesel 4x2 trucks manufactured August 8, 2013, to July 2, 2015. The affected vehicles have a battery harness that may rub against the frame bracket for the right engine mount resulting in an electrical short.
Consequence: If the harness shorts, the vehicle may stall and there is an increased risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the vehicles to confirm that the battery harness is correctly routed and secured. Any harness that shows evidence of wear will be replaced. These repairs will be performed free of charge. The recall began on October 8, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R43.
Jul 23, 2015
Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Ram 1500, 2500, 3500, 4500, and 5500, 2015 Chrysler 200, Chrysler 300, Dodge Charger, and Dodge Challenger, 2014-2015 Jeep Grand Cherokee, Cherokee, and Dodge Durango, and 2013-2015 Dodge Viper vehicles. The affected vehicles are equipped with radios that have software vulnerabilities that can allow third-party access to certain networked vehicle control systems.
Consequence & remedy
Consequence: Exploitation of the software vulnerability may result in unauthorized remote modification and control of certain vehicle systems, increasing the risk of a crash.
Remedy: Chrysler will notify and mail affected owners a USB drive that includes a software update that eliminates the vulnerability, free of charge. Optionally, owners may download the update to their own USB drive from http://www.driveuconnect.com/software-update/ or take their vehicle to a Chrysler dealer for immediate installation. In an effort to mitigate the effects of this security vulnerability, Chrysler has had the wireless service provider close the open cellular connection to the vehicle that provided unauthorized access to the vehicle network. This measure may not have been implemented on all vehicles and does not address access by other means that will be remedied by the software update. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R40.
Jul 22, 2015
Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Ram 1500, 2500, and 3500 trucks manufactured June 20, 2012, to January 26, 2015. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.
Consequence & remedy
Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.
Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on September 8, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R23.
Additional source detail variants (2)
Seat Belts
Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Ram 1500, 2500, and 3500 trucks manufactured June 20, 2012, to January 26, 2015. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.
Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.
Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on September 8, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R23.
Air Bags:side/window
Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Ram 1500, 2500, and 3500 trucks manufactured June 20, 2012, to January 26, 2015. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.
Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.
Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on September 8, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R23.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ25003 · Post Recall Remedy Brake Transmission Shift Interlock (btsi) Failure
Opened Jul 3, 2025 · No close date supplied
Status: open (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:gear Position Indication (prndl)
The Office of Defects Investigation (ODI) has received 14 Vehicle Owner Questionnaire (VOQ) reports and 6 EWR Death & Injury (D&I) reports describing post recall remedy failures of the brake transmission shift interlock (BTSI) system in certain Model Year (MY) 2013-2018 RAM pickup trucks.The subject vehicle models include 1500, 2500, 3500, 4500, and 5500 trucks equipped with a column mounted shift lever.The failures of the BTSI described in the VOQs occurred on vehicles that had all previously been repaired under recall 17V-821 or 18V-100.Both recalls address a potential condition which can cause the BTSI locking pin to become stuck allowing the transmission to be shifted out of Park without depressing the brake pedal and/or without having a key in the ignition.Shifting the transmission out of Park when not having the brake pedal depressed can result in a vehicle rollaway. ODI is opening this Recall Query (RQ) to review the effectiveness of the 17V-821 and 18V-100 recall remedies, understand the root cause of additional vehicle rollaway incidents, and identify any other possible root cause that may affect the performance of the BTSI system. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Power Train:automatic Transmission
The Office of Defects Investigation (ODI) has received 14 Vehicle Owner Questionnaire (VOQ) reports and 6 EWR Death & Injury (D&I) reports describing post recall remedy failures of the brake transmission shift interlock (BTSI) system in certain Model Year (MY) 2013-2018 RAM pickup trucks.The subject vehicle models include 1500, 2500, 3500, 4500, and 5500 trucks equipped with a column mounted shift lever.The failures of the BTSI described in the VOQs occurred on vehicles that had all previously been repaired under recall 17V-821 or 18V-100.Both recalls address a potential condition which can cause the BTSI locking pin to become stuck allowing the transmission to be shifted out of Park without depressing the brake pedal and/or without having a key in the ignition.Shifting the transmission out of Park when not having the brake pedal depressed can result in a vehicle rollaway. ODI is opening this Recall Query (RQ) to review the effectiveness of the 17V-821 and 18V-100 recall remedies, understand the root cause of additional vehicle rollaway incidents, and identify any other possible root cause that may affect the performance of the BTSI system. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:automatic Transmission:gear Position Indication (prndl)
The Office of Defects Investigation (ODI) has received 14 Vehicle Owner Questionnaire (VOQ) reports and 6 EWR Death & Injury (D&I) reports describing post recall remedy failures of the brake transmission shift interlock (BTSI) system in certain Model Year (MY) 2013-2018 RAM pickup trucks.The subject vehicle models include 1500, 2500, 3500, 4500, and 5500 trucks equipped with a column mounted shift lever.The failures of the BTSI described in the VOQs occurred on vehicles that had all previously been repaired under recall 17V-821 or 18V-100.Both recalls address a potential condition which can cause the BTSI locking pin to become stuck allowing the transmission to be shifted out of Park without depressing the brake pedal and/or without having a key in the ignition.Shifting the transmission out of Park when not having the brake pedal depressed can result in a vehicle rollaway. ODI is opening this Recall Query (RQ) to review the effectiveness of the 17V-821 and 18V-100 recall remedies, understand the root cause of additional vehicle rollaway incidents, and identify any other possible root cause that may affect the performance of the BTSI system. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ23003 · Intermittent/comp Loss Of Power Steering
Opened Aug 4, 2023 · No close date supplied
Status: open (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:gear Box (other Than Rack And Pinion); Steering:gear Box:mounting Bracket; Steering:rack And Pinion; Steering:steering Control Module
The Office of Defects Investigation (ODI) has received 380 reports from consumers alleging an intermittent or complete loss of power steering assistance in certain 2013-2016 Ram 1500.The failure allegations occur at various speeds with limited detectability to the driver.On March 23, 2016 Fiat Chrysler Automotive (FCA) conducted recall campaign 16V-167 to address a possible contamination of the electrical power steering unit in certain model year 2015-2016 RAM 1500. The recall involved 440 vehicles and potentially resulted in loss of power steering assist.Consumer complaints indicate a similar failure may be occurring in vehicles that are out of scope of the recall.A Recall Query has been opened to determine if the scope of the recall mentioned above is correct or if another defect might exist that causes the alleged steering concerns.The reports cited above are listed in the attached document.
Additional source detail variants (6)
Steering
The Office of Defects Investigation (ODI) has received 380 reports from consumers alleging an intermittent or complete loss of power steering assistance in certain 2013-2016 Ram 1500.The failure allegations occur at various speeds with limited detectability to the driver.On March 23, 2016 Fiat Chrysler Automotive (FCA) conducted recall campaign 16V-167 to address a possible contamination of the electrical power steering unit in certain model year 2015-2016 RAM 1500. The recall involved 440 vehicles and potentially resulted in loss of power steering assist.Consumer complaints indicate a similar failure may be occurring in vehicles that are out of scope of the recall.A Recall Query has been opened to determine if the scope of the recall mentioned above is correct or if another defect might exist that causes the alleged steering concerns.The reports cited above are listed in the attached document.
Steering:electric Power Assist System
The Office of Defects Investigation (ODI) has received 380 reports from consumers alleging an intermittent or complete loss of power steering assistance in certain 2013-2016 Ram 1500.The failure allegations occur at various speeds with limited detectability to the driver.On March 23, 2016 Fiat Chrysler Automotive (FCA) conducted recall campaign 16V-167 to address a possible contamination of the electrical power steering unit in certain model year 2015-2016 RAM 1500. The recall involved 440 vehicles and potentially resulted in loss of power steering assist.Consumer complaints indicate a similar failure may be occurring in vehicles that are out of scope of the recall.A Recall Query has been opened to determine if the scope of the recall mentioned above is correct or if another defect might exist that causes the alleged steering concerns.The reports cited above are listed in the attached document.
Steering:gear Box:mounting Bracket
The Office of Defects Investigation (ODI) has received 380 reports from consumers alleging an intermittent or complete loss of power steering assistance in certain 2013-2016 Ram 1500.The failure allegations occur at various speeds with limited detectability to the driver.On March 23, 2016 Fiat Chrysler Automotive (FCA) conducted recall campaign 16V-167 to address a possible contamination of the electrical power steering unit in certain model year 2015-2016 RAM 1500. The recall involved 440 vehicles and potentially resulted in loss of power steering assist.Consumer complaints indicate a similar failure may be occurring in vehicles that are out of scope of the recall.A Recall Query has been opened to determine if the scope of the recall mentioned above is correct or if another defect might exist that causes the alleged steering concerns.The reports cited above are listed in the attached document.
Steering:gear Box (other Than Rack And Pinion)
The Office of Defects Investigation (ODI) has received 380 reports from consumers alleging an intermittent or complete loss of power steering assistance in certain 2013-2016 Ram 1500.The failure allegations occur at various speeds with limited detectability to the driver.On March 23, 2016 Fiat Chrysler Automotive (FCA) conducted recall campaign 16V-167 to address a possible contamination of the electrical power steering unit in certain model year 2015-2016 RAM 1500. The recall involved 440 vehicles and potentially resulted in loss of power steering assist.Consumer complaints indicate a similar failure may be occurring in vehicles that are out of scope of the recall.A Recall Query has been opened to determine if the scope of the recall mentioned above is correct or if another defect might exist that causes the alleged steering concerns.The reports cited above are listed in the attached document.
Steering:rack And Pinion
The Office of Defects Investigation (ODI) has received 380 reports from consumers alleging an intermittent or complete loss of power steering assistance in certain 2013-2016 Ram 1500.The failure allegations occur at various speeds with limited detectability to the driver.On March 23, 2016 Fiat Chrysler Automotive (FCA) conducted recall campaign 16V-167 to address a possible contamination of the electrical power steering unit in certain model year 2015-2016 RAM 1500. The recall involved 440 vehicles and potentially resulted in loss of power steering assist.Consumer complaints indicate a similar failure may be occurring in vehicles that are out of scope of the recall.A Recall Query has been opened to determine if the scope of the recall mentioned above is correct or if another defect might exist that causes the alleged steering concerns.The reports cited above are listed in the attached document.
Steering:steering Control Module
The Office of Defects Investigation (ODI) has received 380 reports from consumers alleging an intermittent or complete loss of power steering assistance in certain 2013-2016 Ram 1500.The failure allegations occur at various speeds with limited detectability to the driver.On March 23, 2016 Fiat Chrysler Automotive (FCA) conducted recall campaign 16V-167 to address a possible contamination of the electrical power steering unit in certain model year 2015-2016 RAM 1500. The recall involved 440 vehicles and potentially resulted in loss of power steering assist.Consumer complaints indicate a similar failure may be occurring in vehicles that are out of scope of the recall.A Recall Query has been opened to determine if the scope of the recall mentioned above is correct or if another defect might exist that causes the alleged steering concerns.The reports cited above are listed in the attached document.
EA23001 · High Pressure Fuel Pump Failure
Opened Mar 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Diesel:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021, to investigate incidents alleging a stall/loss of motive power as a result of high-pressure fuel pump failures in certain model year (MY) 2019-2020 Ram 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines. During the investigation, ODI sought to determine if the related defect allegation was limited in scope to the recalled population. After review of information request response materials from both FCA and BMW, NHTSA determined that sufficient information to identify a comprehensive recall population could not be produced by FCA and BMW.During the investigation FCA filed recalls 22V406, 22E048, 22V767, and 22E087 which include vehicles not identified in the initial subject population by ODI. ODI also received recall 21V586, involving loss of motive power due to failed CP4 fuel pumps on certain BMW manufactured vehicles. An information request letter response received from BMW indicated that failed pumps on their vehicles were caused by an interaction between pump internal components and US market diesel fuel, leading to increased slip and eventual particle-generating wear surface. Additional work will be done to identify whether a similar root cause is associated with the FCA recalled population and if similar wear dynamics occur on pumps supplied to vehicle manufacturers other than those included in the recalled population.ODI has upgraded this investigation to an EA in order to 1) determine engineering specifications of internal pump components that are correlated with pump failure leading to loss of motive power or other safety related hazards, 2) identify vehicle populations equipped with alleged defective pump variants, 3) assess if vehicles equipped with alleged defective pump variants result in an unreasonable risk to motor vehicle safety and 4) gather and review any other relevant information related to high pressure fuel pump failure associated with the subject populations of recalls 21V586, 21V880, 21E094, 22V406, 22E048, 22V767, and 22E087.Review of the above information will allow NHTSA to confirm root cause and recall remedy viability, and identify and evaluate vehicle populations equipped with pump components that may pose an unreasonable risk to motor vehicle safety.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 11257550, 11351441, 11361603, 11361616, 11365300, 11365426, 11365858, 11366401, 11372337, 11373793, 11374797, 11376793, 11377871, 11378173, 11384377, 11386063, 11387018, 11399710, 11402550, 11415339, 11418868, 11418870, 11427075, 11434276, 11436807, 11437226, 11437249, 11437273, 11437292, 11437294, 11437394, 11437399, 11437403, 11437405, 11437423, 11437528, 11437565, 11437579, 11437580, 11437590, 11437679, 11437744, 11437781, 11437842, 11437993, 11438006, 11438008, 11438121, 11438138, 11438155, 11438392, 11438629, 11439359, 11439879, 11440397, 11443030, 11446542, 11448163, 11453556, 11458918, 11460558, 11469337
PE16014 · Vehicle Rollaway
Opened Dec 16, 2016 · Closed Jan 25, 2024
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Power Train:automatic Transmission:gear Position Indication (prndl)
Basis – On December 16, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE16-014 to investigate 43 vehicle rollaway incidents with operators alleging they had shifted to Park and then exited the vehicle prior to the rollway incidents. These complaints involved multiple Fiat Chrysler Automobiles (FCA) model and model year vehicles that share a common electronic rotary shifter design. Of the 43 consumer complaints, 25 complaints alleged crashes, and eight complaints alleged at least one injury. Subject Vehicles – When NHTSA opened the investigation, the subject vehicles were model year (MY) 2013-2016 Ram 1500 vehicles and MY 2014-2016 Dodge Durango vehicles equipped with a rotary electronic shifter. However, NHTSA expanded the scope of the investigation to include subsequent model years of the same model vehicles when the Agency learned that those new model year vehicles use the same rotary shifter. Additionally, all subject vehicles manufactured by FCA are equipped with electronic rotary shifters supplied by Kostal Automotive. Reason for closing - During the course of this investigation, ODI did not find evidence that a vehicle-based design or manufacturing defect was the cause of vehicle rollaway incidents on the subject vehicles. Nevertheless, given the risk of a vehicle rollaway, FCA’s CSN actions provide automated vehicle securement when an operator attempts to exit the vehicle without successfully achieving a Park position with the rotary shifter mechanism. ODI closely monitored the subject vehicles on which the CSN actions implement a vehicle securement strategy and found that the CSN actions were effective in reducing the frequency of vehicle rollaway incidents in the subject vehicles. ODI analyzed the incidents when a CSN had been implemented and a rollaway still occurred, and ODI was unable to find an actionable defect that caused vehicle rollaway incidents. ODI found that the failure rates on subject vehicles that received a CSN remedy were similar to the failure rates on other vehicle populations and additionally had similar mechanisms as other vehicle populations such as slippery surfaces and various mechanical failures. Furthermore, as discussed above, after FCA’s release of the CSN actions, consumer complaints have decreased significantly. Given the absence of an identified safety defect based on available information and FCA’s customer satisfaction campaign which addresses the failure mode, further action is not warranted at this time. Accordingly, this Preliminary Evaluation is closed. However, the Agency reserves the right to take further action, if warranted.Please see the attached detailed closing summary for more information. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Power Train:automatic Transmission
Basis – On December 16, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE16-014 to investigate 43 vehicle rollaway incidents with operators alleging they had shifted to Park and then exited the vehicle prior to the rollway incidents. These complaints involved multiple Fiat Chrysler Automobiles (FCA) model and model year vehicles that share a common electronic rotary shifter design. Of the 43 consumer complaints, 25 complaints alleged crashes, and eight complaints alleged at least one injury. Subject Vehicles – When NHTSA opened the investigation, the subject vehicles were model year (MY) 2013-2016 Ram 1500 vehicles and MY 2014-2016 Dodge Durango vehicles equipped with a rotary electronic shifter. However, NHTSA expanded the scope of the investigation to include subsequent model years of the same model vehicles when the Agency learned that those new model year vehicles use the same rotary shifter. Additionally, all subject vehicles manufactured by FCA are equipped with electronic rotary shifters supplied by Kostal Automotive. Reason for closing - During the course of this investigation, ODI did not find evidence that a vehicle-based design or manufacturing defect was the cause of vehicle rollaway incidents on the subject vehicles. Nevertheless, given the risk of a vehicle rollaway, FCA’s CSN actions provide automated vehicle securement when an operator attempts to exit the vehicle without successfully achieving a Park position with the rotary shifter mechanism. ODI closely monitored the subject vehicles on which the CSN actions implement a vehicle securement strategy and found that the CSN actions were effective in reducing the frequency of vehicle rollaway incidents in the subject vehicles. ODI analyzed the incidents when a CSN had been implemented and a rollaway still occurred, and ODI was unable to find an actionable defect that caused vehicle rollaway incidents. ODI found that the failure rates on subject vehicles that received a CSN remedy were similar to the failure rates on other vehicle populations and additionally had similar mechanisms as other vehicle populations such as slippery surfaces and various mechanical failures. Furthermore, as discussed above, after FCA’s release of the CSN actions, consumer complaints have decreased significantly. Given the absence of an identified safety defect based on available information and FCA’s customer satisfaction campaign which addresses the failure mode, further action is not warranted at this time. Accordingly, this Preliminary Evaluation is closed. However, the Agency reserves the right to take further action, if warranted.Please see the attached detailed closing summary for more information. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Basis – On December 16, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE16-014 to investigate 43 vehicle rollaway incidents with operators alleging they had shifted to Park and then exited the vehicle prior to the rollway incidents. These complaints involved multiple Fiat Chrysler Automobiles (FCA) model and model year vehicles that share a common electronic rotary shifter design. Of the 43 consumer complaints, 25 complaints alleged crashes, and eight complaints alleged at least one injury. Subject Vehicles – When NHTSA opened the investigation, the subject vehicles were model year (MY) 2013-2016 Ram 1500 vehicles and MY 2014-2016 Dodge Durango vehicles equipped with a rotary electronic shifter. However, NHTSA expanded the scope of the investigation to include subsequent model years of the same model vehicles when the Agency learned that those new model year vehicles use the same rotary shifter. Additionally, all subject vehicles manufactured by FCA are equipped with electronic rotary shifters supplied by Kostal Automotive. Reason for closing - During the course of this investigation, ODI did not find evidence that a vehicle-based design or manufacturing defect was the cause of vehicle rollaway incidents on the subject vehicles. Nevertheless, given the risk of a vehicle rollaway, FCA’s CSN actions provide automated vehicle securement when an operator attempts to exit the vehicle without successfully achieving a Park position with the rotary shifter mechanism. ODI closely monitored the subject vehicles on which the CSN actions implement a vehicle securement strategy and found that the CSN actions were effective in reducing the frequency of vehicle rollaway incidents in the subject vehicles. ODI analyzed the incidents when a CSN had been implemented and a rollaway still occurred, and ODI was unable to find an actionable defect that caused vehicle rollaway incidents. ODI found that the failure rates on subject vehicles that received a CSN remedy were similar to the failure rates on other vehicle populations and additionally had similar mechanisms as other vehicle populations such as slippery surfaces and various mechanical failures. Furthermore, as discussed above, after FCA’s release of the CSN actions, consumer complaints have decreased significantly. Given the absence of an identified safety defect based on available information and FCA’s customer satisfaction campaign which addresses the failure mode, further action is not warranted at this time. Accordingly, this Preliminary Evaluation is closed. However, the Agency reserves the right to take further action, if warranted.Please see the attached detailed closing summary for more information. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:automatic Transmission:gear Position Indication (prndl)
Basis – On December 16, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE16-014 to investigate 43 vehicle rollaway incidents with operators alleging they had shifted to Park and then exited the vehicle prior to the rollway incidents. These complaints involved multiple Fiat Chrysler Automobiles (FCA) model and model year vehicles that share a common electronic rotary shifter design. Of the 43 consumer complaints, 25 complaints alleged crashes, and eight complaints alleged at least one injury. Subject Vehicles – When NHTSA opened the investigation, the subject vehicles were model year (MY) 2013-2016 Ram 1500 vehicles and MY 2014-2016 Dodge Durango vehicles equipped with a rotary electronic shifter. However, NHTSA expanded the scope of the investigation to include subsequent model years of the same model vehicles when the Agency learned that those new model year vehicles use the same rotary shifter. Additionally, all subject vehicles manufactured by FCA are equipped with electronic rotary shifters supplied by Kostal Automotive. Reason for closing - During the course of this investigation, ODI did not find evidence that a vehicle-based design or manufacturing defect was the cause of vehicle rollaway incidents on the subject vehicles. Nevertheless, given the risk of a vehicle rollaway, FCA’s CSN actions provide automated vehicle securement when an operator attempts to exit the vehicle without successfully achieving a Park position with the rotary shifter mechanism. ODI closely monitored the subject vehicles on which the CSN actions implement a vehicle securement strategy and found that the CSN actions were effective in reducing the frequency of vehicle rollaway incidents in the subject vehicles. ODI analyzed the incidents when a CSN had been implemented and a rollaway still occurred, and ODI was unable to find an actionable defect that caused vehicle rollaway incidents. ODI found that the failure rates on subject vehicles that received a CSN remedy were similar to the failure rates on other vehicle populations and additionally had similar mechanisms as other vehicle populations such as slippery surfaces and various mechanical failures. Furthermore, as discussed above, after FCA’s release of the CSN actions, consumer complaints have decreased significantly. Given the absence of an identified safety defect based on available information and FCA’s customer satisfaction campaign which addresses the failure mode, further action is not warranted at this time. Accordingly, this Preliminary Evaluation is closed. However, the Agency reserves the right to take further action, if warranted.Please see the attached detailed closing summary for more information. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ15004 · Software Security Vulnerability
Opened Jul 24, 2015 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Electrical System:software
On July 23, 2015, Fiat Chrysler Automobiles (FCA) launched Safety Recall 15V-461 to remedy security vulnerabilities in approximately 1.4 million model year (MY) 2013 through 2015 vehicles equipped with Uconnect head units (HU) 8.4A (RA3 radio) and 8.4AN (RA4 radio) manufactured by Harman International.On July 24, 2015, the Office of Defects Investigation (ODI) opened Recall Query, RQ 15-004, to investigate HU security vulnerabilities and remedy effectiveness in the recalled population and to determine whether similar units have been supplied for use in other FCA vehicles.In an August 11, 2015 letter, FCA submitted a second Part 573 safety recall report expanding the scope of the Uconnect RA4 model radio to include additional 7,810 MY 2015 Jeep Renegade vehicles manufactured from September 18, 2014 through June 25, 2015 (Recall 15V-508).Scope analysis indicated that Uconnect radios installed in FCA vehicles not included in recalls 15V-461 or 15V-508 (subject recalls) are not equipped with built-in cellular access or short range wireless communication features and, thus, do not contain the security vulnerabilities addressed by the subject recalls. SUBJECT VEHICLES: MY2014 through 2015 Dodge Durango, Jeep Grand Cherokee and Jeep Cherokee sport utility vehicles; MY2013 through 2015 Ram 1500, 2500, 3500 and 4500/5500 pickup trucks; MY2013 through 2015 Dodge Viper vehicles; and MY2015 Chrysler 200, 300, Jeep Renegade, Dodge Charger and Challenger vehicles.According to FCA, long and short range wireless vulnerabilities identified in the recalled vehicles could allow unauthorized third-party access to, and manipulation of, networked vehicle control systems.Successful exploitation of the vulnerabilities, coupled with reverse engineering of networked microprocessor control modules, could result in unauthorized manipulation of vehicle control systems. This unauthorized manipulation of vehicle controls and systems could expose the driver, vehicle occupants or other highway users to an increased risk of injury.FCA and its network provider, Sprint, conducted a nationwide campaign to block access to a radio communications port that was unintentionally left open.On July 27, 2015, short range wireless vulnerabilities were also blocked.Finally, third party security evaluation and regression testing identified vulnerabilities that were either remedied by Sprint or through updates to the FCA Uconnect software.ODI identified a total of 30 complaints or field reports on unique vehicles submitted by FCA (29) or received by NHTSA (1) alleging incidents of theft from a vehicle or anomalous performance that the owner alleged were caused by, or may have been caused by, remote hacking.Twenty-six (87%) of these reports were submitted after a magazine article was published on July 21, 2015, describing the remote hacking of an FCA vehicle by researchers who were able to affect the operation of various vehicle control systems, including the service brakes, steering, throttle and ignition.Most of the complaints involved vehicle systems that were not safety critical (e.g., complaints related to radio, navigation system, or air-conditioning control) and did not affect vehicle control.Three complaints reported engine stalls.One owner reported sudden unintended acceleration allegedly related to hacking.None of the complaints or field reports reviewed involved the steering and braking vehicle control effects demonstrated by the research hackers prior to the recall.There were no confirmed incidents of hacking in any of the records reviewed by ODI.The remedies completed by Sprint and FCA appear to have eliminated vulnerabilities that mi
Illustration